280 sundeck - Yachts | Sea Ray · PDF fileAVOID SKI LINES AND TOW ROPES- ... pOrT THrOug H-Hull CuTO uTs (fIg. 12.7.1) bIlge THrOug H-Hull CuTO uTs ... 12.9 280 sunde Ck

12.1280 Sundeck®

280 sundeCk® speCIfIC InfOrMaTIOn

Model Specificinformation

280 sundeck®

12.2


280 Sundeck®

1. loaD capaciTY

Refer to the General Information Sections for a detailed explanation of load Capacity.

buIlder’s plaTe (InTernaTIOnal)(fIg. 12.2.2)

BOAT MANUFACTURERMFG'S MODEL DESIGNATION

MAXIMUM NUMBER OF PASSENGERS

MAXIMUM LOAD CAPACITY

Nevercarrymoreweightorpassengersthanindicatedon the certification plate, regardless of weather orwaterconditions.

Theboatcancapsize,swamporsink.

! DANGER

Rotatingpropellerscaninjureorkillyou.

Shut off engine when persons are in water nearboat,oronswimplatformorladder.

!DANGER

RearfacingtransomseatsMUST NOT be used while engineisrunningorboatismoving.

! WARNING

2. passenger locaTions

Refer to the General Information Sections for a detailed explanation of Passenger locations.

Boatmotioncanbeerratic.

You can fall overboard or be injured by hittingsomethinginorontheboat.

Allpersonsmustbeincockpitareaorcabinandbepreparedforsuddenboatmovement.

Use frontorbowdeckareaonlyduringanchoring,mooringoremergencies.

! WARNING

Wetdecksareslippery.

Youcanbeseriouslyinjuredifyouslipandfall.

Wearslipresistantfootwearsecuredtoyourfeetandholdontorailsorboatstructure.

! WARNING

passenger lOCaTIOns(fIg. 12.2.3)

ACCOMMODATIONDECK(DECK AREA INTENDED FOR OCCUPATION DURING NORMAL OPERATION)

DONOTSTANDORWALKONTHISAREAWHILEUNDERWAY.

buIlder’s plaTe (dOMesTIC)(fIg. 12.2.1)

C 950

280 SD

12

12.3


280 Sundeck®

G

! WARNINGCarbon monoxide (CO) can cause brain damage or death.

Engine and generator exhaust contains odorless and colorless carbon monoxide gas.

Signs of carbon monoxide poisoning include nausea, headache, dizziness, drowsiness, and lack of consciousness.

Get fresh air if anyone shows signs of carbon monoxide poisoning.

See Owner's Manual for information regarding carbon monoxide poisoning.

NW-204-05

x

CO

CO

CO

CO

CO

CO

CO

CO

CO

COCO CO

CO

CO

CO

CO

CO

CO

COCO

3. safeTY label locaTions

F

A

H

K

D

safeTY label lOCaTIOns(fIg. 12.3.1)

THIS TAG INSTALLED WHEN BOAT IS ORDERED WITH CE INTERNATIONAL OPTION

M

E

J

L

I

C

A

CAUTION!

DANGER!

WARNING!

THEUNITEDSTATESCOASTGUARD(USCG)RECOMMENDSTHATALL

OCCUPANTSWEARAPPROVEDPERSONALFLOATATIONDEVICES(PFDs).

PROPELLER(S)MAYCAUSESERIOUSINJURYORDEATH.

Shut-offengine(s)whennearswimmers,priortousingsunpads,swimplatform,orboardingladder.

AVOIDCOLLISIONS-•Maintainlookoutasrequiredbythe"Rulesof

theRoad"•Visibilitycanbelimitedbyhighboattrim

angles,persons,gear,weatherandatmosphericconditions.

•Atalltimesproceedatasafespeed,inordertotakeproperandeffectiveactiontoavoidhazardousconditions.SUCHISSUESAREUNDERTHECONTROLOF

THEOPERATOR!

AVOIDSKILINESANDTOWROPES-Skilinesandtowropescanbacklashintothe

cockpitwhenreleased.

AVOIDINHALATIONOFTOXICFUMES-Iffireextinguishingsystemdischargeoccurs,

ventilatespacebeforeentering.

MRP # 1895601

N

B

C 950

280 SD

12

12.4


280 Sundeck®

C

MRP 1743507 SR-7313

WARNING!

DOORMUSTBESECUREDWHILEVESSELISUNDERWAY

safeTY label locaTions (conTinueD)safeTY label lOCaTIOns(fIg. 12.4.1)

YOU CAN DIE OR BE SERIOUSLY INJURED BYBREATHING CARBON MONOXIDE

OR BY THE PROPELLER IF YOUFALL OVERBOARD.

REAR FACING TRANSOM SEATS MUST NOTBE USED WHILE ENGINE IS RUNNING OR

BOAT IS MOVING.

WARNING!

1792393

J

L

MRP 1745125 SR-7111

WARNING!USECAUTIONWITHSKIERINTOW

ASTOWROPEMAYBACKLASHINTOCOCKPITWHENRELEASED

F

ON BATTERY SWITCH PANEL UNDER SEAT CUSHION

IFSWITCHISTURNEDOFFWHILEENGINEISRUNNINGALTERNATOR

WILLBEDAMAGED.MRP # 1746901 SR-7167

CAUTION!

! DANGERCarbon monoxide (CO) can cause brain damage or death.

Engine and generator exhaust contains odorless and colorless carbon monoxide gas.

Carbon monoxide will be around the back of the boat when engines or generators are running.

Move to fresh air, if you feel nausea, headache, dizziness, or drowsiness. NW-206-05

xCO

CO

COCO

CO

CO

COCOCO

COCO

COCO

COCO

COCO CO

CO

M

E

CHECKBATTERYCELLFLUIDLEVELAPPROXIMATELYEVERY4WEEKS,ANDMORE

OFTENINSUMMERANDHOTZONES.MRP # 1746895 SR-7139

NOTICE

G

ONLY ON BOATS WITHOUT AN OPTIONAL AUTOMATIC FIRE SUPPRESSION SYSTEM

MRP #1744762 SR-766

MRP 1743571 SR-7102

DANGER!TRANSOMDOORMUSTBE

CLOSEDANDSECUREWHENENGINEISRUNNING

H

TOAVOIDRISKOFSERIOUSINJURYORDEATHSHUTOFFENGINEWHENNEARSWIMMERSORPRIORTOUSINGSWIMPLATFORMAND

BOARDINGLADDER.MRP 1745519 SR-7214

DANGER!

N

K

Gasolinevaporsareexplosive!Avoidseriousinjuryordeathfromfireor

explosion,resultingfromleakingfuel.Inspectsystemforleaksatleastonceayear.

Theuseoffuelscontainingethanolhigherthan10%(E-10)candamageyourengineorfuel

systemandwillvoidthewarranty.Neveruse(E-85).

Openflameappliancescanignitegasolinevaporscausingdeathorinjuriesfromthefireorexplosion.Turnoffallopenflameapplianceswhenrefueling.

!

MRP 1948206 SR-7439

WARNING

FIXEDFIREEXTINGUISHINGSYSTEMMUSTBESUITABLEFORGROSSCOMPARTMENT

VOLUMEOF150cuft.

MRP # 1949485

NOTICE

I

STAYCLEAROFMOVINGPARTSWHILEENGINEISRUNNING.

MRP 1745512 SR-7149

DANGER!

LOCATED UNDER ENGINE HATCH

LEAKINGFUELISAFIREANDEXPLOSIONHAZARD.INSPECTSYSTEMREGULARLY.EXAMINEFUELTANKSFORLEAKSORCORROSIONATLEASTANNUALLY.

MRP 1745513 SR-7151

WARNING!

MRP 1747493 SR-7135

LEAVINGWINDOWOPENCOULDINDUCEEXHAUSTFUMES

INTOCABINRESULTINGINSEVEREPERSONALINJURYORDEATH

DANGER!

B D

VISIBILITYFROMTHESEATEDPOSITIONATTHISHELMSTATIONISLIMITED.

AVOIDSERIOUSINJURYORDEATHFROMCOLLISIONS.OPERATIONFROMASTANDINGPOSITION

MAYBENECESSARYTOMAINTAINLOOKOUTASREQUIREDBYRULESOFTHEROAD.

READOWNERSMANUAL.

!

MRP 1743528 BCM-714

WARNING

12.5


280 Sundeck®

LOCATED ON INSIDE OF WET BAR CABINET DOOR

save our seasIt is illegal todumpplastictrashanywhereintotheoceanornavigablewatersoftheUnitedStates.Violationoftheserequirementsmayresult

incivilpenaltyupto$25,000,afineof$50,000andimprisonmentforuptofiveyears.

PLASTIC - Includes but is not limited to: plastic bags, styrofoam cups and lids, six-pack holders, stirrers, straws, milk jugs, egg cartons, syn-thetic fishing nets, ropes, lines, and bio or photo degradable plastics.

GARBAGE - Means paper, rags, glass, metal, crockery (generated in living spaces aboard the vessel-what we normally call trash), and all kinds of food, maintenance and cargo-associated waste.“Garbage” does not include fresh fish or fish parts, dishwa-ter, and gray water.

DUNNAGE- Material used to block and brace cargo, and is considered a cargo associated waste.

DISHWATER- Means the liquid residue from the manual or au-tomatic washing of dishes and cooking utensils which, have been pre-cleaned to the extent that any food particles adher-ing to them would not normally interfere with the operation of automatic dishwashers.

GRAYWATER - Means drain-age from a dishwasher, shower, laundry, bath, and washbasin, and does not include drainage from toilets, urinals, hospitals, and cargo spaces.

(and in U.S. Lakes, Rivers, Bays and Sounds)

PLASTICSDUNNAGE, LINING AND PACKING

MATERIALS THAT FLOATANY GARBAGE EXCEPT DISHWATER/

GRAYWATER/FRESH FISH PARTS

PLASTICSDUNNAGE, LINNING AND PACKING

MATERIALS THAT FLOATANY GARBAGE NOT GROUND TO LESS

THAN ONE SQUARE INCH

PLASTICSDUNNAGE, LINING AND PACKING

MATERIALS THAT FLOAT

PLASTICS

3 TO 12 MILES

INSIDE 3 MILES

12 TO 25 MILES

12 TO 25 MILES

safeTY label locaTions (conTinueD)safeTY label lOCaTIOns(fIg. 12.5.1)

12.6

280 Sundeck® Specific information

280 Sundeck®

4. Basic Boat Dimensions anD clearances

Boat dimenSionS and clearanceS (fig. 12.6.1)

(A) Overall Length With Std. Swim Platform ......... 28' 0" 8.53 m

(B) Beam (Width) ........................... 8' 10" 2.69 m

(C) Draft (Stern Drive Down) ......... 42"* 107 cm*

Draft (Stern Drive Up) .................... 25"* 64 cm* * MINIMUM WATER DEPTH TO PREVENT RUNNING AGROUND

Dry Weight ..................................... 6,100 lbs. 2,767 kg.

Fuel Capacity ................................. 85 gal. 321 liters

Usable Fuel ................................... 76.5 gal. 289 liters

Fresh Water Capacity (Opt) ........... 20 gal. 75.7 liters

Dead Rise ...................................... 21°

280 Sundeck® SpecificationS HeigHt dimenSionS(D) Keel to Top of Nav Light .................9' 4½" 2.86 m

(E) Waterline to Top of Nav Light .........7' 6" 2.29 m

(F) Waterline to Top of Windshield .......6' 9½" 2.07 m

(A)

WATERLINE

KEEL(C)

(B)

(D)(E)(F)

Note - DimeNsioNs caN vary DepeNDiNg oN loaD aND ruNNiNg coNDitioNs.

12.7


280 Sundeck®

5. funcTion anD locaTion of Through-hull cuTouTs

pOrT THrOugH-Hull CuTOuTs(fIg. 12.7.1)

bIlge THrOugH-Hull CuTOuTs (fIg. 12.7.3)

TransOM THrOugH-Hull CuTOuTs (fIg. 12.7.4)

sTarbOard THrOugH-Hull CuTOuTs (fIg. 12.7.2)

HEAD SINK

WASTE VENT(OPT)

CORSA EXHAUST(OPT)

DOCK LIGHT(OPT)

GRAY WATER HOLDING TANK(OPT)

PROPANE BOXDRAIN (OPT)

STOVE PANDRAIN (OPT)

WET BAR SINKDRAIN

CORSA EXHAUST(OPT)

MANUAL BILGE PUMP(CE OPT)

BILGE PUMP DOCK LIGHT(OPT)

TRANSDUCER

GARBOARD DRAIN

STERN EYETYP P&S

UNDER WATERLIGHTS (OPT)TYP P&S

12.8


280 Sundeck®

6. helM, gauge & sWiTch laYouT

Helm(fIg. 12.8.1)

INSTRUMENT PANEL

STBD SWITCH PANEL

COMPASS

STEREO REMOTE

COnTrOl sTaTIOn InsTruMenT panel(fIg. 12.8.2)

Standard Configuration

DOCKINGLIGHTS

HORN

COCKPIT LIGHTSWIPER ANCHOR

LIGHT

THRU-HULLEXHAUST

HULLLIGHTS

WATERPUMP

BILGEPUMPANCHOR

ANCHORLIGHT

BILGEBLOWER

NAVLIGHTS

!

BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR GASOLINE OR VAPORSOPERATE BLOWER FOR FOUR (4) MINUTES ANDVERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEEDS.

GASOLINE VAPORS CAN EXPLODERESULTING IN INJURY OR DEATH

WARNING

LIGHT ON- UNIT CHARGEDLIGHT OFF- UNIT DISCHARGED

IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER, AND ELECTRICAL SYSTEM.AUTOMATIC EXTINGUISHING SYSTEM

FUEL SPEEDOMETER SYSTEM TACH TRIM

12.9


280 Sundeck®

GASOLINE VAPORS CAN EXPLODERESULTING IN INJURY OR DEATH

AUTOMATIC EXTINGUISHING SYSTEM

WARNING

BEFORE STARTING ENGINE: CHECK ENGINE COMPARTMENT BILGE FOR GASOLINE OR VAPORSOPERATE BLOWER FOR FOUR (4) MINUTES ANDVERIFY BLOWER OPERATION. RUN BLOWER WHEN VESSEL IS OPERATING BELOW CRUISING SPEEDS.

!

LIGHT ON- UNIT CHARGEDLIGHT OFF- UNIT DISCHARGED

IF SYSTEM DISCHARGES, SHUTDOWN ENGINE, BLOWER, AND ELECTRICAL SYSTEM.

COnTrOl sTaTIOn pOrT swITCH panel(fIg. 12.9.1)

COnTrOl sTaTIOn sTarbOard swITCH panel(fIg. 12.9.2)

STEREO REMOTE AUTOMATIC FIRE SUPPRESSION SYSTEM

INDICATOR LIGHT

IGNITION SWITCH

HULLLIGHTS

DOCKINGLIGHTS

HORNTHRU-HULL

EXHAUSTBILGE

BLOWERWATERPUMPANCHOR

WIPER COCKPIT LIGHTS

BILGEPUMP

ANCHORLIGHT

NAVLIGHTS

12.10


280 Sundeck®

7. Deck laYouT

deCk laYOuT (fIg. 12.10.1)

STBD STORAGE (UNDER DASH)

STBD NAV LIGHT

COCKPIT WET BAR

STORAGE

CONTROL STATION

DEDICATED COOLER STORAGE

BOW TABLE BASE(OPT)

HORN

SWIM LADDER

BOW SEATING W/ STORAGE BELOW

STBD BUCKET SEAT

TRANSOM DOOR

WATER SPORTS TOWER (OPT)

L-SHAPED LOUNGER, “MULTI-FUNCTIONAL”

AFT SEAT

BOW FLOOR STORAGE

HEAD COMPARTMENT

PORT BUCKET SEAT

SKI STORAGE

BEACH BOARDING LADDER

(WINDLASS OPT)

PORT NAV LIGHT

SKI TOW EYE

COOLER

SWIM PLATFORM

COCKPIT TABLE BASE (OPT)

TRANSOM STEREO REMOTE (OPT)

BATTERY CHARGER PLUG (OPT)

WASTE WATERPUMP OUT

FUEL FILL

TRANSOMTRIM SWITCH

FRESH WATER FILL

12.11


280 Sundeck®

HULLLIGHTS

DOCKINGLIGHTS

HORNTHRU-HULL

EXHAUSTBILGE

BLOWERWATERPUMPANCHOR

WIPER COCKPIT LIGHTS

BILGEPUMP

ANCHORLIGHT

NAVLIGHTS

8. cleaTs

Cleatsmustnotbeusedforliftingtheboat; they are intended for docking or mooring use only.

CleaT lOCaTIOns(fIg. 12.11.1)

10. lighTing

See General Information Sections for a detailed explanation of the lighting.

*

*

*

*

*

*

9. navigaTion anD anchor lighTs

See General Information Sections for a detailed explanation of the anchor lights.

NAVIGATION LIGHT SWITCH

ANCHOR LIGHT SWITCH

navIgaTIOn and anCHOr lIgHTs(fIg. 12.11.2)

PORT & STBD NAVIGATION

LIGHTS

STARBOARDSWITCH PANEL

ALL-ROUND/ANCHOR LIGHT

lIgHTIng laYOuT(fIg. 12.11.3)

BULB REPLACEMENTBULB# GE2641L

12V R 10WA

PORT&STBDNAV.LIGHTS

STERNNAV./ANCHORLIGHT

BULB REPLACEMENTFUSE TYPE BULB#12V10WPERKOB

RECTANGLELIGHT

BULBREPLACEMENT

BULB#CEC1141D

COCKPITLIGHT

BULB REPLACEMENTFUSE TYPE BULB

#12V10WPERKO #70-0

C

A A

B

C

D

C

D

B

WITH OPTIONALWATER SPORTS

TOWER

STANDARD

12.12


280 Sundeck®

bIlge laYOuT(fIg. 12.12.1)

11. bilge laYouT

BATTERIES

BILGE PUMP

FUEL TANK

FRESH WATERTANK

AUTOMATIC FIRE EXTINGUISHER (OPT)

TRANSDUCER

FRESH WATER PUMP

TRIM TABSPUMP

BILGE BLOWER

WASTE WATER HOLDING TANK

POWER TRIMPUMP

12.13


280 Sundeck®

DECK PLATE

FUEL TANK

FUEL FILL

VENT HOSE

FUEL FEED

13. fuel sYsTeM

The gasoline fuel system on your 280SD consists of a 85 gal. (321 liter) fuel tank, fuel tank vent, mechanical shut-off valve, ultrasonic sending unit, engine fuel supply line and fuel fill.

15. MulTi-funcTional afT seaT

The aft sunpad, extended sunpad and aft facing seat of the multi-functional aft seat are intended for use only when the engine is not running and the boat is not underway.

Youcandieorbeseriouslyinjuredbybreathingcarbonmonoxideorbythepropellerifyoufalloverboard.

Rear facing transomseatsmustnotbeusedwhileengineisrunningorboatismoving.

! WARNING

14. WaTer sYsTeM (opTion)The optional fresh water system on the 280SD consists of a 20 gal. (75.7 liter) tank, 12v water pump with 2 faucets (wet bar and head) and 2 pull out sprayers (transom and bow).

12. fire exTinguishing sYsTeM

Your 280SD has a fire extinguisher port located on the starboard forward face of the aft bench seat base. Refer to the General Information Sections for a detailed explanation of the fire extinguisher port.

An optional automatic fire extinguisher system is also available. Refer to the General Information Sections for a detailed explanation of the automatic fire extinguisher system.

fuel sYsTeM(fIg. 12.13.1)

12.14


280 Sundeck®

16. enTerTainMenT sYsTeM

The standard entertainment system on your 280SD consists of a 12V AM/FM receiver CD player, an MP3 port, iPod® port, amplifier, 6 waterproof speakers and a digital cockpit remote control.

Optional stereo system upgrades include an additional stereo remote on the transom, satellite stereo receiver & antenna, upgraded speakers and speakers mounted on the optional water sports tower.

sTereO COMpOnenTs(fIg. 12.14.1)

STEREOSYSTEM

MP3 PORT IPOD® DOCK

17. canvas

The standard canvas on the 280SD consists of: Bimini Top with BootAn optional Canvas Package for the Bimini Top consists of: Aft Curtain Front Curtains Side Curtains Cockpit Cover Tonneau Cover Canvas Storage Bag

The Cockpit, Tonneau Covers and Canvas Storage Bag are also available as a package.

A forward Bimini and bow for the Water Sports Tower (Opt) and a mooring cover are also available individually.

! DANGER

Exhaustfumesfromenginescontaindeadlycarbonmonoxidegas(CO).Boatsenclosedwithcanvasorwithpoorventilationaremostlikelytocollectfumes.

CO sickness symptoms include headache, nauseaanddizziness.Donotmistake thesesymptomsforseasickness.

Ventilateboat.SeeSection1.4,CarbonMonoxide,formore details.

Do not use the rear (aft) curtain while engine isrunningorboatismoving.

18. elecTrical scheMaTics

This owner's manual contains electrical schematics and wiring harness illustrations for your boat. These electrical schematics were generated by electrical CAD designers at the engineering division for technical reference and service technicians. Sea Ray® does not recommend that you attempt to work on the boat’s electrical system yourself. Instead, we recommend that you take your boat to your authorized Sea Ray® dealer for service. Sea Ray® reserves the right to change or update the electrical system on any model at any time without notice to the consumer and is NOT obligated to make any updates to units built prior to changes.

12V ACCYRECEPTACLE

COCKPIT WET BAR

12.15


280 Sundeck®

dC wIrIng sCHeMaTICdrawIng nO. 09-602 (1 Of 10)(fIg. 12.15.1)

Warning:DO NOT attempt to

work on the electrical systemof this boat without professional

assistance.

12.16


280 Sundeck®




assistance.

12.17


280 Sundeck®




assistance.

12.18


280 Sundeck®




assistance.


12.19


280 Sundeck®




assistance.

12.20


280 Sundeck®




assistance.


12.21


280 Sundeck®




assistance.

12.22


280 Sundeck®




assistance.

12.23


280 Sundeck®

sTereO wIrIng sCHeMaTIC (sTandard)drawIng nO. 09-607(fIg. 12.23.1)



assistance.

12.24


280 Sundeck®

sTereO wIrIng sCHeMaTIC (OpT)drawIng nO. 09-608(fIg. 12.24.1)



assistance.

12.25


280 Sundeck®

TOwer speaker sYsTeM (OpT)drawIng nO. 09-609(fIg. 12.25.1)



assistance.

12.26


280 Sundeck®

TOwer speaker sYsTeM (OpT)drawIng nO. 09-614(fIg. 12.26.1)



assistance.

12.27


280 Sundeck®

saTellITe sTereO sYsTeM dIagraMdrawIng nO. 09-716(fIg. 12.27.1)



assistance.

12.28


280 Sundeck®

baTTerY CHarger sYsTeM prInTdrawIng nO. 09-738 (1 Of 2)(fIg. 12.28.1)



assistance.

baTTerY CHarger sYsTeM prInTdrawIng nO. 09-738 (2 Of 2)(fIg. 12.28.2)

12.29


280 Sundeck®

vHf sYsTeM dIagraMdrawIng nO. 09-745(fIg. 12.29.1)



assistance.

12.30


280 Sundeck®

MerCurY dTs sYsTeM dIagraMdrawIng nO. 09-770(fIg. 12.30.1)



assistance.

Documents

280 sundeck - Yachts | Sea Ray · PDF fileAVOID SKI LINES AND TOW ROPES- ... pOrT THrOug H-Hull CuTO uTs (fIg. 12.7.1) bIlge THrOug H-Hull CuTO uTs ... 12.9 280 sunde Ck