Upload
dinhquynh
View
215
Download
0
Embed Size (px)
Citation preview
Produkte Products
Seite 1 von 10 Page 1 of 10
TÜV Rheinland Energy GmbH Am Grauen Stein 51105 Köln Germany Tel.: +49 221 806-5222 Fax: +49 221 806-1350 Mail: [email protected] Web: www.tuv.com/solarenergy
Prüfbericht-Nr.: Test Report No.:
21290449.002 Auftrags-Nr.: Order No.:
21243643
Kunden-Referenz-Nr.: Client Reference No.:
3201853 Auftragsdatum: Order date:
15 May 2018
Auftraggeber: Client:
Philadelphia Solar, Al Qastal Industrial Area 2, Airfreight Road, 11814 Amman, Jordan
Prüfgegenstand: Test item:
Photovoltaic (PV) modules
Bezeichnung / Typ-Nr.: Identification / Type No.:
see sections 1 "Product details" and "List of test samples"
Auftrags-Inhalt: Order content:
Determination of PV module performance characteristics according to the Guidelines for California's Solar Electric Incentive programs (CEC)
Prüfgrundlage: Test specification:
Photovoltaic (PV) modules
Determination of PV module performance characteristics according to the Guidelines for California's Solar Electric Incentive programs 6th Ed., 11.2016 and IEC 61215:2005 / IEC 61646:2008 - CEC-300-2016-008-CMF
Wareneingangsdatum: Date of receipt:
06 June 2018
Prüfmuster-Nr.: Test sample No.:
see others
Prüfzeitraum: Testing period:
06 June 2018 - 25 September 2018
Ort der Prüfung: Place of testing:
Cologne
Prüflaboratorium: Testing laboratory:
Solar Energy Assessment Center
Prüfergebnis*: Test result*:
Siehe Sonstiges / See Other
geprüft von / tested by:
14 November 2018 N. Schwarze,Project manager
kontrolliert von / reviewed by:
14 November 2018 L.Jakisch,Business Field manager
Datum Date
Name / Stellung Name / Position
Unterschrift Signature
Datum Date
Name / Stellung Name / Position
Unterschrift Signature
Sonstiges / Other: All required test results for California Solar Electric Incentive programme are listed on the following pages of this report. Test sample No.: HV2018001861, HV2018001862, HV2018002027, HV2018002028 This report is a revision of report 21290449.001. Please compare the "history of reporting" attached.
Zustand des Prüfgegenstandes bei Anlieferung: Condition of the test item at delivery:
Prüfmuster vollständig und unbeschädigt Test item complete and undamaged
* Legende: 1 = sehr gut 2 = gut 3 = befriedigend 4 = ausreichend 5 = mangelhaft
P(ass) = entspricht o.g. Prüfgrundlage(n) F(ail) = entspricht nicht o.g. Prüfgrundlage(n) N/A = nicht anwendbar N/T = nicht getestet
Legend: 1 = very good 2 = good 3 = satisfactory 4 = sufficient 5 = poor
P(ass) = passed a.m. test specification(s) F(ail) = failed a.m. test specification(s) N/A = not applicable N/T = not tested
Dieser Prüfbericht bezieht sich nur auf das o.g. Prüfmuster und darf ohne Genehmigung der Prüfstelle nicht
auszugsweise vervielfältigt werden. Dieser Bericht berechtigt nicht zur Verwendung eines Prüfzeichens.
This test report only relates to the a. m. test sample. Without permission of the test center this test report is not permitted to be duplicated in extracts. This test report does not entitle to carry any test mark.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 2 von 10 Page 2 of 10
Liste der verwendeten Prüfmittel List of used test equipment
Rev.:01
Prüfmittel Test equipment
Prüfmittel-Nr. / ID-Nr. Equipment No. / ID-No.
Nächste Kalibrierung Next calibration
All equipment used for tests, including equipment for subsidiary measurements having a significant effect on the accuracy or validity of the result of the test is calibrated before being put into service. The laboratory has an established programme and procedure for the calibration of its equipment according to EN ISO/IEC 17025 (Reg. no.: D-PL-11120-01-00).
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 3 von 10 Page 3 of 10
Produktbeschreibung Product description
Rev.:01
1 Produktdetails Product details
For the tested modules, please see “List of test samples” on page 4. The modules are currently under IEC 61215:2016/61730:2016 and UL 61730 qualification. In this context, tolerances, current and voltage values as well as some of the power classes needed to be adapted following Gate No. 1 (7.2.1) of IEC 61215-1:2016. In addition, type designations were adapted slightly. If all qualification tests are passed, the updated power classes should be as follows:
with 6“ poly cells PS-P72-xxxW (AQABA) (xxx= 320 – 330 in steps of 5) PS-P60-xxxW (MAFRAQ) (xxx= 265 – 275 in steps of 5)* with 6” mono cells PS-M72-xxxW (AMMAN) (xxx= 360 – 365 in steps of 5) PS-M60-xxxW (JARASH) (xxx= 295 – 305 in steps of 5)
xxx represent output power in Wp
* Power classes of PS-P60-xxxW (MAFRAQ) shall now be increased by 5Wp per power class. E.g. PS P60-265W (MAFRAQ) is planned to be labelled with PS-P60-270W (MAFRAQ). Please see the photo appendix for the type labels of the test samples as well as the current versions of the updated test labels.
2 Verwendete Materialien Used materials
see Constructional Data Form (CDF) No. 21290450.001 (still under preparation, as IEC 61215:2016 / 61730:2016 and UL61730 project is still ongoing).
3 Adresse(n) der Fertigungsstätte(n) Address(es) of the manufacturing site(s)
Philadelphia Solar, Al Qastal Industrial Area 2, Airfreight Road, 11814 Amman, Jordan, Inspection report no.: 21183161.006 (October 2017) Next factory inspection is scheduled for 24th of October 2018.
4 Zusammenfassung der Prüfergebnisse Summary of test results
According to the inquiry of the customer the performance characteristics of 4 PV module types were determined according to the Guidelines for California's Solar Electric Incentive programs 6th Ed., 11.2016 and IEC 61215:2005 / IEC 61646:2008 - CEC-300-2016-008-CMF.
This test report includes an appendix “Zusatzdokumentation/Additional Documentation” including the history of reporting and certification and an appendix “Foto-Dokumentation/Photo Documentation”.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 4 von 10 Page 4 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
— Test specification
Crystalline silicon terrestrial photovoltaic (PV) modules – Design qualification and type approval
IEC 61215:2005 —
— Marking
Name, monogram or symbol of manufacturer
— P
Type or model number — P
Serial number — P
Polarity of terminals or leads — P
Maximum system voltage — P
Date and place of manufacture* — P
Remarks:
*Serial number on type label. See photos in appendix.
According to Philadelphia Solar, production order date is prefix of serial number and serial number is connected to the flasher data.
— List of test samples
Sample No. Sample S/N Remarks/constructional characteristics
(e.g. cell, backsheet, frame type)
—
HV2018001861 PS080518429702
PS P72-325W (Aqaba)
(Type name should be changed to PS-P72-325W (AQABA) )
HV2018001862 PS250418420452
PS M72-365W (Amman)
(Type Name should be changed to PS-M72-365W (AMMAN) )
HV2018002027 PS260618436715
PS M60-300W (JARASH)
(Type Name should be changed to PS-M60-300W (JARASH))
HV2018002028 PS260618436702
PS P60-265W (MAFRAQ)
(Power class with new tolerances should be raised to 270W. Type Name should be changed to PS-P60-270W
(MAFRAQ))
Remarks: Module types are currently in IEC 61215/61730 (2016) – qualification testing. Type designations (additionally power classes of PS-P60-xxxW (MAFRAQ) were adapted) were adapted after Gate No. 1 of IEC 61215-1:2016. For further details, please also compare chapter 1 “product details”. Please see the photo appendix for the type labels of the test samples as well as the current versions of the updated test labels.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 5 von 10 Page 5 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
— IEC/EN 61215 - Design qualification and type approval
10 Preconditioning (min. 5.5 kWh) P
10.1 Visual inspection See table 10.1 P
10.2 Maximum power determination —
10.4 Measurement of temperature coefficients See table 10.4 —
10.6 Performance at STC See table 10.6.1 —
10.5 Measurement of Nominal Operating Cell Temperature (NOCT)
See table 10.5 —
10.6 Performance at NOCT See table 10.6.2 —
10.7 Performance at low irradiance See table 10.7 —
10.1 Visual inspection (Initial)
Sample No. Nature and position of initial findings —
HV2018001861 — P
HV2018001862 — P
HV2018002027 junction: Junction box gluing unclean, frame: Gluing unclean P
HV2018002028 junction: Junction box gluing unclean, frame: Gluing unclean P
Supplementary information: -
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 6 von 10 Page 6 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
10.4 Measurement of temperature coefficients
Ambient air temperature °C 25 ± 2
—
Irradiance W/m² 1000 ± 50
Module temperature °C high/low 68.2 / 24.4
Sample No. Coefficient Calculated value
HV2018001861
ISC %/°C 0.038
Impp %/°C -0.017*
Uoc %/°C -0.313
Umpp %/°C -0.405
%/°C -0.419
Supplementary information: Temperature coefficients were measured under a flashlight solar simulator.
* Measurement results show a strong and not clear linear variation of Impp over temperature. This is attributed to the fact that the value of Pmpp can remain constant even though its operating point on the IV curve changes slightly. Therefore measurements of temperature coefficient of current at MPP always have high uncertainties. Basing yield predictions on these values is not suggested.
10.4 Measurement of temperature coefficients
Ambient air temperature °C 25 ± 2
—
Irradiance W/m² 1000 ± 50
Module temperature °C high/low 75 / 26.5
Sample No. Coefficient Calculated value
HV2018001862
ISC %/°C 0.033
Impp %/°C -0.030*
Uoc %/°C -0.291
Umpp %/°C -0.370
%/°C -0.393
Supplementary information: Temperature coefficients were measured under a flashlight solar simulator.
* Measurement results show a strong and not clear linear variation of Impp over temperature. This is attributed to the fact that the value of Pmpp can remain constant even though its operating point on the IV curve changes slightly. Therefore measurements of temperature coefficient of current at MPP always have high uncertainties. Basing yield predictions on these values is not suggested.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 7 von 10 Page 7 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
10.5 Measurement of Nominal Operating Cell Temperature (NOCT)
Wind velocity m/s high/low* 1.75 / 0.25
—
Ambient temperature °C high/low* 35.00 / 18.74
Irradiance W/m² high/low* 1124.82 / 400.77
Module temperature °C high/low* 70.62 / 36.15
Number of NOCT Value 1 2 3 4
Wind velocity m/s (average) 0.94 0.95 1.01 0.92
NOCT correction factor °C 2 2 2 0
Calculated NOCT °C 52.35 54.99 51.03 49.58
Number of NOCT Value 5 6 7 8
Wind velocity m/s (average) 1.08 0.89 0.96 1
NOCT correction factor °C 1 0 1 1
Calculated NOCT °C 50.48 51.45 56.04 51.73
Sample No. Average NOCT °C
HV2018001861 52.2
Supplementary information: Primary method was used.
Number of total NOCT values: 8.
*Highest/lowest values of all 8 NOCT values.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 8 von 10 Page 8 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
10.5 Measurement of Nominal Operating Cell Temperature (NOCT)
Wind velocity m/s high/low 1.75 / 0.25
—
Ambient temperature °C high/low 35.00 / 18.74
Irradiance W/m² high/low 1124.82 / 400.77
Module temperature °C high/low 69.79 / 34.8
Number of NOCT Value 1 2 3
Wind velocity m/s (average) 0.94 0.95 1.01
NOCT correction factor °C 2 2 2
Calculated NOCT °C 51.02 52.35 50.40
Number of NOCT Value 4 5
Wind velocity m/s (average) 0.98 0.92
NOCT correction factor °C 1 0
Calculated NOCT °C 46.85 48.68
Sample No. Average NOCT °C
HV2018001862 49.9
Supplementary information: Primary method was used.
Number of total NOCT values: 5.
*Highest/lowest values of all 5 NOCT values.
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 9 von 10 Page 9 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
10.6.1 Performance at STC
Test method indoor outdoor
—
Ambient temperature °C 25 ± 2
Irradiance W/m² 1000 ± 50 corrected to 1000
Module temperature °C 25 ± 2 corrected to 25
Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF %
HV2018001861 319.3 37.26 8.57 45.73 9.07 77.0
HV2018001862 351.6 38.76 9.07 47.54 9.52 77.7
HV2018002027 291.8 32.03 9.11 39.72 9.62 76.4
HV2018002028 265.1 31.05 8.54 38.05 9.04 77.1
Supplementary information: -
10.6.2 Performance at NOCT
Test method indoor outdoor
—
Ambient temperature °C 25 ± 2
Irradiance W/m² 800
Module temperature °C NOCT:
HV2018001861, HV2018002028: 52.2°C
HV2018001862, HV2018002027: 49.9°C
Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF %
HV2018001861 225.0 33.05 6.81 41.35 7.29 74.7
HV2018001862 256.5 35.33 7.26 43.83 7.72 75.8
HV2018002027 211.6 29.13 7.26 36.54 7.75 74.7
HV2018002028 189.8 27.81 6.82 34.52 7.29 75.4
Supplementary information: -
Produkte Products
Prüfbericht-Nr.: 21290449.002 Test Report No.:
Seite 10 von 10 Page 10 of 10
Absatz Photovoltaic (PV) modules Messergebnisse - Bemerkungen Bewertung
Evaluation Clause Anforderungen - Prüfungen / Requirements - Tests Measuring results - Remarks Evaluation
Rev.:01
10.7 Performance at low irradiance
Test method indoor outdoor
—
Ambient temperature °C 25 ± 2
Irradiance W/m² 200 ± 20 corrected to 200
Module temperature °C 25 ± 2 corrected to 25
Sample No. Pmax W Vmpp V Impp A Voc V Isc A FF %
HV2018001861 55.0 35.73 1.54 41.86 1.63 80.5
HV2018001862 63.9 38.13 1.67 44.16 1.76 82.1
HV2018002027 58.0 31.44 1.85 36.73 1.94 81.6
HV2018002028 50.8 29.97 1.70 35.30 1.80 80.1
Supplementary information: -
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 1 von 5 Page 1 of 5
ZUSATZ-DOKUMENTATION
ADDITIONAL DOCUMENTATION
Appendix: History of reporting and certification
No. Project no. Date of issue Result Remarks
001 21243643 17/10/2018 — —
002 21243643 14/11/2018 —
- Chapter 1 “Product details: o Correction of module type
names and update of module power classes
o Minor changes in wording + some supplementary information (e.g. regarding adaptation of some parameters like power classes, tolerances, current, voltage, etc.)
- Chapter “ List of test samples” o Adding of additional information
regarding change of type names - Photo Appendix: Adding of lay-out of
new, updated labels
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 2 von 5 Page 2 of 5
ZUSATZ-DOKUMENTATION
ADDITIONAL DOCUMENTATION
Fig 1: HV201801861- P@STC, P@NOCT
Fig 2: HV2018001861 – P@LI
0.0
0.2
0.4
0.6
0.8
1.0
1.2
1.4
1.6
1.8
0 10 20 30 40 50
Cu
rre
nt
in [A
]
Voltage in [V]
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 3 von 5 Page 3 of 5
ZUSATZ-DOKUMENTATION
ADDITIONAL DOCUMENTATION
Fig 3: HV201801862 – P@STC, P@NOCT
Fig 4: HV2018001862 – P@LI
0.0
0.2
0.4
0.6
0.8
1.0
1.2
1.4
1.6
1.8
2.0
0 10 20 30 40 50
Cu
rre
nt
in [A
]
Voltage in [V]
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 4 von 5 Page 4 of 5
ZUSATZ-DOKUMENTATION
ADDITIONAL DOCUMENTATION
Fig 5: HV2018002027 – P@STC, P@NOCT
Fig 6: HV2018002027 – P@LI
0.0
0.5
1.0
1.5
2.0
2.5
0 10 20 30 40 50
Cu
rre
nt
in [A
]
Voltage in [V]
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 5 von 5 Page 5 of 5
ZUSATZ-DOKUMENTATION
ADDITIONAL DOCUMENTATION
Fig 7: HV2018002028 – P@STC, P@NOCT
Fig 8: HV2018002028 – P@LI
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 1 von 8 Page 1 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS M60-300W (JARASH) PS M60-300W (JARASH)
Label of test sample: PS M60-300W (JARASH) Updated label: PS M60-300W (JARASH)
PS M60-300W (JARASH) PS M60-300W (JARASH)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 2 von 8 Page 2 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS M60-300W (JARASH)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 3 von 8 Page 3 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ)
Label of test sample: PS P60-265W (MAFRAQ) Updated label PS-P60-270W (MAFRAQ)
PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 4 von 8 Page 4 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS P60-265W (MAFRAQ) PS P60-265W (MAFRAQ)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 5 von 8 Page 5 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS M72-xxxW (Amman) PS M72-xxxW (Amman)
Label of test sample: PS M72-365W (Amman) Updated label: PS-M72-365W (AMMAN)
PS M72-365W (Amman)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 6 von 8 Page 6 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS M72-365W (Amman)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 7 von 8 Page 7 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS P72-325W (Aqaba) PS P72-325W (Aqaba)
Label of test sample: PS P72-325W (Aqaba) Updated label: PS-P72-325W (AQABA)
PS P72-325W (Aqaba) PS P72-325W (Aqaba)
Produkte Products
ANLAGE zum Prüfbericht-Nr.: 21290449.002 APPENDIX to Test Report No.:
Seite 8 von 8 Page 8 of 8
FOTO-DOKUMENTATION
PHOTO-DOCUMENTATION
PS P72-325W (Aqaba)