Upload
votruc
View
214
Download
1
Embed Size (px)
Citation preview
2
Step by step, from raw material to final product, quality constitutes a major concern toLiban Cables.
Raw material are continuously and repetitively tested from trial orders till the last batchreceived afterwards.
Products are tested within two simultaneous procedures :
- A built in quality control system carried out by the production itself at any step of workin process.
- A parallel and contradictory procedure is also carried out on the same stages andproducts by independent inspectors reporting to the quality control service.
End users and/or third part inspection authorities are also constantly commissioning thefinished products and assessing the strict conformity to ordered specifications.
In fact, our ISO certification stated in February 1997 and renewed in February 2000 bythe International Certification Network (EQNET) is certified by the French A s s o c i a t i o nfor Quality Assurance (AFAQ), the well known rigourous and independant A c c r e d i t e dEuropean assessor. This certification, under reference A FAQ Nº QUAL / 1997 / 7034,confirms the soudness and the performance of the Quality System we apply for theDesign, the Development, the Manufacturing and the Marketing & Sales of all ourproducts.
For prompt quotation / supplies please make sure your inquiries and your orders are
securing the following data:
1 - International or Special Standard. (Alternatively, the precise usage of the cable.)
2 - Rated voltage.
3 - Copper or Aluminium conductors.
4 - Size of each conductor.
5 - Insulation material : general purpose PVC, special PVC, XLPE or others.
6 - Insulation colour :
- Usual colour are : grey for the neutral and black, red and blue for the phases.
-Any other colour is available on request.
7 - Number of conductors.
8 - Othre requirements.
9 - Packing.
10 - Required delivery time.
11 - Required validity.
2 QUALITY
3 RECOMMENDED ORDERING PARAMETERS
As this catalogue is not intended to cover all of LIBAN CABLES S A L possibilities inLow Tension cables manufacturing, the hereafter listing of the types of cables is notrestrictive but only indicative of the main and most current types we manufacture.
On the other hand, our specification sheets are inspired mainly from InternationalElectrotechnical Commision Specification (IEC) only in order to conform with thesustained trend, noticed both regionally and worlwide, towards these same IEC supposedto inspire any further standardization approaches.
Whereas, in fact, some Low Tension cables may require special conception, fully withinthe capabilities of LIBAN CABLES S A L, ISO 9001 certified, precisely because inposition to conceive / tailor your special needs.
That is why, while consulting this catalogue, it is important to take into account that anycombination or change of the constructional details mentioned in this catalogue remainfeasible, on base of special conception / development, matching any special or diff e r e n tspecifications.
F i n a l l y, and within our policy of constant improvement, we reserve the right to alter anypart of the information contained in this publication without incurring any obligation.In all cases this brochure being only indicative, and unless expressly agreed upon, itcannot be considered by any mean as contractual document.
NOTICE
INTRODUCTION
QUALITY ASSURANCE
RECOMMENDED ORDERING PARAMETERS
GENERALITIES :
Conductors
Properties of Insulating Materials
Determination of the cross sectional area
Current carrying capacities
Buried cables
Cables laid in the air
Voltage Drop
Conductors short circuit current
Minimum bending radius
INDUSTRY AND DISTRIBUTION 0.6/1KV POWER CABLES
Unarmoured PVC or XLPE insulated and PVC sheathed cables
Armoured PVC or XLPE insulated and PVC sheathed cables
Concentric conductors, PVC insulated and sheathed cables
Self supported, aerial cables
Control multicore cables
Aerial Bundled Conductors (TORSADES)
3 phases + Neutral / messenger + Street lighting conductor
2 and 4 aluminium conductors + Pilot copper conductor
TECHNICAL INFORMATION
Formulae
Conversion factors and units
5
4
3
2
1
P a g e
CONTENTS
4.1
4.2
4.3
4.4
5.1
5.2
5.3
5.4
5.5
5.6
1
2
2
3
3
4
4
4
4
6
7
8
8
10
10
20
40
42
47
52
52
54
56
56
57
6.1
6.2
6
4.5
4.6
4.7
4.4.1
4.4.2
5.6.1
5.6.2
NOTICE
1
Devoted to the manufacturing of electric and telecomcables, Liban Cables is the first and largest supplier inLebanon and a leader in the Middle-East region.
Liban Cables was founded in 1968 by a group ofLebanese industrialists backed up by the technicalassistance of two international leading firms :
- Les Cables de Lyon - France (became ALCATEL afterwards)
- Phelps Dodge - U.S.A
Staffed with qualified engineers and highly skilledtechnicians, our plant is located in Nahr-Ibrahim at 30Km from Beirut, where cables are designed andmanufactured according to all internationalspecifications : IEC, VDE, UTE, BS, and others oncustomer request.
Early after its foundation, Liban Cables has become themajor supplier of the Lebanese market in both thepublic and private sectors. The product range of LibanCables covers all electric cables up to 36 KV,communications cables (copper and optical fiber) inaddition to a wide variety of special cablesmanufactured on customer request.
High quality cables, continuous developments of theproduction range, direct and fast shipments havecontributed in rendering Liban Cables an importantexporter for many countries on the three limitrophecontinents (Asia, Europe, Africa). Liban Cablesproducts are particularly appreciated by administrationsand international contractors operating in the region andseeking reliable and direct supplies of power andcommunication cables.
INTRODUCTION
11
2
Step by step, from raw material to final product, quality constitutes a major concern toLiban Cables.
Raw material are continuously and repetitively tested from trial orders till the last batchreceived afterwards.
Products are tested within two simultaneous procedures :
- A built in quality control system carried out by the production itself at any step ofwork in process.
- A parallel and contradictory procedure is also carried out on the same stages andproducts by independent inspectors reporting to the quality control service.
End users and/or third part inspection authorities are also constantly commissioning thefinished products and assessing the strict conformity to ordered specifications.
QUALITY ASSURANCE
2
3 RECOMMENDED ORDERING PARAMETERS
For prompt quotation / supplies please make sure your inquiries and your orders aresecuring the following data :
1 - International or Special Standard. (Alternatively, the precise usage of thecable.)
2 - Rated voltage.
3 - Copper or Aluminium conductors.
4 - Size of each conductor.
5 - Insulation material : general purpose PVC, special PVC, XLPE or others.
6 - Number of conductors.
7 - Other requirements.
8 - Packing.
9 - Required delivery time.
10 - Required validity.
N.B.: Liban Cables certification to ISO 9001 is planned for January 1997.
4.1 CONDUCTORS
The commonly used conductors materials are copper and aluminium meeting therequirements of IEC 60228.
Theoretical characteristics of copper and aluminium are as follows :
4 GENERALITIES
Copper(mm2)
Aluminium(mm2)
610162535507095120150185
10162535507095150185240300
3
Equivalent standardized cross sectional area at equal voltage drop
Specific Gravity (kg/dm3)
Resistivity at 20˚C (Ohm. mm2/m)
Breaking Load (daN/mm2)
Elongation at break (%)
Annealed Copper Annealed Aluminium
8.9
17.241 x 10-3
23 to 25
20 to 40
2.7
28.264 x 10-3
12 to 15
1 to 4
4.3 DETERMINATION OF THE CROSS SECTIONAL AREA
The determination of the cross sectional area depends on the :
- Current carrying capacities in continuous loading,- Voltage drop in continuous loading- Permissible short-circuit current,- Conditions of installation (temperature, spacing, ...).
4.4 CURRENT CARRYING CAPACITIES
The heat produced by the cable under the set conditions must be able to dissipate to theambient environment at any point of the cable installation; therefore the loading of thecable must be limited accordingly. The current carrying capacities shown in theelectrical characteristics tables are calculated according to the internationally adoptedmethod of the IEC publication 60287 for a maximum core temperature of 70˚C forPVC insulated cables and 90˚C for XLPE insulated cables, at the following installationconditions :
4.4.1. BURIED CABLES
The stated values are for cables or ducts placed in the ground at a depth of 600 mm ofaverage thermal resistivity of 100˚C.cm/w and spaced so that the temperature rise ineach duct has no effect on the other ducts ( space being greater than 1 meter ), for a soiltemperature of 20˚C.
4.2 PROPERTIES OF INSULATING MATERIALS
PVC PE XLPE
Specific gravity (kg/dm3)
Dielectric constant
Breaking load (bars) min.
Elongation at break min.
Max. continuous operatingtemperature (˚C)
Max. short circuittemperature (˚C)
Moisture proof
Flame proof
Flexibility
Insulation resistance constant, Kiat 20˚C (Megohm x km)
MATERIAL
1.3 - 1.5
5 - 8
100 - 200
150 %
70 - 105
160
Good
Very good
Good
5000
0.92 - 0.97
2.3
100
350 %
70
150
Very good
Poor
Poor
> 20.000
0.92 - 1.18
2.5
125 - 150
200 %
90
250
Very good
Poor
Poor
> 20.000
4
DIMENSIONAL CHARACTERISTICS
DOUBLE STEEL TAPE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.80.81.01.01.01.01.21.2
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.983.384.254.955.826.838.429.55
1415161820222527
274470
107179284450624
259302390485625805
11201410
...
...
...
...5587
138191
...
...
...
...500610810975
100010001000100010001000500500
mm mm
InnerSheath
1.01.01.01.01.01.01.01.0
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.81.92.12.32.42.52.72.93.1
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
14151719212326263033394248515763
4066
105160269426675945
12791848256232423978499065578226
285338448560730975
139015301990272039904800590071509100
11200
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...545680920875
11001440221025503140369045505500
100010001000100010001000500500500500500250250250250250
THREE CORE
1.01.01.01.01.01.01.01.01.01.21.21.21.41.41.41.6
34
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE
mm mm
InnerSheath
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.92.12.22.42.52.72.93.13.3
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
5388
140213358568900
12591705246434174323530566548743
10969
322388520660875
118017101970262038605100625075509300
1185014600
...
...
...
...110174275385521754
104413201621202326723352
...
...
...
...625785
1090110014402150273032503870468058007000
100010001000100010001000500500500500500250250250250250
1.01.01.01.01.01.01.01.01.21.21.21.41.41.61.61.6
15161820222528303439444852586470
Ph.1.21.21.41.41.61.61.82.02.22.4
1.81.82.02.12.32.42.62.72.93.1
28283236424649546066
817108615042163298938584594584576389552
16001740232031404570565066508200
1045012850
249333460662914
11791404178623342919
1030925
12801640250029703460414051506200
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.1.01.01.21.21.41.41.41.61.61.8
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.8.42shapedshaped
N.6.836.838.42
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
1.01.01.01.21.21.41.41.41.61.6
DIMENSIONAL CHARACTERISTICS
35
DOUBLE STEEL TAPE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
3041536791
115146176212261313358400451522590680
...
...
...
...6790
114137165204244279312352407460530
23.314.2
9.06.13.72.31.51.10.90.60.50.40.40.30.30.20.2
...
...
...
...6.13.82.41.71.41.00.70.60.50.40.30.30.2
223040527196
127157190242293339390444522595695
...
...
...
...557599
125151192232269309353415472552
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
36
DOUBLE STEEL TAPE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
DIMENSIONAL CHARACTERISTICS
DOUBLE STEEL TAPE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.70.70.70.70.70.70.90.9
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.783.183.654.355.226.237.828.95
1414151719212426
274470
107179284450624
251293348434570735
10401340
...
...
...
...5587
138191
...
...
...
...446540730905
100010001000100010001000500500
mm mm
InnerSheath
1.01.01.01.01.01.01.01.0
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.81.92.02.12.32.42.62.83.0
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
14151617192225252831354046495559
4066
105160269426675945
12781848256232423978499065578325
274326395500675895
128014301850254033904560570068008700
10650
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...490600810775965
1260161023102940334041504840
100010001000100010001000500500500500500250250250250250
THREE CORE
1.01.01.01.01.01.01.01.01.01.01.21.21.41.41.61.6
37
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE
mm mm
InnerSheath
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.81.92.12.32.42.62.83.03.2
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
5388
140213358568900
12591705246434174323530566548743
10969
307371457585790
109015801830238033304790590071508850
1130013900
...
...
...
...110174275385521754
104413201621203326723352
...
...
...
...540695955955
12001620242029003470423052506300
100010001000100010001000500500500500500250250250250250
1.01.01.01.01.01.01.01.01.01.21.21.21.41.41.61.6
15161719212327273136414550556167
Ph.0.90.91.01.11.11.21.41.61.71.8
1.81.81.92.12.22.42.52.72.93.0
26272934394347525863
817108615042163298938584594584576389552
14701630214029704260535063007850
1000012000
249333460662914
11791404178623342919
900875
11001470219026703110379047005550
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.0.70.70.90.91.01.11.11.11.21.4
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.7.82shapedshaped
N.6.236.237.82
shapedshapedshapedshapedshapedshapedshaped
1.01.01.01.21.21.21.41.41.61.6
DIMENSIONAL CHARACTERISTICS
38
DOUBLE STEEL TAPE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
34465974
101128162195235290347397444500578655754
...
...
...
...79
100126152183226271310346390452512588
24.814.8
9.26.23.72.41.61.20.870.640.480.400.350.290.240.230.22
...
...
...
...6.13.92.51.91.41.00.750.600.500.420.330.300.28
2737506488
119157194235299362419481549645735859
...
...
...
...6993
122151183234282327375428503575670
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
39
DOUBLE STEEL TAPE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
2. CONSTRUCTION
2.1 Conductor
Plain, annealed electrolytic copper con-ductors, solid, circular stranded, or sec-toral stranded conforming to the ap-plicable requirements of IEC 60228.
2.2 Insulation
PVC based thermoplastic material con-forming to the applicable requirementsof VDE 0209.
2.3 Assembly
Insulated conductors are laid up, filledwhere necessary with non-hygroscopicmaterial and covered with an additionallayer of extruded thermoplastic materi-al or a PVC binding tape.
2.4 Concentric Conductor
Bare, plain, annealed electrolytic cop-per wires are layed over the commoncovering of cores with a counter helixof copper tape on top.
2.5 Sheath
PVC based thermoplastic material, con-forming to the applicable requirementsof VDE 0209.
2.6 TESTS
Conforming to the applicable re-quirements of relative specifications.
5.3 CONCENTRIC CONDUCTOR, PVC INSULATED AND SHEATHED 0.6 / 1 KV POWER CABLES
4 2 1
3 2 1
3
54
4 PVC sheath
5 Bedding
3 Concentric copper wires
2 PVC insulation
1 Stranded circular copper conductor
40
1. SCOPE
This specification covers circular, single, twin, three or four PVC insulatedconductors with a concentric conductor over the assembly of cores, rated 0.6/1KV,type NYCY to VDE 0271; for use in aerial, direct burial, conduit, open tray andundergroud duct installations, These cables offer high resistance to ageing,abrasion, moisture, chemicals, oils and acids and afford protection of phasecoductors against external ingress.
Where the thermal resistivity is different (not 100˚ C.cm/w) the current rating shouldbe multiplied by the correction factors shown in the following table.
Nature of the soil Soil thermal resistivity˚C.cm/w Correction factor
405070
1.251.211.13
Very wet soil
85100
1.051.00
Normal soil
120150
0.940.86
Dry soil
200250300
0.760.700.65
Very dry soil
05
10
1520253035404550
Soiltemperature
(˚C)
651.201.151.11
1.0510.940.880.820.750.670.58
701.181.141.10
1.0510.950.890.840.770.710.63
Carrying core temperature (˚C)
751.171.131.09
1.0410.950.900.850.800.740.67
801.151.121.08
1.0410.960.910.870.820.760.71
851.141.111.07
1.0410.960.920.880.830.780.73
901.131.101.07
1.0410.960.930.890.850.800.76
951.131.101.06
1.0310.970.930.890.860.820.77
1001.121.091.06
1.0310.970.940.900.870.830.79
1051.111.081.06
1.0310.970.940.910.870.840.80
Correction factor for different soil thermal resistivity
Correction factor for different soil temperatures
Where the temperature of the soil is different (not 20˚C) the current rating should bemultiplied by the following correction factors.
5
When several cables or ducts are laid underground with less than one meter spacing thecurrent rating values should be multiplied by the following correction factors :
Number ofcircuits
Touchingcables
One diameterspaced cables
a = D
2
3
4
5
6
0.76
0.64
0.57
0.52
0.49
0.79
0.67
0.61
0.56
0.53
0.84
0.74
0.69
0.65
0.60
0.88
0.79
0.75
0.71
0.69
0.92
0.85
0.82
0.80
0.78
a = 0.25m a = 0.5m a = 1.0m
4.4. 2. CABLES LAID “ IN AIR ” :
The stated values are for cables or ducts laid “ in air ” with an ambient temperature of30˚C and out of direct sunlight, spaced so that the temperature rise of individual cableshas no influence on others. The spacing between adjacent cables is at least twice thecable or duct diameter.When the ambient temperature is different ( not 30˚C ) the current rating values shouldbe multiplied by the following correction factors :
Ambienttemperature (˚C)
05
101520253035404550556065707580859095
100
Carrying core temperature (˚C)
1.361.311.251.201.131.0710.930.850.760.650.530.38
1.321.271.221.171.121.0610.940.870.790.710.610.500.35
1.291.251.201.151.111.0510.940.880.820.750.670.580.470.33
1.261.221.181.141.101.0510.950.890.840.770.710.630.550.450.32
1.241.211.171.131.091.0410.950.900.850.800.740.670.600.520.430.30
1.221.191.151.121.081.0410.960.910.870.820.760.710.650.580.500.410.29
1.211.181.141.111.071.0410.960.920.880.830.780.730.680.620.550.480.390.28
1.201.161.131.101.071.0410.960.930.890.850.800.760.710.650.600.530.460.380.27
1.181.151.131.101.061.0310.970.930.890.860.820.770.730.680.630.580.520.450.370.26
65 70 75 80 85 90 95 100 105
Correction factor of proximity effect for underground cables
D = overall outer sheath diameter a = Space between cables
Correction factor for different ambient temperatures
Single or multicore cables
6
When several cables are grouped, the current ratings values should be corrected asfollows :
ad
H
a & HNumber of layers
1234561
Number of cables
1
1.000.920.850.820.800.791.00
Distance
≥ 2d
1/4d to 2d
≤ 1/4d
No proximity effect2
0.940.870.810.780.760.750.80
3
0.910.840.780.740.720.710.70
4
0.880.810.760.730.710.700.65
5
0.870.800.750.720.700.690.60
6
0.860.790.740.720.700.680.57
Correction of proximity effect for Cables in air
4.5 VOLTAGE DROP
In addition to the current rating, the determination of the cross sectional area shouldensure that the selected cable size is capable to carry the required current betweensending and receiving ends of line with a maximum of 3 % in voltage drop for lightingpurpose circuits and 5 % for others.
The voltage drop values shown in the electrical characteristics tables are in V/A x Kmcalculated for a maximum core temperature of 70˚C for PVC cables and 90˚C forXLPE cables.
The voltage drop between sending and receiving ends of line is :DU = U1 - U2 in VoltsDU = U1 - U2 x 100 in %
U1
In D.C.In Single phaseIn three phase
:::
DU = 2 l RIDU = 2 l I ( R cos ϕ + LW sin ϕ )DU = l I√3 ( R cos ϕ + LW sin ϕ )
7
Voltage drop in voltCable length in kmCurrent rating in AmperConductor resistance at the maximum operating temperature in Ohm/kmInductance in H/kmPulsation = 2 πF = 314 for F = 50 HzPower factor
0.1446424375458436351557538439
4.6 CONDUCTORS SHORT - CIRCUIT CURRENT
Current densities given in the table below are in (A / mm2 ), for different insulationmaterials and different overload time.
Temperatureof conductors
overload in secs0.2315300237324309248394380311
0.5199189150205195158249241196
Copper AluminiumConductor metal
Current density ( A / mm2 )
For an overload duration (t) different than those figured in the above table, thecorrespondant current density is given by the following formula :
Current density for a duration (t) = Current density for 1 sec
√ t
WhereDUlIRLWcos ϕ
=======
material
PE
PVC
XLPE
Initial˚C
Final˚C
203070203070203090
150
160
250
1141134106145138111176170139
999575
1029879
12412098
2 0.1294278221304284231367354288
0.2208197156215210163260254203
13112599
135127104164159129
0.5938870969073
11611291
1 2666349686452827965
4.7 MINIMUM BENDING RADIUS
Listed values represent the permanent bending radius the cables withstand in fixedinstallation and on dispatching reels. Other constraints may impose greater bendingradius.
Unarmoured single core cables
Unarmoured multi core cables
Armoured cables - steel tapes
- steel wires
Cable on drum Cable duringinstallation
Installed Cable
18 D
12 D
16 D
20 D
9 D
6 D
8 D
10 D
D = Overall diameter in mm
9 D
6 D
8 D
10 D
8
5 INDUSTRIAL AND DISTRIBUTION 0.6 / 1KV POWER CABLES
1. SCOPE
This specification covers single, two,three or four core cables, PVC or XLPEinsulated and PVC sheathed, rated at 0.6/1KV, unarmoured type to InternationalElectrotechnical Commission PublicationIEC 60502-1 for use in cable ducts andindoors and for underground burial, wherethey are not likely to suffer mechanicaldamage.
The cables have excellent thermalproperties, high dielectric strength andhigh resistance to ageing, abrasion,moisture, chemicals, acids and oils.
2. CONSTRUCTION
2.1 Conductor
Plain, annealed electrolytic copper oraluminium conductors, solid, circularstranded, or sectoral stranded; conformingto the applicable requirements of IEC228.
2.2 Insulation
PVC based thermoplastic or XLPEthermosetting material, conforming tothe applicable requirements of IEC 60502-1.
2.3 Assembly
Insulated conductors are laid up, filledwhere necessary with non-hygroscopicmaterial and covered with an additionallayer of extruded thermoplasticmaterial or non-hygroscopic bindingtape.
2.4 Sheath
PVC based thermoplastic material,conforming to the applicablerequirements of IEC 60502-1.
2.5 TESTS
Conforming to the applicablerequirements of IEC 60502-1 either onraw materials or on finished products.
5.1 UNARMOURED, PVC OR XLPE INSULATED AND PVC SHEATHED CABLES
1
Stranded circular copper oraluminium conductor
*stranded sectoral copper oraluminium conductor
2 PVC or XLPE insulation
3 PVC Sheath
3 2 1
3 2 1
3 2 1*
10
DIMENSIONAL CHARACTERISTICS
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
1 x 1.51 x 2.51 x 41 x 61 x 101 x 161 x 251 x 351 x 501 x 701 x 951 x 1201 x 1501 x 1851 x 2401 x 3001 x 4001 x 5001 x 6301 x 800
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.42.62.82.82.8
1.41.41.41.41.41.41.41.41.41.41.51.51.61.71.81.92.02.12.22.3
1.381.782.252.953.824.836.027.158.30
10.0011.8013.3014.8016.5519.4021.3024.1027.3 31.0 37.1
2.983.384.254.955.826.838.429.55
11.1012.8015.0016.5018.4020.5523.8026.1029.3032.9036.6042.70
5.96.37.27.98.79.8
1213141619202225283134384248
1322355389
141223309418604838
105912991630214326883439433555977203
496286
113160225332434565775
1060130015901990259032104070510064508250
...
...
...
...28436895
128185256324398499655822
1051132517102188
...
...
...
...99
127177220275356478565690860
110013401680209025603240
100010001000100010001000500500500500500500500500500500500500500250
SINGLE CORE
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.80.81.01.01.01.01.21.2
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.983.384.254.955.826.838.429.55
1111131516192224
274470
107179284450624
131164233306425590870
1130
...
...
...
...5587
138191
...
...
...
...301393560695
100010001000100010001000500500
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
11
DIMENSIONAL CHARACTERISTICS
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.81.81.92.12.22.32.52.72.9
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
11121415172023242730353844465259
4066
105160269426675945
12791848256232423978499065578226
152194279373530750
112013101730239032804060500062008050
10050
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...343454650655840
1110150018102240274035004340
100010001000100010001000500500500500500250250250250250
THREE CORE
FOUR CORE
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.81.92.12.22.32.52.72.93.2
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
12131517192125273034394347535966
5388
140213358568900
12591705246434174323530566548743
10969
180232337456655940
14101730232032204400545066508350
1080013500
...
...
...
...110174275385521754
104413201621203326723352
...
...
...
...310545785855
11401510203024502970373047305900
100010001000100010001000500500500500500250250250250250
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
12
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
Ph.1.21.21.41.41.61.61.82.02.22.4
1.81.81.92.02.22.32.42.62.83.0
24262932384144505662
817108615042163298938584595584576389552
132015302080285038904890580073509500
11800
249333460662914
11791404178623342919
750775
10401350182022102610329042005150
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.1.01.01.21.21.41.41.41.61.61.8
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.8.42shapedshaped
N.6.836.838.42
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
13
Where the thermal resistivity is different (not 100˚ C.cm/w) the current rating shouldbe multiplied by the correction factors shown in the following table.
Nature of the soil Soil thermal resistivity˚C.cm/w Correction factor
405070
1.251.211.13
Very wet soil
85100
1.051.00
Normal soil
120150
0.940.86
Dry soil
200250300
0.760.700.65
Very dry soil
05
10
1520253035404550
Soiltemperature
(˚C)
651.201.151.11
1.0510.940.880.820.750.670.58
701.181.141.10
1.0510.950.890.840.770.710.63
Carrying core temperature (˚C)
751.171.131.09
1.0410.950.900.850.800.740.67
801.151.121.08
1.0410.960.910.870.820.760.71
851.141.111.07
1.0410.960.920.880.830.780.73
901.131.101.07
1.0410.960.930.890.850.800.76
951.131.101.06
1.0310.970.930.890.860.820.77
1001.121.091.06
1.0310.970.940.900.870.830.79
1051.111.081.06
1.0310.970.940.910.870.840.80
Correction factor for different soil thermal resistivity
Correction factor for different soil temperatures
Where the temperature of the soil is different (not 20˚C) the current rating should bemultiplied by the following correction factors.
5
When several cables or ducts are laid underground with less than one meter spacing thecurrent rating values should be multiplied by the following correction factors :
Number ofcircuits
Touchingcables
One diameterspaced cables
a = D
2
3
4
5
6
0.76
0.64
0.57
0.52
0.49
0.79
0.67
0.61
0.56
0.53
0.84
0.74
0.69
0.65
0.60
0.88
0.79
0.75
0.71
0.69
0.92
0.85
0.82
0.80
0.78
a = 0.25m a = 0.5m a = 1.0m
4.4. 2. CABLES LAID “ IN AIR ” :
The stated values are for cables or ducts laid “ in air ” with an ambient temperature of30˚C and out of direct sunlight, spaced so that the temperature rise of individual cableshas no influence on others. The spacing between adjacent cables is at least twice thecable or duct diameter.When the ambient temperature is different ( not 30˚C ) the current rating values shouldbe multiplied by the following correction factors :
Ambienttemperature (˚C)
05
101520253035404550556065707580859095
100
Carrying core temperature (˚C)
1.361.311.251.201.131.0710.930.850.760.650.530.38
1.321.271.221.171.121.0610.940.870.790.710.610.500.35
1.291.251.201.151.111.0510.940.880.820.750.670.580.470.33
1.261.221.181.141.101.0510.950.890.840.770.710.630.550.450.32
1.241.211.171.131.091.0410.950.900.850.800.740.670.600.520.430.30
1.221.191.151.121.081.0410.960.910.870.820.760.710.650.580.500.410.29
1.211.181.141.111.071.0410.960.920.880.830.780.730.680.620.550.480.390.28
1.201.161.131.101.071.0410.960.930.890.850.800.760.710.650.600.530.460.380.27
1.181.151.131.101.061.0310.970.930.890.860.820.770.730.680.630.580.520.450.370.26
65 70 75 80 85 90 95 100 105
Correction factor of proximity effect for underground cables
D = overall outer sheath diameter a = Space between cables
Correction factor for different ambient temperatures
Single or multicore cables
6
When several cables are grouped, the current ratings values should be corrected asfollows :
ad
H
a & HNumber of layers
1234561
Number of cables
1
1.000.920.850.820.800.791.00
Distance
≥ 2d
1/4d to 2d
≤ 1/4d
No proximity effect2
0.940.870.810.780.760.750.80
3
0.910.840.780.740.720.710.70
4
0.880.810.760.730.710.700.65
5
0.870.800.750.720.700.690.60
6
0.860.790.740.720.700.680.57
Correction of proximity effect for Cables in air
4.5 VOLTAGE DROP
In addition to the current rating, the determination of the cross sectional area shouldensure that the selected cable size is capable to carry the required current betweensending and receiving ends of line with a maximum of 3 % in voltage drop for lightingpurpose circuits and 5 % for others.
The voltage drop values shown in the electrical characteristics tables are in V/A x Kmcalculated for a maximum core temperature of 70˚C for PVC cables and 90˚C forXLPE cables.
The voltage drop between sending and receiving ends of line is :DU = U1 - U2 in VoltsDU = U1 - U2 x 100 in %
U1
In D.C.In Single phaseIn three phase
:::
DU = 2 l RIDU = 2 l I ( R cos ϕ + LW sin ϕ )DU = l I√3 ( R cos ϕ + LW sin ϕ )
7
Voltage drop in voltCable length in kmCurrent rating in AmperConductor resistance at the maximum operating temperature in Ohm/kmInductance in H/kmPulsation = 2 πF = 314 for F = 50 HzPower factor
0.1446424375458436351557538439
4.6 CONDUCTORS SHORT - CIRCUIT CURRENT
Current densities given in the table below are in (A / mm2 ), for different insulationmaterials and different overload time.
Temperatureof conductors
overload in secs0.2315300237324309248394380311
0.5199189150205195158249241196
Copper AluminiumConductor metal
Current density ( A / mm2 )
For an overload duration (t) different than those figured in the above table, thecorrespondant current density is given by the following formula :
Current density for a duration (t) = Current density for 1 sec
√ t
WhereDUlIRLWcos ϕ
=======
material
PE
PVC
XLPE
Initial˚C
Final˚C
203070203070203090
150
160
250
1141134106145138111176170139
999575
1029879
12412098
2 0.1294278221304284231367354288
0.2208197156215210163260254203
13112599
135127104164159129
0.5938870969073
11611291
1 2666349686452827965
4.7 MINIMUM BENDING RADIUS
Listed values represent the permanent bending radius the cables withstand in fixedinstallation and on dispatching reels. Other constraints may impose greater bendingradius.
Unarmoured single core cables
Unarmoured multi core cables
Armoured cables - steel tapes
- steel wires
Cable on drum Cable duringinstallation
Installed Cable
18 D
12 D
16 D
20 D
9 D
6 D
8 D
10 D
D = Overall diameter in mm
9 D
6 D
8 D
10 D
8
5 INDUSTRIAL AND DISTRIBUTION 0.6 / 1KV POWER CABLES
1. SCOPE
This specification covers single, two,three or four core cables, PVC or XLPEinsulated and PVC sheathed, rated at 0.6/1KV, unarmoured type to InternationalElectrotechnical Commission PublicationIEC 60502-1 for use in cable ducts andindoors and for underground burial, wherethey are not likely to suffer mechanicaldamage.
The cables have excellent thermalproperties, high dielectric strength andhigh resistance to ageing, abrasion,moisture, chemicals, acids and oils.
2. CONSTRUCTION
2.1 Conductor
Plain, annealed electrolytic copper oraluminium conductors, solid, circularstranded, or sectoral stranded; conformingto the applicable requirements of IEC228.
2.2 Insulation
PVC based thermoplastic or XLPEthermosetting material, conforming tothe applicable requirements of IEC 60502-1.
2.3 Assembly
Insulated conductors are laid up, filledwhere necessary with non-hygroscopicmaterial and covered with an additionallayer of extruded thermoplasticmaterial or non-hygroscopic bindingtape.
2.4 Sheath
PVC based thermoplastic material,conforming to the applicablerequirements of IEC 60502-1.
2.5 TESTS
Conforming to the applicablerequirements of IEC 60502-1 either onraw materials or on finished products.
5.1 UNARMOURED, PVC OR XLPE INSULATED AND PVC SHEATHED CABLES
1
Stranded circular copper oraluminium conductor
*stranded sectoral copper oraluminium conductor
2 PVC or XLPE insulation
3 PVC Sheath
3 2 1
3 2 1
3 2 1*
10
DIMENSIONAL CHARACTERISTICS
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
1 x 1.51 x 2.51 x 41 x 61 x 101 x 161 x 251 x 351 x 501 x 701 x 951 x 1201 x 1501 x 1851 x 2401 x 3001 x 4001 x 5001 x 6301 x 800
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.42.62.82.82.8
1.41.41.41.41.41.41.41.41.41.41.51.51.61.71.81.92.02.12.22.3
1.381.782.252.953.824.836.027.158.30
10.0011.8013.3014.8016.5519.4021.3024.1027.3 31.0 37.1
2.983.384.254.955.826.838.429.55
11.1012.8015.0016.5018.4020.5523.8026.1029.3032.9036.6042.70
5.96.37.27.98.79.8
1213141619202225283134384248
1322355389
141223309418604838
105912991630214326883439433555977203
496286
113160225332434565775
1060130015901990259032104070510064508250
...
...
...
...28436895
128185256324398499655822
1051132517102188
...
...
...
...99
127177220275356478565690860
110013401680209025603240
100010001000100010001000500500500500500500500500500500500500500250
SINGLE CORE
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.80.81.01.01.01.01.21.2
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.983.384.254.955.826.838.429.55
1111131516192224
274470
107179284450624
131164233306425590870
1130
...
...
...
...5587
138191
...
...
...
...301393560695
100010001000100010001000500500
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
11
DIMENSIONAL CHARACTERISTICS
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.81.81.92.12.22.32.52.72.9
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
11121415172023242730353844465259
4066
105160269426675945
12791848256232423978499065578226
152194279373530750
112013101730239032804060500062008050
10050
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...343454650655840
1110150018102240274035004340
100010001000100010001000500500500500500250250250250250
THREE CORE
FOUR CORE
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.81.92.12.22.32.52.72.93.2
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
12131517192125273034394347535966
5388
140213358568900
12591705246434174323530566548743
10969
180232337456655940
14101730232032204400545066508350
1080013500
...
...
...
...110174275385521754
104413201621203326723352
...
...
...
...310545785855
11401510203024502970373047305900
100010001000100010001000500500500500500250250250250250
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
12
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
Ph.1.21.21.41.41.61.61.82.02.22.4
1.81.81.92.02.22.32.42.62.83.0
24262932384144505662
817108615042163298938584595584576389552
132015302080285038904890580073509500
11800
249333460662914
11791404178623342919
750775
10401350182022102610329042005150
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.1.01.01.21.21.41.41.41.61.61.8
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.8.42shapedshaped
N.6.836.838.42
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
13
DIMENSIONAL CHARACTERISTICS
CONCENTRIC CONDUCTOR PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to VDE 271 / 3.69
TYPE : NYCY
Radial Thickness of Lengthon
drum
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable
mm2 mm mmmm mm Kg/Km Kg/Km m
OuterSheath
Nominalcross
section* Insulation
TWO CORE
0.91.01.01.01.01.2
1.81.81.81.81.81.8
1.782.252.953.824.836.02
3.584.254.955.826.838.42
9.39.09.9121315
4369
101175283443
112147197287413580
100010001000100010001000
mm
0.91.01.01.01.01.2
1.81.81.81.81.82.0
1.782.252.953.824.836.02
3.584.254.955.826.838.42
151718212429
87130207353567902
315380505710
10301530
10001000100010001000500
FOUR CORE
0.80.80.80.81.22.2
* - Solid conductor for sizes up to and including 4 mm2.- Stranded circular conductor for sizes of 6 mm2 and above.- Greater sections also available
1x 2.5 +2.51 x 4 + 41 x 6 + 61 x 10 +101 x 16 + 161 x 25 + 25
3x 2.5 + 2.53 x 4 + 43 x 6 + 63 x 10 + 103 x 16 + 163 x 25 + 25
41
Current carrying capacity**
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
DC Resistance at 20˚C* Underground CableTwo Core Three core Two Core Three core
Cables in air
Nominalcross
section
Amp
Voltage DropCos ϕ = 0.8
Two Core Three core
V/A x Km V/A x Km
2.546101625
7.414.613.081.831.15
0.727
41536791
115146
36465879
100132
14.29.06.13.72.31.5
12.37.85.33.22.01.3
2635466385
112
2432415776
100
* At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
** Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w- In air : Ambient temperature 30˚C
1. SCOPE
This specification covers PVC or XLPEinsulated, multicore, self supportingcables rated 0.6/1KV; for use outdoorsin overhead and surface mountingapplications on walls, in street lightingand other overhead electricalapplications. These cables have highdielectric strength, excellent aging,thermal, chemical and mechanicalproperties which make them highlyresistant to the most strenuous weatherconditions.
2. CONSTRUCTION
2.1 Conductor
Plain, annealed electrolytic copper or al-uminium conductors, solid, circularstranded conforming to the applicable re-quirements of IEC 60228.
2.2 Insulation
PVC based thermoplastic or XLPE ther-mosetting material conforming to the ap-plicable requirements of VDE 0209.
2.3 Assembly
Insulated conductors are laid up, filledwith non-hygroscopic material and cov-ered with an extruded thermoplastic ma-terial or a PVC binding tape.
2.4 Suspension strand
Torsion free strand of galvanized steelwires, laid up together parallel to the as-sembly of cores under a common PVCsheath.
2.5 Sheath
PVC based thermoplastic material si-multaneously covering steel supporter andassembly of cores and conforming to theapplicable requirements of VDE 0209.
2.6 TESTS
Conforming to the applicable re-quirements of relative specifications.
4 PVC sheath
5 Stranded galvanized steel wires
3 Bedding
2 PVC or XLPE insulation
1Stranded circular copperor aluinium conductor
5.4 SELF SUPPORTED, AERIAL, PVC OR XLPE INSULATED,0.6 / 1 KV POWER CABLES
42
4
2
1
3
5
43
DIMENSIONAL CHARACTERISTICS
SELF SUPPORTED AERIAL PVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to VDE 0271 / 3.69
Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableSheathNominal
crosssection*
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 25
0.80.81.01.01.01.01.2
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.983.384.254.955.826.838.42
274470
107179284450
252285352427545710990
...
...
...
...5587
138
...
...
...
...421515680
100010001000100010001000500
mm
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 25
0.80.81.01.01.01.01.2
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.983.384.254.955.826.838.42
4066
105160269426675
273315400494650870
1240
...
...
...
...82
130206
...
...
...
...463575770
100010001000100010001000500
THREE CORE
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
RadialThickness
ofInsulation
FOUR CORE
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 25
0.80.81.01.01.01.01.2
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.983.384.254.955.826.838.42
5388
140213358568900
301353458575775
10601530
...
...
...
...110174275
...
...
...
...525665905
100010001000100010001000500
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
* - Solid conductor for sizes up to and including 4 mm2.- Stranded circular conductor for remaining sizes.- Different sections also available.
Sizeof thesteel
messenger
nbr./dia
7.27.27.27.27.27.27.2
11121415171922
21222425272932
7.27.27.27.27.27.27.2
12131416182023
22232426283033
7.27.27.27.27.27.27.2
12141517192226
22242527293236
Current carrying capacity (3)
mm2 Ω/Km Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C (1)
AluCopper
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.546101625
...
...
...
...3.081.911.20
12.17.414.613.081.831.150.727
223040527196
127
23.314.29.06.13.72.31.5
...
...
...
...6.13.82.4
...
...
...
...557599
Copper
44
SELF SUPPORTED AERIAL PVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to VDE 0271 / 3.69
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) Ambient temperature 30˚C
45
DIMENSIONAL CHARACTERISTICS
SELF SUPPORTED AERIAL XLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to VDE 0271 / 3.69
Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableSheathNominal
crosssection*
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 25
0.70.70.70.70.70.70.9
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.783.183.654.355.226.237.82
274470
107179284450
241272316383496650915
...
...
...
...5587
138
100010001000100010001000500
mm
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 25
0.70.70.70.70.70.70.9
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.783.183.654.355.226.237.82
4066
105160269426675
258299356441590795
1140
...
...
...
...82
130206
...
...
...
...403500670
100010001000100010001000500
THREE CORE
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
RadialThickness
ofInsulation
Sizeof thesteel
messenger
FOUR CORE
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 25
0.70.70.70.70.70.70.9
1.81.81.81.81.81.81.8
1.381.782.252.953.824.836.02
2.783.183.654.355.226.237.82
5388
140213358568900
282333405510700970
1410
...
...
...
...110174275
...
...
...
...452575785
100010001000100010001000500
7/1.27/1.27/1.27/1.27/1.27/1.27/1.2
* - Solid conductor for sizes up to and including 4 mm2.- Stranded circular conductor for remaining sizes.- Different sections also available.
nbr./dia
...
...
...
...372
14561605
7.27.27.27.27.27.27.2
10111213151721
20212223252731
7.27.27.27.27.27.27.2
11121314161822
21222324262832
7.27.27.27.27.27.27.2
11121415172024
21222425273034
Current carrying capacity (3)
mm2 Ω/Km Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C (1)
AluCopper
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.546101625
...
...
...
...3.081.911.20
12.17.414.613.081.831.150.727
2737506488
119157
24.814.89.26.23.72.41.6
...
...
...
...6.13.92.5
...
...
...
...6993122
Copper
46
SELF SUPPORTED AERIAL XLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to VDE 0271 / 3.69
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) Ambient temperature 30˚C
47
1. SCOPEThis specification covers multicorecables for signalisation and control pur-poses, PVC insulated and sheathed rat-ed 0.6 / 1 KV; to International Electro-technical Commission IEC 60502-1,for use in cable ducts and indoors andfor underground burial. High re-sistance to deformations under hightemperature and pressure, and high re-sistance to ageing, abrasion, moisture,chemicals, acids and oils.
2. CONSTRUCTION
2.1 ConductorPlain, annealed electrolytic copper con-ductors, solid or circular stranded con-forming to the applicable requirementsof IEC 60228.
2.2 InsulationPVC based thermoplastic or XLPEthermosetting material conforming tothe applicable requirements of IEC 60502-1.
2.3 AssemblyInsulated conductors are laid up, filledwhere necessary with non-hygroscopicmaterial or covered with a layer of non-hygroscopic tape.The assembly is covered with an extrudedlayer of PVC in armoured cables.
2.4 Armour ( in armoured cables )Galvanized steel wires or double steeltapes, covering the assembly of cores,complying to the applicable re-quirements of IEC 60502-1.
2.5 SheathPVC based thermoplastic material con-forming to the applicable requirementsof IEC 60502-1.
2.6 TESTSConforming to the applicable re-quirements of IEC 60502-1 either onraw materials or on finished products.
5.5 CONTROL, PVC OR XLPE INSULATED AND PVC SHEATHEDMULTICORE CABLES.
3
2
1
4
2
1
5
3
4 Bedding
5Round galvanized steelwire armour
3 PVC sheath
2 PVC or XLPE insulation
1Solid circular copperconductor
DIMENSIONAL CHARACTERISTICS
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV CONTROLE CABLES
Conforming to IEC 60502-1
Radial Thickness of Lengthon
drum
Nominal Diameters Approximative net weight
Conductor Insulation Overall Copper Cable
mm mmmm mm Kg/Km Kg/Km m
OuterSheathInsulation
CONDUCTOR 1.5 mm2
mm
Number*
ofConductors
1.81.81.81.81.81.81.81.81.81.81.81.9
1.381.381.381.381.381.381.381.381.381.381.381.38
2.982.982.982.982.982.982.982.982.982.982.982.98
0.80.80.80.80.80.80.80.80.80.80.80.8
131415171718202324262729
6692
105131157184249314393484524628
1000100010001000100010001000100010001000500500
CONDUCTOR 2.5 mm2
578
101214192430374048
1.81.81.81.81.81.81.81.81.81.91.92.0
1.781.781.781.781.781.781.781.781.781.781.781.78
3.383.383.383.383.383.383.383.383.383.383.383.38
0.80.80.80.80.80.80.80.80.80.80.80.8
141516181920222526293033
1091531752182623054145236538068711045
277325375448515585755940
1140139015001790
1000100010001000100010001000100010001000500500
48
* Greater number of conductors also available.
578
101214192430374048
212244281332378428545680815975
10501250
49
DIMENSIONAL CHARACTERISTICS
ARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV CONTROLE CABLES
Conforming to IEC 60502-1
Radial Thickness of Lengthon
drum
Nominal Diameters Approximative net weight
Conductor Insulation Overall Copper Cable
mm mmmm mm Kg/Km Kg/Km m
OuterSheathInsulation
CONDUCTOR 1.5 mm2
mm mm
InnerSheath
Number*
ofConductors
578
101214192430374048
1.81.81.81.81.81.81.81.81.91.92.02.1
1.381.381.381.381.381.381.381.381.381.381.381.38
2.982.982.982.982.982.982.982.982.982.982.982.98
0.80.80.80.80.80.80.80.80.80.80.80.8
1.01.01.01.01.01.01.01.01.01.01.01.0
171819212324252830323336
6692
105131147184249314393484524628
455520575670
10301080126015001700192020202560
10001000100010001000100010001000500500500500
CONDUCTOR 2.5 mm2
578
101214192430374048
1.81.81.81.81.81.81.81.92.02.12.12.2
1.781.781.781.781.781.781.781.781.781.781.781.78
3.383.383.383.383.383.383.383.383.383.383.383.38
0.80.80.80.80.80.80.80.80.80.80.80.8
1.01.01.01.01.01.01.01.01.01.01.21.2
181920242525273133363740
109153175218262305414523653806871
1045
535625700
111012001310155018702130269028903310
1000100010001000100010001000500500500500500
* Greater number of conductors also available.
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400500630800
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.07780.06050.04690.0367
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.04700.03660.02830.0221
3041536791
115146176212261313358400451522590680769870979
...
...
...
...6790
114137165204244279312352407460530599678763
23.314.2
9.06.13.72.31.51.10.90.60.50.40.40.30.30.20.20.20.20.2
...
...
...
...6.13.82.41.71.41.00.70.60.50.40.30.30.20.20.20.2
223040527196
127157190242293339390444522595695780885990
...
...
...
...557599
125151192232269309353415472552618705790
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
UNARMOURED, PVC INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
14
ELECTRICAL CHARACTERISTICS
DIMENSIONAL CHARACTERISTICS
UNARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
1 x 1.51 x 2.51 x 41 x 61 x 101 x 161 x 251 x 351 x 501 x 701 x 951 x 1201 x 1501 x 1851 x 2401 x 3001 x 4001 x 5001 x 6301 x 800
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.81.92.22.42.6
1.41.41.41.41.41.41.41.41.41.41.51.51.61.61.71.81.92.02.22.3
1.381.782.252.953.824.836.027.158.3010.0011.8013.3014.8016.5519.4021.3024.1027.0031.0037.10
2.783.183.654.355.226.237.828.9510.312.2014.0015.7017.6019.7522.8024.9028.1031.7035.8042.30
5.76.16.67.38.19.2
1112141618192124272933364148
1322355389
141223309418604838
105912991630214326883439433555977203
45577499
144206307406525735
1000124015201890246030603890487062508050
...
...
...
...28436895
128185256324398499655822
1051132517102188
...
...
...
...83
108152192235316418505620760970
11901500186023703040
100010001000100010001000500500500500500500500500500500500500500250
SINGLE CORE
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.70.70.70.70.70.70.90.9
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.783.183.654.355.226.237.828.95
1011121315172123
274470
107179284450624
120151195262375530795
1040
...
...
...
...5587
138191
...
...
...
...251333483605
100010001000100010001000500500
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
15
DIMENSIONAL CHARACTERISTICS
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.81.81.92.02.12.32.42.62.8
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
11121314161822222529323642445054
4066
105160269426675945
12781848256232423978499065578325
137178235320470675
1020122016102270306038404760590076509550
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...283379550565725985
128015902000244031003740
100010001000100010001000500500500500500250250250250250
THREE CORE
FOUR CORE
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.81.92.02.12.32.42.62.83.0
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
11121415172024252833374145505662
5388
140213358568900
12591705246434174323530566548743
10969
161212284391580850
12901620215030304100515063507950
1030012850
...
...
...
...110174275385521754
104413201621202326723352
...
...
...
...332456665745965
1320173021502670333042305250
100010001000100010001000500500500500500250250250250250
UNARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
16
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section * Insulation
Ph.0.90.91.01.11.11.21.41.61.71.8
1.81.81.81.92.12.22.32.52.72.9
23242631353942475359
817108615042163298938584594584576389552
120014201910267036204630550070009000
11200
249333460662914
11791404178623342919
630665865
1170150019502310294037004570
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.0.70.70.90.91.01.11.11.11.21.4
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.7.82shapedshaped
N.6.236.237.82
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Grater sections also available
UNARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
17
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400500630800
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.07780.06050.04690.0367
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.04700.03660.02830.0221
34465974
101128162195235290347397444500578655754852961
1081
...
...
...
...79
100126152183226271310346390452512588665750844
24.814.8
9.26.23.72.41.61.20.870.640.480.400.350.290.240.230.220.220.210.21
...
...
...
...6.13.92.51.91.41.00.750.600.500.420.330.300.280.270.260.26
2737506488
119157194235299362419481549645735859960
10961235
...
...
...
...6993
122151183234282327375428503575670750855955
UNARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
18
20
5.2 ARMOURED, PVC OR XLPE INSULATED AND PVC SHEATHED CABLES
1. SCOPE
This specification covers PVC or XLPE insulated, circular, twin, three or fourconductors armoured cables, rated at 0.6/1 KV to international Electrotechnicalcommission Publication IEC 60502-1 for use indoors, outdoors, in cable ducts, inwater and for direct burial underground, where severe mechanical stresses arepresent. These cables have high dielectric strength, an excellent resistance todeformations under high temperature and pressure, and high resistance to ageing,abrasion, moisture, chemicals, acids and oils.
2. CONSTRUCTION
2.1 Conductor
Plain, annealed electrolytic copper or Aluminium conductors, solid, circularstranded, or sectoral stranded, conforming to the applicable requirements of IEC60228.
2.2 Insulation
PVC based thermoplastic or XLPE thermosetting material, conforming to theapplicable requirements of IEC 60502-1.
2.3 Assembly
Insulated conductors are laid up, filled where necessary with non-hygroscopicmaterial and covered with an extruded thickness of thermoplastic material.
2.4 Armour
Galvanized round wires, or flat strips, completely covering the assembly of coresand a counter helix of galvanized steel tape on top; or two layers of steel tape,complying to the applicable requirements of IEC 60502-1.
2.5 Sheath
PVC based thermoplastic material, conforming to the applicable requirements ofIEC 60502-1.
2.6 TESTS
Conforming to the applicable requirements of IEC 60502-1 either on Raw materialsor on finished products.
1
Stranded circular copper oraluminium conductor
*stranded sectoral copper oraluminium conductor
2 PVC or XLPE insulation
3 Bedding
4Galvanized flat steel striparmour with flat steel tapeapplied in helical form
6 Double steel tape armoured
7 Galvanized round steelwire armour
5 PVC or PE sheath
12345
12365
12375
1*2365
1*2345
1*2375
21
5.2 ARMOURED, PVC OR XLPE INSULATED AND PVC SHEATHED CABLES
DIMENSIONAL CHARACTERISTICS
GALVANIZED STEEL WIRE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.80.81.01.01.01.01.21.2
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.983.384.254.955.826.838.429.55
1516171921242830
274470
107179284450624
345394496605760
127016602000
...
...
...
...5587
138191
...
...
...
...635
107013501570
100010001000100010001000500500
mm mm
InnerSheath
1.01.01.01.01.01.01.01.0
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.81.92.12.22.32.52.62.83.03.2
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
15161820232529293437424652556166
4066
105160269426675945
12791848256232423978499065578226
374434560685
1170147019602140292037504800610073508700
1080013100
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...985
11701490148020302470302038504590520062507400
100010001000100010001000500500500500500250250250250250
THREE CORE
1.01.01.01.01.01.01.01.01.01.21.21.21.41.41.41.6
22
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE
mm mm
InnerSheath
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.80.81.01.01.01.01.21.21.41.41.61.61.82.02.22.4
1.81.81.81.81.81.81.92.02.22.32.52.62.83.03.23.4
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.983.384.254.955.826.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
5388
140213358568900
12591705246434174323530566548743
10969
417490640795
135017202350264036504670645077009100
111001385017600
...
...
...
...110174275385521754
104413201621202326723352
...
...
...
...11001330173017702470296040804700540065007800
10000
100010001000100010001000500500500500500250250250250250
1.01.01.01.01.01.01.01.01.21.21.21.41.41.61.61.6
16171921252731323741475156616875
Ph.1.21.21.41.41.61.61.82.02.22.4
1.91.92.12.22.42.52.72.83.03.2
30313539444953586470
817108615042163298938584594584576389552
22202400329042405450705081509850
1230014850
249333460662914
11791404178623342919
1650165022502740338043704960580070008200
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.1.01.01.21.21.41.41.41.61.61.8
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.8.42shapedshaped
N.6.836.838.42
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
1.01.01.01.21.21.41.41.41.61.6
23
GALVANIZED STEEL WIRE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
3041536791
115146176212261313358400451522590680
...
...
...
...6790
114137165204244279312352407460530
23.314.2
9.06.13.72.31.51.10.90.60.50.40.40.30.30.20.2
...
...
...
...6.13.82.41.71.41.00.70.60.50.40.30.30.2
223040527196
127157190242293339390444522595695
...
...
...
...557599
125151192232269309353415472552
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
24
GALVANIZED STEEL WIRE ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
DIMENSIONAL CHARACTERISTICS
GALVANIZED STEEL WIRE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 1.52 x 2.52 x 42 x 62 x 102 x 162 x 252 x 35
0.70.70.70.70.70.70.90.9
1.81.81.81.81.81.81.81.8
1.381.782.252.953.824.836.027.15
2.783.183.654.355.226.237.828.95
1415161819212629
274470
107179284450624
327372434535685880
15501880
...
...
...
...5587
138191
...
...
...
...560685
12401450
100010001000100010001000500500
mm mm
InnerSheath
1.01.01.01.01.01.01.01.0
3 x 1.53 x 2.53 x 43 x 63 x 103 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.82.02.12.22.42.62.72.93.1
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
15161718202428283135394350535863
4066
105160269426675945
12791848256232423978499065578226
354419490610795
135018201990249035004480540071508300
1035012450
...
...
...
...82
130206289391565783990
1216152520042514
...
...
...
...610
10501350133016002220270031504390484058006650
100010001000100010001000500500500500500250250250250250
THREE CORE
1.01.01.01.01.01.01.01.01.01.01.21.21.41.41.61.6
25
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE
mm mm
InnerSheath
4 x 1.54 x 2.54 x 44 x 64 x 104 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.70.70.70.70.70.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.81.81.81.81.92.12.22.42.52.72.93.13.3
1.381.782.252.953.824.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2.783.183.654.355.226.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
5388
140213358568900
12591705246434174323530566548743
10969
388459560705935
15702160247033404430565072508700
105001320015950
...
...
...
...110174275385521754
104413201621202326723352
...
...
...
...685
11801540160021602720328042505000590071508350
100010001000100010001000500500500500500250250250250250
1.01.01.01.01.01.01.01.01.01.21.21.21.41.41.61.6
15161819222530313540444953596571
Ph.0.90.91.01.11.11.21.41.61.71.8
1.81.92.02.22.32.42.62.83.03.1
29303338424651566267
817108615042163298938584594584576389552
20502240305040805100625077509400
1175014150
249333460662914
11791404178623342919
1480149020102580303035704560535064507500
500500500500500250250250250250
FOUR CORE WITH REDUCED NEUTRAL
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.0.70.70.90.91.01.11.11.11.21.4
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.7.82shapedshaped
N.6.236.237.82
shapedshapedshapedshapedshapedshapedshaped
1.01.01.01.21.21.21.41.41.61.6
26
GALVANIZED STEEL WIRE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
34465974
101128162195235290347397444500578655754
...
...
...
...79
100126152183226271310346390452512588
24.814.8
9.26.23.72.41.61.20.870.640.480.400.350.290.240.230.22
...
...
...
...6.13.92.51.91.41.00.750.600.500.420.330.300.28
2737506488
119157194235299362419481549645735859
...
...
...
...6993
122151183234282327375428503575670
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
27
GALVANIZED STEEL WIRE ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
DIMENSIONAL CHARACTERISTICS
GALVANIZED STEEL STRIP ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 162 x 252 x 35
1.01.21.2
1.81.81.8
4.836.027.15
6.838.429.55
232628
284450624
108014401760
87138191
88511301330
1000500500
mm mm
InnerSheath
1.01.01.0
3 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
1.01.21.21.41.41.61.61.82.02.22.4
1.81.81.82.02.12.22.32.52.62.83.0
4.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
6.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2427283135394249515763
426675945
12791848256232423978499065578226
1260173018902420319041605000615073509300
11600
130206289391565783990
1216152520042514
9651260123015301910238027503390389047505900
1000500500500500500250250250250250
THREE CORE
1.01.01.01.01.21.21.21.41.41.41.6
FOUR CORE
4 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
1.01.21.21.41.41.61.61.82.02.22.4
1.81.81.92.12.22.42.52.72.83.13.3
4.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
6.838.42
shapedshapedshapedshapedshapedshapedshapedshapedshaped
568900
12591705246434174323530566548743
10969
150020802370308040405350650078009700
1230015100
174275385521754
104413201621202326723352
11001460150019002330298035004120510062507500
1000500500500500500250250250250250
1.01.01.01.21.21.21.41.41.61.61.6
2630313539444852586571
28
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE WITH REDUCED NEUTRAL
mm mm
InnerSheath
Ph.1.21.21.41.41.61.61.82.02.22.4
1.81.92.02.12.32.42.52.72.93.1
29303337424649546167
817108615042163298938584594584576389552
19602140276036304770590068508500
1090013300
249333460662914
11791404178623342919
1390139017202130270032203660444056006650
500500500500500250250250250250
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.1.01.01.21.21.41.41.41.61.61.8
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.8.42shapedshaped
N.6.836.838.42
shapedshapedshapedshapedshapedshapedshaped
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available.
1.01.01.01.21.21.41.41.41.61.6
29
GALVANIZED STEEL STRIP ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
3041536791
115146176212261313358400451522590680
...
...
...
...6790
114137165204244279312352407460530
23.314.2
9.06.13.72.31.51.10.90.60.50.40.40.30.30.20.2
...
...
...
...6.13.82.41.71.41.00.70.60.50.40.30.30.2
223040527196
127157190242293339390444522595695
...
...
...
...557599
125151192232269309353415472552
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
GALVANIZED STEEL STRIP ARMOUREDPVC INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
30
31
DIMENSIONAL CHARACTERISTICS
GALVANIZED STEEL STRIP ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
TWO CORE
2 x 162 x 252 x 35
0.70.90.9
1.81.81.8
4.836.027.15
6.237.828.95
222527
284450624
98513401650
87138191
79010301220
1000500500
mm mm
InnerSheath
1.01.01.0
3 x 163 x 253 x 353 x 503 x 703 x 953 x 1203 x 1503 x 1853 x 2403 x 300
0.70.90.91.01.11.11.21.41.61.71.8
1.81.81.81.92.02.22.32.42.62.82.9
4.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
6.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
2326262933374047495559
426675945
12781848256232423978499065578325
1160160017702230297039004760585070508950
11000
130206289391565783990
1216152520042514
8651130115013401690212025103090359044005200
1000500500500500500250250250250250
THREE CORE
1.01.01.01.01.01.21.21.41.41.61.6
FOUR CORE
4 x 164 x 254 x 354 x 504 x 704 x 954 x 1204 x 1504 x 1854 x 2404 x 300
0.70.90.91.01.11.11.21.41.61.71.8
1.81.81.92.02.12.32.42.62.83.03.2
4.836.02
shapedshapedshapedshapedshapedshapedshapedshapedshaped
6.237.82
shapedshapedshapedshapedshapedshapedshapedshapedshaped
568900
12591705246434174323530566548743
10969
138019302220282038305000610074009150
1180014400
174275385521754
104413201621203326723352
9851310135016402120263031003720453057506800
1000500500500500500250250250250250
1.01.01.01.01.21.21.21.41.41.61.6
2428293237414550556268
GALVANIZED STEEL STRIP ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
Radial Thickness of Lengthon
drumCable
Nominal Diameters Approximative net weight
Conductor Insulation Overall Conductor Cable Conductor
mm2 mm mmmm mm Kg/Km Kg/Km Kg/Km Kg/Km m
Copper cable Aluminium cableOuterSheath
Nominalcross
section* Insulation
FOUR CORE WITH REDUCED NEUTRAL
mm mm
InnerSheath
Ph.0.90.91.01.11.11.21.41.61.71.8
1.81.81.92.12.22.32.52.62.83.0
27283135394347525864
817108615042163298938584594584576389552
18101990256034504470555065508100
1040012700
249333460662914
11791404178623342919
1240124015201950240028703360404051006050
500500500500500250250250250250
3 x Ph. +N.3 x 25+163 x 35 + 163 x 50 + 253 x 70 + 353 x 95 + 503 x 120+703 x 150+703 x 185+953x240+1203x300+150
N.0.70.70.90.91.01.11.11.11.21.4
Ph.6.02shapedshaped
N.4.834.836.02
shapedshapedshapedshapedshapedshapedshaped
Ph.7.82shapedshaped
N.6.236.237.82
shapedshapedshapedshapedshapedshapedshaped
1.01.01.01.21.21.21.41.41.61.6
32
* - Solid conductor for sizes up to and including 4 mm2.- Stranded sectoral conductor for sizes of 35 mm2 and above in three and four core cables.- Stranded circular conductor for remaining sizes.- Greater sections also available.
Current carrying capacity (3)
mm2 Ω/Km Amp Amp Amp
ELECTRICAL CHARACTERISTICS
Alu
Ω/Km
DC Resistance at 20˚C(1)
Underground CableCopper Alu Copper Alu
CopperCables in air
Nominalcross
section
Amp
Voltage Drop (2)
Cos ϕ = 0.8
Copper Alu
V/A x Km V/A x Km
1.52.54610162535507095120150185240300400
...
...
...
...3.081.911.200.8680.6410.4430.3200.2530.2060.1640.1250.1000.0778
12.17.414.613.081.831.150.7270.5240.3870.2680.1930.1530.1240.09910.07540.06010.0470
34465974
101128162195235290347397444500578655754
...
...
...
...79
100126152183226271310346390452512588
24.814.8
9.26.23.72.41.61.20.870.640.480.400.350.290.240.230.22
...
...
...
...6.13.92.51.91.41.00.750.600.500.420.330.300.28
2737506488
119157194235299362419481549645735859
...
...
...
...6993
122151183234282327375428503575670
(1) At different operating T(˚C) : R = R20˚C 1+ α (T˚C - 20)α : Temperature coefficient at 20˚C = 0.00393 for copper & 0.00403 for aluminium
(2) In three phase system decrease above listed voltage drop by 15%(3) a) Laying conditions : - Underground : Temperature of the soil 20˚C - Thermal resistivity 100˚C cm/w
- In air : Ambient temperature 30˚Cb) In three phase system decrease above listed current ratings by 10%
33
GALVANIZED STEEL STRIP ARMOUREDXLPE INSULATED, PVC SHEATHED
0.6 / 1 KV POWER CABLESConforming to IEC 60502-1
DIMENSIONAL CHARACTERISTICS
UNARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV CONTROLE CABLES
Conforming to IEC 60502-1
Radial Thickness of Lengthon
drum
Nominal Diameters Approximative net weight
Conductor Insulation Overall Copper Cable
mm mmmm mm Kg/Km Kg/Km m
OuterSheathInsulation
CONDUCTOR 1.5 mm2
mm
Number*
ofConductors
578
101214192430374048
1.81.81.81.81.81.81.81.81.81.81.81.8
1.381.381.381.381.381.381.381.381.381.381.381.38
2.782.782.782.782.782.782.782.782.782.782.782.78
0.70.70.70.70.70.70.70.70.70.70.70.7
121314161617192123242527
6692
105131157184249314393484524628
189216246293355375515635710845910
1070
1000100010001000100010001000100010001000500500
CONDUCTOR 2.5 mm2
578
101214192430374048
1.81.81.81.81.81.81.81.81.81.81.81.9
1.781.781.781.781.781.781.781.781.781.781.781.78
3.183.183.183.183.183.183.183.183.183.183.183.18
0.70.70.70.70.70.70.70.70.70.70.70.7
131415171819212425272830
1091531752182623054145236538068711045
251293336403462525675840
1020123013201570
1000100010001000100010001000100010001000500500
50
* Greater number of conductors also available.
51
DIMENSIONAL CHARACTERISTICS
ARMOURED, XLPE INSULATED, PVC SHEATHED0.6 / 1 KV CONTROLE CABLES
Conforming to IEC 60502-1
Radial Thickness of Lengthon
drum
Nominal Diameters Approximative net weight
Conductor Insulation Overall Copper Cable
mm mmmm mm Kg/Km Kg/Km m
OuterSheathInsulation
CONDUCTOR 1.5 mm2
mm mm
InnerSheath
Number*
ofConductors
578
101214192430374048
1.81.81.81.81.81.81.81.81.81.81.92.0
1.381.381.381.381.381.381.381.381.381.381.381.38
2.782.782.782.782.782.782.782.782.782.782.782.78
0.70.70.70.70.70.70.70.70.70.70.70.7
1.01.01.01.01.01.01.01.01.01.01.01.0
161718202023242728303134
6692
105131157184249314393484524628
433493530615685
1000116013701530174018402320
10001000100010001000100010001000500500500500
CONDUCTOR 2.5 mm2
578
101214192430374048
1.81.81.81.81.81.81.81.81.81.82.02.2
1.781.781.781.781.781.781.781.781.781.781.781.78
3.183.183.183.183.183.183.183.183.183.183.183.18
0.70.70.70.70.70.70.70.70.70.70.70.7
1.01.01.01.01.01.01.01.01.01.01.01.2
171819232425263031343538
109153175218262305414523653806871
1045
505580645
104011201210143017201950246025703040
1000100010001000100010001000500500500500500
* Greater number of conductors also available.
Phase and street lighting conductors :
Round stranded and compactedaluminium conforming to the applicablerequirements of IEC 60228.
Neutral / Messenger Conductor :
Round stranded and compactedaluminium alloy conforming to theapplicable requirements of IEC 60208.
Insulation :
Extruded black XLPE.
Design :
The cable consist of three phaseconductors and one or two optionalstreet lighting conductors strandedarround the messenger.
Core identification :
Either by longitunal ridges or bynumbering.
Marking :
Embossed on the phase insulation.
5.6 AERIAL BUNDLED CONDUCTORS (TORSADES)
5.6.1 - 3 PHASES + NEUTRAL / MESSENGER + STREET LIGHTING CONDUCTOR
1 23
MA
RK
ING
2
1
3
4
5
CHARACTERISTICS OF THE NEUTRAL / MESSENGER CONDUCTOR
Nominal cross sectional area
Diameter of the Conductor
Diameter over the insulation
Breaking load
Elasticity Modulus
Linear dilatation factor
( mm2 )
( mm )
( mm )
( daN )
( MPA )
min.
max.
min.
54.6
9.2
12.3
13.0
1660
62000
23 x 10-6
(7/3.15)70
10
13.1
13.6
2000
62000
23 x 10-6
(7/3.45)
1 Stranded Aluminium alloyconductor (Neutral / Messenger)
2 XLPE Insulation
3 Stranded Aluminium conductor(Phase or street lighting conductor)
5 Marking
4 XLPE Insulation
52
53
TECHNICAL CHARACTERISTICS
AERIAL BUNDLED CONDUCTORS (TORSADES03 PHASES + NEUTRAL / MESSENGER + STREET LIGHTING CONDUCTOR
Conforming to NFC 33 - 209
Conductors Insulation
mm2 mm
Nominalcross
section phase
mm mm
streetlighting
weight
Kg/Km
DC Resistance at20˚C
Current carryingcapacity
phase streetlighting phase street
lighting
Ω/Km Ω/Km Amp
phase
mm mm
Overall
Nominal Diameters
Amp
3 x 25+54.63 x 25+54.6+163 x 25+54.6+2x16
3 x 35+54.63 x 35+54.6+163 x 35+54.6+2x16
3 x 50+54.63 x 50+54.6+163 x 50+54.6+2x16
3 x 70+54.63 x 70+54.6+163 x 70+54.6+2x16
3 x 70 + 703 x 70 + 70+163 x 70 + 70+2x16
3 x 150 + 703 x 150+70+163 x 150+70+2x16
5.85.85.8
6.86.86.8
7.97.97.9
9.79.79.7
9.79.79.7
13.913.913.9
-4.64.6
-4.64.6
-4.64.6
-4.64.6
-4.64.6
-4.64.6
8.68.68.6
10.210.210.2
11.211.211.2
13.313.313.3
13.313.313.3
17.317.317.3
-7.17.1
-7.17.1
-7.17.1
-7.17.1
-7.17.1
-7.17.1
242526.5
24.625.527.5
2728.530
3032.233
323334
404142
531600670
644713781
773841990
994106311431
103411031172
168417531822
1.2001.2001.200
0.8680.8680.868
0.6410.6410.641
0.4430.4430.443
0.4430.4430.443
0.2060.2060.206
-1.9101.910
-1.9101.910
-1.9101.910
-1.9101.910
-1.9101.910
-1.9101.910
979797
118118118
141141141
180180180
213213213
335335335
-7474
-7474
-7474
-7474
-7474
-7474
streetlighting
5.6.2 - 2 and 4 ALUMINIUM CONDUCTORS + PILOT COPPER CONDUCTORCONFORMING TO NFC 33 - 209
1 Stranded Aluminium conductor
2 XLPE Insulation
3 Marking
Phase Conductor
Pilot Conductor
4
5 XLPE Insulation
Solid Copper Conductor
TECHNICAL CHARACTERISTICS
Nominal Diameters
Overall
mm
Conductormin.
InsulationNominal
CrossSection
2x162x254x164x252x16+2x1.54x16+2x1.52x25+2x1.54x25+2x1.5
mm2
max.Weight
DCResistance
at 20˚C
CurrentCarryingCapacity
VoltageDrop
Breaking load of eachConductor
min. max.min.
mm
7.08.77.08.77.07.08.68.6
4.76.04.76.04.64.55.85.8
mm
7.99.67.99.67.87.89.49.4
14.818.217.821.816.017.419.521.6
mm
140213280426191328270486
Kg/Km
1.911.201.911.201.911.911.201.20
Ω/Km
831087497837410897
Amp
3.982.543.282.183.983.283.542.18
V/A Km
190300190300190190300300
daN
290450290450290290450450
daN
1 2
MA
RK
ING
2
3
4
5
3
1
54
x S U x ∆u U
2 L Ix S
6.1 Formulae
U = RI
2Lx S
P(w) = U I
P(w) = U I cos ϕ
P (w)
UP(VA) P (W)
U cos ϕU
P(VA) P (W)
U 3 cos ϕU 3
W = RI2 t
P(w) = √3 U I cos ϕ
Ohms law
Joules law
Resistance of a line(feed and return)
DC Power
Single phase Power
Three phase Power
AC Single core current
DC Current
AC Three phase current
Efficiency P outputP input
Voltage drop
Three phasesystem
Voltage drop Size ∆u (v) mm2
If current known
2 L Ix ∆u
If power known2 L P(w) 2L P(w)x S U x ∆u U
If current known
1.73 L I cos ϕ 1.73 L I cos ϕx S x ∆u
If power known
L P(w) L P(w)
Nature of the current
Single phaseAC/DC systems
U
IRW
tL1x11S1P1Cosϕe∆u
=11
===1==1=11=1=1===
Rated Voltage in V(volts)(between phase in threephase system).
Current in A (Amperes).
Resistance in (ohms).
Energy in Ws (Wattsecond).
Time in s (second)
Length of cable in m(meter).
Conductivity (56 forcopper and 34 forAluminium).
Cross sectional area inmm2.
Power in W (Watt) orVA (Volt Ampere).
Power factor.
Efficiency.
Voltage drop sending toreceiving end of line inV(Volts).
R =
I =
I = =
I = =
e =
∆u =
∆u =
∆u =
∆u =
S =
S =
S =
S =
6 TECHNICAL INFORMATION
56
6.2 Conversion factors and units
The SI unit for power is the W1W = 0.102 Kgm / s = 1.359 x 10-3 HP = 3.412 BTU / h1 Kgm / s = 9.81 W = 0.0133 HP = 33.47 BTU / h1HP = 735.5 W = 75 Kgm / s = 2510 Btu /h1 BTu /h = 0.2931 W = 0.0298 Kgm / s = 0.393 x 10-3 HP
w = watt, Kgm / s = Kilogramme meter per second,HP = metric Horse power, BTU /h = British thermal unit per hour
The SI unit for force is the N1N = 0.10197 Kgf = 0.2248 Lbf1Kgf = 9.80665 N = 2.2046 Lbf1Lbf = 4.4482 N = 0.4536 Kgf
N = Newton, Kgf = Kilogram force, Lbf = pound force
The SI unit for length is the m1m = 102 cm = 103 mm = 10-3 Km1m = 39.37 in = 3.28 ft = 1.0936 Yd = 0.6214 x 10-3 miles1 in = 0.0254 m = 0.0833 ft = 0.0277 Yd = 0.0158 x 10-3 miles1 ft = 0.3048 m = 12 in = 0.333 Yd = 0.189 x 10-3 miles1 Yd = 0.9144 m = 36 in = 3 ft = 0.568 x 10-3 miles1 mile = 1609 m = 63360 in = 5280 ft = 1760 Yd
m = meters, in = inches, ft = feet, Yd = Yards
The SI unit for volume is the m3
1m3 = 10 dm3 = 106 cm3 = 109 mm3
1m3 = 1000 L = 35.315 ft3 = 219.97 I.gal = 264.17 U.S. gal1L = 0.001 m3 = 0.0353 ft3 = 0.21997 I.gal = 0.26417 U.S. gal1 ft3 = 28.317x10-3 m3 = 28.317 L = 6.2288 I.gal = 7.479 U.S. gal1 I.gal = 4.546 x 10-3 m3 = 4.546 L = 0.1605 ft3 = 1.2009 U.S. gal1 U.S. gal = 3.7854 x 10-3 m3 = 3.785 L = 0.1366 ft3 = 0.8327 I. gal
l = liters, ft = feet, I.gal = Imperial gallon, U.S.gal = United States gallon
Length :
Weight :
Volume :
Force :
Power :
The SI unit for weight is the Kg1 Kg = 103 g = 10-3 T (metric ton)1 Kg = 2.20462 lb = 35.27 oz1 oz = 28.349 x 10-3 Kg = 0.0625 lb
Kg = Kilogrammes, lb = pounds, oz = ounces
57
The SI unit for pressure is the Pa = 1 N/m2
1 N /m2 = 10-5 Kgf / cm2 = 10-5 bar1Kgf / cm2 = 105 N / m2 = 1 bar
Pa = Pascal, N/m2 = Newton per square meterKgf / cm2 = Kilogramme force per square centimeter
Pressure :
Work : The SI unit for work is the J1J = 1Ws (Wattsecond) = 1Nm (Newton meter)1J = 0.2778 x 10-6 Kwh = 0.239 x 10-3 Kcal1Kwh = 3.6 x 106 J = 859.8 Kcal1Kcal = 4186.8 J = 1.163 x 10-3 Kwh
J = Joules, Kwh = Kilowatt hour, Kcal = Kilocalories
Temperature : The SI unit for Temperature is the Kelvin (K)Temperature in o C = Temperature in o K - 273 = 5/9 (Temperature in o F - 32)
Temperature in o K = Temperature in o C + 273o C = degree celcius, o K = degree Kelvin, o F = degree Fahrenheit
58