1_index

TITLERev. 13

EC 135 T2 (CPDS)APPROVED ROTORCRAFT

FLIGHT MANUAL

Valid for Model / Variant: EC135 T2 (CPDS)

Registration Mark:

Serial No.:

Year of Manufacture:

IT IS THE OPERATORS RESPONSIBILITY TO MAINTAIN THIS MANUAL IN A CURRENT STATUSIN ACCORDANCE WITH THE LIST OF EFFECTIVE PAGES.

This manual is part of the above designated helicopter. It includes the material to be furnished to thepilot as required by JAR-27.

The Airworthiness Limitations section of the Rotorcraft Maintenance Manual shall be complied with.

THIS MANUAL MUST BE CARRIED IN THE HELICOPTER AT ALL TIMES.

Original Issue - AUGUST 09, 2002

Luftfahrt-BundesamtBraunschweig

Approved by:Published by:

EUROCOPTER DEUTSCHLAND GmbH

This page is printed under user's responsibility and must not be retained for reference

TITLEAPPROVING AUTHORITIESMANUAL CONTENTLORRORROSRLEPROTRROIVROOTOOM1. GENERAL / 2. PAGE NUMBERING3. EFFECTIVITY STATEMENTS4. REVISION SERVICE

Section 1 TABLE OF CONTENTS1.1 INTRODUCTION / 1.2 ORGANIZATION OF THE MANUAL1.3 GENERAL DESCRIPTION OF THE HELICOPTER1.4 HELICOPTER DIMENSIONS1.5 NOISE LEVELS / 1.6 CONVERSION CHARTS1.7 TERMINOLOGY AND DEFINITIONS OF TERMS1.8 ABBREVIATIONS AND SYMBOLS

Section 2 TABLE OF CONTENTS2.1 GENERAL / 2.2 KINDS OF OPERATION / 2.3 BASIS OF CERTIFICATION / 2.4 MINIMUM FLIGHT CREW / MAXIMUM NUMBER OF OCCUPANTS / 2.5 FLIGHT WITH OPTIONAL EQUIPMENT INSTALLED2.6 MASS AND LOAD LIMITS2.7 CENTER OF GRAVITY LIMITATIONS2.8 AIRSPEED LIMITATIONS2.9 ALTITUDE LIMITATIONS2.10 ENVIRONMENTAL OPERATING CONDITIONS2.11 ROTOR RPM LIMITATIONS2.12 ENGINE AND TRANSMISSION POWER LIMITATIONS2.13 OTHER ENGINE AND TRANSMISSION LIMITATIONS2.14 FUEL LIMITATIONS2.15 OIL LIMITATIONS2.16 HYDRAULIC SYSTEM LIMITATIONS / 2.17 OPERATIONAL LIMITATIONS2.18 INSTRUMENT MARKINGS2.19 PLACARDS AND DECALS

Section 3 TABLE OF CONTENTS3.1 GENERAL3.2 WARNINGS AND CAUTIONS3.3 CPDS MALFUNCTIONS3.4 ENGINE EMERGENCY CONDITIONS3.5 FIRE EMERGENCY CONDITIONS3.6 TAIL ROTOR FAILURE CONDITIONS3.7 SYSTEM EMERGENCY/MALFUNCTION CONDITIONS

Section 4 TABLE OF CONTENTS4.1 GENERAL / 4.2 PREPARATION FOR FLIGHT4.3 PREFLIGHT CHECK4.4 STARTING ENGINES AND SYSTEM CHECKS4.5 PRE - TAKEOFF CHECK4.6 TAKEOFF4.7 PRE - LANDING CHECK / 4.8 LANDING4.9 ENGINE SHUTDOWN4.10 ENGINE VENTILATION (DRY CRANK)4.11 CHANGING ENGINE CONTROL MODE

Section 5 TABLE OF CONTENTS5.1 APPROVED PERFORMANCE DATA5.2 ADDITIONAL NON-APPROVED PERFORMANCE DATA

Section 6 TABLE OF CONTENTS6.1 GENERAL6.2 BASIC EMPTY MASS CENTER OF GRAVITY6.3 LOADING EXAMPLE6.4 LOADING CHARTS AND TABLES

Section 7 TABLE OF CONTENTS7.1 GENERAL / 7.2 COCKPIT ARRANGEMENT7.3 FLIGHT CONTROL SYSTEM7.4 POWER PLANT AND RELATED SYSTEMS7.5 FUEL SYSTEM (Fig. 7-18)7.6 TRANSMISSION SYSTEM7.7 ROTOR SYSTEMS7.8 HYDRAULIC SYSTEM7.9 ELECTRICAL SYSTEM7.10 NEW MAP HOLDER (optional)7.11 CENTRAL PANEL DISPLAY SYSTEM (CPDS)

Section 8 TABLE OF CONTENTS8.1 GENERAL / 8.2 REFUELING8.3 DRAINAGE PROCEDURE8.4 OVSP system test PROCEDURE

Section 9Section 9-0 Section 9-1Section 9-1-LOS Section 9-1-1A FMS 9-1-1AA.1. GENERALA.2. LIMITATIONSA.3. EMERGENCY AND MALFUNCTION PROCEDURESA.4. NORMAL PROCEDURESA.5. PERFORMANCE DATAA.6. MASS AND BALANCE / A.7. SYSTEMS DESCRIPTION / A.8. HANDLING, SERVICING AND MAINTENANCE

Section 9-1-1B B.1. GENERAL / B.2. LIMITATIONS (In addition to the limitations given in part A, "GENERAL")B.3. EMERGENCY AND MALFUNCTION PROCEDURESB.4. NORMAL PROCEDURESB.5. PERFORMANCE DATAB.6. MASS AND BALANCE / B.7. SYSTEM DESCRIPTIONS / B.8. HANDLING, SERVICING AND MAINTENANCE

Section 9-1-1C C.1. GENERAL / C.2. LIMITATIONS (In addition to the limitations given in part A, "GENERAL", of this supplement)C.3. EMERGENCY AND MALFUNCTION PROCEDURESC.4. NORMAL PROCEDURESC.5. PERFORMANCE DATAC.6. MASS AND BALANCE / C.7. SYSTEM DESCRIPTIONS / C.8. HANDLING, SERVICING AND MAINTENANCE

Section 9-1-1D D.1. GENERAL / D.2. LIMITATIONS (In addition to the limitations given in part A, "GENERAL", of this supplement)D.3. EMERGENCY AND MALFUNCTION PROCEDURESD.4. NORMAL PROCEDURESD.5. PERFORMANCE DATAD.6. MASS AND BALANCE / D.7. SYSTEM DESCRIPTIONS / D.8. HANDLING, SERVICING AND MAINTENANCE

Section 9-1-1E E.1. GENERAL / E.2. LIMITATIONS (In addition to the limitations given in part A, "GENERAL", of this supplement)E.3. EMERGENCY AND MALFUNCTION PROCEDURESE.4. NORMAL PROCEDURESE.5. PERFORMANCE DATAE.6. MASS AND BALANCE / E.7. SYSTEM DESCRIPTIONS / E.8. HANDLING, SERVICING AND MAINTENANCE

Section 9-1-2 FMS 9-1-21. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-1-4 FMS 9-1-4A.1. GENERAL / A.2. LIMITATIONSA.3. EMERGENCY AND MALFUNCTION PROCEDURESA.4. NORMAL PROCEDURES (example shown for eng 1 in Training Mode)A.5. PERFORMANCE DATAA.6. MASS AND BALANCE / A.7. SYSTEMS DESCRIPTIONB.1. GENERAL / B.2. LIMITATIONS / B.3. EMERGENCY AND MALFUNCTION PROCEDURES / B.4. NORMAL PROCEDURESC.1. GENERAL / C.2. LIMITATIONSC.3. EMERGENCY AND MALFUNCTION PROCEDURES / C.4. NORMAL PROCEDURES / C.5. PERFORMANCE DATAD.1. GENERAL / D.2. LIMITATIONSD.3. EMERGENCY AND MALFUNCTION PROCEDURES / D.4. NORMAL PROCEDURES / D.5. PERFORMANCE DATA

Section 9-2Section 9-2-LOS Section 9-2-002 FMS 9-2-0021. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-003 FMS 9-2-0031. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION / 8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-004 FMS 9-2-0041. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-005 FMS 9-2-0051. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA / 6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (Fig.1+2)

Section 9-2-006 FMS 9-2-0061. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION


Section 9-2-008 FMS 9-2-0081. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-009 FMS 9-2-0091. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-010 FMS 9-2-0101. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-011 FMS 9-2-0111. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (Fig.2)8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-013 FMS 9-2-0131. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION




Section 9-2-018 FMS 9-2-0181. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-019 FMS 9-2-0191. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING, AND MAINTENANCE

Section 9-2-020 FMS 9-2-0201. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE7. SYSTEM DESCRIPTION

Section 9-2-022 FMS 9-2-0221. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-024 FMS 9-2-0241. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING, AND MAINTENANCE


Section 9-2-026 FMS 9-2-0261. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION


Section 9-2-029 FMS 9-2-0291. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (P/N L661C1801002)8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-031 FMS 9-2-0311. GENERAL2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION


Section 9-2-033 FMS 9-2-0331. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICE, MAINTENANCE

Section 9-2-035 FMS 9-2-0351. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE7. SYSTEM DESCRIPTION



Section 9-2-039 FMS 9-2-0391. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA


Section 9-2-041 FMS 9-2-0411. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-044 FMS 9-2-0441. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEMS DESCRIPTION


Section 9-2-046 FMS 9-2-0461. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-047 FMS 9-2-0471. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING, AND MAINTENANCE

Section 9-2-048 FMS 9-2-0481. GENERAL2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-049 V640 FMS 9-2-049 V6401. GENERAL2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION




Section 9-2-053 V640 FMS 9-2-053 V6401. GENERAL2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-054 FMS 9-2-0541. GENERAL / 2. Limitations3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION / 8. HANDLING, SERVICING AND MAINTENANCE

Section 9-2-055 FMS 9-2-0551. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (Fig.1)8. HANDLING, SERVICING, MAINTENANCE


Section 9-2-058 FMS 9-2-0581. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICE, MAINTENANCE

Section 9-2-059 FMS 9-2-0591. GENERAL / 2. Limitations3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION / 8. HANDLING, SERVICING AND MAINTENANCE


Section 9-2-061 FMS 9-2-0611. GENERAL / 2. LIMITATIONS / 3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE



Section 9-2-067 FMS 9-2-0671. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (Fig.2)


Section 9-2-069 FMS 9-2-0691. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION / 8. HANDLING, SERVICE, MAINTENANCE









Section 9-2-079 FMS 9-2-0791. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE



Section 9-2-082 FMS 9-2-0821. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION8. HANDLING, SERVICING AND MAINTENANCE




Section 9-2-086 FMS 9-2-0861. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES4. NORMAL PROCEDURES / 5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (Observe respective FMA for approved configurations & descriptions - refer to page 9.2-86-1)8. HANDLING, SERVICING, AND MAINTENANCE

Section 9-2-087 FMS 9-2-0871. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURE4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION

Section 9-2-089 FMS 9-2-0891. GENERAL / 2. LIMITATIONS3. EMERGENCY AND MALFUNCTION PROCEDURES / 4. NORMAL PROCEDURES5. PERFORMANCE DATA6. MASS AND BALANCE / 7. SYSTEM DESCRIPTION (including optional systems)

















Section 10 10.1 Guidelines for low noise operations

EMS EQUIPMENT

Documents

1_index