Upload
doananh
View
214
Download
1
Embed Size (px)
Citation preview
~ThflIR1PARTS CATALOGUE
GROUP 9.000BODY MOUNTING
AIR CONDITIONINGILLUSTRATION INDEX
Description Page
1967-70 Gauges 1
Air Conditioning 2-28Ventilation 29Fitting Packages 30
Stereo 32-36Antennas 37-38
Body Mounts 39
1967-70 FIREBIRD HOOD MOUNTED TACHOMETER
Key Part Name Group No.
1 — WIRE ASM., Engine Tachometer 9.750
2 — RETAINER, Engine Wire Harness N.5.
3 — TACHOMETER ASM., Engine 9.750
4 — NUT, Tachometer to Hood (#10~24) 8.915
LOCKWASHER, Tachometer to Hood
(#10 Ext. Tooth) 8.9325 — RIVET, Tachometer to Hood N.S.
6— SCREW, Tachometer to Hood (p10-32 x 3/4V) 8.977
7 — SCREW, Tachometer Wire Ground(i/4”-i4x 5/8”) 8.977
1967 FIREBIRD FLOOR MOUNTED CLOCK1968 FIREBIRD FLOOR MOUNTED CLOCK
(EXC. CONSOLE)
Key Part Name Group No.
1 — WIRE ASM., Floor Mounted Clock 9.7722 — SCRFW, Clodc to Consol. (#1O...2t 1”) R.977
SCREW, Clock to Floor Brkt. (#10~24 x 1/2”) 8.9773 — CLOCK ASSEMBLY, Floor Mounted 9.7724 — WASHER, Clock to Console
(1/4” ID. x 9/16” O.D.) 8.9295 — NUT, Clock to Console (#10..24) 8.9156 -~ SCREW, Clock Bracket to Floor
(#10.32 x 5/8”) 8.9777 — BRACKET, Floor Mounted Clock 9.772B — NUT, Clock Bracket ta Floor (#10.32 Spec.) N.S.
1968 FIREBiRD FLOOR MOUNTED CLOCK-W/CONSOLE
Key Part Name Group No.
1 — WIRE ASM., Floor Mounted Clack 9.7722 — SCREW, Clock to Console (#10~24 x 1”) N.S.3 — SCREW, Clock to Console (#10—24 x 2”) . . . N.S.4 — CLOCK ASM., Floor Mounted 9.7725 — BRACKET, Clock to Console 9.7726 — WASHER, Clack to Console
(7/32” l.D. x 1/2”) 8.9297 — NUT, Clock to Console (#10—24) 8.9158 — ADAPTER, Clock to Console 9.772
PARTS CATALOGUE1GM TThflIRD
GROUP 9.000 ILLUSTRATION 1
PARTS CATALOGUE1GM flflIRD
AIR CONDITIONING COMPRESSOR PARTS
Key Part Name
1 — SEAL, “0’ Ring (A)2 — HEAD, Compressor—Front3 — SEAL, “0” Ring (A)4 — SEAL, Shaft OilS — SEAT, Oil Seal6 — SNAP RING, Oil Seal Seat7— SEAL KIT, Shaft Oil8 — HOUSING, Compressor9 — GASKET, Oil Fitting Screw
10 — SCREW, Oil Fitting11 — SHELL ASSY., Compressor12 — COIL, Clutch13 — SNAP RING, Coil14 — PULLEY, Compressor15 — BEARING, Pulley16 — RING, Pulley Bearing Ret17 — PULLEY ASSY., Compressor18 — SNAP RING, Bearing to Head Retainer19— PLATE ASSY., Clutch20 — SPACER, Clutch Hub21 — SNAP RING, Clutch Hub22 — NUT, Shaft (B)23 — “0” Ring, Intake & Discharge Port (A)24 — NUT, Compressor Head (B)25 — VALVE, Pressure Relief26 — GASKET, Pressure Relief27 — HEAD, Cylinder—Rear28 — “0” RING, Cylinder Head (A)29 — SCREEN, Suction30 — PUMP PKG., Camp. Oil31 — PLATE, Discharge Valve—Rear32 — REED, Suction Valve33 — BUSHING, Discharge Tube34 — “0” RING, Discharge Tube (A)35 — CYLINDER &BEARINGASSY., (Includes Front & Rear Unit & Na’s. 36—54—55)36 — BEARING, Shaft37— TUBE, Oil Inlet38 — “0” RING, Oil Inlet Tube (A)39 — BEARING, Needle Thrust40 — RACE, Thrust Bearing41 — SHAFT ASSY., Drive (No. 50 Included)42 — RING, Piston43 — BALL, Piston Drivea—PISTON
(A)
Group Na.
N S.9.174N.S.N S.N.S.
9.1759.175N.S.
9.1779.1779.1709.1869.175N.S.
9.1819.1819.1809.1819.1889.1819.1759.1819.2409.1749.1789.1789.174N.S.
9.1729.1729.1729.1729.172N.5.
9.1709.1729.172N.S.
9.1729.1729.1709.1729.1729.1729.1729.1729.1729.1729,1729.1889.1729.172kS.
45 — RING, Piston4.6 — BALL, Piston Drive47 — DISC, Shoe48 — TUBE PKG., Crossover Discharge (Na. 33 Included)49 — BEARING, Needle Thrust50— KEY, Clutch Hub51 — RACE, Thrust Bearing52 — COVER, Suction Passage53 — SEAL, Suction Passage Cover (See Nate Group 9.170)54 — BEARING, Shaft 9.17255 — CYLINDER &BEARINGASSY., (Includes Front &Rear Unit & No’s. 35—36—54) 9.17056 — “0” RING, Discharge Tube (A) N.S.57 — BUSHING, Discharge Tube 9.17258 — REED, Suction Valve 9.17259 — PLATE, Discharge Valve—Front 9.172NOTE; Cylindci & Shuft Auembly Include: No’:. 35-36-39—40-41-4243445~47
4849-51—54-55.The ports indicated with letters are serviced in the following packages:A Ports Serviced in Compressor Overhaul Seal Pkg.—9.170B Parts Serviced in Nut Pkg.—9.170
GROUP 9.000 ILLUSTRATION 3
PARTS CATALOGUE1GM fl~IRD
Group No. Key Part Name
1 — SCREW, Pulley Rim Mounting
2 — WASHER, Pulley Rim
3— RIM, Compressor Pulley
4—COIL & HOUSING ASM., Compressor
5— BEARING, Pulley Rotor
6—ROTOR & BEARING ASM., Compressor
7 — RING, Bearing to Front Head Retainer
8— DRIVE ASM., Compressor Clutch
9— KEY, Drive Hub to Shaft
10— NUT, Drive Shaft Pulley
11 — CAP, Therme~ Switch Protecttve
12— RETAINER, Superheat Switch Ring
13—SWITCH KIT, Superheat .-
14— “0” RING, Superheat Switch
15— VALVE ASM., Compressor Pressure Relief
lIncI.#161
9.180
9.180
9.180
9.186
9.181
9.1 72
9.172
9.186
9.188
9.181
N .5.
9.172
9.172
9.172
9.178
16— SEAL, Relief Valve (Part of #15)
17—CYLINDER & SHAFT ASM., Compressor
18 — WASHER KIT, Compressor Thrust
19— “0” RING, Cylinder to Shell
20 — SHELL ASM., Compressor
21 — SEAL, Front Head to Cylinder Ring
22—BEARING, Front Head - Main
23—HEADASM., Compressor Front
24—SEAL,Seat”O” Ring
25 — RING, Seal Seat Retainer
26— SEAL KIT, Compressor Shaft
27 — SCREW & WASHER ASM., Front Head
Mounting
28—PLATE ASM., Valve
29— RING, Valve Plate Retaining
30 — ‘0” RING, Suction Disc Port
Key Part Name
RADIAL 4 CYLINDER AIR CONDITIONING COMPRESSOR
Group No.
N.S.
N .S.
9.170
9.172
9.170
9.172
9.172
9.174
9.175
9.172
9.170
N.S.
9.172
9.172
9.172
GROUP 9.000 ILLUSTRATION 3A
j~M FIREBIRD 1PARTS CATALOGUE
1967-68 FIREBIRD AIR CONDITIONING—CONTROLSGROUP 9.000 ILLUSTRATION 4
A
j~flThIRDPARTS CATALOGUE
1967-68 FIREBIRD AIR CONDITIONING—CONTROLS
Key Part Name Group No.
1 — HOSE, Reducer to Engine Vacuum (5/32” l.D. 33” 6—Cyl.) (37” 8—Cyl.) . 9.2812 — HARNESS ASM., Vacuum Hose 9.2813 — REDUCER, Carb. Vacuum Hose (1/4” to 3/169 3.7654 — HOSE, Vacuum Control Tank to Reducer (7/32” l.D. x 6”) 9.2815 — TANK ASM., Refrigerant Vacuum Control 9.2816 — SCREW, Tank to Fender Reinf. (1/4—14 x 5/8”) N.S.7 — NUT, Heater Air Control Cable 9.2818 — CABLE ASM., Defroster Control 9.7799 SCREW, Cables to Control (#10~16 ~c5/8”) 8.977
10 — CABLE ASM., Heater Temperature Control 9.28 111 — CABLE ASM., Heater Diverter Valve Control 9.28 112 — SWITCH ASM., Heater Control Master 9.27513 — SCREW, Switch to Control (#TO.24 x 3/8”) N.S.14 — CLIP, Air Inlet Plenum Valve Housing N.S.15 — VALVE ASM., Air Inlet Plenum 9.78616 — NUT, Air Inlet Valve Link 9.789I? — WASHER, Plenum Valve L;nL to VoI~. 9.78618 — NUT, Vacuum Valve to Valve Housing Plate (#10~32) 8.91519 — LOCKWASHER, Vacuum Valve to Valve Housing Plate (#10..Ext) 8.93220 — SCREW, Valve Housing Plate to Plenum Plate (#10~16 x 1/2”) 8.97721 — SPRING, Air Inlet Plenum Valve to Plate 9.78622 — PLUG, Air Inlet Plenum Valve Plate N.S.23 — PLATE, Air Inlet Plenum Valve Housing 9.78624 — LINK, Air Inlet Plenum Valve 9.78625 — SCREW, Vacuum Valve to Link (#8~18 x 3/8”) 8.97726 — ACTUATOR ASM., Air Inlet Plenum Valve Vacuum 9.21527 — CLAMP, Vacuum Control Hose 9.28?28 — HOSE, Vacuum Control Hose Tee to Plenum (7/64” I.D. x 6”) 9.28129 — SEAL, Air Inlet Plenum Valve Housing Plate 9.78630 — SEAL, Air Inlet Plenum Valve Housing to Plenum — Rear N.S.31 — HOUSING, Air Inlet Plenum 9.78932 — SEAL, Air Inlet Plenum Valve Housing to Plenum — Front N.S.33 — TEE, Vacuum Control Hose 9.28 134 — HOSE, Vacuum Control Hose Tee to Plenum (7/64” I.D. x 6”) 9.28135 — GROMMET, Vacuum Control Hose 9.77536 — SCREW, Grommet to Dash (#IO~16 x 1/2”) 8.97737 — SWITCH, Compressor Vacuum - On Control 9.27538 — SCREW, Vacuum Valve to Control N.S.39 — VALVE, Heater Control Vacuum 9.27940 — LINK, Air Inlet Side Shroud Vacuum Control 9.7894) — RING, Air Inlet Side Shroud Control Arm 9.78642 — ARM, Air Inlet Side Shroud Vacuum Control 9.78943 — DOOR ASM., Shroud Panel Air Outlet 9.78944 — SCREW & WASHER ASM., Cover to Shroud Side Panel 14.81045 — NUT, Side Shroud Control Cover to Panel 9.78946 — COVER, Shroud Side Vacuum Control 9.78947 — SPRING, Air Inlet Side Shroud Vacuum Control 9.78948 — BRACKET, Air Inlet Side Shroud Vacuum Control 9.78949 — SCREW, Bracket to Side Shroud Panel (1/4—14 x 5/8”) N.S.50 — SCREW, Diaphragm Control Arm to Control (A8~18 x 3/8”) 8.97751 — DIAPHRAGM ASM., Vacuum Air Inlet Side Shroud 9.28 152 — HOSE, Control Hose Tee to Side Vent (7/641.0. x 20”) 9.28153 — PIN, Air Inlet Side Shroud Vacuum Control 9.78654 — CONTROL ASM., Air Conditioner 9.27355 — KNOB, Heater & Air Conditioner Control 8.85256 — SCREW, Control to Inst. Panel.(#l0~16 x 3/4”) 8.97757 — SWITCH ASM., Air Cond. Heater Control Master 8.85258 — SCREW, Switch to Control (#10..24 x 3/8”) N.S.59 — SWITCH ASM., Compressor Vacuum On Heater Case (1968) 9.275
GROUP 9.000 ILLUSTRATION 5
PARTS CATALOGUEGM flflR1
1967-69 F)REBIRD AiR CONDiTiONiNG—iNTERIOR AIR SYSTEM
GROUP 9.000 ILLUSTRATION 6
PARTS CATALOGUE1GM ThTflnfl1967-69 FIREBIRD AIR CONDITIONING—INTERIOR AIR SYSTEM
Key Part Name— OUTLET ASM., Center Air —Upper
2 — VALVE, Center Air Outlet
3 — RETAINER, Center Air Outlet Valve (Felt)
4 — BEZEL, Center Air Outlet
S — SCREW, Outlet to Inst. Panel
6 — PLATE, Inst. Panel Trim - With A.C
7 — COMPARTMENT, Inst. Panel - With A.C8 — HOSE, Air Outlet - R.H. (2—3/4” Dia. x 19”)
9 — SCREW, Trim Plate to Inst. Panel (#8~18 x 1/2”)
10 — SEAL, Heater Core Tubes to Dash
11 — GASKET, Heater Aim. to Dash
12 — BRACKET, Heater Diverter Volve Cable
13 — BRACKET, Heater Temperature Cable — On Case
14 — BAFFLE, Heater Temperature Valve — Linearity
15 — VALVE & SHAFT ASM., Heater Temperature Control
16 — CLIP, Temperature Valve Shaft Retainer
17 — SHAFT, Temperature Control (Part of #15)
18 — HOUSING, Heater Temperature Control
19 — SEAL, Heater Air Baffle — Upper
20 — SEAL, Heater Air Baffle - Lower
21 — CORE ASM., Heater — With Fittings
22 — CLAMP, Heater Core
23 — DUCT, Distributor to Center Air Outlet
24 — DUCT ASM., Air Distributor - R.H
25 — SCREW, Distributor Duct to Distributor (#10~16 x 5/8”)
26 — DUCT ASM., Air Distributor - L.H
27 — GASKET, Air Distributor Duct to Heater
28 — CASE & CORE ASM., Heater (Less Dist. & Defroster Duct)
29 — OUTLET ASM., Center Air — Lower
30 — WASHER, Outlet to Dash
31 — SCREW, Duct to Dash (#10..16 x 3/4”)
32 — DUCT ASM., Air Distributor to Defroster End
33 — DISTRIBUTOR ASM., Heater Defroster
34 — SCREW, Air Outlet Bezel to Retainer (#8~18 x 3/4”)
35 — SCREW, Mr Outlet Bezel to Inst. Pane! (4—78 x 7/2”)
36 — BEZEL, Air Outlet Nozzle — L.H
37 — SEAL, Air Outlet Adapter or Bezel
38 — DEFLECTOR, Air Outlet
39 — ADAPTER, Air Outlet Nozzle
40 — NUT, Air Outlet Bezel to Retainer (p8—18 ‘~J,’ Shape)
41 — RETAINER, Air Outlet Bezel
42 — HOSE, Air Outlet — L.H. (2—3/4” Dia. x 24”)
43 — STRAP, Air Outlet Hose — L.H
44 — SCREW, Strap to Plenum
45 — SUPPORT, Inst. Panel — Lower Centre
GROUP9.000 ILLUSTRATION 7
Group No.9.262
9.264
9.264
9.264
N.S.
10.256
10.260
9.260
N.S.
8.846
8.854
9.281
9.281
8.866
8.866
9.786
N.S.
8.866
8.866
8.866
8.854
N.S.
9.262
9.262
8.977
9.262
9.262
8.854
9.264
N.S.
N.S.
9.262
9.779
8.977
8.977
9.264
9.264
9.262
9.264
N.S.
9.262
9.260
9.260
N.S.
10.230
PARTS CATALOGUEWM~IRD
7
1967-69 FIREBIRD AIR CONDITIONING—REFRIGERATION SYSTEM
GROUP 9.000 ILLUSTRATION S
1969
1969
PARTS CATALOGUE1GM WflRl
1967-69 FIREBIRD AIR CONDITIONING—REFRIGERATIONSYSTEMKey Port Nome Group No.
1 — WASHER, Blower Case to Dash (19 64” ID. x 1/2’ 0.0.) N.S.2 — STUD ASM., Blower Motor & Inlet Asm. to Dash 9.2153 — NUT, Blower Case to Dash (1~4” —20) 8.9154—CASE, Evaporator Inlet 9.2115 — SCREW, Evaporator & Blower to Dash (1 4” — 14 x I “) 8.9776 — HOSE, Condenser to Compressor (1 p2” ID. x 42”) 9.2277 — CLAMP, Freon Hose 9.2428 — FITTING ASM., Compressor - With Mtffler (6—Cyl.) 9.2269 — LOCKWASHER, Fittings to Compressor (3 ‘8”) 8.931
10 — BOLT, Fittings to Compressor 13/8—24 x 1”) 8.900II — HOSE & COUPLING, Receiver to Evaporator 9.23?12 — SEAL, Evaporator Core to Case 9.21113 — GASKET, Expansion Valve Inlet TuE~e 9.21414 — SEAL, Evaporator Case 9.21115 — CORE ASM,, Evaporator — With Pipes 9.21016 — SEAL, Evaporator Case 9.21117 — INSULATION, Expansion Valve Bulb 9.21318 — GASKET, Refrigerant Control Valve ‘‘0’’ Ring 9.19819 SCREW, Outlet Clamp Tube to Evaporator I#10~16 x 5/8”) 8.977
20 — CLAMP, Refrigerant Control Valve Tube 9.19821 — GASKET, Refrigerant Control Valve (3/4” ‘‘0” Ring) 9.21022 — VALVE ASM., Thermostatic Expansion 9.21323 TUBE ASM., Suction Throttling Valve to Compressor Hose 9.22924 — SCREW, Control Valve Bracket to Evaporator (1/4—14 x 5 8”) 8.97725 — BRACKET, Refrigerant Control Valve N.S.26 — VALVE ASM., Suction Throttling 9.19827 — HOSE, Control Valve Tube to Fittings (5/8” ID. x 18” (8—Cyl.) 23(6—Cyl.) 9.22928 — CASE, Evaporator Outlet 9.21129 — CLAMP, Evaporator Case Drain Tube 9.21130 — TUBE, Evaporator Case Drain 9.21131 — COMPRESSOR, Air Conditioner 9.17032 — BOLT, Support to Compressor (5/16—24 x 3~4”) 8.90033 — CLAMP, Muffler to Compressor Support 9.24234 — FITTING ASM., Compressor - With Muffler (8—Cyl.) 9.22635 — SUPPORT, Muffler to Compressor (8—CA.) 9.24236 — BOLT, Support to Compressor (5: 16—24 x 1—3 8”) 8.90037 — HOSE, Condenser to Compressor (1 2” ID. x 42”) 9.22738 — SPACER, Compressor Condenser to Muffler Hose 9.24239 — SCREW & WASHER ASM., Condenser Bracket to Support (5.16—18 x 7 8”) N.S.40 — BRACKET, Condenser Mounting - L.H. 9.19041 — NUT, Condenser to Bracket (~1 0—12 ‘U’’ Shape) 8.92142 — SCREW, Bracket to Condenser (p10—16 x 1 2”) 8.97743 — WASHER, Fittings to Support (5/16” ID. x 5/8” 0.0. x 1 16”) N.S.44 — LOCK WAS HER, Fittings to Support (5 16”) 8.93145 — BOLT, Fittings to Support (5/16—24 x 1—1/4”) 8.90046 — NUT, Fittings to Support (5 16—24) 8.91547 — SUPPORT, Muffler to Compressor (6—Cy I.) 9.24248 — BOLT, FiHings to Support (5 16—24 x 3 4”) 8,90049 — TERMINAL, Blower Motor ground — Mole 9.21550 — SCREW, Terminal to Case (#8~18 x 1 ‘2”) 8.97751 — BRACKET, Condenser Mounting — R.H 9.19052 — ELBOW, Blower Motor Coaling Tube 9.21853 — TUBE, Blower Motor Cooling 9.21854 — SCREW, Elbow to Case (p8—18 x 1/2”) 8.97755 — NUT, Impeller to Motor (#10~32) 8.91556 — LOCKWASHER, Impeller to Motor (~10) 8.93157 — IMPELLER, Heater Blower 9.21658 — MOTOR ASM., Blower 9.2 1559 — LOCKWASHER, Blower Motor to Case (p8) 8.93260 — SCREW, Blower Motor to Case (~8—18 x 1/2”) 8.97761 — SUPPORT, Receiver & Liquid Indicator 9.20662 — NUT, Receiver to Support (1/4—14) 8.92163 — SCREW, Receiver to Support (1 4.14 x 3/4”) 8.97764 — TUBE ASM., Receiver to Condenser Hose 9.22765 — BR.ACKET, Receiver 9.20666 — RECEIVER ASM., Refrigerant 9.19567— HOSE, Receiver to Condenser (13/32” ID. x 13—1/2”) 9.22968 — CONDENSER ASM., ReFrigerant 9.19069 - WIRE ASM., Blower Motor Ground (1968) 9.21570 — GROMMET, Wiring 9.775
71 — VALVE, Vacuum Check 9.28172 — HOSE, Vacuum Control 9.28173 — HOSE, Condenser to Receiver . 9.227
74 — TUBE, Compressor Discharge ... 9.225
GROUP 9.000 ILLUSTRATION 9
PARTS CATALOGUE
1967-69 FIREBIRD AIR CONDITIONING—ELECTRICAL PARTS(O.H.C. 6 CYLINDER ENGINE)
Key Part Name Group No.
I — GASKET, Heater Blower Motor Resistor2 — RESISTOR, Blower Motor3 — RELAY ASM., Blower Motor Cut—Out4 — SCREW, Resistor to Case (# 10—16 x 5/8”)5 — SEAL, Blower Motor Resistor6 — SCREW, Relay to Case (#1D~16 x 5/B”)7 — CONTROL ASM., Heater & Air Conditioner8 — HARNESS ASM., Air Conditioner Main9 — SCREW, Ground Wire to Dash (1/4—14 x 5/8”)
10 — BOLT, Compressor Mounting (5/16—24 x 2”)11 — LOCKWASHER, Wire to Compressor (5/16”)12 — COMPRESSOR, Air Conditioner13 — CABLE, Battery Ground14 — SCREW, Battery Ground Wire (1/4-14 x 5/8”)15 — LOCKV/ASHER, Battery Ground Wire Screw (1/4”)16 — BLOCK ASM., Junction17 — SCREW, Junction Black to Body (#0..10 x 1/2”)18 — NUT, Cable to Junction Block (~10—24)
19 — CABLE ASM., Battery to Starter Motor — Positive20 — GASKET, Ambient Switch to Evaporator (1968)21 — SWITCH ASM., Compressor Ambient Sensor (1968)
9.2759.2759.2758.9779.2 758.9779.2739.2768.9778.9008.9329.1702.348.97 78.9322.4832.977N.S.2.3429.2759.275
GROUP 9.000 ILLUSTRATION 10
IGM FIREBIRD I
Key
PARTS CATALOGUE
Part Name
1 — GASKET, Heater Blower Motor Resistor
2 — RESISTOR, Blower Motor
3 — RELAY ASM., Blower Motor Cut—Out
4 — SCREW, Resistor to Case (#10~16 x 5/8”)
5 — SEAL, Blower Motor Resistor
6 — SCREW, Relay to Case (#10.46 x 5/B”)
7 — CONTROL ASM., Heater & Air Conditioner
8 — HARNESS ASM., Air Conditioner Main
9 — LOCKWASHER, Ground Wire to Dash (1/4”)
10 — SCREW, Ground Wire to Dash (1/4—14 x 5/8”)
11 — RETAINER, Alt. Wires to Rocker Arm Covers
12 — COVER, Delcotron Battery Protective
13 — NUT, Wire to Delcotron (#I2~24)
14 — LOCKWASHER, Wire to Delcotron
15 — DELCOTRON ASM
16 — COMPRESSOR, Air Conditioner
17 — LOCKWASHER, Wire to Compressor (5/16”)
18 — BOLT, Compressor Mounting (5/16-24 x 2”)
19 — GASKET, Ambient Switch to Evaparator (1968)
20 — SWITCH ASM., Compressor Ambient Sensor (1968)
Group No.
9.275
9.275
9.275
8.977
9.275
8.977
9.273
9.276
8.932
8.9771
2.482
2.3 13
8.915
N.S.
2.275
9.170
8.932
8.900
9.275
9.275
1967-69 FIREBIRD AIR CONDITIONING—ELECTRICAL PARTS(8 CYLINDER ENGINE)
GROUP 9.000 ILLUSTRATION 11
PARTS CATALOGUE1GM flfllRfl
Key Port Name
1 — PLATE, Compressor Mounting — Rear2 — SPACER, Compressor & Clutch to Rear Plate3 — BRACKET, Compressor Mounting4 — PULLEY, Water Pump and Fan (6—1/4” dia.)5 — SPACER, Fan6 — FAN, 7—Blade (18” dia.)7—BOLT, Fan to Pulley (5/16—24 x 1-3/4”)8 — BOLT, Pulley to Bolancer (3/8—16 x 1/2”)9 — PULLEY, Harmonic Baloncer
10 — BOLT, Plate to Compressor (5/16—24 x 5/8”)11 — COMPRESSOR, Air Conditioner12 — BOLT, Compressor Mounting Plate to Bracket (3/8—16 x 1—1/4”)13—WASHER, Compressor Mounting Plate to Bracket (13/32”x3/4”)14 — PLATE, Compressor Mounting—Front15 — BOLT, Front Mounting Plate to Compressor (5/16—24 x 1/2”)16 — BOLT, Front Mounting Plate to Compressor (5/16—24 x 1—1/4”) .
17 — CLAMP, Heater Hose Outlet18 — CLIP, Heater Hose to Skirt19 — STRAP, Heater Water Hose20 — HOSE, Heater Water Outlet (3/4” I.D. x 38—1/2”)21 — CLAMP, Heater Hose Inlet22 — GROMMET, Heater Core Pipe23 — SCREW, Core Pipe Grommet to Case (#10..16 x 5/8”).24 — HOSE, Heater Water Inlet (5/8” l.D. x 30”)25 — NIPPLE, Heater Hose to Cylinder Head26 — LOCKWASHER, Mounting Bracket to Block (3/8” Ext.)27 — BOLT, Mounting Bracket to Block (3/8”16 x 4”)28 — BOLT, Coil to Mounting Bracket (3/8—16 x 5/8”)29 — STRAP, Compressor30 — BOLT, Strap and Plate to Bracket (3/8—16 x 1”)31 — BOLT, Strap and Plate to Bracket (3/8—16 x 3/8”)
Group No.
9.1719.1719.1711.0621.0641.064
8.9008.9000.6598.9009.1708.9008.9299.1718.9008.9001.166N.S.
8.8468.8461.1669.7758.9778.8468.866
8.9328.9008.9009.1718.9008.900
1967-69 FIREBIRD AIR CONDITIONING—COMPRESSOR MOUNTING AND DRIVE PARTS(O.H.C. 6 CYLINDER ENGINE)
GROUP 9.000 ILLUSTRATION 12
PARTS CATALOGUEWM~IRD
Group No. Key
— BOLT, Compressor Rear Brace—Rear—To IntakeManifold (5/16—18/1-3/8”)
2 — WASHER, Compressor Rear Brace to IntakeManifold (11/32” 1.0. x 3/4” 0.0. x 3/32”).
3 — BOLT, Compressor tear Brace—Side—To IntakeManifold (3/846 x 3/4”)
4 — WASHER, Compressor Rear Brace—Side—To IntakeManifold (13/32” I.D. x 3/4” OD. x 1/8”)
S — BRACE, Compressor Rear to Intake Manifold6 — SPACER, Compressor Rear Brace to Compressor
(13/32” ID. x 3/4” O.D. x 3/4”)7 — INDICATOR ASM., Engine Oil Level8 — BOLT, Compressor Mtg. Plate—Rear-To Bracket
(3/8-16 x 7/8”)9 — BOLT, Cyl. Head & Camp. Mtg. Bracket—Rear
(1/2”—13 x 4—5/8” Stud Hd.)10 — BOLT, Camp. Brkt. to Cyl. Head-Front
(1/2”-13x4—5/8”)
11 — PULLEY, Water Pump & Fan12 — BOLT, Pulley to Water Pump
(5/16”.-24x3/4”)13 — BOLT, Fan to Fan Clutch Asm.
(5/16”-18x5/8”)14 — FAN ASM., Engine15 — CLUTCH ASM., Engine Fan Fluid16 — COMPRESSOR & CLUTCH ASM., Air Conditioner17 — BOLT, Compressor Front Support to Cyl. Head
(3/8”-16x3—l/2”)18 — BOLT, Compressor Front Support to C
14. Hd. Brkt.(3/8-16 x 2—1/4”)
19 — WASHER, Compressor Front Support to Cyl. Md.8.900 Bolt (13/32” x 1—1/8” x 3/16”)
20 — SUPPORT, Compressor Front9.173 21 — SPACER, Compressor Frt. Support to Cyl. Head
(13/32” 1.0. x 1—1/4” O.D. x 1”)8.900 22 — BALANCER ASM., Harmonic
23 — BOLT, Compressor Muffler Support—Lower—To Frt.9.173 Support (5/16”—24x 1—3/8”)9.171 24 — BOLT, Compressor to Front Support
(5/16”—24x2”)9.171 25 — BRACKET, Compressor Mounting1.516 26 — PLATE, Compressor Mounting—Rear
27 — TUBE ASM., Oil Level Indicator8.900 28 — BRACKET, Spark Plug Wims at Compressor Brace
29 — BOLT, Plug Wire BrIct. & Rear Brace to Compressor0.293 (3/8”-l6x 1—3/4”)
30 — SPACER, Compressor Rear Brace—Rear—To Intake0.293 Manif. (21/64” I.D. x 3/4” 0.0. x 5/8”)1.062 31 — GROMMET, Heater Care Pipe
32 — SCREW, Heater Care Pipe Grommet to Case8.900 (#10-16x5/8”)
33 — HOSE, Heater Water—Inlet (Farmed)8.900 34 — CLAMP, Heater Water Hose—Inlet1.064 35 — CLAMP, Heater Water Hose-Outlet1.050 36 — HOSE, Heater Water—Outlet9.170 (3/4”I.D.x47”)
8.900
8.900
Key Part Name
1967-69 FIREBIRD AIR CONDITIONING—COMPRESSOR MOUNTING AND DRIVE PARTS(8 CYLINDER ENGINE)
Port Name Group No.
9.1739.171
9.1710.659
8.900
8.9009.1719.1711.3162.251
8.900
9.1739.775
8.9778.8441.1661.166
8.846
GROUP 9.000 ILLUSTRATION 13
PARTS CATALOGUE1GM FIREBIRD
Part Name
1 — COMPRESSOR,Air Conditioner - A, F, X
2—BRACKETASM., Compressor - A, X
BRACKETASM., Comprasor - F
3—SUPPORT,Bra~cet - A, F, X
4—BRACE,Compressor Adjusting- A, XL
BRACE, Compressor Adjusting- F
5—BRACKETASM., To Brace Adjusting- A, X
BRACKETASM., To Brace Adjusting-F
6 — BOLT(318”-16 x 4”)
7 — LOCKWASHER13/8”)
8 — BOLT (318”-16 x 3/4”)
9—NUT (318”-16)10—STUD, Front Bracket to Cyl. Head
11—BOLT (318”-lBx 1”)
12—BOLT (318”-16 x 7/8”)
13—WASHER,Flit (3/8”)
1975 6 CYL. ENGINE AIR CONDITIONING RADIALCOMPRESSOR MOUNTING
Key Group No.
9.170
9.171
9.171
9.171
9.171
9.171
9.171
9.171
8.900
8.931
8.900
8.915
9.173
8.900
8.900
8.929
GROUP 9.000 ILLUSTRATION 13A
PARTS CATALOGUEW?~IRl1969 FIREBIRD AIR CONDITIONING—CONTROLS
Key Port Name
1 — HARNESS, Vac. Hose
2 — CABLE, Temp. Control
3 — SWITCH, Blower Motor
4 — SUPPORT, Control
5 — CONTROL, Air Conditioner
6 — VALVE, Heater Cant. Vacuum (Lower)
7 — CLIP, Vac. Hose Retaining (Long)
8 — SWITCH, Heater Cant. — Vent
9 — VALVE, Heater Cant. Vacuum (Upper)
10 — CLIP, Vac. Hose Retaining (Short)
11 — SWITCH, Master
12 — PLATE, Valve Hsg
13 — SPRING, Valve to Plate
14 — SCREW, Hsg. Plate to Plenum Plate (#10~16 x 1/2”)
15 — SEAL, Valve Hsg. Plate
16 — VALVE, Plenum
17 — CLIP, Plenum Valve Hsg
18 — SEAL, Valve Hsg. to Plenum — Front
19 — NUT, Inlet Valve Link
20 — WASHER, Valve Link to Valve
21 — HOUSING, Plenum
22 — SEAL, Valve Hsg. to Plenum — Rear
23 — LINK, Plenum Valve
24 — SCREW, Vac. Valve to Link (~8—18 x 3/8”) -
25 — DIAPHRAGM, Plenum Valve Voc
26 — DOOR, Air Outlet - R.H
DOOR, Air Outlet - L.H
27 — NUT, Cable to Door
28 — LINK, Shroud Vac. Cant
29 — ARM, Shroud Voc. Cant
30 — RING, Control Arm (5/16” dia.)
31 — NUT, Cover to Panel
32 — DIAPHRAGM, Inlet Side Shroud
33 — SCREW, Cover to Panel
34 — COVER, Side Vac. Control
35 — SCREW, Cant. Arm to Cant. (#8~18 x 3/8”)
36 — BRACKET, Shroud Vac. Cant
37 — SPRING, Shroud Vac. Cont
38 — PIN, Shroud Vac. Cant
39 — GROMMET. Vac. Cant. Hose
GROUP 9.OUO ILLUSTRATION 15
Group No,
9.28 1
8.849
8.852
8.852
8.849
9.279
9.281
9.275
9.279
9.281
8.852
9.786
9.786
8.977
9.786
9.786
N.S.
N.S.
9.789
9.786
9.786
N.S.
9.786
8.977
9.281
9.789
9.789
9.281
9.789
9.789
8.934
9.789
9.28 1
N.S.
9.789
8.977
9.789
9.789
9.786
9.775
WM FIRE BIRDiPARTS CATALOGUE
1969 FIREBIRD AIR CONDITIONING—ELECTRICAL PARTS & WATER HOSE(6 CYL. ENGINE)
Part Name
1 — HARNESS, Engine Wire2 — WIRE, Temp. Gauge Jumper3 — WIRE, Blower & Relays to Cant. Wire4 — GASKET, Switch to EvopS — SWITCH, Ambient Sensor6 — SCREW, Switch to Case (#10~16 x 5/8”)7— RELAY, Hi—Blower8 — GASKET, Motor Resistor9 — RESISTOR, Blower Motor
10 — BRACKET, Relay Mounting11 — SCREW, Relay to Brkt. (#10~16 x 1/2”)12 — GROMMET, Heater Core Pipe13 — CLAMP, Water Hose14 — VALVE, Heater Water15 — HOSE, Valve to Engine16 — HOSE, Heater Outlet (3/4” I.D.)17—STRAP,HosetoPipe18 — BRACKET, Water Valve19—SPACER, Water Hose20 — HOSE, Heater to Valve (5/8” I.D.)
GROUP 9.000 ILLUSTRATION 16
Groyp No.
2.4802.4809.2769.2759.2758.9779.2759.2759.2759.2168.9779-7758.9489-7958.8468.9622.5599.7958.8468.962
Key
PARTS CATALOGUE
1 — WIRE, Engine Jumper
2 — CLIP, Wire to Strap
3 — BRACKET, Relay Mounting
4 — RELAY, Hi—Blower
S — GASKET, Motor Resistor
6 — RESISTOR, Blower Motor
7 — WIRE, Blower & Relays to Cant. Wire
8 — GASKET, Switch to Evap
9 — SWITCH, Ambient Sensor
10 — SCREW, Switch to Case (#l0~16 x 5/8”)
11 — GROMMET, Heater Core Pipe
12 — HARNESS, Vacuum Hose
13 — HOSE, Valve to Engine
14 — CLAMP, Water Hose
15 — HOSE, Heater Outlet (3/4” I.D.)
16 — VALVE, Heater Water
17 — BRACKET, Water Valve
18 — SPACER, Heater Hose
19— HOSE, Heater to Valve (5/8” l.D.)GRUUP 9.000 ILLUSTRATION 17
1GM ~flRD
1969 FIREBIRD AIR CONDITIONING—ELECTRICAL PARTS & WATER HOSE(8 CYL. ENGINE)
Key Part Name Group No.
9.276
N.S.
9.216
9.275
9.275
9.275
9.276
9.275
9.275
8.977
9.775
9.28 1
8.846
3.9488.962
979S
9-795
8.84.6
8.962
Wjj FIREBIRDPARTS CATALOGUE
1970-76 FIREBIRD AIR CONDITIONING — INTERIOR AIR SYSTEM
Key Port Name Group No.
— NOZZLE, Defroster 9.779
2 — NUT, Case to Dash (1/4—20) 8.915
3 — LOCKWASHER,Case to Dash (5/16”) 8.931
4 — WASHER, Case to Dash (13/16” 0. D. x 13/MI. D.) N.S.
S — SEAL, Core Tube to Dash—Lower 8.846
6 — CORE, Heater 8.854
7 — CASE & CORE ASM., Heater 8.854
8 — SCREW, Case to Dash (1/4—14 x 1”) 8.977
9 — ADAPTER, Heater to Diet. Duct N.S.
10 — SEAL, Duct to Heater Case N.S.
11 — DUCT, Air Outlet—Center 9.262
12 — DUCT, Dist.. to R. H. Outlet & Center Duct 9.262
13 — STRAP, Center ~ct to Diet 9.262
14 — DUCT, Main Air Dist 9.262
15 — DEFLECTOR, Outer Air—R. H 9.262
16 — RETAINER, Deflector—R. H 9.262
17 — RETAINER, Deflector—Felt 9.264
18 — OUTLET, Air 9.262
19 — DOOR, Inst. Panel Compt. (Color) 10.261
20 — BEZEL, Trim Plate Opening —1970-72 .. . . 10.252—1973-74 . 10.252
21 — PLATE, Inst. Panel Trim 10.252
22 — SCREW, Outlet to Pad (#10~16 x 3/4”) N.S.
23 — OUTLET, Center Air 9.262
24 — OUTLET, Outer Air—L. H 9.262
25 — RETAINER, Vent Deflector 9.262
26 — COVER, Cal. Opening 6.760
27 — STUD, Cover to Pad 6.760
28 — RETAINER, Cover to Pad 6.760
29 — RECEPTACLE, Cover to Pod 6.760
30 — RETAINER, Deflector—L. H 9.262
31 — SEAL, Side Vent Duct—L. H 9.262
32 — DUCT, Ext. to L. H. Outlet Duct.—L. H 9.262
33 — DUCT, Air Outlet-L. H 9.262
34 — EXTENSION, Main Air Dist.-L. H 9.262
35 — OUTLET, Air Dist. Air—Center 9.786
36 — SEAL, Main Air Dist. Outlet 9.262
37 — SEAL, Heater Air Outlet 9.262
38 — OUTLET, Air Dist.Kenter 9.786
39 — DIAPHRAGM, Defroster Valve 9.779
40 — GASKET, Case & Core to Dash 8.8S4
41 — RIVET, Bracket to Nozzle N.S.
42 — BRACKET, Case to Nozzle N. S.
GROUP 9.000 ILLUSTRATIUN 19 ‘ __________________ —
~TTh~IRDPARTS CATALOGUE
1970.74 FIREBIRD AIR CONDITIONING — REFRIGERATION SYSTEM (EXC. V.LR.)
GROUP 9.000 ILLUSTRATION 20
[~~jFIRE’ThW1PARIS CATALOGUE
1970-74 FIREBIRD AIR CONDITIONING — REFRIGERATION SYSTEM (EXC. VIR.)
Key Part Name
— HARNESS, Vacuum Hose (F/B)2 — VALVE ASM., Vacuum Check3 — CLAMP, Valve4 — HOSE, Vacuum Check Valve (3/16” I. D. x 8” Ig.)5 — VALVE ASM., Suction Throttle (P.O.A.)6 — GASKET, Refrigerant Control Valve7 — GASKET, “0” Ring (3/4” 0. D.)8 — DIAPHRAGM, Evap. Purge Valve9 — VALVE, Refrigerant Expansion
10 — GASKET, Hose to Valve11 — CUP, Hose & Coupling12 — HOSE & COUPLING ASM., Receiver to Evop13 — BRACKET, Muffler Mtg14 — SPACER, Hose15 — HOSE, Freon (1/2” I. D. — 17” req’d.)16 — CLAMP, Fittings to Brkt17 — TUBE ASM., P.O.A. Value to Suction Hose18— CLAMP, Valve Tube19 — HOSE, Freon (5/8” I. D. — 15 1/2” req’d.)20 — BOLT, Fittings to Camp. (3/8—24 x 1 1/8”)21 — LOCKWASHER, Fittings to Camp. (3/8”)22 — FITTING ASM., Compressor23 — BRACKET,, Muffler to Compressor24 — BOLT, Fitting to Comp. (5/16—24 x 1 3/4”)25 — WASHER, Fitting to Camp26— NUT, Fitting to Camp. (5/16-24)27 — LOCKWASHER, Fitting to Comp. (5/16” Ext. Tooth)28 — BOLT, Fitting to Comp. (5/16” — 24x 1”)29 — LOCKWASHER, Fitting to Comp. (5/16”)30 — NUT, Fitting to Camp. (5/16—24)31 —MUFFLER ASM., Compressor—1970.71 All, 1972 1st Type
—1972 2nd Type, 1973 All32 — CLAMP, Hose33 — CONDENSER ASM., Refrigerent34— NUT, Condenser to Baffle (5/16—18)35 — INSULATORS Condenser36 — SEAL ASM., Rad. Baffle Frame Bar Opening37 — SUPPORT, Receiver38 — BRACKET, Receiver39 — RECEIVER & DEHYDRATOR ASM40— EVAPORATOR ASM41 — HOSE, Heater (5/8” I. D. — 23” req’d.)42 — CLAMP, Water Hose43 — HOSE, Henter Outlet (3/4” I. D.)44—STRAP, Hose to Pipe45 — VALVE ASM., Water Temp. Control46 — BRACKET, Temp. Control Valve47 — NUT, Valve to Brkt. (13/16-20)48 — HOSE, Heater to Valve (5/8” I. D.)49 — CLAMP, Drain Hose50 — HOSE, Drain51 — MOTOR ASM., Blower52 — GROMMET,Heater Core Tube—Upper53 — IMPELLER, Blower Motor54 — STUD, Motor & Inlet to Dash55 — WASHER (Spec. 19/6*’ I. D. x 1/2” 0. D.)56 — GROMMET,Condenser to Receiver Hose57 — HOSE & COUPLING ASM., Condenser to Receiver
Group No.
9.2819.2819.198N.5.
9.1989.1989.2 149.2119.2 139.2149.2819.2229.2429.2428.962N.5.
9.2299.1988.962N.S.
8.9319.2269.2428.9009.173N.S.
8.9328.9008.93 1N.S.
9.2269.2269.2429.1908.915
9.1901.2749.2069.2069.1959.2108.9628.9489.9628.9469.7959.795N .5.
8.9629.2 119.2 119.2158.8469.2169.2 15N.5.
9.7759.227
GRUUP 9.000 ILLUSTRATION 21
PARTS CATALOGUE1GM 7ThflIR1
1973-76 FIREBIRD AIR CONDITIONING — REFRIGERATION SYSTEM (WITH V.I.R.)
GROUP 9000 ILLUSTRATION 22
PARTS CATALOGUE1GM W~flR1
1973-76 FIREBIRD AIR CONDITIONING — REFRIGERATION SYSTEM tWITH V.I.R.)
Key Part Name Group No.
— FIrING ASM., Muffler 1w/Hoses & Muffler) 9.226
2— COMPRESSOR, Air Conditioner 9.170
3—GASKET.‘0” RIng (27160Z I.D. xl,’ 0.0.) 9.214
4 — WASHER(5/16” I.D. x 3/4” 0.0.1 8.929
5—NUT 1114”—20) 8.915
6—GASKET, “0” Ring 13/8” O.D.l 9.214
7—TUBE ASM., VIR to Condenser 9.227
8—CONDENSER, Refrigerant 9.190
9—SCREW (5/16”—18 x 3/4”) 1.276
10—TUBEASM.,CondensersoVlRTube 9.227
11 — GROMMET,Cond. to Receiver Tube 9.775
12—NUT(5/16”—18) N.S.
13— RECEIVER ASM., Refrigerant IVIR) 9.195
14—MOTOR,Blower 9.215
15— FAN, Blower 9.216
18—SCREW (1/4”—14x 1”) N.S.
17— EVAPORATOR, Refrigerant 9.210
18— WASHER (9/32” I.D. x 1/2” O.D.l N.S.
19—STUD, Evaporator 9.275
20— SCREW (1/4”—14 x 1/2”) NS.
21 — WASHER (9/32” 1.0. x 1” 0.0.1 N.S.
22 — BRACKET, Muffler Mtg 9.242
23 — GASKET, “0” Ring (3/4” 0.0.) 9.214
24 — BOLT (3/8”—24 x 1-3/8”) N.S.
25— LOCKWASHER (3/8”) 8.931
GROUP 9.000 ILLUSTRATION 23
Key
PARTS CATALOGUE1GM WThIRfl
Part Name
1 — EVAPORATOR ASM., Refrigerant2 — RECEIVER ASM., Refrigerant3 — GASKET, Pipe to Receiver 13/4” 0.0. “0” Ring)4 — FIrINGS, Compressor 1w/Muffler & Fittings)5— BOLT (3/8”-16 x 1-5/8”)6— WASHER (1/8” I.D.)7 — COMPRESSOR, A.C8— GASKET 127/64” 1.0. x 1” 0.0. “0” Ring)9 — TUBE ASM., Condenser to Muffler
10—NUT (1/4”-20)11 — WASHER 15/16” I.D. x 3/4” O.D.)12— CONDENSER, Refrigerant13— SCREW (5/16”-18 x 13/16”)14— GASKET (3/8” OD. “0” Ring)15— TUBE ASM., Condenser to V.I.R. Tube16 — CLIP, A.C. Tubes Condenser Mtg. BrkR17—SCREW l1/4”-14x3/4”)18 — BRACKET, Condenser Tubes Mtg19—NUT I1/4”-14)20—NUT 15/16”-18121 — TUBE ASM., VIR. to Condenser Tube22 — MOTOR, Blower23—SCREWI1/4”-14x 1”!24— FAN, Blower Motor
1975-76 AIR CONDITIONING —6 CYL. ENGINE REFRIGERATION SYSTEM
Group No.
9.2109.1959.2149.226N.S.N.S.9.1709.2149.2278.9158.9299.190N.S.__9.2149.2279.1908.9779.1908.9218.9159.2279.215N.S.9216
GROUP 9.000 ILLUSTRATION 23A
1GM’ FIREBIRD I7
1970 FIREBIRD AIR CONDITIONING—CONTROLS
Key Part Name
1 — VALVE, Heater Control Vacuum (3 Opening)2—HARNFSS,VncuumRn~p
3 — NUT, Hose to Diophcogrn4 — SWITCH, Heater Control Vent5 — CONTROL ASM. Heater & Air Conditioning6 — VALVE, Heater Control Vacuum (9 Opening)7 — SWITCH, Blower Motor8 — SWITCH, Master9 — CABLE; Temp. Control
10 — SCREW,Cable Clip Retaining (#l0~16 x 1/2”)11 — CLIP, Hose Retaining12 — INLET, Plenum Air
— RAFFIF, Sid Skrn,id Vnr,j,,m Control
14 — DIAPHRAGM, Air Inlet Valve15 — LINK, Inlet Valve16— NUT, Inlet to Panel (#lD~24)17 — SPRING, Valve to Plate18 — LINK, Shroud Vacuum Control19 — NUT, Link Retaining20 — RETAINER, Pin to Arm (5/16”)21 — NUT, Shroud Side Control Cover to Panel22 — NUT, Diaphragm to Bracket23 — WASHER, Diaphragm to Bracket Lock24 — SCREW,Inlet Bracket Attadhing (1/4—14 x 5 8”)25 — DIAPHRAGM, Inlet Side Shroud26 — SCREW,Cover to Panel27 — COVER, Side Vacuum Control28 — SCREW, Diaphragm to Arm (#8~l8 x 3/8”)29 — BRACKET, Inlet Side Shroud30 — SPRING, Side Shroud Vacuum Control31 — PIN, Shroud Vacuum Control32 — ARM, Side Shroud Vacuum Control
Group No.
9.2799. 2R 1
9.7899.2759.2739.2799.2759.2759.2818.977N.5.
9.7869.2 lB9.2819.7868.9219.7869.7869.7898.9349.7898.9 158.932N.S.
9.281N.S.
9.7898.9779.7869.789
9.7869.786
GROUP 0.000 ILLUSTRATION 24
1GM r~mriPARTS CATALOGUE
1970-73 FIREBIRD AIR CONDITIONING ELECTRICAL PARTS
Key Port Name
1 — WIRE HARNESS ASM., Blower & Relays (Exc. Elec. Def.) (197D—71)WIRE HARNESS ASM., MC Dash (1972)
(197312 — WIRE HARNESSASM., A.C. & Heater Control (Exc. Elec. Def.)3 — WIRE HARNESS ASM., Inst. Panel4—GASKET, Blower Resistor5— SCREW, Blower Resistor Mtg. (#10~l6 x 5/8”)6—RESISTOR, Blower Motor (1970-71) .
RESISTOR, Blower Motor 11972-73) .
7 — CLIP, Harness (Adj.—plastic)8 — RELAY, Interlock (1970)9—SCREW, Relay Mtg. (#l0~l6 x 1/2”)
10— WIRE HARNESS11 — RELAY, Hi—Blower (1970-71)
RELAY, Hi—Blower (1972-73)12 — CLIP, Blower & Relay Harness13 — SWITCH, Camp. Ambient Sensor14— GASKET, Ambient Switch to Evap. (1970)15 — SWITCH KIT, Super Heat Shut—Off (1971-73)16— HARNESS ASM., Compressor Protection (197 1-72)17— FUSE, Compressor Protection Thermal (1971-73)
Group No.
9.2769,2769.276
9.2762.480
N.S.8.9779.2759.2752.4829.7788.9772.4809.2759.2752.4829.2759.2759.1729.1729.172
GROUP 9.000 ILLUSTRATION 25’
1GM [PIREBIRD 1
1974 FIREBIRD AIR CONDITIONING—ELECTRICAL & VACUUM
Part Name
1 — FUSE, Comp. Protection Thermal2—HARNESS,Vacuum Hose3—WIRE,A.C. & Heater Control4—WIRE, Inst. Panel5—CONTROL,A.C. (Exa. Trans Am) - . -
CONTROL,A.C. (Trans Am)6 — CABLE, Temp. Control7—WIRE,A.C.Dash
8— VALVE, Vacuum Check
9— RECEIVER ASM., Refrigerant (VIR)
10—SWITCH, Compressor Ambient11 — EVAPORATOR,Refrigerant12 — RESISTOR, Blower Motor13— RELAY, HI-Blower
14— SCREW (#10—15x 51W’)
Key Group No.
9.172
9.281
9.278
2.480
8.849
8.849
9.787
9.276
9.281
9.195
9.275
9.210
9.275
9.275
8.977
GROUP 9.000 ILLUSTRATION 26
GM SDPARTS CATALOGUE
Key
1 — BRACE, Compressor—Rear2 — ROD, Engine Oil Level Indicator3 — NUT, Tube Asia. to Camp. Brace (1/4—14 “U”)4— BOLT, Camp. Rear Brace to Mfld. (3/8” —16x 5/8”)S — BOLT, Camp. Front Brace to Supt. (3/8—16 x 7/8”)6 — SCREW, Camp. Brace to Tube km. (1/4-14 x 3/4”)7 — BRACE, Compressor Frant—1970-72
B — NUT, Camp. Frt. Brace to MfId. Bolt (5/16—18)9 — BOLT, Camp. to Frt. Supt. (5/16—24 x 5/8”)
10 — SUPPORT, Compressor—Front11 — PULLEY, Water Pump & Fan (59/16” dia.)—double groove12 — NUT, Camp. Lower Rear Brace to Head Bolt (3/8—16)13 — COMPRESSOR ASM., Air Conditioning14— BOLT, Camp. to Rear Mtg. Plate (3/8—16 x 1 1/8”)15 — BOLT, Camp. Frt. Supt. to Head (3/8-16 x 1 7/8”)16 — WASHER, Camp. !rt. Supt. to Head (13/32” I. D.)17 — SPACER, Camp. Frt. Supt. to Head18— BOLT, Crankshaft Pulley Plate (5/16”—24x 3/4”)19 — PLATE, Crankshaft Pulley Reinforcement20— PULLEY, Cronkshaft—(7 3/16” dio.)—double groove21 — PULLEY, Crankshoft—(7 7/16” dia.)—single groove22 — SCREW, Oil Tube to Brace (5/16—12 x 5/8”)23 — TUBE MM., Oil Level Indicator—Upper24 — INDICATOR ASM., Engine Oil Level25 — BOLT, Camp. Mtg. Brkt. to Head (3/8—16 x 1 1/4”)26 — BRACKET, Compressor Mtg.—1970-72
27 — TUBEMM., Engine Oil Level Ind.—Upper28 — PLATE, Compressor Mtg.—Rear29 — SPACER, Camp. Rear Brace to Comp.—1970
30 — BRACE, Comp. Lower Rear-to Head31 — WASHER, Camp. Frt. (13/32” I. D.)32 — SPACER, Camp. Rear Brace to Camp. (3/8—16 x 2 1/4”)33 — BOLT, Camp. Rear Brace to Camp. (3/8—16 x 2 1/4”)34 — BOLT, Camp. Rear Brace to MfId. (5/16”—18 x 1 1/8”)
GROUP 9.000 ILLUSTRATION 27
PARTSGroup No.
9.1711.5168.9218.9008.9008.9779.171
8.9158.9009.1711.0628.9 159.1708.9008.9009.1739.1718.9000.6600.6590.6598.9771.5161.5 168.9009.171
1.5169.1719.17 1
9.1719.1739.171
8.9008.900
1070-72 FIREBIRD A/C COMPRESSOR MOUNTING AND DRIVEPart Name
j~TThflIRflPARTS CATALOGUE
Key Part Name Group No.
1 — BRACE, Camp. Rear - Upper 9.1712— BOLT 13/8-16 x 5/81 8.900
3— BRACE, Camp. Front 9.1714— NUT (5/16”-181 8.9155— BOLT l5/16”.24 x 3/4”! 8.9006— SUPPORT, Camp. Front 9.1717—NUT 13/8-161 8.915
8— COMPRESSOR, A.C 9.1709—BOLT(3/8”-16x1-1/8”l 8.900
10—BOLTI3/8”-16x1.7/8”I 8.90011 — WASHER, Supt. to Head 113/32” ID.! 9.17312— SPACER, Supt. to Hose 9.17113— BOLT l5/16”-24 x 3/4”! 8.90014— BRACKET, Camp. Mounting 9.17115—BOLT (3/8”-16x1-1/4”! 8.90016— BRACE, Camp. Lower Rear IAII exc. 455 HO. or S.D.! 9.171
BRACE,Camp. Lower Rear 1455 HO. or 5.0.1 9.17117— PLATE, Camp. -Rear 9.17118— BOLT (3/8”-16 x 7/8”! 8.90019— SPACER, Rear Brace to Camp 9.17120— WASHER, Camp. Mtg. (13/32’ ID. x 3/4” 0.0.! 6.60621 — BOLT 13/8”-16 x 2.1/8”l N.S.22— TUBE ASM., Indicator - Upper (455 S.D.! 1.516
TUBE ASM., Indicator - Upper (Ram Air! 1.516
23—INDICATOR ASM., Oil Level 1.51624— TUBE ASM.. Indicator - Uaaer (Exc. 455 or Ram Air! 1.516
GROUP 9.000 ILLUSTRATION 28
RAM AIR& S.D.
1973-74 A/C COMPRESSOR MOUNTING
1GM’ FIREBIRD I. .a int ..s.u mzu, in1:m: ,p. Sfl
1970-74 VENTILATION CONTROL (EXC. A.C.)
Key Part Name
1 — CONTROL,Shroud Duct Air—Lower (10%” Long)
2—DOOR,Shroud Lower Air Oudet—L.H
3 — PANEL, Shroud Side Trim Finish
4 — CLIP, Upper Level Control Cable to Outlet Asm
5 — DOOR,Upper Level Vent—L.H
6 — OUTLET, Upper Level Air—L.H
7 — OUTLET, Upper Level Air—R.H
8 — DOOR,Upper Level Vent—R.H
9 — SEAL, Inst. Panel Side Vent Duct—R.H
10— DUCT. Inst. Panel Side—R.H
11 — DEFLECTOR, Outer Air—R.H
12 — CONTROL, Shroud Duct Air—Upper
13 — DOOR,Shroud Lower Air Outlet—R.H
14 — DEFLECTOR, Outer Air—L.H
15 — CONTROL, Shroud Duct Air—Upper
16 — DUCT, INst. Panel Side—L.H
17 —SEAL, Inst. Panel Side Vent Duct—L.H
Group Na.
9.787
9.789
14.630
9.787
9.789
9.789
9.789
9.789
9.784
9.784
9.262
9.787
9.789
9262
9.787
9.784
9.784
GROUP 9.000 ILLUSTRATION 29
j~T7~IRDPARTS CATALOGUE
Hose Fitting Packages and Related Parts, Air Conditioning Refrigerant
HOSE FITTINGS PACKAGESINCLUDE “0” RINGS AND CLAMPS REO’D. FOR INSTALLATION.
0? rtGICrKnflflrNr~J
uU~~LrrTHREAD HOSE
SIZE I. 0.
A 11/16-16A 5/8-16A 3/4-18A 7/8-18A 1- 1/16-16A 5/8-18A 3/4-18
B 5/8-18B 3/418B 7/8-18B 1 1/16-16B 5/8-18B 3/4-18
C 11/16-16C 5/8-18C 11/16-16C 3/4-18C 7/8-18C 1 1/16-16C 5/8-18C 3/4-18
D 5/8-18D 3/410D 7/8-14D 1 1/16-14D 5/8-18D 3/4-16D 7/8-14
5/165/16
13/321/25/8
13/321/2
5/1613/32
1/25/8
13/321/2
5/165/16
13/3213/32
1/25/8
13/321/2
5/1613/321/25/8
13/321/25/8
PARTNO.
3023674302367530236763023677302367830236793023680
3023657302365830236593023660302366130236623023663
30245343023711302371230237133023714
30236823023683302368420236R830245363023664302366530236663023667
THREAD HOSETYPE SIZE 1.0.
E 5/8-18E 3/4-16E 7/8-14E 1 1/16-14E 5/8-18E 3/4-16E 7/8-14F 5/8-18F 3(4-16F 7/8-14F 1 1/16-14F 5/8-18F 3/4-16F 7/8-14
G 5/8-18G 5/8-180 3/4-160 7/8-14G 1 1/16-14
H 5/8-18H 3/4-16H 7/8-14H 1- 1/16-14
J 5/8-18J 5/8-18J 3/4-16J 7/8-14J 1 1/16-14
5/1613/32
1/25/8
13/321/25/8
5/1613/32
1/25/8
13/321/25/8
5/1613/32
1/25/85/8
13/321/25/85/8
5/1613/32
1/25/85/S
PARTNO.
3023686302368730236883023689
30237183023719
3024791
3023722
3023715
3023716
3023717
3023721
3023720
3981880
3923139
3970541
3024788
3024789
FITTING
THREAD HOSETYPE SIZE 1.0.
KKKK
LL
MMl
N
N
0P
UR
S
T
U
V
ONLY
5/1613/32
1/25/8
1/2
5/8
5/8-18(MaIeI 5/16
1/16-14 IFemale)5/8
13/32
1/2
5/8
13/32-5/S
13/32
1/2
1/2-5/8
1/2-5/8
5/8
13/32
A r
TYPEPART
NO.
302453~302369130236923023693302369430236953023696
302366830236693023670302367130236723023673
30245373023651392575130236523023653302365430236553023656
30236973023030302369930237003023701302370930237 10
HOSE, CLAMP, O’RINGS
230882 Haag RefrIg. (5/16” .0. x 15’) 8526398 O’plng (3/8” 1.0.)230883 Nasa, Refrig. I1~I32” 1.0. x 15’) 3140800 O’RIng (1/2” (.0.)230884 Nasa, Rafrig. (1/2” t.D. x 15’) 3140748 O’Rlng (5/8” (.0.)230885 Nasa, Ratrig. (5/8” i.D. x 15’! 3140852 O’Rlflg (3/4” 1.0.)
5887997 O’Rlng. Fitting to Camp.eoooao Clamp, Adj. Mass (with Locator Tab)
GROUP 9.000 ILLUSTRATiON
PARTS CATALOGUE1GM flflRD
1967-68 FIREBIRD STEREO TAPE PLAYER SYSTEM
Key Part Name Group No
.
1 — WIRE HARNESS, Rear Seat Speaker Stereo Tape 9.670
2 — SCREW, Front Speaker and Grille Attaching (#10~16 x 7/8”) N.S.
3 — GRILLE, Stereo Tape Front Speaker 9.670
4 — SPEAKER, Front Stereo Tape Player 9.650
5 — SPACER, Front Stereo lope Speaker to Grille 9.655
6 — SPACER, Front Stereo Tape Speaker to Panel 9.655
7 — SPACER, Front Stereo Tape Speaker to Panel 9.655
8 — “U’ NUT, Speaker Grille to Panel Attaching (#10~l6) N.S.
9 — TAPE PLAYER, Stereo (Serviced in Accessory Package Only)
10 — SCREW, Top Cover to Tape Player (#6—20 x 7/16”) N.S.
11 — BRACKET, Stereo Tape Player Mtg. (Exc. Console) 9.670
12 — SCREW, Mounting Bracket to Inst. Panel (#10~24 x 1/2”) N.S.
13 — LOCKWASHER, Mounting Bracket Plate to Bracket (#8 — Ext.) NS.
14 — NUT, Mounting Bracket Plate to Bracket (#8~32) 9.670
15 — SCREW, Mounting Plate to Mounting Bracket (#8~32 x 1/2”) N.S.
16 — PLATE, Stereo Tape Mounting Bracket 9.670
17 — KNOB, Stereo Tape Switch (w,tWire) 9.670
18 — SCREW, Bottom Cover to Tape Player (#6~20 x 7/16”) N.S.
19 — COVER, Stereo Tape Player (Top and Bottom) 9.670
20 — BEZEL, Stereo Tape Control Knob 9.670
21 — NUT, Trim Plate to Tape Player 9.670
22 — KNOB, Stereo Tape Player 9.670
23 — PLATE, Stereo Tape Player Trim 9.670
24 — BRACKET, Stereo Tape Player Mounting (w/Console) 9.670
25 — SCREW, Mounting Bracket toConsole (#10~32 x 5/8”) 8.977
26 — NUT, Mounting Bracket to Console (#10~32) N.S.
27 — GRILLE, Rear Seat Speaker 9.655
28 — SCREW, Rear Seat Speaker Grille Attaching (#8~32 x 1 1/4” Oval Hd.) N.S.
29 — SPRING, Ground N.S.
30 — NUT, Rear Seat Speaker Grille Attaching (#8~32 Stamped) 8.921
31 — SPEAKER, Rear Seat 9.665
32 — WIRE ASM., Front Speaker Stereo Tape 9.670
GROUP 9.000 ILLUSTRATION 33
PARTS CATALOGUEGM flrflIRlL.
15
CONSOLE
ill
14 .i. — — —
/
FLOORMOUNTED
1969 FIREBIRD STEREO TAPE PLAYER SYSTEM
Group No. Key Part Name
1 — BRACKET, Stereo Tape Player to Console2 — SCREW, Tape Player to Console (#10~32 x 7/8”).3 — RETAINER, Tape Player to Mtg. Bracket
(w/Console)4 — PLAYER, Stereo Tape (Serviced in Accessory Package5 — NUT, Tape Player Housing to Player6 — BEZEL, Stereo Tape Player Control Knob7 — WASHER, Stereo Tape Player Knobs8 — KNOB, Stereo Tape Control9 — BEZEL, Stereo Tape Balance Control Knob
10 — NUT, Tape Player to Bracket — (#10~24)11 — NUT, Bracket to Console (#l0~32~special)12 — BRACKET, Stereo Tape Player Mtg. — (Upper).13 — SCREW, Lower Mtg.Bracket to Pan (1/4”.14 x 3/4”)14 — BRACKET, Stereo Tape Player Mtg. — (Lower).
9.670 15 — SCREW, Upper Bracket to Lower BracketN.S. & Console (#8 — 18 x 5/8”)
16 — RETAINER, Tape Player to Mtg. Bracket —
9.670 (cxc. Console)Only) 17 — NUT, Upper Brkt. to Lower Brkt. — (#8~18)9.670 18 — SCREW, Housing to Tape Player — (#8 — 18 x 1/2”)9.670 19 — GRILLE, Stereo Front Speakers9.649 20 — SCREW, Grille to Speaker — (#10 — 16 x 3/4”)9.649 21 — SCREW, Grille to Speaker — (#10 — 16 x 1”)9.670 22 — SPEAKER, Stereo Tape — (Front)8.915 23 — NUT, Speaker to Shroud Panel — (#10 — 16)
N.S. 24 — WIRE ASM., Stereo Tape Player
9.670 25 — HOUSING, Stereo Tape Player8.977 26 — WIRE ASM., Stereo Tape Player (AM & AM/FM).9.670 27 — WIRE ASM., Stereo Tape Player (AM/FM Stereo).
Key Part Name Group No.
N.S.
9.6708.9218.9779.6708.9778.9779.6508.9219.6 709.6 709.6709.670
GROUP 9.000 ILLUSTRATION 34
~IRflPARTS CATALOGUE
FIREBIRD STEREO TAPE SYSTEM (TYPICAL)
Part Name
1 — TAPE PLAYER, Stereo
2 — SCREW, Housing to Tape Player (#8—18 x 1/2”)
3 — HOUSING, Player
4— NUT, Player to Housing
5 — BEZEL, Control Knob
6 — SPRING, Control Knob
7 — KNOB, Control
8 — BEZEL, Tone Control Knob
9 — PLATE, Trim
— BRACKET, Player Supt. - RH (w/consale)
11 — BRACKET, Player Mtg. — Lower (w/canso Ic)
12 — BRACKET, Player Supt. — LH (w/console)
Group Na. Key Part Name Group Na.
9.670 13 — SCREW, Lower Brkt. to Console (#10~16 x 1/2”) - -
8.977 14 — DUCT ASM., Air Distributoc
9.670 15 — SEAL, Air Distributor
9.670 16 — SEAL, Air Outlet
9.670 17 — BASE, Player Housing (cxc. console)
9.670 18 — BRACKET, Player Lower Mtg
9.670 19 — RETAINER, Player to Upper Mtg. Brkt
9.670 20 — BRACKET, Player Upper Mtg
9.670 21 — NUT, Player to Bracket (10—24)
9.670 22 — SCREW, Lower Srnrkms to Pan (1/4” — 14 x 5/8”) -
9.670 23 — WIRE ASM., Tape Player (cxc. stereo radio)
9.670 24 — WIRE ASM,, Tape Player (w/sterea radio)
Key
8.977
9.786
N.S.
N.S.
9.670
9.670
9.670
9.670
8.9 15
N.S.
9.670
9.670
GROUP 9.000 ILLUSTRATION ‘35
Key Part Name Group No.
1 — WIRE, Rear Mounted Tape Player — w/Console 9.670
2 — CLIP, Control Feed to Cluster & Clock 2.482
3 — CLIP, Wire to Maunting Brkt N.S.
4— SCREW, Cover to Maunting Brkt. (#8~18 x 1/2”) 8.977
5 — COVER, Tape Player Mounting Brkt 9.670
6 — TAPE PLAYER, Stereo 9.670
7 — COVER, Tape Player - Rear 9.670
8 — BRACKET, Tape Player Mounting — Upper (w/Consale) 9.670
9 — SCREW, Upr. Brkt. to Lwr. Brkt. (1/4—14 x 5/8”) N.S.
10— BRACKET, Player Mounting — On Floor Pan N.S.
11 — SEAL, Heater Air Outlet 9.262
12 — SEAL, Main Air Distributor Outlet 9.262
13 — DUCT ASM., Air Distributor 9.786
14 — CARTRIDGE, Stereo Cassette 9.670
15 — NUT, Player to Mtg. Brkt. (#l0~24) 8.915
16 — BRACKET, Player Mounting (cxc. Console) 9.670
17— SCREW, Bracket to Pan (1/4—14 x 5/8”) N.S.
18 — WIRE, Tape Player Jumper 9.670
GROUP 9.000 ILLUSTRATION 36
FIREBIRDPARTS CATALOGUE
AM-FM 1W/STEREO)AMRECEIVER & TAPE PLAYER
& TAPE PLAYER
FIREBIRD CASSETTE TAPE PLAYER (TYPICAL)
PARTS CATALOGUE1GM flflIRfl
1967-66 FIREBIRD MANUAL ANTENNAS
REAR MOUNTED
Key Description Part No. Oty. Group
9.6479.6479.647
1 Antenna Assy. —1967 .. .— 1968 with AM/FM—1968 Exc. AM/FM
393422438757003934224
111
2 Nut Antenna Mounting 3863499 1 9.647
3 Gasket, Antenna Mounting Nut to Bezel 3138635 1 9.647
4 Bezel, Antenna to tender — 1967...—1968 . .
38695173903424
11
9.6479.647
5 Gasket, Antenna Bezel to Fender . , . . 3820672 1 9.647
6 Ring, Antenna Ground 3903406 1 9.647
7 Body Assy., Antenna . 3880695 1 9.647
8 Lead-in Assy., Antenna 3897311 1 9.647
FRONT MOUNTED
Key Description Part No.
Antenna Assy, — 1967 . 3934224— 1968 with AM/FM 3875700—1968 Exc. AM/FM .... 3934224
2 Nut, Antenna Mounting 3863499
3 Bezel, Antenna to Fender . 3897333
4 Gasket Antenna Bezel to Fender 3820672
5 Ring, Antenna Ground . 3863239
6 Body Assy., Antenna 3880695
7 Lead-in Assy., Antenna 3897334
Qty. Group
1 9.6471 94471 9.6471 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
GROUP YAYJO I LLUSTRATI ON 37
PARTS CATALOGUEGM rflflRfl
MANUALANTENNA
Key Description Part Na. Qty. Group
1 Rod and Mast Assy., Manual . . 9794673 1 9.647
2 Nut, Antenna Mounting 536343 1 9.647
3 Adopter, Antenna to tenders . 9795979 1 9.647
4 Pad, Antenna to Fender 9774043 1 9.647
5 Body Assy., Antenna 9784386 1 9.647
6 Leod.in Assy., Antenna 9796809 1 9.647
7 Ring, Antenna Ground 9784334 1 9.647
B Clip, Lead-in to Defroster Duct ... 9798933 1 9.647
ELECTRICAL
Qty. Group
1 9.647
Key Description Part Na.
I Switch and Wire, Power Antenna Control 9797084
2 Clip, Power Antenna Control SwitchRetaining 9796965
4 Antenna Assy., Includes Motor 9796289
5 Nut Antenna Mounting—Upper Adapter 9796252
6 Seal, Power Antenna—Antenna MountingNut to Fender 9796326
7 Seol, Power Antenna—Mounting Nut 9796325
B Adopter, Antenna to Fender —Upper .. 9796516
9 Pod, Antenna to Fender—Ta Upper
Adopter 9782911ID Seal, Power Antenna—Mounting
Lower Adapter 9779667
11 Adopter, Antenna to Fender—Lower 9796515
12 Bracket, Antenna—Mounting 9796374
13 Bracket, Antenna—Anti-Twist 9796373
15 Lead.in Assy., Antenna 9793107
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1 9.647
1969 FIREBIRD ANTENNAS
GROuP 9.000 ILLUSTRATION 38
I
PARTS CATALOGUE1GM flflIRWl
1967-75 BODY MOUNTS — GROUP 9.023
PositiOnCushion
#1 #2
ModelYear Upper Lower Upper Lower Upper Lower1967 3893159 3893156 3893161 3914802 3901361 3914802
1968 3893159 3893156 3928380 3914802 3901361 3914802
1969 3893159 3893156 3928380 3914802 3901361 332654
1970 3893159 3893156 3928380 332654 3901361 332654
1971 478779 478778 3928380 332654 3901361 332654
1972 478779 478778 3928380 332654 3901361 332654
1973 478779 478778 332608 332654 332609 332654
1974-76 478779 478778 332608 332654 332609 332654
GROUP 9.000 ILLUSTRATION 39