Upload
others
View
14
Download
0
Embed Size (px)
Citation preview
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd.,Ankleshwar. 1
1.0 EXECUTIVE SUMMARY
M/s. J.R.Corporation is engaged in manufacturing of Bulk drugs and its intermidiates at Plot no.
B/1085, Lamdapura road, Vill:Manjusar, Tal: Savli, Dist: Vadodara- 391 770. The unit is having valid
Consolidated Consent & Authorization (CC&A) from Gujarat Pollution Control Board vide CC&A
order no.: AWH-69376 with validity upto 10/02/2020 for manufacturing of Bulk drugs and its
intermidiates. The copy of CC&A is enclosed herewith as Annexure-I. They have now proposed to go
for expansion by increasing existing production capacity and proposed new production capacity of
Synthetic API’s. As per EIA Notification dated 14th Sep, 2006 as amended from time to time, the
project falls under as Category ‘A’ Project. The existing unit is engaged in manufacturing of Bulk
drugs and its intermidiates and production capacity is 2.6 MT/Month. The details of products are given
below table 1.
TABLE: 1
LIST OF PRODUCTS
Sr. No.
Name of Products Existing Quantity in MT/Month
Proposed Quantity in MT/Month
Total Quantity in MT/Month
EXISTING 1 Cellulose Acetate Phthalate-
I pluse p grade 1.5 0 1.5
2 Hydroxy propyl methyl cellulose phthalate USP grade(HPMCP)
1.1 0 1.1
3 Crude sodium Acetate(by production)
8 0 8
PROPSOED 1 Metoprolol titrate/succinate 0.0 3 3 2 Diclofenac sodium 100 100 3 Dextromethophan Hbr 5 5 4 Captopril 1 1 5 fexofenadine HCl 3 3 6 Entaxapone 1 1 7 Amoldipine besylate 2 2 8 Clinidipine 1 1 9 Devalproex sodium 1 1 10 Iopamidol & its derivatives 20 20 11 Nebivolol 1 1 12 Venlafaxine HCl
&derivative 5 5
13 Bethanechol chloride 1 1 14 Pidotimod 5 5
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 2
15 Oxybutynin chloride 1 1 16 Pregablin 4 4 17 Aceelofenac 50 50 18 Valproic acid 3 3 19 Sodium valproate 10 10 20 Diatrizoic acid 5 5 21 R&d products 3 3 Total 0.00 225 235.6
The expected cost of project is Rs. 5 Crores. The total plot area of the unit is 9765 sq.m. The green
belt area will be 1000 sq.m. The unit is using Wood as fuel. The fuel consumption is 1.50 T/day for
boiler. Existing fresh water consumption requirement is 1.525 KLD for industrial and domestic
purpose. For proposed expansion, total water consumption will be 86.525 (38.5 KLD (Recovered) +
48.025 KLD (Fresh)) for industrial and domestic purpose after proposed expansion. The existing
connected load is 60 HP. Aditional load will be 440 HP.It will be met through Madhya Gujarat Vij
Company Ltd.In existing, Unit is using 1.5 T/day wood as fuel for boiler. After Proposed expansion,
unit will be using bio-coal (4 MT/day) as a fuel for two boilers (1 TPH Each), furnace oil (200
Liters/day) thermo pack (2 Lakh K.cal/Hr.) and diesel (100 Liters/day) for one DG set of 150 KVA.
The total hazardous waste generation from proposed expansion will be Residue & waste- 5MT/Month,
Spent Catalyst-2 MT/Month, Discarded Containers-600 Nos./year, Crude Sodium Acetate (8
MT/Month), Distilled solvents-50MT/Month and MEE salt/ETP Sludge-45MT/month.
2.0 INTRODUCTION
2.1 The Project
M/s. J.R.Corporation is engaged in manufacturing of bulk drugs intermidiates at Plot no. B/1085,
Lamdapura road, Ta: savli, Dist: Vadodara- 391 770.
The list of products is provided in table 1.
2.2 Project Proponent
The details of project proponent are given below in table. TABLE: 2
CONTACT DETAILS OF THE PARTNERS
Sr. No.
Name of Director
Designation Address Mobile No.
1 Pawan Jain Partner B/365 shastrinagar, bhilwara, Rajasthan
9309242010
2 Shilpa Chaudhary
Partner 43 Gangotri residency, Gotri road, Vadodara
8140411000
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 3
The partners of the company have good experience in handling the production management, financial
management and all the allied areas.
2.3 Nature of project
The existing unit is engaged in manufacturing of bulk drugs & intermidiates. The existing production
capacity is 2.6 T/Month. As per EIA notification 2006, the proposed project is falling under category
5(f).
2.4 Market Feasibility
The pharmaceutical industry in India is expanding at rate of 14% per annum. The share of Pharma
industry in export has crossed almost 35% of value. This is likely to further increase in coming years.
With this background in mind there will be good scope of drug intermediate sector also. The product
selection in present project can fulfill requirement of several bulk drugs. The promoters will not have
any problem in marketing their products.
3.0 PROJECT DESCRIPTION
3.1 Type of project
M/s. J.R.Corporation is engaged in manufacturing of bulk drugs intermidiates at plot no. B/1085,
Lamdapura road, Vill: Manjusar, Tal: Savli, Dist: Vadodara- 391 770.
3.2 Project location
The proposed expansion of production will be in existing site. It is approximately 20 km distance
from Dist. Vadodara. The approximate geographical positioning of the project site is at Latitude:
22°28’0.84”N, Longitude: 73°12'39.90”E.The salient features of the location of the project site are
presented in table 3.
TABLE: 3
SALIENT FEATURES OF THE PROJECT SITE
Particulars Details
Village Manjusar
Taluka/ Tehsil Savli District Vadodara
Approx. Geographical positioning
Latitude: 22°28’0.84” N Longitude: 73°12'39.90” E
Nearest City Vadodara- 20 Km Nearest Town Savli- 8 Km
Nearest Highway National Highway No. 8 Nearest State highway GSH 158 Nearest Railway line/ Railway station
Vadodara
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 4
Nearest Airport/ Airbase Vadodara
Protected Areas/ Sanctuaries ---
FIGURE: 1
SATELLITE IMAGE OF THE PROJECT SITE
3.3 Site selection
The project proponent is not considering any other alternative site for proposed expansion.
3.4 Neighboring Industries
The industry is proposed to be located in an area, which is already industrialized. The industries in the
vicinity of the proposed project are given in the table 4.
TABLE: 4
NEARBY INDUSTRIES IN THE VICINITY
Sr.No.
Name of Industry Address
1 M/s. Allchem Laboratories
Survey No. 1088/B/P, 1088/A Lamdapura road, Manjusar, Savli, Dist: Vadodara, Gujarat
2 M/s. Anugrah In Org P Ltd
Survey No. 1088/B , Lamdapura Road, Village Manjusar, Taluka Savli, Dist. Vadodara.
3. M/s Gurunanak Chemicals Industries
Survey No. 663, Lamdapura road, Manjusar, Savli, Dist: Vadodara, Gujarat
4. M/s. Universal Ester Ltd.
Plot No. 1088(B) Manjusar, Savli, Dist: Vadodara, Gujarat
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 5
3.5 Size of project
The existing unit is manufactured bulk drugs intermidiates and production capacity is 2.6 MT/Month.
The expected cost of proposed expansion of project is Rs.5 Crore. New Plant and machinery
installations will also have to be acquired and installed. Environment Protection and safety systems
have also been considered in planning the Cost Projection. Green belt development, provision of fire
extinguishers etc. are also calculated. The below table shows the break-up of the proposed project cost.
TABLE: 5
CAPITAL COST PROJECTION
Sr. No.
Purpose Proposed (Rs. In Crore)
1. Land Already done
2. Building 1
3. Plant and Machinery 2.25 4. Q.A. Lab set up 0.5
a) Effluent treatment Plant 0.5 b) Safety Equipment (PPE, fire
extinguishers, Ventilation, etc.) 0.35
c) Green belt development 0.15
d) Fire 0.25
Total 5
3.6 Process Technology
The proposed products are “Synthetic API’s”. These are characterized for their physico-chemical
properties. Process details like Process description, chemical reactions and mass balance for each
product are as Annexure-VI.
3.7 Raw-Materials
The proposed products are Synthetic API’s and the required raw materials will be purchased from the
local/ Indian market. Details of raw-material consumption are given in Annexure-III.
3.8 Resource optimization/recycling and reuse
3.8.1 Solvent Recovery
Unit will achieve solvent recovery more than 98%. The all condensers will be 2 stage condensers 1st
attach to cooling tower and 2nd attached to chilled water circulation. The vent will be passed through
carbon column and thus traces of solvents will get absorbed in carbon. Thus there will be zero VOC
emission from the project.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 6
3.9 Resource Requirements
3.9.1 Land
The plot has been purchased by M/s. J.R.Corporation. The total plot area of the unit is 9765 Sq. m.
3.9.2 Building
The new building will be constructed and the approximate requirement of construction materials is
given table 6.
TABLE: 6
APPROXIMATE REQUIREMENT OF CONSTRUCTION MATERIALS
Sr. No.
Construction material Proposed Quantity
1. Bricks Locally available construction material will be used in the project that will be transported by road transportation.
2. TMT Steel 3. Kapchi 4. Cement 5. Sand
3.9.3 Power and Fuel
TABLE: 7
POWER AND FUEL REQUIREMENT
Sr. No.
Name Requirement Source
1 Wood – Existing 1.5 T/day Local Market 2 Energy – Electricity Additional 500 HP MGVCL 3 Bio Coal – Proposed 4 MT/Day Local supplier 4 Furnace Oil – Proposed 200 Liters/Day Local supplier 5 Diesel 100 Liters/Day Local supplier
3.9.4 Water
The category wise bifurcation of the water requirement is given in Table 8. The source of water will
be from Bore-well.
TABLE: 8
WATER CONSUMPTION
Sr. No.
Section Water Consumption KL/Day
Existing As Per CCA No AWH-69376
Water Consumption As Per Proposed Expansion
Total
1. Domestic 0.5 5 5.5
2. Gardening 0 5 5
2. Industrial
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 7
2.1 Process 0.025 40 ( 0 Fresh +40.025 Recycle)
40.025( 0 Fresh +40.025 Recycle)
2.2 Washings 15 (7 Fresh +8 Recovered )
15 (7 Fresh +8 Recovered )
2.3 Boiler 0.5 10 10.5 2.4 Cooling 0.5 10 10.5 Total (Industrial) 1.025 65 66.025 Total (Industrial + domestic)
1.525 85 (36.975 Fresh +48.025 Recovered)
86.525 (48.025 KLD fresh + 38.5 KLD recovered water)
3.9.5 Manpower
The manpower required for the project as well as during the construction/ commissioning activities
will be employed from the local area.
TABLE: 9
MAN POWER REQUIREMENT
Phase of project Type of labor No. of workers (Proposed Scenario)
During construction Contractual 20 During commissioning Contractual 30 During operations Managerial 10
Skilled 20 Un-skilled 40
3.10 Mitigation Measures & EMP
Based on overall manufacturing & operation activities, the mitigation measures have been proposed by
the company for the control of the anticipated pollution load.
3.10.1 Wastewater Management
3.10.1.1 Wastewater Generation
The category-wise bifurcation of the anticipated wastewater generation details is given in Table 10.
TABLE: 10
WASTEWATER GENERATION
Sr. No.
Section Waste Water Generation Existing KL/Day
Proposed KL/Day
Total KL/Day
1 Domestic 0.35 4 4.35 2 Industrial 2.1 Process & Washing 0 37 37
2.2 Boiler 0 2 2 2.3 Cooling 0 2 2 2.4 Gardening 0 0 0
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 8
Total (Industrial) 0 41 41
Total (Industrial + domestic)
0.35 45 45.35
Note: i) Domestic effluent will be disposed in soak pit system. ii) Total industrial effluent will be treated in Effluent treatment plant. Out of 56 KLD effluent,
high COD/high TDS effluent i.e.41 KLD will be sent to MEE, and remaining effluent i.e.15 KLD will be sent to CETP of M/s, Enviro Infrastructure Ltd. Umraya,Vadodara for final disposal.
iii) Condensate from MEE i.e. 38.5 KLD will be recycled in process and MEE salt will be sent to land fill site.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 15
FIGURE: 2 WATER BALANCE DIAGRAM
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 16
3.10.1.2 Wastewater Characteristics
Industrial wastewater will be generated from process, washing, cooling tower blow down and boiler
blow down. The expected characteristics of industrial wastewater are provided in Table 11.
TABLE: 11
CHARACTERISTICS OF WASTEWATER
Sr.No.
Parameters Unit ETP inlet ETP outlet
1 pH pH scale 5-7 7-8 2 COD mg/l 5000-7000 1000-2000 3 TDS mg/l 3000-5000 3000-5000 4 TSS mg/l 100-200 100-200 5 Ammonical Nitrogen mg/l 15-30 10-15
3.10.1.3 Wastewater Treatment & Disposal
The effluent will be segregated into two streams of 1. High COD/High TDS and 2. Low COD/Low
TDS
The High COD/High TDS stream from the process will be collected in collection cum equalization tank
and will be neutralized. The stram from equalization tank will be sent to MEE for recovery. The
condensate will be reused in process, whereas the MEE salt will be sent to TSDF site.
The low COD/low TDS effluent from the Boiler blow down, cooling tower blow down and washing
will be collected in collection cum equalization tank, Equalized wastewater will be neutralized in
neutralization tank by adding chemical, and brings pH with in permissible limit. Flocc agents will be
added to water and stirred in primary settling tank and flocc will be allowed settling in primary settling
tank for 1.5 hrs. Suspended solid settle will be removed on sludge drying bed, clarified wastewater
pumped in aeration tank. This treated effluent will be discharged into CETP of M/s. Enviro
Infrastructure Co. Ltd., Umraya, Vadodara for final treatment after achieving CETP norms. Leachate
from the sludge drying bed returns to equalization tank.
TABLE: 12
EQUIPMENTLIST OF ETP
Sr.No.
Name of unit Qty. Volume
1. Collection Tank 2 15 KLD
2. Neutralization Tank 2 10 KLD
3. Primary Settling Tank 1 15 KLD
5. Final Collection Tank 1 20 KLD
6. Multiple Effect Evaporator 1 30 KLD
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 17
FIGURE: 3
EFFLUENT TREATMENT PLANT
3.10.2 Gaseous emissions & control
3.10.2.1 Flue gas emissions
There will be flue gas emission from existing Boiler and proposed Boiler (2nos.) and Thermo pack.
Wood, Bio-coal and Furnace oil will be used as fuel for utility. The fuel consumption detail and air
pollution control measures are covered under table 13.
TABLE: 13
FLUE GAS EMISSIONS
Sr. No.
Stack Attached To
Stack Height (M)
Type of Fuel
Air Pollution Control Measures
Parameter Permissible Limit
1. Existing Boiler- 0.8 T/hr
11 Wood-1.5 T/day
Cyclone separator
PM SO2 NOX
150 mg/ Nm3
100 ppm 50 ppm
2. Proposed Boiler- 1 TPH (2 nos.)
30 meter (Common)
Bio coal-4 MT/Day
Cyclone separator and Bag Filter
PM
150 mg/ Nm3
3. Proposed Thermo pack 2 Lac Kcal/hr capacity
Furnace Oil-200 Liters/day
--- SO2 100 ppm
4. Proposed DG set 150 KVA 1 nos.
9 meter Diesel-100 Liters/day
Adequate stack height
PM SO2 NOX
150 mg/ Nm3
100 ppm 50 ppm
Boiler blow down
Cooling blow down
Collection cum Equalization tank
Neutralization tank
Primary settling tank
Collection Tank
To CETP of M/s. Enviro Infrastructure Ltd., Umraya, Vadodara
Washing Effluent
MEE
(high COD effluent)
Process waste water
Collection cum Equalization tank
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 18
3.10.2.2 Process emissions
The process emissions from the proposed manufacturing activities are given in Table 14.
TABLE: 14
PROPOSED PROCESS EMISSIONS
Sr.No.
Stack Attached To
Stack Height (M)
Air Pollution Control Measures
Parameter Permissible Limit
1 Acidic based Reaction
10 Alkali Scrubber SO2, HCl,
40 mg/Nm3
20 mg/Nm3
2 Ammonia used reactor
10 Water Scrubber followed by acid Scrubber
NH3 175 mg/Nm3
3.10.3 Hazardous/ Non-hazardous waste management
The following type of hazardous waste will be generated from the operational activities. All the waste
will be stored separately in a designated storage area.
TABLE: 15
DETAILS OF HAZARDOUS WASTE
Sr. No.
Type of Waste
Category Existing Quantity
Proposed Quantity
Total Quantity
Method of Disposal
1. Residue & waste
28.1 -- 5 MT/Month
5 MT/Month
Collection, Storage, Transportation, Disposal to TSDF site/ incineration/ Cement Industries
2. Spent Catalyst/ Spent carbon
28.2 Whatever generated
1 MT/month
1MT/Month Collection, Storage, Transportation and sell to authorized re-processors/ cement industries for co processing.
3. Discarded Containers
33.1 100 Nos./year
500 Nos./year
600 Nos./year
Collection, Storage, Transportation, Disposal to authorized recyclers.
4. Crude Sodium Acetate
28.4 8 MT/Month
0 8 MT/month
Collection, Storage, Transportation, Disposal by incineration.
5. MEE salt/ ETP Sludge
34.1 0 45 MT/month
45 MT/month
Collection, Storage, Transportation, Disposal to TSDF site for land filling.
6. Distilled Solvents
-- 0 50 MT/Month
50 MT/Month
Collection, Storage, and Sell to actual user.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 18
In addition to the provision of above, the unit will ensure proper management for hazardous waste as
below:
Transportation of hazardous waste to the TSDF Site will be governed as per the guidelines and
accompanied with Form-9.
Annual returns of the disposal of wastes in Form-4 and Form-13 will be submitted regularly to the
local office of the GPCB.
3.10.4 Noise Control & Odour
Ear plugs will be provided to the operating personnel in boiler room.
The following steps will be taken for odour control.
Raw-material feeding will be carried out by pumps.
All reactions will be taken in closed reactor system.
Roof top ventilation will be provided in the entire plant area.
Regular monitoring will be done of piping and fittings for checking of any leakages.
3.10.5 Storage, Handling and Transport of Hazardous Chemicals
The storage and mode of transport of chemicals will be done as per detailed MSDS and chemical
hazards guide (NIOSH) for the hazardous chemicals.
Few chemical to be used in the proposed activities are listed as ‘Hazardous Chemicals’ as per the
Schedule-1 of the MSIHC Rules, as amended in 2000.
3.10.6 Health and Safety measure
Few chemical to be used in the proposed activities are listed as ‘Hazardous Chemicals’ as per the
Schedule-1 of the MSIHC Rules, as amended in 2000.
Physical hazards may manifest as fires, explosions, excessive temperatures, or the release of large
volumes of gas or toxic or flammable gases or vapors. According to Schedule 2 & 3 of MSIHC Rules,
Below mentioned is the summary proposed safety measures to be taken at site for control of
anticipated hazards.
4.0 SITE ANALYSIS
4.1 Connectivity
The site is located at plot no. B/1085, Lamdapura road, Vill: Manjusar, Ta: savli, Dist: Vadodara- 391
770 in the state of Gujarat. The site is 20 km from Vadodara town. The land and Infrastructure is
already available. And the raw material is easily available through the easy transport via road
connectivity. The district headquarter has railway station. The site is in the existing unit compound.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 19
4.2 Land use and land ownership
The proposed project site is into Manjusar Village of Vadodara district in state of Gujarat which is
meant for this type of industries. The approximate geographical positioning of the project site is at
Latitude: 22°28’0.84” N and Longitude: 73°12'39.90” E. It has an average elevation of 41 m. The land
is at plot no. B/1085, Lamdapura road, Vill:Manjusar, Ta: Savli, Dist: Vadodara- 391 770 in the state
of Gujarat. The total plot area of the unit is 9765 Sq.m.
Land ownership is with project proponents.
4.3 Existing Land use
The proposed project site is located at plot no. B/1085, Lamdapura road, Vill:Manjusar, Ta: savli,
Dist: Vadodara- 391 770 in the state of Gujarat
4.4 Existing Infrastructure
The plant is located near GIDC Savli.
4.5 Soil Classification
The soils of the district are derived from the Deccan trap which is main rock formation of the district.
The soil of the district can be classified as light, medium and heavy according to depth, texture and
location. There is sandy loam to loamy in texture, brownish black in color.
4.6 Climate data
For Baseline Study, meteorological data for study period between the March 2015 to May 2015. The
maximum and minimum as well as relative humidity for a period of March 2015 to May 2015 are
presented in table 16
Table 16
Micro metrological Data
(Data from Indian Meteorological Department, Baroda)
Month
Temperature(ºC) Humidity (%) Rain fall (mm)
Maximum Minimum Maximum Minimum Maximum Minimum
March-15 41 17 57 32 012.1 00
April-15 41.4 22.4 67 30 006.9 00
May-15 42.7 27.0 75 29 0.0 00
Based on the site specific metrological data, wind rose has been prepared for the post monsoon
season period from March 2015 to May 2015. The wind rose prepared from same data is shown at
figure 4.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 20
FIGURE: 4
WIND ROSE
4.7 Social Infra structure
The Manjusar village falls at Dist. Vadodara of Gujarat. It is positioned on the bank of River
Vishwamitri. It is situated to South of Anand Dist. and to the North of Vadodara. Manjusar is largely
an industrial area dominated by small scale industries, Medium scale industries, and large scale
industries.
Infrastructure like Airport is at the distance of 15 km in South-West direction. Nearest habitation is
Vadodara Town, 20 km away from project site in South direction. All the required infrastructure
facilities are available in this town. National highway no.8 is 11.5 km away in North-west direction
from project site.
5.0 PLANNING BRIEF
5.1 Planning concept
Manjusar is largely an industrial area dominated by small scale, Medium scale and large scale
industries.
Now the unit has proposed to manufacture bulk drugs and intermediates (2.6 MT/Month)
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 21
Govt. agencies provide many basic facilities like uninterrupted water supply, power and road network.
5.2 Population projection
As per provisional reports of Census India, Population of Vadodara in 2011 is 4,165,626 of which
male and female are 2,153,736and 2,011,890 respectively. The sex ratio of Vadodara city is 934 per
1000 males.
In education section, total literates in Vadodara city are 2,893,080 of which 1,614,087 are males while
1,278,993 are females. Average literacy rate of Vadodara city is 78.92%
5.3 Land use planning
The proposed project is established in Village Manjusar of Vadodara district. This is not a prime
agriculture land.
5.4 Assessment of Infrastructure Demand
M/s. J.R.Corporation is get water from Own bore-well.
The existing connected load is 60 HP. Aditional load will be 440 HP.It will be met through Madhya
Gujarat Vij Company Ltd.The transportation facilities will also expect to improve due to increase in
the movement of workers and raw material and finished products.
5.5 Amenities
The available basic amenities are as under:
(A) Education Facilities:
Education Facilities are available and the literacy rate is about 45.67 % within 5 km periphery. All the
villages have a minimum of one primary school.
(B) Medical Facilities:
The medical facilities are available in satisfactory amount in study area. These facilities are available
in form of child welfare center, primary health sub center, and allopathic dispensary, maternity & child
welfare centers, registered private medical practitioners and family welfare Centre within the range.
(C) Drinking water Facilities & Power Supply:
All the villages have potable water supply and in 100% area the drinking water is supplied through
bore-wells. All the villages have power supply facilities in the study region.
(D) Post, Telegraph & Telephone facilities:
The information collected clearly indicates that the infrastructural facilities are provided by respective
government agencies for the development of this area. For communication purpose, post office and
phones are available in most of the villages. The villages having non-availability of these facilities can
get these facilities within 5-10km distance.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 22
(E) Transport Facilities:
Bus services are available in all the villages of the study region within 5 km area and are the most
preferable mode of transport in the region. Auto-rickshaw is also used as transport facility. Villages
are connected with paved roads.
Source: 2001, Census.
6.0 PROPOSED INFRASTRUCTURE
6.1 Processing Area
The process area will cover plant area, raw material storage area, hazardous waste storage area and
utilities. The process area covered by the unit at ground level will be 482.5 sq. m.
6.2 Non Processing Area
The non process area will cover Admin Building, and security cabin. The non process area covered by
unit at ground level will be 262 sq. m.
6.3 Green Belt Area
The proposed greenbelt area is 4618 sq. m. Species like Baval, Kadam, Bili, Neem, Gulmahor,
Ashoka, Ambo, Badam, Pipro, and Vad etc are suggested for plantation. There will be provision of
budget of 0.5 lakh rupees for green belt development .The unit will plant 500 trees and shrubs in green
belt area.
6.4 Social Infrastructure
The availability of basic amenities is covered as under:
(A) Training & Education: All the employees will be trained and educated periodically about the
hazardous nature of chemicals used in the process. Also, training for firefighting, work permit
system, first aid, safe handling of hazardous chemicals and integrating safety, in all activities.
(B) Medical facility: Pre-employment medical checkup at the time of employment. In order to safe
guard the health of the employees, all the employees undergo periodic health checkup. Drinking
water: There will be provision of Aqua
(C) Guard/R.O. at different places to provide purified water for drinking purpose.
(D) Transportation: The unit will provide basic transportation facility for workers.
(E) Telegraph & Post: There will be provision of telephone, fax & internet facility.
(F) Power supply: The existing connected load is 60 HP. Aditional load will be 440 HP.It will be met
through Madhya Gujarat Vij Company Ltd.
6.5 Connectivity
The Manjusar area is very well connected with both National Highway No.8 and State Highway
No.188 and it is near to Vadodara about approx. 15 Km.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 23
6.6 Drinking water Management
The source of water is already availability from existing Bore-well and the same is adequate and
satisfactory. The unit has proposed 5.0 KL/Day water for domestic purpose.
6.7 Sewage system
The sewage will be treated in soak pit and the overflow of it will be disposed into soak pit system.
6.8 Industrial waste management
The hazardous waste like used oil, ETP sludge, Discarded Containers, Spent Carbon and distillation
residues will be generated from proposed project activity. The hazardous waste management and
disposal is shown in table 15.
6.9 Solid waste management
The record of non-hazardous solid waste like, Fiber board drum, Polyethylene bag, wooden waste etc.
will be mentioned.
6.10 Power requirement & supply
The existing connected load is 60 HP. Aditional load will be 440 HP.It will be met through Madhya
Gujarat Vij Company Ltd.
7.0 REHABILITATION AND RESETTLEMENT(R &R) PLAN
The proposed project is located in Manjusar village, Tal. Savli, Dist. Vadodara. There will be no any
human settlement affected by proposed project.
8.0 PROJECT SCHEDULE & COST ESTIMATES
8.1 Project implementation Schedule
Table 17
Project implementation schedule
Project implementation schedule after getting NOC from GPCB Sr. No.
Activity Required Period
1. Civil work Immediately after getting NOC 2. Procurement of machinery 1 month after getting NOC 3. Eraction& installation of
machinery Immediately after competition of activity no.2
4. Trial of machinery &equipment
Within 1 months after competition of activity no.3
5. Commercial activity 1 months after competition of activity no.4 8.2 Estimated project cost
Total project cost is Rs. 5 Crore for this proposed project.
M/s. J.R.Corporation, Lamdapura road, Savli, Vadodara-391 770.
M/s. Jyoti Om Chemical Research Centre Pvt. Ltd., Ankleshwar. 24
9.0 ANALYSIS OF PROPOSAL
All the manpower is utilized from local region around Manjusar and Savli. Company shall also try to
provide indirect employment opportunities by availing local contract services during transportation
during operational phase.
The company intends to donate 5 % of the profit to agencies like NGOs or social welfare societies for
projects carried out in nearby village for their welfare and upliftment.