Simplifying Sewage Treatment and Re with

SimplifyingSewage Treatment and Recycling

with

Simple, Safe & Clear…

www.biologicalwastewatertreatment.com

SimplifyingSewage Treatment and Recycling

with

Simple, Safe & Clear…

LIFETIME ASSOCIATES PVT LTDD BLOCK, GROUND FLOORSANGEETH APARTMENT 137 CART TRACK ROADVELACHERY CHENNAI-600042ph.no.044-22455811/22554677Email: [email protected]/[email protected]

LIFETIME ASSOCIATES STAND ALONE STRENGTH

• Aim of is to develop Low Cost Advanced indigenous products for Sewage, Wastewater and Water Treatment andRecycling by Reverse Osmosis etc.,

• Technologies targeted at:

o

o

o

o

o

Individual

Industrial

Commercial

Domestic

Communityo Community

• Our Focus:

o

o

o

Membrane based Biological treatment like MBR, Microbial Digestion and others

Reverse Osmasis

• Business Model adopted by Lifetime Associates is Research, Development, Demonstration and Deployment usingDistributor and Retailer network


Low temperature Evaporator Technology For Effluent Treatment

LIFETIME ASSOCIATES STAND ALONE STRENGTH

• Aim of is to develop Low Cost Advanced indigenous products for Sewage, Wastewater and Water Treatment andRecycling by Reverse Osmosis etc.,

Membrane based Biological treatment like MBR, Microbial Digestion and others

• Business Model adopted by Lifetime Associates is Research, Development, Demonstration and Deployment usingDistributor and Retailer network

LIFETIME ASSOCIATES PVT LTDD BLOCK, GROUND FLOORSANGEETH APARTMENT 137 CART TRACK ROADVELACHERY CHENNAI-600042Ph.No.044-22455811/22554677Email: [email protected]/[email protected]

Low temperature Evaporator Technology For Effluent Treatment

WHATmakes BIOFLOCS – STP SPECIAL - ?..

• Basically BIOFLOCS – STP are membrane Bio Reactors

• BIOFLOCS – STP works of principle of bacterialdigestion followed by submerged membrane filtration

• On the surface of membranes very fine pores of 0.1 –

• Microbial Digestion at Collection Tank with the help of Jetaerator. Reduces the organic load.

• On the surface of membranes very fine pores of 0.1 –0.4 micron are present which aids filtration and alsohelps to remove even bacteria and pathogens

• BIOMEM – plusmembranes are of very high strengthand are unlikely to break easily


WHATmakes BIOFLOCS – STP SPECIAL - ?..

• Microbial Digestion at Collection Tank with the help of Jetaerator. Reduces the organic load.

LIFETIME ASSOCIATES PVT LTDD BLOCK, GROUND FLOORSANGEETH APARTMENT 137 CART TRACK ROADVELACHERY CHENNAI-600042ph.no.044-22455811/22554677Email: [email protected]/[email protected]

WHATMAKES BIOFLOCS – STP SPECIAL - ?..

• Mode of filtration is OUT -> IN

• Depending upon the daily flow we canincrease or decrease the number ofmembranes

• Need very less Footage very less space occupies


• Need very less Footage very less space occupies

• Can be Accommodated Vertically

• The Collection Tank at the Ground Level

• The MBR system can be Fixed at Terrace to save land space

WHATMAKES BIOFLOCS – STP SPECIAL - ?..


• The MBR system can be Fixed at Terrace to save land space


Microbial DigestionTakes place sludgeand load tomembrane


CASE OF 200 KLD STP


CASE OF 200 KLD STP

Project Description:

• The project is for a resort ,wherein the fabrication is of SS316 material.

• The plant is designed as a singlestage aerobic system.

• MBR system helps the resultsave precious space on theisland where its located.

• MBR system helps the resultsave precious space on theisland where its located.

• Thus the technology deliversenvironmental and economicvalue at the same time.


DESIGNED AND ACTUAL PLANT PICTURES

DESIGNED BY RECICLAR TECHNOLOGIES PVT LTD



ACTUAL SITE PHOTO



DESIGNED BY RECICLAR TECHNOLOGIES PVT LTD ACTUAL SITE PHOTO



DESIGNED BY RECICLAR TECHNOLOGIES PVT LTD ACTUAL SITE PHOTO


ACTUAL RAWAND TREATED SAMPLE

RAW TREATED


ACTUAL RAWAND TREATED SAMPLETREATED SAMPLE AFTER - BIOFLOCS


Tentative space requirement for 500 KLD – Packaged


L : 17 mB : 11 m

Tentative space requirement for 500 KLD – PackagedBIOFLCOS - STP

B : 11 m




100 KLD – PACKAGED BIOFLOCS - STP

















CLIENT NAME: All Time Plastics Pvt. Ltd.LOCATION: Silvassa , Gujraatwww.biologicalwastewatertreatment.com


CLIENT NAME: All Time Plastics Pvt. Ltd.LOCATION: Silvassa , Gujraatwww.biologicalwastewatertreatment.com




CLIENT NAME: Shreeji Metazine LLPLOCATION: Sanand , Gujarat





CLIENT NAME: Globe Paints - UgandaLOCATION: South Africa


2 KLD – PACKAGED- ECO- BIOFLOCS - STP2 KLD – PACKAGED- ECO- BIOFLOCS - STP

CLIENT NAME: Vasit Print PerfectionLOCATION: Tiruppur , Tamil Nadu

2 KLD – PACKAGED- ECO- BIOFLOCS - STP


2 KLD – PACKAGED- ECO- BIOFLOCS - STP


New STP norms – A Challenge to conventional technology

It would be difficult tomeet the new STPnorms usingconventional methods,without making thewithout making theplants more

BIGGERwww.biologicalwastewatertreatment.com

New STP norms – A Challenge to conventional technology


MEMBRANE BIOREACTOR

Lower MLSS concentration leads to high foot print oftreatment plants

Residence time (HRT) of sewage in reactor is low due tohigh concentration of bacteria

Reactor have high residence time due to low concentrationof bacterial mass, increasing the plant foot print and civilcost

Bacterial removal is very good, nearly 100 % Bacterial removal is very poor

The plant takes less start-up time comparedto MBBR as the bacterial growth is suspended

Attached bacterial growth (as in MBBR, FAB, SAAF)requires longer time and high level of expertise for

MEMBRANE BIOREACTOR compared to conventional treatment plants

Higher concentration of MLSS gives Bettertreatment in less space

operation and stabilization

The plant takes less start-up time comparedto MBBR as the bacterial growth is suspended


Sludge generation is lessconcentration

due to high biomass Higher sludge generation

Operating cost of plant is at PAR with a properly functioningconventional technology plant

Operating cost of (sub 100 KL) plant is in the range of Rs.12 – Rs. 20 per KL depending on the operating condition ofplant


Removal of nutrients like Ammonia, Nitrate andphosphate is good

Removal of nutrients like Ammonia, Nitrate andphosphate is poor


Conventional like ASP, MBBR, FABetc.

Lower MLSS concentration leads to high foot print oftreatment plants

Reactor have high residence time due to low concentrationof bacterial mass, increasing the plant foot print and civilcost

Bacterial removal is very poor


MEMBRANE BIOREACTOR compared to conventional treatment plants



due to high biomass Higher sludge generation

Operating cost of plant is at PAR with a properly functioningconventional technology plant

Operating cost of (sub 100 KL) plant is in the range of Rs.12 – Rs. 20 per KL depending on the operating condition ofplant


Removal of nutrients like Ammonia, Nitrate andphosphate is poor


Parameter BIOFLOCS Activated Sludgeprocess

Treated BOD(mg/litre)

< 10

Sludge Production Minimal

Nutrient Removal HighEase of Flushing

reuseHigh

Compatibility withother Technology High

Technological comparison with MBR

Compatibility withother Technology High

Ease of Startup High

Portability High

Tertiary treatmentrequirement Negligible Always


Activated Sludgeprocess

MBBR/FBR SBR

< 50 < 30 < 10

High Average Minimal

Low Low High

Low Low High

Low Low Low

Technological comparison with MBR

Low Low Low

Low Low Low

Low Low Low

Always Always Always


POWER OF MEMBRANE PROCESS: NEWater in SingaporeConverting crisis into opportunity

• NEWater is the brand name given toreclaimed water produced by Singapore’sPublic Utilities Board. More specifically, it istreated wastewater (sewage) that has beenpurified using dual-membrane (viamicrofiltration and reverse osmosis).

• The water is potable and is consumed byhumans, but is mostly used by industriesrequiring high purity water.

• Membrane based sewage treatmenttechnology have been tested and applied attechnology have been tested and applied atNEWater treatment plants.

• Research have shown that MBR-ROprocess could produce equivalent orbetter high grade water (NEWater)and have better resistance to shockloading than the conventional AS-MF/UF-RO from the domestic usedwater.


POWER OF MEMBRANE PROCESS: NEWater in SingaporeConverting crisis into opportunity


THE NECCESSITY OF TREATMENT PLANT

• The availability of soft water very less• Wasting the untreated waste water contaminates water sources,

mother earth etc.,• The source is getting exhausted.• To recharge the ground by treated water to improve resources.• To make use of treated water as secondary water for all purposes.• The treated water processed through RO to get utility water

(Newater).



(Newater).


THE NECCESSITY OF TREATMENT PLANT



(Newater).



(Newater).LIFETIME ASSOCIATES PVT LTDD BLOCK, GROUND FLOORSANGEETH APARTMENT 137 CART TRACK ROADVELACHERY CHENNAI-600042Ph.No.044-22455811/22554677Email: [email protected]/[email protected]

What is the solution?• By adopting our system of treatment by microbial digestion

followed by MBR and RO a complete solution and soft watermade available for reuse.

• Least quantity of sludge generated compared to othersystems.

• Needs less land space and can be installed vertically.• The treated water can match quality standards.• Needs very less maintenance of the plant.

• By adopting our system of treatment by microbial digestionfollowed by MBR and RO a complete solution and soft watermade available for reuse.




What is the solution?• By adopting our system of treatment by microbial digestion

followed by MBR and RO a complete solution and soft watermade available for reuse.



• By adopting our system of treatment by microbial digestionfollowed by MBR and RO a complete solution and soft watermade available for reuse.




THANK YOU

LIFETIME ASSOCIATES PVT LTDD BLOCK, GROUND FLOORSANGEETH APARTMENT 137 CART TRACK ROADVELACHERY CHENNAI-600042.Ph.No.044-22455811/22554677Email: [email protected]/[email protected]

For enquiry contact us



THANK YOU


For enquiry contact us



Documents

Simplifying Sewage Treatment and Re with