View
4.042
Download
8
Category
Tags:
Preview:
Citation preview
Lockout/TagoutLockout/Tagout
Lockout/TagoutLockout/Tagout• Each employer is required to have a written
lockout/tagout program in place with training for all employees under OSHA 29 CFR, Part 1910.147.
• Every two minutes there is a fatality resulting from employees and/or employers not complying with the lockout/tagout standard.
• Every day there are approximately 170 severe to disabling injuries due to failure to lockout and tagout equipment.
Lockout/TagoutLockout/Tagout• All employees who are directly affected by
lockout/tagout must receive training as well as employees who may not be directly affected.
• When a piece of equipment is down for repairs or maintenance, all employees who are directly affected must be notified including supervisors.
Lockout/TagoutLockout/TagoutThe most common types of energy sourcesinclude:
1. Electricity2. Pneumatic3. Steam4. Vacuum5. Hydraulic6. Gravity7. Compressed or stretched springs8. Spinning flywheels
Lockout/TagoutLockout/Tagout
• All sources of energy must be identified, locked out, neutralized, etc.
• Each employee must attach his/her lock to the lockout device for each energy source.
• When the next shift comes on duty for repairs, each employee will attach their lock as the previous shift personnel remove their locks.
Lockout/TagoutLockout/Tagout
• If unplugging a power source is the only way to isolate the energy source, a lockout device does not have to be utilized as long as the employee maintains control over the cord. However, if the employee has to leave for any reason, a lockout device must be utilized.
Lockout/TagoutLockout/Tagout• Each make and model of equipment must
have specific lockout/tagout checklist developed.
• Leaving a key in a lock does not constitute that lockout/tagout has taken place.
• After all sources of energy have be locked out and blocked, all controls must be tried to insure all sources of energy are neutralized.
Lockout/TagoutLockout/Tagout
Locked out?
Lockout/TagoutLockout/Tagout
Lockout Hasp
Lockout/TagoutLockout/Tagout
Ball Valve Lockout
Lockout/TagoutLockout/Tagout
Gate Valve Lockout
Lockout/TagoutLockout/Tagout
Circuit Breaker Lockout
Lockout/TagoutLockout/Tagout
Locked out?
Lockout/TagoutLockout/Tagout
Heartbeat from enternity!
Lockout/TagoutLockout/Tagout
Locked Out ???? No !!!!!!
Lockout/TagoutLockout/TagoutWhat’s Wrong Here? The Correct Way
Lockout/TagoutLockout/TagoutGrounds for immediate termination.
Lockout/TagoutLockout/Tagout
????
Recommended