View
248
Download
3
Category
Preview:
Citation preview
1171642-X2-C ©2012 Kohler Co.
Installation and Care GuideOne-Piece Toilet
คมอการตดตงและการดแลรกษา
สขภณฑชนเดยว
K-45382X
1171642-X2-C 2 Kohler Co.
ขอขอบพระคณทเลอกใชสขภณฑโคหเลอร
Thank You For Choosing Kohler Company
Thank you for choosing Kohler. Kohler craftsmanship offers you a rare combination of proven performance and graceful sophistication that will satisfy you for years to come. The dependability and beauty of your Kohler product will surpass your highest expectations. We’re very proud of our products here at Kohler and we know you will be too.
Please take a few minutes to review this manual before you start installation. If you encounter any installation or performance problems, please don’t hesitate to contact us. Our phone numbers and website are listed on back cover.
All information in this manual is based upon the latest product information available at the time of publication. At Kohler, we constantly strive to improve the quality of our products. We reserve the right to make changes in product characteristics, packaging or availability at any time without notice.
Thank you for choosing Kohler Company.
ขอขอบพระคณททานไดเลอกใชสขภณฑโคหเลอร สขภณฑของโคหเลอรทกชนนำาเสนอประสทธภาพทพสจนไดควบคกบความประณตงดงามทจะสรางความพงพอใจไปตลอดอายการใชงาน ทานจงมนใจไดในคณภาพและรปลกษณของสขภณฑโคหเลอรเชนเดยวกบทพวกเราชาวโคหเลอรภมใจในการสรางสรรคสขภณฑทดตลอดมา
โปรดสละเวลาสกครเพอศกษาคมอกอนการตดตง หากทานมปญหาเกยวกบการตดตงหรอสขภณฑกรณาตดตอเราทนทเบอรโทรศพทและเวปไซตของเราไดแจงอยบนปกหลง
ขอมลในคมอเลมนมาจากขอมลผลตภณฑลาสดทมอยในชวงเวลาการจดพมพ บรษทฯไดพฒนาผลตภณฑตอเนองอยางสมำาเสมอดงนนบรษทฯขอสงวนสทธในการเปลยนแปลงขอมลผลตภณฑและบรรจภณฑทมอยโดยมตองแจงใหทราบลวงหนา
ขอขอบพระคณททานเลอกใชสขภณฑโคหเลอร
Kohler Co. 3 1171642-X2-C
Before You Begin
CAUTION: Risk of personal injury or product damage. Handle with care. Product can break, chip, or cause injury if handled carelessly.
ขอสำ�คญ
Important Information
IMPORTANT NOTICE TO INSTALLERS!: Please leave these instructions for the consumer. They contain important information.
In addition to installation procedures, this manual contains important care and cleaning. Please retain for future reference.
NOTE: Some installation parts might not be provided.
NOTE: The toilet pictured in the installation steps may differ from the model being installed.
ขอสำ�คญถงผตดตง! คมอนมขอมลสำาคญโปรดมอบเอกสารใหกบเจาของสขภณฑ
คมอนประกอบดวยขนตอนการตดตง,การดแลรกษาและการทำาความสะอาดสขภณฑโปรดเกบคมอนเพอเปนเอกสารอางองในอนาคต
ขอสงเกต อปกรณสำาหรบการตดตงบางชนอาจไมรวมอยในชดสขภณฑ
ขอสงเกต รปภาพของสขภณฑทแสดงอยในขนตอนการตดตงสขภณฑอาจจะแตกตางไปจากรนสขภณฑททานกำาลงตดตง
¨ Observe all local plumbing and building codes.¨ Prior to installation, unpack the new product and inspect it for damage.
Return the product to its protective carton until you are ready to install it.¨ Use the template supplied with the product.¨ Failure to follow these precautions may result in a poor installation.¨ If the existing toilet does not have a supply shut-off valve below the tank,
install one before installing the new toilet.¨ Fixture dimensions are nominal and conform to tolerances established by
Standards TIS.
CAUTION: Risk of property or product damage. Turn on the water and allow water to flow through the supply pipe to flush the system of any debris before connecting fill valve.
1171642-X2-C 4 Kohler Co.
Tools/เครองมอ
กอนเรมก�รตดตง
1/2"
ขอควรระวง คว�มเสยงซงอ�จทำ�ใหไดรบบ�ดเจบหรอผลตภณฑเสยห�ย ควรเคลอนยายสขภณฑดวยความระมดระวงสขภณฑอาจแตกหรอบนไดหากเคลอนยายสขภณฑอยางไมระมดระวง
¨ ตรวจสอบระบบสขาภบาลและกฎหมายควบคมอาคาร
¨ กอนทำาการตดตงตรวจสอบสขภณฑใหมวาชำารดหรอไมนำาสขภณฑกลบลงกลองจนกระทงทานพรอมทจะดำาเนนการตดตง
¨ หากไมปฏบตตามขอแนะนำาการตดตงอาจทำาใหการตดตงไมสมบรณ
¨ หากสขภณฑชดเกายงไมตดตงวาลวเปด-ปดนำาใตถงพกนำา ใหทำาการตดตงกอนการตดตงสขภณฑชดใหม
¨ ผลตภณฑผลตภายใตมาตรฐานผลตภณฑอตสาหกรรม(มอก.)
ขอควรระวง คว�มเสยงซงอ�จทำ�ใหเกดคว�มเสยห�ยแกทรพยสนหรอผลตภณฑชำ�รด เปดนำาเพอทำาความสะอาดและขจดเศษตางๆออกจากทอนำาดกอนประกอบกบวาลวนำาเขา
ขอควรระวง คว�มเสยงจ�กก�ซซงอ�จทำ�ใหเกดอนตร�ย หากยงไมตดตงสขภณฑชดใหมทนทควรใชผาอดหนาแปลนของทอนำาทงไวกอนเพอปองกนกาซทเปนอนตราย
Kohler Co. 5 1171642-X2-C
Installation/ขอแนะนำ�ก�รตดตง
Position the template.2
1
Template
3
3/8"
Install or relocate the supply and outlet as necessary to comform to the roughing-in dimensions.
Important: Toilet must have 305 mm rough-in for S-trap to install properly.
Tape in place and drill holes.
3/8" D. Mounting Holes
1/2" NPT Supply
เกลยวทอนาด
เสนผาศนยกลางของรยด
255
700
621
174305178
296
360
180
185
305
ตดตงหรอเปลยนตำแหนงของทางนาดและทางนาออกเพอใหเหมาะกบระยะการตดตงของสขภณฑ
ขอสำคญ: สขภณฑมระยะการตดตง 305 มม. สำหรบการตดตงทางนำเสยแบบลงพน
กำหนดตำแหนงกระดาษแมแบบ ตดเทปใหอยในตำแหนงและเจาะร
กระดาษแมแบบ
1171642-X2-C 6 Kohler Co.
Installation/ขอแนะนำ�ก�รตดตง
255
4
6
5
Anchor
1/2" NPT Supply
180
8989
Position brackets as shown on the template and install.
For thick floors, greater than 1-1/2" (38 mm)thick, insert the anchors. For thin floors, less than 1-1/2" (38 mm)thick, do not insert the anchors.
ประกอบสายนาดเขากบกานวาลวนาเขา สวมปลอกสายนาดเขากบสายนาด ประกอบตวลอคปลอกสายนาดเขากบปลอกสายนาด และประกอบเขากบโถสขภณฑ
สำหรบพนทมความหนามากกวา 1-1/2" (38 มม.),สวมพกสำหรบพนทมความหนานอยกวา 1-1/2" (38 มม.),ไมตองสวมพก
วางตวยดขาฐานตามตำแหนงทแสดงอยบนกระดาษแมแบบ จากนนจงตดตง
เกลยวทางนาด
พก
ปลอกสายนาดHose Guide
Thread the supply hose onto the fill valve shank. Take hose guide apart and slide onto the supply hose, with the flared end last. Slide the two inserts into the flared end of the hose guide. Insert into toilet wall.
Adapter15/16" to1/2"(OptionalPart)
Kohler Co. 7 1171642-X2-C
Installation/ขอแนะนำ�ก�รตดตง
98
7
Cap/ฝาครอบ Screw/สกร
Sleeve/ปลอก Silicone
Install the new toilet with sleeves, screw and attach the caps.
Apply silicone around base.
Connect the connector on the bowl, position between outlet and waste pipe. Ensure outlet is properly engaged to connector.
S-trap Connector
ตดตงสขภณฑใหมดวยปลอก, สกร และ ฝาครอบสกร
ประกอบขอตอนำทงเขากบโถสขภณฑ จดตำแหนงระหวางทางนาออกและทอนาเสย ใหแนใจวา ทอนาเสยครอบขอตอนาทง
ยาแนวซลโคนรอบขอบโถสขภณฑ
ซลโคน
ขอตอทางนาเสยแบบลงพน
P-trap Connector
ขอตอทางนาเสยแบบออกผนง
ตดตงออกผนง ตดตงกบพนConnector to Wall Connector to Floor
1171642-X2-C 8 Kohler Co.
Installation/ขอแนะนำ�ก�รตดตง
ประกอบสายนาดและวาลวนา
กดปมใหญลง ดนปมเลกออกมา ดนปมใหญออกมา
สายนาด 1/2"1/2" Supply
11
12 13 Pull out and remove the large button.
14Pull out and remove the small button.
Press down on the large button.
10 Connect supply and turn on the water.
แกะเทปและวสดกนกระแทกออก
ฝาถงพกนาTank Cover
Remove the tape and protective pad.
Kohler Co. 9 1171642-X2-C
Installation/ขอแนะนำ�ก�รตดตง
16 17
15
18
สวมปมกดทประกอบกานกดแลว ประกอบเขากบเรอนปมกด จดตำแหนงปมกดทงสองใหเขาตำแหนง
Insert the push buttons with rods into the holes of the push button housing until they click into place.
สวมกานกดสเขยวเขากบรเลก สวมกานกดสดำเขากบรใหญ กำหนดตำแหนงตดบนกานกดตามขอบบนของเรอนปมกด
Insert green rod into small hole. Insert black rod into large hole. Mark the position on both rods along the top of the housing.
ตดกานกดทง 2 กาน ใหมนใจวา กานกดมความสงเทาขอบบนของเรอนปมกด
Green Rod Black Rod
Small Button
Cutting position
Top of housingPosition
Large Button
Cut both rods, ensure that they are equal the top of push button housing.
กดสวมปมกดใหญเขากบกานกดสดำกดสวมปมกดเลกเขากบกานกดสเขยว
Press the large button onto the black rod. Press the small button onto the green rod.
กานกดสเขยว
ปมเลกตำแหนงตด
ตำแหนงขอบเรอนปมกด
ปมใหญ
กานกดสดำ
กานกดสเขยว กานกดสดำGreen rod Black rod
เรอนปมกดHousing
กดชกโครกหลายๆ ครง เพอตรวจสอบการรวซมอยาขนแนนจนเกนไป!
19 Flush several timesand check for leaks.Do not overtighten!
1171642-X2-C 10 Kohler Co.
Replace the Seal/เปลยนซลย�ง
ปดวาลวนา เปดฝาถงพกนา
จดตำแหนงสปมกดเพอการตดตงใหมอกครง
บดเลกนอยและดงกระบอกวาลวออก
วธเปลยนซลยาง
43 Squeeze the tabs and pull straight up on the canister.
Note the position of the colored buttons for reinstallation.
Buttons/ปมกด
21Replace the Seal
Shut off the water supply. Remove the tank cover.
หมนทน เพอปรบระดบนา
Turn here to adjust the water level.
เสนระดบนาWaterline
+
-
ปรบปรมาณระดบนาAdjust the water level.20
ประกอบฝาถงพกนำ และทรองนงสขภณฑ
Install the tank lid and the seat.
21
Kohler Co. 11 1171642-X2-C
ถอดและเปลยนซลยาง
หมนกระบอกวาลวใหสของปมกดตรงตามตำแหนงเดม
ตดตงฝาถงพกนา
เปดวาลวนากดปมชำระลางและตรวจสอบการรวซม
ตดตงกระบอกวาลวใหมอกครง ใหเขาตำแหนงเดม
65 Reinstall the canister so it snaps into place.
8 Reinstall the tank cover.
7Rotate the canister so that the colored buttons are in their original positions.
Remove and replace the seal.
10 Flush several times and check for leaks.
9 Turn on the water supply.
Buttons/ปมกด
Replace the Seal/เปลยนซลย�ง
1171642-X2-C 12 Kohler Co.
Care and Cleaning
For best results, keep the following in mind when caring for your product:• Carefully read the cleaner product label to ensure the cleaner is safe for use
on the material.• Always test your cleaning solution on an inconspicuous area before applying
to the entire surface.• Wipe surfaces clean and rinse completely with water immediately after
cleaner application. Rinse and dry any overspray that lands on nearby surfaces.
• Do not allow cleaners to sit or soak on the surface.• Use a soft, dampened sponge or cloth. Never use an abrasive material such as
a brush or scouring pad to clean surfaces.• Be careful not to leave staining materials in contact with the surface for
extended periods of time.• The ideal cleaning technique is to rinse thoroughly and blot dry any water
from the surface after each use.
WARNING: Risk of property or product damage. Do not use in-tankcleaners in your toilet. Products containing chlorine (calcium hypochlorite)can seriously damage fittings in the tank. This damage can cause leakage and property damage.
Kohler Co. 13 1171642-X2-C
ก�รดแลรกษ�และก�รทำ�คว�มสะอ�ด
คำ�เตอน คว�มเสยงซงอ�จกอใหเกดคว�มเสยห�ยกบทพกอ�ศยและสขภณฑหามใชนำายาทำาความสะอาดสขภณฑภายในถงพกนำาเนองจากนำายาทำาความสะอาดสขภณฑทมสวนผสมของคลอไรด(แคลเซยมไฮโปคลอไรด)อาจทำาใหอปกรณภายในถงพกนำาเกดการรวซมและชำารดได
เพอใหไดประสทธภาพสงสดในการดแลรกษาและทำาความสะอาดสขภณฑของทานโปรดปฏบตตามคำาแนะนำาดงน
• อานฉลากผลตภณฑนำายาทำาความสะอาด เพอใหแนใจวา นำายาทำาความสะอาดใชไดกบสขภณฑของทาน
• ตรวจสอบผลตภณฑทำาความสะอาดกบสขภณฑกอนใชงานทกครงโดยทดสอบบนผวสขภณฑทไมสามารถสงเกตเหนไดกอน
• ลางนำาออกทนทหลงจากใชผลตภณฑทำาความสะอาดและเชดผวสขภณฑใหแหงสะอาดเพอไมใหละอองนำาอยบนผวสขภณฑ
• หามแชนำายาทำาความสะอาดบนผวสขภณฑ
• ใชฟองนำาชบนำาหมาดๆหรอผานมทำาความสะอาดหามใชวสดขดผวเชนแปรงขดหรอแผนขดในการทำาความสะอาด
• ระวงอยาทงวสดททำาใหเกดคราบไวบนผวสขภณฑเปนเวลานาน
• เทคนคการทำาความสะอาดทดคอลางนำาทำาความสะอาดและเชดผวสขภณฑใหแหง หลงจากการใชงาน
1171642-X2-C 14 Kohler Co.
Troubleshooting
Symptoms Recommended Action
1. Poor flush. A. Adjust the tank water level to match the waterline.B. Fully open the water supply shut-off valve.C. Clear obstructions from the trapway, jet, or bowl rim
holes.D. Clear obstructions from the waste line.
2. No flush. A. Reconnect the flapper chain to the trip lever or flush valve.
B. Adjust the flapper chain assembly to remove excessive slack.
3. The fill valve turns on/off by itself without the toilet being flushed, or it runs, allowing water to enter the tank.
A. Adjust the flapper chain for proper slack so the flapper closes.B. Clean or replace the flapper if it is worn, dirty, or
misaligned with the opening.C. Clean the area around the opening to allow the flapper to seal.D. Adjust the tank water level if it is too high.E. Replace the fill valve if the valve float sinks.
4. Tank takes excessive time
to fill.
A. Fully open the water supply shut-off valve.B. Check the flexible supply line (if applicable) for a kink. Remove the kink.C. Clean the valve inlet, valve head, or supply line.
Flush the lines.
5. There is excessive noise when the tank is filling.
A. Partially close the water supply shut-off valve if the waterpressure to the toilet is too high. Check the toilet performance following any such adjustment.
B. Remove dirt or obstructions from the valve head. Flush the lines.
Kohler Co. 15 1171642-X2-C
ขอแนะนำ�ก�รแกไขปญห�เบองตน
ปญห�ทพบ วธก�รแกไข
1 ระบบชกโครก ทำ�ง�นไม สมบรณ
ก.ปรบระดบนำาในถงพกนำาใหเทาเสนระดบนำาข.เปดวาลวนำาใหมากทสดค.ตรวจดสงกดขวางในคอหานรเจทและรใตขอบโถสขภณฑง. ตรวจดสงกดขวางททอรบนำาเสยและทอดกกลน
2 ระบบชกโครก ไมทำ�ง�น
ก.ประกอบขอโซของลนเปด-ปดวาลวเขากบกานกดชำาระหรอ ชดวาลวนำาออกอกครงข.ปรบตำาแหนงขอโซของลนเปด-ปดวาลวนำาออกหากขอโซหยอน
3 ว�ลวนำ�เข� ไมทำ�ง�น ทำ�ใหนำ�ไหล เข�ถงพกนำ� ตลอดเวล�
ก.ปรบขอโซของลนเปด-ปดวาลวเพอใหลนเปด-ปดวาลวอยในตำาแหนงปดทเหมาะสม
ข.หากลนเปด-ปดวาลวนำาออกสกปรกใหทำาความสะอาดบรเวณนหรอควรเปลยนหากเสอมสภาพซงอาจทำาใหลนเปด-ปดวาลว
นำาออกไมอยในตำาแหนงทเหมาะสมค.ทำาความสะอาดบรเวณลนเปด-ปดวาลวนำาออกง. ปรบระดบนำาในถงพกนำาใหลดลงหากพบวานำาอยสงเกนเสนระดบนำาจ.เปลยนวาลวนำาเขาหากลกลอยไมทำางาน
4. ระยะเวล� นำ�เข�ถงพกนำ�
น�นเกนไป
ก.เปดวาลวนำาใหมากทสดข.ตรวจสอบสายนำาดปรบสายนำาดหากสายนำาดขดหรอบดตวค.ทำาความสะอาดวาลวนำาเขา,ฝาครอบวาลวหรอทางนำาดจากนนกดชกโครกเพอทำาความสะอาดทางนำา
5. เกดเสยงดง ขณะนำ�เข� ถงพกนำ�
ก.หากมแรงดนนำามากเกนไปปรบวาลวเปด-ปดนำาใหลดลงจากนนจงตรวจสอบประสทธภาพการทำางานของสขภณฑอกครง
ข.นำาสงสกปรกหรอสงแปลกปลอมออกจากวาลวนำาเขา
1171642-X2-B
บรษท โคหเลอร (ประเทศไทย) จำากด (มหาชน)
ชน 16 อาคารจสมน ซต, 2 ซอยสขมวท 23 ถนนสขมวท แขวงคลองเตยเหนอ เขตวฒนา กรงเทพฯ 10110
ลกคาสมพนธ โทร. 0 2204 6222 โทรสาร 0 2204 6224
E-mail: callcenterthailand@kohler.com
KOHLER (THAILAND) PUBLIC COMPANY LIMITED16th FL. Jasmine City Bldg., 2 Soi Sukhumvit 23, Sukhumvit Road, Wattana, Bangkok 10110 Thailand Call Center Tel. +(66) 2204 6222 Fax. +(66) 2204 6224
Recommended