View
0
Download
0
Category
Preview:
Citation preview
Disclosure to Promote the Right To Information
Whereas the Parliament of India has set out to provide a practical regime of right to information for citizens to secure access to information under the control of public authorities, in order to promote transparency and accountability in the working of every public authority, and whereas the attached publication of the Bureau of Indian Standards is of particular interest to the public, particularly disadvantaged communities and those engaged in the pursuit of education and knowledge, the attached public safety standard is made available to promote the timely dissemination of this information in an accurate manner to the public.
इंटरनेट मानक
“!ान $ एक न' भारत का +नम-ण”Satyanarayan Gangaram Pitroda
“Invent a New India Using Knowledge”
“प0रा1 को छोड न' 5 तरफ”Jawaharlal Nehru
“Step Out From the Old to the New”
“जान1 का अ+धकार, जी1 का अ+धकार”Mazdoor Kisan Shakti Sangathan
“The Right to Information, The Right to Live”
“!ान एक ऐसा खजाना > जो कभी च0राया नहB जा सकता है”Bhartṛhari—Nītiśatakam
“Knowledge is such a treasure which cannot be stolen”
“Invent a New India Using Knowledge”
है”ह”ह
IS 11082 (1984): Technical requirements of agriculturaltractors for wet land cultivation [FAD 11: AgriculturalTractors and Power Tillers]
IS : 11082 - 1984
Indian Standard TECHNICAL REQUIREMENTS OF AGRICULTURAL TRACTORS FOR
WET LAND CULTIVATION
Agricultural Tractors and Power Tillers Sectional Committee, AFIE 52
Chairman Representing
PR~F M. M. MEIIT.\ Escorts Limited, Faridabad; and Indian Society of Agricultural Engineers, New Delhi
Mm bers
SHHI A. K. R.WAN Escorts Limited, Faridabad ( Alternate I to ProI’M. M. Mehta )
DR K. N. SINoH Indian Society of Agricultural EngincLers, New Delhi ( Alternate II to Prof M. h4. Mrhta )
Dn A. hr,n~ Indian Council of Agricultural Research, New Delhi Smtr A. V. AT.I~>XANI)~L Escorts Tractors Limited, Faridabad
SHRI E;. P. JAIN ( &ternate ) SHRI S. S. BAHHUI.I<I\I(. Kirloskar ‘I’ractors Limitctl, Nasik
SHRI P. N. B.\LGCIYII: ( &em& ) SHRI BR~PENI)HA National Agricultural Co-operative Marketing
Fedcratiun of India Limited, New Delhi SIIRI Y. 1;. J>\IN ( /Illem& )
SHRI A. K. CHAKRAVOl<TY National Bank for Agricultural and Rural Develop- men t, Bombay
SHFLI CIIANUIRA MOILAN Punjab ‘Tractors Limited, Ropar SHRI G. S. IirllhL ( Alternate I ) S 1m1 S. S. Glu<w.\f. ( Alternate II )
SHRl c. 1%. CRlrc:lr Indian Investment Crntrc, New Urlhi Drt<u:ToIL Centr.11 Institute of Agriculturnl Engineering
( ICAR ), Bhopal DIL R. C. M.\rrasw.+,t I ( Alternate )
SHltl iv. c. Gum‘% Auto Tractors Ltd, Partapgarh SJIR I R. K. Gr:r,rn State I’nrlns Corporaticm of India Ltd, xrw Dellli
S ,,RI M. L. G.\JLCI ( Alternate ) SIII<; :;. C. GUPTA Harsha ‘l’ractors Limited, Ghaziabnd
s ,I I~T M. S. K>\o ( /l!terrcnte ) SIII~I S. C. JAIN Central Farm Machincary Training and ‘J‘esting
Institute ( Ministry of :\griculturc ), I<ud,>i SHJ~IJ. PRAS $1) ( nl!ernatc I ) SIIRI R. S. D,\ss ( Alternate II )
( Continued on page 2 )
@ COll;~i~hl 1985
INDIAN STANDARDS INS’l’ITUTION
This publication is protected under the In&l Co,@+ht Act i XIV of 1957 ) nnd reproduction in whole or in part by any means except with written permission of the publisher shall be deemed to bc an infringement of cop)Iight under the said Acl.
IS:11082 -1984
( Continued from pqe 1 )
Members Repasen t inz
SHILI V. K. J <IN Directorate General of Technical Development ( Ministry of Industries ), New Delhi
SIIXI T. K. B. V.\~lnr.\ ( Alternate ) Slrl<r G. N. hfx~~~a Gujarat Tractors Corporation Ltd, Vadodara
SIIRI G. C. PATIL ( Alternate ) DIG V. K. MLWAL Punjab Agricultural University, Ludhiana
DIL R. 1~. RAM ( ,4llernale ) SJIRI J. S. MI:DJIAIL HM-f Limited ( Tractor Division ), Pinjore
Snnr G. B. LAL ( At?ernate ) SJlllI H. M. MUT’~A Mahindra & Mahindra Ltd ( International Tractor
Division ). Bombay Slrnr M. V. VI~NJCA’~J~SW.\I‘,\N ( Alternate I ) Srritr A. R. ~~JNAI>KAl~ ( Alternate II )
SHEI A. T. NAHXNDEIL VST Tillers Tractors Limited, Bangalore Snnr V. P. M~nzwn~t.~ ( Alternate I ) Slrltr K. CIIANL~IL SEICH~I< R 20 ( Alternate II )
Dn S. T. NAI~AYANA~W~MY Bharat Earthmovers Ltd, Bangalore SHLtI s. B. P.&Xl)Yn Nationa! Farmers Organization, New Delhi ?,JIltI R. N. PAY’ITI Ministry of Agriculture ( Department of Agriculture
8r Co-operation ), New Delhi SllILI v. v. PhTlrr Bharat Krishak Samaj, New Delhi SHRI K. R.~M~~I.M.\JL Kerala Agro Machinery Corporation Limited,
Ernakulam SIII<J M. I(. ~II~\NI~ILAMOIIAN,ZN
N h tn ( Alternate ) DIG M. R.\M.\ SWAMY Tractors and Farm Equipment Ltd, Madras
SJTILI S. R,~NP.ANAYIIAN ( Alternate I )
SIIRT G. VENKA~‘IC.YMAN ( Alternate II ) SJllLI 13. ROY Development Commissioner ( Small Scale Industries )
( Ministry of Industries ), New Delhi DIL S SATYAMURTY Either Goodearth Limited, New Delhi
s’rrnr P. J. %A(:J~.%HI <II ( Alternate 1 ) Dlt J. BIIAWA~H.\RYYA ( A&cmate II )
SI~RI N. C. S.~XI:NA J. K. Satoh Agricultural Machines Limited, Kanpur SllJl1 R. K. BAJP.\I ( Alternafe)
SHIRT V. P. SJIRIVAST:IV.\ Department of Agriculture, Government of Bihar, Patna
SJIM R. K. VEI<MI\ Central Mechanical Engineering Research Institute ( CSIR ), Durgapur
SHIII T. PKJI~NANAN~~M, Director General, IS1 ( Ex-ofi& Member ) Diwctor ( Agri & Food )
SHRI R. N. SJ~AI~MA Senior Deputy Director ( Agri & Food ), IS1
IS : 11082 - 1984
Indian Standard
TECHNICAL REQUIREMENTS OF AGRICULTURAL TRACTORS FOR
WET LAND CULTIVATION
0. FOREWORD
0.1 This Indian Standard was adopted by the Indian Standards Institution on 30 November 1984, after the draft finalized by the Pgricultural Tractors and Power Tillers Sectional Committee had been approved by the Agricultural and Food Products Division Council.
0.2 Wet land cultivation, popularly known as puddling is an important tillage operation in the cultivation of transplanted paddy. The agri- cultural tractors are increasingly being used for Lj’et Iancl cultivation. The success of mechanized paddy cultivation with the agricultural tractors depend upon how efficiently it can be operated in wet paddy fields. 11 need was, therefore, felt to formulate an lndian Standard on this subject for the guidance of the manufacturers and users.
0.3 In the formulation of this Indian Standard, assistance has been derived from the Central Farm Machinery Training and Testing Institute, 13udni.
0.4 For the purpose of deciding whether a particular requirement of this standard is complied with, the final value, observed or calculated, expressing the result of a test or analysis, shall be rounded off in accor- tlance with IS : 2-1960*. The number of significant places retained in the rounded off value should be the same as that of the specified value in this standard.
1. SCOPE
1.1 This standard covers the technical requirements for use of agricultural tractors for wet land cultivation ( puddling operation ).
2. TERMINOLOGY
2.0 For the purpose of this standard, the following definition shall apply.
*Rules for rounding off numerical values ( revised ).
3
IS : 11082 - 1984
2.1 Agricultural Tractors - See 11.1 ofIS : %X39-1981*.
2.2 Cage Wheel - See 2.3 of IS : 9939-1981*.
2.2.1 Half Cage Wheel - See 2.4 of IS : 9939-1981*.
2.2.2 Full Cage Wheel - The cage wheel used in place of pneumatic wheels ( tyres ).
2.3 Puddling - The mechanical manipulation of soil in presence of standing water in the field to create an m~pervious hard pan below the puddle zone so as to prevent loss of water through Ieacliing and facilitate the transplanting of paddy seedlings by making the soil softer.
3. CONSTRUCTIONAL REQUIREMENTS
3.1 As the tractor is required to be operated under wet conditions, r”e- treatment to sheet metal should be adequate to prevent corrosion.
3.2 The tractor should have independent braking system.
3.3 The tractor may be equipped with differentiai lock.
3.4 Adequate provision should be made for the drainage of water near foot rest and operator’s work place.
3.5 Outside part should be such that they are not affected c!uring the water cleaning of the tractor as normally tractor requires thorough cleaning with water after puddling operation.
3.6 Where choice for fitting tyre is available, it is advisable to use tyres having broader contact area. .
3.7 Exhaust system of the tractor shou1d be appropriately 1:ojirionccl to
prevent ingress of water and mud during operation.
3.8 Provision for fitting half cage wheel and full cage wh~~cl shall 1~ made. The half cage wheel may conform to the requirements given in IS : 11081-1984.7.
3.9 The sealing of the critical components should be eflect;ve. ‘I’he following critiral components and SyStefilS Slloultl be free fIWI:l Cl:i?): Of
water and dust, mud:
a) I.ubricatin,q oil in the cn,gine yump, transmis:.ion, llydraulic housings, final c!rive housings anJ steering box.
*Glossary of term\ relating to agricultur:ll tractors and power tillers. @pecificatioll for half rage wheel for agrirultural tractors.
IS : 11m2 - 1984
1)) firakc assembly.
c) Clutch assembly.
cl) Rear axle assemb!y.
e) Front axle assembly including stub axle, front wllcel liIIl)s, king pin ant1 ccntre ( pivot ) pin assembly.
f) Starter motor and dynamo.
g) Electrical components, such as magneto, battery: and cut Out.
3.10 Provision shoul~l be made to plug various weep ho!cs or inspection 11olcs provided in the transmission housing, clutch housing, rear axle housing, etc.
4. OPERATING REQUIREMENTS
4.1 All the necessary instructions of the manufacturers for preparing tile tractor for wet land operation should be strictly folio\ved.
4.2 Necessary servicing and periodic maintenance during and nftcr the USC for wet land operation should he conducted in accordance with the printed literature of manufacturers.
4.3 ‘L’apcr plugs usetl for plugging the weep holes or inspection ho!es sl~ould be opened to allow the water to drain out at suitable intervals as recommended by the manufacturers.
4.4 While using cage wheels, for reasons of safety and obtaining good cluality puddle, a suitable implement like puddlcr, disc harrow, rotavator may be used.
5. LITERATURE
5.1 The operator’s manual or other printed literature supplied with tractor should include necessary instructions for preparation, safe operation and the mamtenance of the tractor for wet land operation.
5.2 The manufacturers should also provide the information lvith respect to front axle reaction in terms of the front mass for various usage of the wet lancl cultivation, that is for half cage wheel or fu!l cage wheel to ensure stability and steerability of the tractor. ‘1’11~ mass can be varied by the user depending upon the need.
5
INTERNATIONAL SYSTEM OF UNITS ( SI UNITS )
Base Units
QIJANTIZY
I.ength
Mass
Time
lilcctric current
Thermodynamic temperature
Luminous intensity
Amount of substance
Supplementary Units
Q~JANTITY
Plane angle
Solid angle
Derived Units
QCI ANTITY
Force
Energy
Power
Flux
FIux density
Frequency
Electric conductance
Electromotive force
Pressure, stress
UNIT
metre
kilogram
srcontl
ampere
kelvin
candela
mole
UNIT
radian
steradian
UNIT
newton
joule
watt
weher
tesla
hertz
siemens
volt
Pascal
SYM IWL
m
kg s
A
K
cd
rnol
SYallloL
rnd
sr
SYMBOL
N
J TV Wb T
HZ
s
V
Pa
DEFINITION
1 N = 1 kg.m/s*
1 , J = 1 N.m 1 W = 1 J.‘s
1 Wb = 1 v.s
1 T = 1 \‘I’tj/ml
1 Hz = 1 c/s (s-1) 1 s = 1 A/V
I v = I w/n 1 Pa = 1 N/m2
Recommended