View
16
Download
0
Category
Preview:
Citation preview
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
The Drive & Control Company
Table of Contents 9 535 233 792/06.04
Table of Contents
– Section 1 – Pumps
Vane pumps .......................................................................1
– Section 2 – Servo Solenoid Valves
Direct operated servo solenoid valves ........................6Pilot operated servo solenoid valves ...........................7Injection valves ..................................................................8
– Section 3 – Proportional ValvesPilot operated proportional directional valves ........... 9Proportional directional & throttle valves ................. 10Proportional pressure relief valves ............................ 11Proportional throttle cartridges .................................. 12
– Section 4 – Electronics & Accessories
Amplifier cards ............................................................... 13Auxiliary cards & Accessories .................................... 14
– Section 5 – Pressure Transducers
Pressure transducers ................................................... 15
– Section 6 – Directional Control Valves
Directional valves – NG6 (D03) ................................ 16Directional valves – NG10 (D05) .............................. 18Pilot operated directional valvesNG16 (D07) ................................................................... 20Pilot operated directional valvesNG25 (D08) 4600 PSI ................................................ 21Pilot operated directional valvesNG25 (D08) 3000 PSI ................................................ 22Subplates ........................................................................ 23
– Section 7 – Modular Valves
NG6 (D03) Modular valves ......................................... 24NG10 (D05) Modular valves ...................................... 26
– Section 8 – Logic Elements
Cartridge valve inserts ................................................. 28Right angle cartridge check valves ........................... 29Cartridge valve covers ................................................. 30
– Section 9 – Flow Control Valves
Subplate mounted 3/4” feed valves ......................... 31
– Section 10 – Accumulators
Bladder accumulators .................................................. 32Diaphragm accumulators ............................................. 33
– Section 11 – Accumulator Accessories
Safety and shut-off blocks ........................................... 34Accumulator brackets .................................................. 35Accumulator discharge valves .................................... 35
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Vane Pumps
Bosch is leading the way in advanced variable vane pumptechnology.
Market conditions favor hydraulic components that operate at lownoise levels without sacrificing efficiency or durability whilekeeping pricing competitive. VPV pumps feature an outstandingresponse to the needs of the market today and for the future.
– Flows from 7.6 gpm to 75.8 gpm in single pumps– Available in combination with other VPV pumps and
Bosch gear pumps– Through-drive horsepower transfer is 100% to the
second pump– VPV pumps are available with through shaft versions for
quick combinations– Pressures to 3000 psi– Continuous speeds from 1000 to 1800 rpm– Overall efficiencies to 89%– A variety of fluids can be used: mineral oil, water glycol,
phosphate ester and environmentally friendly fluids– Controls include standard pressure compensation, remote
pressure compensation, load sense, solenoid 2-pressure, andsolenoid vented
Pumps 1 Section 1
EASw
ni–eziS 3 )ver/cc(ver/ )61(0.1 )52(5.1 )23(0.2 )54(57.2 )36(48.3 )08(88.4 )001(0.6 )031(39.7 )461(0.01wolF )1 6.7 4.11 1.51 8.02 1.92 0.73 4.54 0.06 8.57
)isp(erusserP.xaM 0003 0003 0003 0003 0003 0003 0003 0003 0003
egnardeepS __________________________________________________________________ mpr0081ot059 _________________________________________________________________
gnitnuoM _____________________________________________________________ 1/9103OSIotegnalF ______________________________________________________________
noitisoPtnuoM ____________________________________________________________________________ ynA ______________________________________________________________________________
noitatoR ____________________________________________________________________________ HR _______________________________________________________________________________
leveLerusserPdnuoS )2 76 96 96 86 96 17 47 67 77)1 .mpgnimpr0571)2 etercsid7tayawaretem1decalpenohporcimhtiwrebmahcciohcena-imehaniwolflluf,mpr0571,isp0003ta)A(Bd
.degarevadethgiewemitdnayllaicapseraslevelerusserpdn
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Pumps 2 Section 1
spmuPrepsihWVPV MT
nieziS 3 ver/)ver/cc( tnuoM mumixaM
)isp(erusserP 0571@mpg noitatoR noitpircseD .oNlairetaM thgieW)sbl(
)61(00.1 AEAS 0003 6.7 R 30BYH12MS61VPV3C81R3150 2120033150 0.93
)61(00.1 AEAS 0003 6.7 R 1P30BYH12MS61VPV3C81R3150 6420033150 0.64
)52(05.1 BEAS 0003 4.11 R 2120043150 0.76
)52(05.1 BEAS 0003 4.11 R 1P30BYH12MS52VPV3C81R3150 8420043150 0.47
)23(00.2 BEAS 0003 1.51 R 30BYH12MS23VPV3C81R3150 0220053150 0.76
)23(00.2 BEAS 0003 1.51 R 1P30BYH12MS23VPV3C81R3150 4520053150 0.47
)54(57.2 CEAS 0003 8.02 R 50BYH12MS54VPV3C81R3150 4120063150 0.721
)54(57.2 CEAS 0003 8.02 R 4320063150 0.531
)36(48.3 CEAS 0003 1.92 R 50BYH12MS36VPV3C81R3150 8120073150 0.721
)36(48.3 CEAS 0003 1.92 R 2420073150 0.531
)08(88.4 CEAS 0003 0.73 R 8420083150 0.721
)08(88.4 CEAS 0003 0.73 R 8320083150 0.531
)001(00.6 DEAS 0003 4.54 R 6120583150 0.542
)001(00.6 DEAS 0003 4.54 R 4120583150 0.552
)031(39.7 DEAS 0003 0.06 R 0520683150 0.542
)031(39.7 DEAS 0003 0.06 R 8520683150 0.552
)461(0.01 DEAS 0003 8.57 R 6220783150 0.542
)461(0.01 DEAS 0003 8.57 R 1P40BYH12MS461VPV3C81R3150 6120783150 0.552
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4273325359#golataceeS
snoitanibmoCrofstiKrotpadA rebmuNdlO .oNlairetaM
EAS61VPVot61VPV 8150321159 8150321159
yeKEASpmuPraeG”F“ot61VPV 1250321159 977117879R
EAS23/52VPVot23/52VPV 3250321159 3250321159
EAS61VPVot23/52VPV 5250321159 5250321159
EAS08/36/54VPVot08/36/54VPV 8250321159 8250321159
EAS61VPVot08/36/54VPV 2350321159 2350321159
23/52VPVot08/36/54VPV 0350321159 0350321159
yeKEASpmuPraeG”F“ot08/36/54VPV 3350321159 187117879R
yeKEASpmuPraeG”G“ot08/36/54VPV 4350321159 287117879R
461/031/001VPVot461/031/001VPV 6350321159 6350321159
08/36/54VPVot461/031/001VPV 8350321159 8350321159
23/52VPVot461/031/001VPV 0450321159 0450321159
61VPVot461/031/001VPV 2450321159 2450321159
yeKEASpmuPraeG”F“ot461/031/001VPV 3450321159 387117879R
yeKEASpmuPraeG”G“ot461/031/001VPV 4950321159 808117879R
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4273325359#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Pumps 3 Section 1
spmuPrepsihWVPV MT )deunitnoc(
rab012EASstiKriapeRpmuP rebmuNdlO .oNlairetaM
pmuPdradnatS61VPV 6060321159 218117879R
pmuP”1P“61VPV 8060321159 418117879R
pmuPdradnatS23/52VPV 8950321159 908117879R
pmuP”1P“23/52VPV 3260321159 528117879R
pmuPdradnatS36/54VPV 9360321159 838117879R
pmuP”1P“36/54VPV 2460321159 148117879R
pmuPdradnatS08VPV 1460321159 048117879R
pmuP”1P“08VPV 3460321159 248117879R
pmuPdradnatS031/001VPV 0560321159 948117879R
pmuP”1P“031/001VPV 2560321159 158117879R
pmuPdradnatS461VPV 1560321159 058117879R
pmuP”1P“461VPV 3560321159 258117879R
EASVPVrofstiKlaeS rebmuNdlO .oNlairetaM
61VPV 5060321159 5060321159
23/52VPV 7950321159 7950321159
08/36/54VPV 8560321159 8560321159
461/031/001VPV 9560321159 9560321159
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4273325359#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
SV Pumps
The Bosch line of SV variable displacement vane pumps hasbeen a workhouse variable vane pump in the hydraulic industry formany years. The SV product offering dates back to the early1970’s and continues to satisfy customers in many old and newapplications.
The SV product line is available in sizes 1 in3/rev. through 8 in3/rev., with 10 in3/rev. available on demand, and is available in bothsubplate and flange mounted versions in many sizes. Maximumpressure of SV pumps vary between 1000 and 2000 psi depend-ing on size, while speed range is restricted to 1000 to 1800RPM. The SV product line is only available in right hand rotation,and can accommodate special fluids such as phosphate estersand water glycol on demand.
Pumps 4 Section 1
SPMUPVS
eziS tnuoM )isp(.sserP.xaM 0571@mpg noitatoR noitpircseD rebmuNdlO .oNlairetaM )sbl(.tW
000.1 AEAS 0002 75.7 R 65MRH01FSSPVSP 4178295 452907879R 0.04
000.1 AEAS 0002 75.7 R 66MRH01FASPVSP 4098296 115907879R 0.04
005.1 AEAS 0001 04.11 R 65MRE51FSSPVSP 3678295 362907879R 0.04
005.1 AEAS 0001 04.11 R 66MRE51FASPVSP 2198296 415907879R 0.04
000.2 BEAS 0002 01.51 R 65MRH02FSSPVSP 6475295 222907879R 0.56
000.2 BEAS 0002 01.51 R 66MRH02FCSPVSP 0575296 264907879R 0.56
005.2 BEAS 0001 49.81 R 65MRE52FSSPVSP 5785295 232907879R 0.56
005.2 BEAS 0001 49.81 R 66MRE52FCSPVSP 1095296 284907879R 0.56
000.4 CEAS 0002 3.03 R 66MRH04FCSPVSP 6335196 834907879R 0.601
000.8 DEAS 0051 6.06 R 56MRG08FCSPVSP 3015196 804907879R 0.281
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
)deunitnoc(spmuPVS
*spmuPVSrofstiKriapeR
eziSpmuP gnitnuoM epyTtfahS tigiDngiseD rebmuNdlO .oNlairetaM
01VS )S(etalpbuS tfahSdednEelgniSmuideM 65-urht05- 701497-TIK 263007879R
01VS )B(detroPraeR,egnalF tfahSdednEelgniSmuideM 66-urht06- 701497-TIK 263007879R
01VS )A(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 593497-TIK 414007879R
51VS )S(etalpbuS tfahSdednEelgniSmuideM 65-urht05- 011497-TIK 463007879R
51VS )B(detroPraeR,egnalF tfahSdednEelgniSmuideM 66-urht06- 011497-TIK 463007879R
51VS )A(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 793497-TIK 514007879R
02VS )S(etalpbuS tfahSdednEelgniSmuideM 65-urht05- 331497-TIK 373007879R
02VS )B(detroPraeR,egnalF tfahSdednEelgniSmuideM 66-urht05- 331497-TIK 373007879R
02VS **)C(detroPediS,egnalF tfahSdednEelgniSmuideM 65-urht05- 331497-TIK 373007879R
02VS **)A(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 993497-TIK 614007879R
02VS **)C(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 993497-TIK 614007879R
52VS )S(etalpbuS tfahSdednEelgniSmuideM 65-urht05- 441497-TIK 873007879R
52VS )B(detroPraeR,egnalF tfahSdednEelgniSmuideM 66-urht05- 441497-TIK 873007879R
52VS **)C(detroPediS,egnalF tfahSdednEelgniSmuideM 65-urht05- 441497-TIK 873007879R
52VS **)A(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 104497-TIK 714007879R
52VS **)C(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 104497-TIK 714007879R
04VS )C(detroPediS,egnalF tfahSdednEelgniSmuideM 55-urht05- 121497-TIK 963007879R
04VS )R(detroPraeR,egnalF tfahSdednEelgniSmuideM 66-urht05- 121497-TIK 963007879R
04VS )C(detroPediS,egnalF tfahSnoitanibmoC 66-urht06- 304497-TIK 814007879R
08VS )R(detroPraeR,egnalF tfahSdednEelgniSmuideM 56-urht05- 101497-TIK 953007879R
08VS )C(detroPediS,egnalF tfahSdednEelgniSmuideM 55-urht05- 101497-TIK 953007879R
08VS )C(detroPediS,egnalF tfahSnoitanibmoC 56-urht06- 504497-TIK 914007879R
001VS )R(detroPraeR,egnalF tfahSdednEelgniSmuideM 56-urht05- 501497-TIK 163007879R
001VS )C(detroPediS,egnalF tfahSdednEelgniSmuideM 55-urht05- 501497-TIK 163007879R
001VS )C(detroPediS,egnalF tfahSnoitanibmoC 56-urht06- 704497-TIK 024007879R
spmuPVSrofstiKlaeS
eziSpmuP gnitnuoM epyTtfahS tigiDngiseD rebmuNdlO .oNlairetaM
51/01VS egnalFdnaetalpbuS noitanibmoC/elgniSmuideM 66-urht05- 853877-TIK 753007879R
52/02VS egnalFdnaetalpbuS noitanibmoC/elgniSmuideM 66-urht05- 427327-TIK 982007879R
04VS egnalFdnaetalpbuS noitanibmoC/elgniSmuideM 66-urht05- 137327-TIK 292007879R
001/08VS egnalFdnaetalpbuS noitanibmoC/elgniSmuideM 66-urht05- 337327-TIK 392007879R
).cte,elgnistrohs,dedneelbuod(selytstfahsrehtoroF.slaesnotivdnanwohsstigidngisedehthtiwylnostfahsnoitanibmocdnamuidemroferastiklaesdnariapeR*tikecivrestcerrocehtniatbootsesacesehtnierutaretiltcudorpetairporppaehtweiveresaelP.tnereffideblliwsrebmuntraptiklaesdnariaper,stigidngisedrehtodna
.srebmuntraptlob4htiwdetropedisera’C‘edocgnitnuomhtiwspmup52/02VS.snoitcennocdaerhtthgiartsEAShtiwdetropedisera’A‘edocgnitnuomhtiwspmup52/02VS**
.snoitcennocegnalf
Pumps 5 Section 1
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Direct Operated Servo Solenoid Valves
The spool is directly operated by the solenoid thus eliminating thehydraulic amplifier card of the conventional servo valve.
– Less than 0.1% repeatability– Available in NG6 (D03) and NG10 (D05) sizes– Flow rates up to 26 gpm (100 L/min)– Up to 130 Hz frequency response– Defined fail-safe position (except for 0 811 404 552)– Zero lap– On-board electronics
sevlaVdioneloSovreS sevlaVdioneloSovreS sevlaVdioneloSovreS sevlaVdioneloSovreS sevlaVdioneloSovreS
)30D(6GNerusserP
gnitaR)isp(
wolF .oNlairetaM thgieW)sbl( reifilpmA
MPG nim/l
0754 133.65.01
4214204
isp005
0064041180106404118020640411803064041180
0.6 NIP7EBO
1 4 1364041180 NIP7Am–EBO
0754 33.65.01
214204
236404118033640411804364041180
0.6NIP7EBO
0754 133.65.01
4214204
0164041180116404118021640411803164041180
0.6 NIP7EBO
)50D(01GN
07542.314.624.62
05001001
isp005
00840411801084041180 0.61 NIP7EBO
7184041180 NIP7Am–EBO
0754 2.314.62
05001
20840411803084041180
0.61 NIP7EBO
0754 1.12 08isp37
2554041180 0.61 NIP7EBO
0754 *73 *041isp061
7012041180 0.61 NIP7EBO
srotcennoC rebmuNdlO .oNlairetaM
EPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCCITSALPNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879RP* 1 P+A 2 B
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof2/310YKA3231677891#golataceeS
[Int. EI]
or
DC/DCA B
P T
[Int. EI]
or
DC/DCA B
P T
[Int. EI]
or
DC/DCA B
P T
[Int. EI]
or
DC/DCA B
P T
[Int. EI]
or
DC/DC
5/3 P1 P2 T
P/Q
[Int. EI]
UD–E
01
m.LR
A B
P T
US
TP
A B
Servo Solenoid Valves 6 Section 2
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Servo Solenoid Valves 7 Section 2
sevlaVdioneloSovreS
noitpircseD wolFepyT
erusserPgnitaR)isp(
wolFgnitoliP .oNlairetaM thgieW
)sbl( reifilpmAMPG nim/l
)50D(01GN%02
kcinK0005 5.41
5.225558
∆ =pisp37
TPTP
16640411802664041180
0.02 NIP7EBO
)70D(61GN%02
kcinK0005 7.13
35021002
∆ =pisp37
YXYXTPYP
05240411801524041180
793417879R3724041180
0.42 NIP7EBO
)80D(52GN%02
kcinK0005 89 073 ∆ =p
isp37YX 0344041180 0.14 NIP7EBO
VRH:)50D(01GN%02
kcinK0005 5.22 58 ∆ =p
isp37YX 1964041180 6.71 NIP21EBO
VRH:)70D(61GN%02
kcinK0005 35 002 ∆ =p
isp37YX 1924041180 0.32 NIP21EBO
%02kcinK
0005 89 073 ∆ =pisp37
YX 5444041180 0.14 NIP21EBO
srotcennoC rebmuNdlO .oNlairetaM
EPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCCITSALPNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R
EPYTREDLOSCITSALPNIP21ROTCENNOCGNITAMVRH 2414844381 2414844381)1 .isp0063=)troPX(erusserptolipmumixaM)2 0302321189si793417879RrofrebmuntrapdlO)3 tseuqernopuelbaliavasevlavdionelosovres23GN
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof3/310YKA8231677891#golataceeS
Pilot Operated Servo Solenoid Valves
The servo solenoid pilot valve drives a zero lap main stage therebycontrolling greater flow rates.
– Less than 0.1% repeatability– Sizes in NG10 (D05), NG16 (D07), NG25 (D08) and
NG32 (D10)– Nominal flow rates up to 264 gpm (1000 L/min)– Up to 62 Hz frequency response– Position feedback on mainstage– Zero lap– On-board electronics
[Int. EI]
or
DC/DCA B
PX YT
[Int. EI]
or
DC/DCA B
PX YT
A B
P TX Y
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Servo Solenoid Valves 8 Section 2
sevlaVnoitcejnI
oitpircseD n wolFepyT
erusserPgnitaR)isp(
wolFgnitoliP rebmuNdlO .oNlairetaM thgieW
)sbl( reifilpmAMPG nim/l
01GN noitcejnI 0005 5.22 58 TX 8664041180 8664041180 0.02 NIP7EBO
01GN noitcejnI 0005 5.22 58 TP 0764041180 0764041180 0.02 NIP7EBO
01GN noitcejnI 0005 5.22 58 YX 5312321189 984417879R 0.02 NIP7EBO
61GN noitcejnI 0005 35 002 YX 6724041180 6724041180 0.42 NIP7EBO
61GN noitcejnI 0005 35 002 TX 5724041180 5724041180 0.42 NIP7EBO
61GN noitcejnI 0005 35 002 TP 0724041180 0724041180 0.42 NIP7EBO
61GN noitcejnI 0005 35 002 YP 0212321189 674417879R 0.42 NIP7EBO
52GN noitcejnI 0005 89 073 TP 4344041180 4344041180 0.14 NIP7EBO
52GN noitcejnI 0005 89 073 YP 5344041180 5344041180 0.14 NIP7EBO
23/52GN noitcejnI 0005 711 034 YX 1444041180 1444041180 0.14 NIP7EBO
23/52GN noitcejnI 0005 711 034 TX 2444041180 2444041180 0.14 NIP7EBO
srotcennoC
EPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCCITSALPNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R)1 noitcejnI23GN .tseuqernopuelbaliavasevlav
9873325359#golataceeS .snoitacificepsecnamrofrepdnanoitpircsedetelpmocro2/310YKA3231677891osladna
Injection Valves
The injection valve was designed for plastic injection moldingapplications.
– Less than 0.1% repeatability– Sizes in NG10 (D05), NG16 (D07), NG25 (D08) and
NG32 (D10)– Nominal flow rates up to 264 gpm (1000 L/min)– Up to 62 Hz frequency response– Position feedback on mainstage– On-board electronics
A B
P TX Y
B
BU
U
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Proportional Valves 9 Section 3
Pilot Operated Proportional DirectionalValves
The proportional pilot valves drive a main stage with 20% overlapthereby providing open loop control for greater flow rates.
– Less than 0.1% repeatability– Sizes in NG10 (D05), NG16 (D07), NG25 (D08) and
NG32 (D10)– Nominal flow rates up to 291 gpm (1100 L/min)– Regenerative and 2:1, flow curves available– Position feedback on mainstage– 20% overlap on main stage spool– On-board electronics
sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD
noitpircseD epyTwolFerusserP
gnitaR)isp(
wolFgnitoliP .oNlairetaM thgieW
)sbl( reifilpmAMPG nim/l
PPH
)50D(01GNcirtemmyS 0005 12:12 08:08 ∆ =p
isp37YXTP
00740411803174041180
3.91 NIP7EBO
)70D(61GNcirtemmyS 0005 84:84 081:081 ∆ =p
isp37YXTP
50340411809134041180
0.42 NIP7EBO
)80D(52GNcirtemmyS 0005 29:29 053:053 ∆ =p
isp37YX 4544041180 0.14 NIP7EBO
PPH
)50D(01GN
cirtemmyS 0005 12:12 08:08 ∆ =pisp37
YXTP
20740411807074041180
3.91 NIP7EBO
)70D(61GNcirtemmyS 0005 84:84 081:081 ∆ =p
isp37YX 7034041180 0.42 NIP7EBO
)80D(52GNcirtemmyS 0005 29:29 053:053 ∆ =p
isp37YX 6544041180 0.14 NIP7EBO
PPH
)50D(01GN1:2
laitnereffiD0005 31:12 05:08 ∆ =p
isp37YX 1174041180 3.91 NIP7EBO
)70D(61GN1:2
laitnereffiD0005 92:84 011:081 ∆ =p
isp37YX 0234041180 0.42 NIP7EBO
)80D(52GN1:2
laitnereffiD0005 16:29 032:053 ∆ =p
isp37YX 2744041180 0.14 NIP7EBO
srotcennoC rebmuNdlO .oNlairetaMEPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R.tseuqernopuelbaliavasevlavdionelosovreslanoitidda23GN)1
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof3/310YKA8231677891#golataceeS
DC/DCA B
PX YT
or
[Int. El]
[Int. EI]
or
DC/DCC1 / C2 A B
P
C1
C2X YT
A B
P TX Y
01+LDiff. A B
PX YT
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Proportional Valves 10 Section 3
Proportional Throttle & Directional Valves
A proportional solenoid actuates the valve’s main spool directlythus providing accurate flow control.
– Available as throttle or directional valves– Available with or without LVDT feedback– NG6 (D03) and NG10 (D05) sizes– Nominal flow rates up to 21 gpm (80L/min)– Up to 4570 psi (315 bar) operating pressure– 20% overlap on spool
sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD sevlaVlortnoClanoitceriD
)30D(6GN wolFepyT
dioneloS)W/A(
erusserP)isp(gnitaR
wolF.oNlairetaM thgieW
)sbl( reifilpmAMPG nim/l
ON 52/5.2RL 3= Ω
0754 4.7 82 ∆ =pisp37
8013041180 5.4 3415041180
CN 4013041180 7.6
CN V42AV03xam
0754 8 03 ∆ =pisp37
8213041180 NIP7EBO
)50D(01GNCN RL 8.5= Ω
AV05xam0754 12 08
∆ =pisp37
0574041180 61 NIP7EBO
1003041180 5.51 9905041180
lortnoClanoitceriD
6GN)30D(
V42AV03xam
0754 8.45.8
8123
∆ =pisp37
15140411800514041180
7 NIP7EBO
01GN)50D(
V42AV05xam
3.971
5356
25840411800584041180
5.81
6GN)30D(
V42AV03xam
0754 8.45.8
8123
∆ =pisp37
04140411801414041180
9 NIP7EBO
01GN)50D(
V42AV05xam
2.3112
0508
07740411801774041180
5.81
6GN)30D(
V42AV03xam
0754 8.45.8
8123
∆ =pisp37
24140411803414041180
9 NIP7EBO
01GN)50D(
V42AV05xam
2.31122.71
050856
277404118037740411801584041180
5.81
2.31 05 8774041180 NIP7Am-EBO
01GN)50D(
V42AV05xam
0754 6.61 36 ∆ =pisp37
1004041180 6.71 0215041180
srotcennoC rebmuNdlO .oNlairetaMEPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCCITSALPNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof1/310YKA7131677891#golataceeS
A B
P T
[Int. EI]
UD–E
A B
P T
[Int. EI]
UD–E
A B
P T
[Int. EI]
UD–E
01
o.LR
A B
P T
[Int. EI]
UD–E
01
m.LR
A B
P T
[Int. EI]
UD–E
01+L
m.LR
A B
P T
01A B
P T
A B
P T
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Proportional Valves 11 Section 3
Proportional Pressure Relief Valves
A proportional solenoid provides force against a poppet to controlpressure. These valves could be direct or pilot operated.
– Relief and/or reducing functions available– Available with or without LVDT feedback– Sizes in NG6 (D03) and NG10 (D05)– Nominal flow rates up to 31.7 gpm (120 L/min)– Up to 4570 psi (315 bar) pressure range– Reducing/relieving valve will go to 0 psi
sevlaVlortnoClanoitroporP
)30D(6GN epyTwolF dioneloS)W/A(
erusserPgnitaR)isp(
)mpg(wolF .oNlairetaM thgieW)sbl( reifilpmA
feileR 81/8.0RL 02= Ω
5263 62.0xam4.0
9102041180 2.4 4415041180
feileR V42AV03xam
5263 62.0xam4.0
3702041180 6 NIP7EBO
)30D(6GN
feileR 52/7.2 5263 62.0.xam8.0
1202041180 5 5905041180
)30D(6GN
feileR 81/8.0RL 22= Ω
0754 6.01 3402041180 5 4415041180
feileR V42AV03xam
0754 6.01 6702041180 5.7 NIP7EBO
0162 9702041180 NIP7Am-EBO
/gnicudeRgniveileR
V42AV03xam
07548352
6.01 18020411800802041180
5.7 NIP7EBO
8352 3802041180 NIP7Am-EBO
srotcennoC rebmuNdlO .oNlairetaMEPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCNIP7–EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof1/310YKA7131677891#golataceeS
P
T
[Int. EI] P
TUD–E
Lin. DBV P
T
P
T
[Int. EI]
UD–E
P T
A
[Int. EI]
UD–E
P
T
P T
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Proportional Valves 12 Section 3
Proportional Throttle Cartridges
Cartridge type proportional throttle valves are actuated by a smallservo pilot valve. This pilot valve is located on the cover with theposition sensor.
These proportional throttle valves fit in the standard DIN cartridgecavities. The cover and cartridge are one piece.
– Nominal flow rates up to 264 gpm (1000 L/min)– Repeatability less than 0.2%– On board electronics
05GN-61GNsevlaVlanoitroporP
eziSerusserP
gnitaR)isp(
)mpg(wolF .oNlairetaM thgieW)sbl( reifilpmA
61GN52GN23GN04GN05GN
0064 845558231462
∆ =pisp37
25420411805152041180416204118002620411803362041180
811318142
6705041180
61GN52GN23GN04GN05GN
0064 845558231462
∆ =pisp37
45420411807152041180616204118022620411802462041180
701217132
EBO
srotcennoC rebmuNdlO .oNlairetaMEPYTREDLOSCITSALPNIP7–EBOROFROTCENNOCGNITAM 2202844381 2202844381
EPYTDEPMIRCNIP7-EBOROFROTCENNOCGNITAM 6202844381 6202844381
EPYTREDLOSSMNIP7–EBOROFROTCENNOCGNITAM 4500326359 895317879R.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof3/310YKA8231677891#golataceeS
NC B
YA X
NC B
YA X
B
YXA
US
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Electronics & Accessories 13 Section 4
Amplifier Cards
The following amplifier cards convert voltage or current com-mands into the appropriate current signals to operate the associ-ated hydraulic valve. Available card functionality: ramps, setpoints, failing outputs, etc.
Amplifier cards come in three forms:– Euro-card (requires card holder)– Active plugs (mounts directly on the solenoid)
sdraCreifilpmA
epyT pmaR ciremuNahplAdlO noitpircseDlairetaM .oNlairetaM
drac-oruE
pmartuohtiw 06VP06VQ
V2/2
VP/0V/01-735-1APRV-TVVQ-OV-01-735-1APRV-TV
V2/2-OV-02-725-1APRV-TV
790504118099050411806705041180
pmarhtiw 1CGR-06VP PTR-VP/0V/01-735-1APRV-TV 2015041180
gulpevitcA
pmarhtiw V-5.2SAAm-5.2SA
0V/02-525-1APSS-TVI/0V/02-525-1APSS-TV
34150411805415041180
gulpevitcA
pmarhtiw V-8.0SAAm-8.0SA
0V/02-805-1APSS-TVI/0V/02-805-1APSS-TV
44150411802615041180
drac-oruE
pmarhtiw 1CGR-1LDP2CGR-06VW
PTR/0V/01-725-1APRV-TVPTR-0V-01-735-2APRV-TV
00150411800215041180
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof1/310YKA7131677891#golataceeS
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof3/310YKA8231677891#golatacees,6705041180roF www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
sdraCyralixuA
epyT ciremuNahplAdlO noitpircseD .pircseDlairetaM .oNlairetaM
eludomNID
V-CPVAPMAR-MTOP
kcabdeefegatlov-lortnoCnoitisoP&yticoleVgolanAeludoMpmaRdnatniopteS
0V/01-005-SACAM-TVDNU-TREWLLOSLUDOM-NEPMAR
93150411808015041180
drac-oruE
IQP-6LPIQP-01LP
1-IQP
sevlaVdioneloS-ovreS6GNrofdraClortnoCQPsevlaVdioneloS-ovreS01GNrofdraClortnoCQP
sevlaVEBOdioneloS-ovreSrofdraClortnoCQPlennahC1
0V/02-725-1PARAV-TV0V/02-735-1PARAV-TV
0V/02-005-PACAV-TV
251504118035150411807515041180
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4/310YKA7131677891#golataceeS
Electronics & Accessories 14 Section 4
Accessories consist of card holders, card racks, powersupplies, and connectors.
Auxiliary Cards & Accessories
The following auxiliary cards can be used with an on-boardelectronic valve or with a valve and amplifier combination. Severalcards provide closed loop control and others provide set pointgeneration. These auxiliary cards come in two forms:
– Euro-card (requires card holder).– DIN module (mounts on standard DIN rail).
seirosseccA
ciremuNahplAdlO noitpircseD noitpircseDlairetaM .oNlairetaM
redloHdraC REDLOHDRAC 1006844381
02HC stbS2htiwsissahClasrevinU KCARLASREVINUTOLS202HC 4008127181
04HC stbS4htiwsissahClasrevinU KCARLASREVINUTOLS404HC 6008127181
02HC-10SP stbS2dnaylppuSrewoPhtiwsissahC YLPPUSREWOP+KCARTOLS202HC10SP 7008127181
20SP eludoMliaRNID-A4,V42-ylppuSrewoP RETLIFZTEN 9015041180
3001337381 Fu0074-roticapaC CDV36,FU0074ROTICAPAC 7001337381
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4/310YKA7231677891#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Pressure Transducers 15 Section 5
Pressure Transducers
The following pressure transducers are suitable for monitoringand regulating pressure in machine construction, plastic injectionmolding, presses and many other fields.
The most important features of these sensors are:– Stainless-steel membrane (spring material) with thin layer
strain gauge sensor– Integrated electronics with temperature compensation– Signal output proportional to pressure– Precise balance adjustment for zero point and sensitivity set
by manufacturer (no user access)
srecudsnarTerusserP
tuptuO egnaR dohteMnoitcennoC noitpircseD noitpircseDlairetaM .oNlairetaM
V01-0 ISP5403-0 gulPNIDllamS recudsnarTerusserP 0/0V/S-V-012/X1-81MH 0455041180
V01-0 ISP5705-0 gulPNIDllamS recudsnarTerusserP 0/0V/S-V-053/X1-81MH 7455041180
V01-0 ISP5403-0 gulPNIP-7 recudsnarTerusserP 0/0V/R-V-012/X1-81MH 1355041180
V01-0 ISP5705-0 gulPNIP-7 recudsnarTerusserP 0/0V/R-V-053/X1-81MH 2355041180
Am02-4 ISP5403-0 gulPNIDegraL recudsnarTerusserP 0/0V/B-C-012/X1-81MH 5455041180
Am02-4 ISP5705-0 gulPNIDegraL recudsnarTerusserP 0/0V/B-C-053/X1-81MH 6455041180
rebmuNdlO .oNlairetaM
recudsnarTrofretpadA)elam(4-EASotPPSB 842564 059607879R
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4/310YKA7231677891#golataceeS
)rosneshtiwdeilppus(3604844381:sirotcennocNIDkcalbllamsrofrebmuntraP)rosneshtiwdeilppus(0604844381:sirotcennocNIDkcalbegralrofrebmuntraP
)rosneshtiwdeilppuston(1414844381:sirotcennoc04PIgulpnip-7rofrebmuntraP)rosneshtiwdeilppuston(0414844381:sirotcennoc76PIgulpnip-7rofrebmuntraP
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 16 Section 6
Directional Valves – NG6 (D03 )
NG6 (D03) directional control valves are available in directsolenoid, pneumatic pilot, manual (lever) and hydraulic pilotoperated configurations. These valves are rated for 4600 psicontinuous operating pressures in P, A and B ports. T port israted for 2300 psi with a maximum flow rate of 23 gpm. Seecatalog 9 535 233 717 for additional information.
Bosch offers a wide range of solenoid voltages with DIN style, orwiring box connections. Our valves have viton seals, CSAapproved and are available with manual overrides. Approximateweight is 4 lbs.
P T
BA
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 17 Section 6
)30D(6GN-sevlaVlanoitceriD
epyTlortnoC loopSedoC noitcennoCeriW
dioneloSegatloV)zH/V(
.oNlairetaM noitpircseD
lacirtcelE
000
xoBeriW CA06/511 9601320189 15D06/511AK0001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/21 7931320189 15D00/210SW0001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 0341320189 15D00/420SW0001V1P60VW180
lacirtcelE
100
xoBeriW CD00/42 1151320189 15E00/420AK1001V1P60VW180
lacirtcelE xoBeriW CA06/511 0701320189 15D06/511AK1001V1P60VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 6311320189 15D06/511LK1001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/21 8931320189 15D00/210SW1001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 1341320189 15D00/420SW1001V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 4001320189 15D06/511SW1001V1P60VW180
reveLlaunaM 1831900180 0D1007V1P60VW180
lacirtcelE
200
xoBeriW CA06/511 1701320189 15D06/511AK2001V1P60VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 7311320189 15D06/511LK2001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/21 9931320189 15D00/210SW2001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 2341320189 15D00/420SW2001V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 5001320189 15D06/511SW2001V1P60VW180
toliPcitamuenP 7631900180 0D2006V1P60VW180
reveLlaunaM 3831900180 0D2007V1P60VW180
lacirtcelE
400
xoBeriW CA06/511 2701320189 15D06/511AK4001V1P60VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 8311320189 15D06/511LK4001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/21 0041320189 15D00/210SW4001V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 3341320189 15D00/420SW4001V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 6001320189 15D06/511SW4001V1P60VW180
reveLlaunaM 5831900180 0D4007V1P60VW180
lacirtcelE
010
xoBeriW CA06/511 5701320189 15D06/511AK0101V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 6341320189 15D00/420SW0101V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 9001320189 15D06/511SW0101V1P60VW180
lacirtcelE
210
xoBeriW CA06/511 7701320189 15D06/511AK2101V1P60VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 3411320189 15D06/511LK2101V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/21 5041320189 15D00/210SW2101V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 8341320189 15D00/420SW2101V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 1101320189 15D06/511SW2101V1P60VW180
relloR.hceM 4331900180 0D2104V1P60VW180
toliPcitamuenP 9631900180 0D2106V1P60VW180
reveLlaunaM 8831900180 0DG2107V1P60VW180
lacirtcelE810
0044OSI/05634NID CD00/42 1441320189 15D00/420SW8101V1P60VW180
lacirtcelE
020
xoBeriW CA06/511 1801320189 15D06/511AK0201V1P60VW180
lacirtcelE 0044OSI/05634NID CD00/42 2441320189 15D00/420SW0201V1P60VW180
lacirtcelE 0044OSI/05634NID CA06/511 5101320189 15D06/511SW0201V1P60VW180
toliPciluardyH 9531900180 0D0202V1P60VW180
toliPcitamuenP 1731900180 0D0206V1P60VW180
lacirtcelE330
0044OSI/05634NID CD00/42 8441320189 15D00/420SW3301V1P60VW180
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocro7173325359#golataceeS
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 18 Section 6
Directional Valves – NG10 (D05)
NG 10 (D05) directional control valves are available in directsolenoid, pneumatic pilot, manual (lever) and pilot operatedconfigurations. These valves are rated for 4600 psi continuousoperating pressures in ports P, A and B. T port is rated for 2300psi, maximum flow rate of 34 gpm. See catalog 9 535 233 717for additional information.
Bosch offers a wide range of solenoid voltages with DIN or wiringbox connections. For applications requiring controlled spool shiftover time we offer a “slow shift” option with both fixed andadjustable switching times. Our valves have viton seals, CSAapproved and are available with manual overrides. Approximateweight is 17 lbs.
P T
BA
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 19 Section 6
)50D(01GN-sevlaVlanoitceriD
epyTlortnoC loopSedoC noitcennoCeriW
dioneloSegatloV)zH/V(
.oNlairetaM noitpircseD
lacirtcelE
000
xoBeriW CA06/511 9602320189 15D06/511AK0001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 0342320189 15D00/420SW0001V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 3002320189 15D06/511SW0001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/69 4842320189 11/15D00/690SWT0001V1P01VW180
lacirtcelE
100
0044OSI/05634NID CD00/69 5842320189 11/15D00/690SWT1001V1P01VW180
lacirtcelE xoBeriW CA06/511 0702320189 15D06/511AK1001V1P01VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 6312320189 15D06/511LK1001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/21 8932320189 15D00/210SW1001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 1342320189 15D00/420SW1001V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 4002320189 15D06/511SW1001V1P01VW180
toliPcitamuenP 7581000180 0D1006V1P01VW180
reveLlaunaM 5091000180 0D1007V1P01VW180
lacirtcelE
200
xoBeriW CA06/511 1702320189 11/15D06/511AK2001V1P01VW180
lacirtcelE )1 0044OSI/05634NID CD00/69 0842320189 11/15D00/690SWT2001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/21 9932320189 11/15D00/210SW2001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 2342320189 11/15D00/420SW2001V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 5002320189 11/15D06/511SW2001V1P01VW180
lacirtcelE
400
xoBeriW CA06/511 2702320189 15D06/511AK4001V1P01VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 8312320189 15D06/511LK4001V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 3342320189 15D00/420SW4001V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 6002320189 15D06/511SW4001V1P01VW180
lacirtcelE010
0044OSI/05634NID CD00/42 6342320189 15D00/420SW0101V1P01VW180
lacirtcelE
110
xoBeriW CA06/511 6702320189 15D06/511AK1101V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 7342320189 15D00/420SW1101V1P01VW180
lacirtcelE
210
xoBeriW CA06/511 7702320189 15D06/511AK2101V1P01VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 3412320189 15D06/511LK2101V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 8342320189 15D00/420SW2101V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 1102320189 15D06/511SW2101V1P01VW180
relloR.hceM 7781000180 0D2104V1P01VW180
toliPcitamuenP 6581000180 0D2106V1P01VW180
lacirtcelE
810
xoBeriW CA06/511 0802320189 15D06/511AK8101V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 1442320189 15D00/420SW8101V1P01VW180
lacirtcelE
020
xoBeriW CA06/511 1802320189 15D06/511AK0201V1P01VW180
lacirtcelE 0044OSI/05634NID CD00/42 2442320189 15D00/420SW0201V1P01VW180
lacirtcelE 0044OSI/05634NID CA06/511 5102320189 15D06/511SW0201V1P01VW180)1 .tfihstfossiedocloopS
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7173325359#golataceeS
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 20 Section 6
Pilot Operated Directional Valves –NG16 (D07)
NG16 (D07) directional control valves are available in solenoid orhydraulic operation with fixed or adjustable pilot chokes. Thesevalves are rated for 4600 psi continuous operating pressures inports P, A and B. T port is rated for 2300 psi. Maximum flow rateis 80 gpm. See catalog 9 535 233 717 for additional information.
Bosch offers a wide range of solenoid voltages with both DIN orwiring box connections.
Our valves have viton seals, CSA approved and are available withmanual overrides. Approximate weight is 20 lbs.
)70D(61GN-sevlaVlanoitceriD
epyTlortnoC loopSedoC noitcennoCeriW
dioneloSegatloV)zH/V(
.oNlairetaM noitpircseD
lacirtcelE
100
xoBeriW CA06/511 5304320189 15D06/511AKTP1003V1P61VW180
lacirtcelE 0044OSI/05634NID CD00/42 5414320189 15D00/420SWTPF1003V1P61VW180
lacirtcelE 0044OSI/05634NID CD00/42 3014320189 15D00/420SWTXF1003V1P61VW180
lacirtcelE
400
0044OSI/05634NID CD00/42 9414320189 15D00/420SWTPF4003V1P61VW180
lacirtcelE 0044OSI/05634NID CD00/42 0514320189 15D00/420SWYXF4003V1P61VW180
lacirtcelE010
0044OSI/05634NID CD00/42 8414320189 15D00/420SWTPF0103V1P61VW180
lacirtcelE020
0044OSI/05634NID CD00/42 7414320189 15D00/420SWTPF0203V1P61VW180
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7173325359#golataceeS
P T
A B
P T
A B
P T
A B
BA
P TX Y
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 21 Section 6
Pilot Operated Directional Valves –NG25 (D08) 4600 PSI
NG25 (D08) directional control valves are available with fixed oradjustable pilot chokes and spool stops. These valves are ratedfor 4600 psi continuous operating pressures in ports P, A and B.T port is rated for 2300 psi. Maximum flow rate is 185 gpm. Seecatalog 9 535 233 717 for additional information.
Bosch offers a wide range of solenoid voltages with DIN or wiringbox connections.
Our valves have viton seals, CSA approved and are available withmanual overrides. Approximate weight is 38 lbs.
ISP0064)80D(52GN–sevlaVlanoitceriD
epyTlortnoC loopSedoC noitcennoCeriW
dioneloSegatloV)zH/V(
.oNlairetaM noitpircseD
lacirtcelE
000
xoBeriW CA06/511 3305320189 15D06/511AKYX0003V1P61VW180
lacirtcelE 0044OSI/05634NID CD00/42 0205320189 15D00/420SWYX0003V1P52VW180
lacirtcelE 0044OSI/05634NID CA06/511 5005320189 15D06/511SWYX0003V1P52VW180
lacirtcelE
100
xoBeriW CA06/511 5305320189 15D06/511AKTP1003V1P52VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 1605320189 15D06/511LKTP1003V1P52VW180
lacirtcelE 0044OSI/05634NID CD00/42 2205320189 15D00/420SWTP1003V1P52VW180
lacirtcelE 0044OSI/05634NID CA06/511 7005320189 15D06/511SWTP1003V1P52VW180
lacirtcelE
200
xoBeriW CA06/511 7305320189 15D06/511AKYX2003V1P61VW180
lacirtcelE xoBeriW CA06/511 2805320189 15D06/511AKYP2003V1P52VW180
lacirtcelE 0044OSI/05634NID CA06/511 0105320189 15D06/511SWYX2003V1P52VW180
lacirtcelE
400
xoBeriW CA06/511 9305320189 15D00/420SAKTP4003V1P52VW180
lacirtcelE thgiLtneS+xoBeriW CA06/511 4605320189 15D00/420SLKTP4003V1P52VW180
lacirtcelE 0044OSI/05634NID CD00/42 6205320189 15D00/420SWTP4003V1P52VW180
lacirtcelE010
xoBeriW CA06/511 3405320189 15D06/511AKTP0103V1P52VW180
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7173325359#golataceeS
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
BA
P TX Y
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 22 Section 6
Pilot Operated Low PressureDirectional Valves –NG25/55 (D08) 3000 PSI
3000 psi, NG25 (D08) directional control valves are available asa pilot operated type valve. This main stage valve utilizes the NG6(D03) valve as the pilot valve controlling oil into and out of eachend of the main stage spool. This valve is rated for 3000 psi withmaximum flow rate of 75 gpm and is available with several spooloptions. We offer a wide range of solenoid voltages along withboth wiring box and DIN style connectors. All of our pilot valveshave viton seals, CSA approved and are available with manualoverrides.
Optional load check in P-port and sandwich mounted pilot flowcontrols are available for control of the main spool switching time.Approximate weight is 27 lbs.
)80D(55/52GN–sevlaVlanoitceriDerusserPrewoLdetarepOtoliP
epyTlortnoC loopSedoC snoitcennoCdioneloS
dioneloSegatloV)zH/V(
.oNlairetaM noitpircseDmumixaMerusserP
)isp(
lacirtcelE000
xoBgniriW 06/511 3855320189 55/15D06/511AKYX003V1P52VW180 0003
05634niD CD00/42 4575320189 55/15D00/420SWYX003V1P52VW180 0003
lacirtcelE
100
xoBgniriW 06/511 5055320189 55/15D06/511AKTP103V1P52VW180 0003
xoBgniriW 06/511 3555320189 55/15D06/511AKYP103V1P52VW180 0003
05634niD 06/511 0855320189 55/15D06/511SWTP103V1P52VW180 0003
lacirtcelE200
xoBgniriW 06/511 7055320189 55/15D06/511AKYP203V1P52VW180 0003
lacirtcelE400
xoBgniriW 06/511 8055320189 55/15D06/511AKTP403V1P52VW180 0003
xoBgniriW 06/511 4455320189 55/15D06/511LKTP403V1P52VW180 0003
lacirtcelE 010 xoBgniriW 06/511 2155320189 55/15D06/511AKTP013V1P52VW180 0003
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7173325359#golataceeS
P T
A B
P T
A B
P T
A B
P T
A B
P T
A B
BA
P TX Y
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Directional Control Valves 23 Section 6
Subplates
Ductile iron subplates are available with both SAE and NPT ports.All subplates are offered for directional valve sizes NG6 (D03) toNG25 (D05). Side and bottom ported plates are available withpressure ratings of 4600 psi.
setalpbuS
nrettaPgnitnuoM eziStroP noitacoLtroP gnitnuoMevlaVdaerhTtloB rebmuNdlO .oNlairetaM
)30D(6GN 3/8 FTPN" ediS CNU42-01# 5410100009 735017879R
)30D(6GN 3/8 FTPN" mottoB CNU42-01# 6410100009 835017879R
)30D(6GN 1/2 FTPN" ediS CNU42-01# 2410100009 435017879R
)30D(6GN .dhTthgiartSEAS6– ediS CNU42-01# 3410100009 535017879R
)30D(6GN .dhTthgiartSEAS8– ediS CNU42-01# 1410100009 335017879R
)30D(6GN .dhTthgiartSEAS8– mottoB CNU42-01# 0410100009 235017879R
)50D(01GN 1/2 FTPN" ediS 1/4 CNU02- 4610100009 645017879R
)50D(01GN 1/2 FTPN" mottoB 1/4 CNU02- 2710100009 255017879R
)50D(01GN 3/4 FTPN" ediS 1/4 CNU02- 6610100009 845017879R
)50D(01GN .dhTthgiartSEAS8– ediS 1/4 CNU02- 5610100009 745017879R
)50D(01GN .dhTthgiartSEAS21– ediS 1/4 CNU02- 5710100009 555017879R
)50D(01GN .dhTthgiartSEAS21– mottoB 1/4 CNU02- 3810100009 165017879R
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7173325359#golataceeS www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Modular Valves 24 Section 7
NG6 (D03) Modular Valves
NG6 (D03) modular valves are provided with standard NFPA andISO 4401 mounting. These are CETOP standard design valvessupplied in steel bodies. The maximum pressure rating is 4600psi with a flow range of 13.2–15.8 gpm.
Modules offered: pressure relief, pressure reducing, flow controland check valve. Viton seals come standard with all valves.Adjustment options include locknut or keylock.
P T A
P T A B
B
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Modular Valves 25 Section 7
)30D(6GNsevlaVraludoM
epyT lobmyS noitpircseD rebmuNdlO .oNlairetaMmumixaM
wolF)mpg(
-/mumixaMmuminiMerusserP
)isp(
evlaVssenkcihT
)ni(
.xorppAthgieW
)sbl(
feileR
05-S10MDABS1EF 6711610189 6711610189 2.31 0611/06 75.1 3
05-S10MHDES1EF 8711610189 8711610189 2.31 0054/003 75.1 3
05-S10MEABS1EF 7711610189 7711610189 2.31 0032/07 75.1 3
05-S10MEABS1EF 1811610189 1811610189 8.51 0032/07 75.1 3
05-S10MHDBS1EF 2811610189 2811610189 8.51 0064/07 75.1 3
gnicudeR
05-S10MCPBS3EF 3511610189 8057582747 8.51 034/54 75.1 3.3
05-S10MDPBS3EF 4511610189 9057582747 8.51 0611/06 75.1 3.3
P10MHDBS3EF 6511610189 6511610189 8.51 0063/003 75.1 3.3
05-S10MFDBS3EF 5511610189 0157582747 8.51 0032/003 75.1 3.3
A10MDPBS3EF 8511610189 2157582747 8.51 0611/06 75.1 3.3
B10MDPBS3EF 2611610189 4157582747 8.51 0611/06 75.1 3.3
kcehC
7P101MGDD1BF 3711610189 3711610189 8.51 0064 6.1 2
22T101MGDD1BF 4711610189 4711610189 8.51 0064 6.1 2
A101MHDP1BF 9611610189 9611610189 8.51 0064 6.1 8.2
B/A101MHDP1BF 1711610189 1711610189 8.51 0064 6.1 8.2
B101MHDP1BF 0711610189 0711610189 8.51 0064 6.1 8.2
wolFlortnoC
H10LMGS1FF 9801610189 *1357582747 2.31 0064 6.1 3.3
S10LMGS1FF 8801610189 *0357582747 2.31 0064 6.1 2.2
.8611610189otralimiswon,degnahcsahngisedydoB*.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof7613325359#golataceeS
TA P B
G
TA P B
TA P B
G
TA P B
G
TA P B
G
TA P B
TA P B
TA P B
TA P B
TA P B
TA P B
180°
TA P B
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Modular Valves 26 Section 7
NG10 (D05) Modular Valves
NG10 (D05) modular valves are provided with standard NFPAand ISO 4401 mounting supplied in steel bodies. The pressurerating of these valves is 4600 psi with a maximum flow of 26 gpm.
Modules offered: pressure relief, pressure reducing, flow controland check valve. Viton seals are standard in all valves. Locknutand keylock adjustment options are available.
P T A
P T A B
B
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Modular Valves 27 Section 7
)50D(01GNsevlaVraludoM
epyT lobmyS noitpircseD rebmuNdlO .oNlairetaM.xaM.sserP
)isp(
.sserPegnaR)isp(
.xaMwolF
)mpg(
.xorppAthgieW
)sbl(
.O.PfeileR T-PmetStoliPevlaVfeileR 0121011180 6121011180 0064 0611-001 62 7.5
tceriDfeileR
T-PmetSRIDevlaVfeileR 2521011180 7721011180 0064 0064-001 62 4.6
T-AmetSRIDevlaVfeileR 7521011180 2821011180 0064 0064-001 62 4.6
T-B&T-AmetSRIDevlaVfeileR 7621011180 2921011180 0064 0064-001 62 7.7
XmetSRIDevlaVfeileR 1721011180 6921011180 0064 0032-001 62 7.7
gnicudeR
PmetSevlaVgnicudeRerusserP 6115411180 6715411180 0064 0611-06 62 0.6
PmetSevlaVgnicudeRerusserP 7115411180 7715411180 0064 0032-021 62 0.6
PmetSevlaVgnicudeRerusserP 8115411180 8715411180 0064 0064-021 62 0.6
KC/WAmetS 4215411180 4815411180 0064 0611-06 62 0.6
KC/WBmetS 2315411180 2915411180 0064 0611-06 62 0.6
kcehC
ISP7PnotceriDevlaVkcehC 5200001180 8200001180 0064 – 62 0.4
A1:5.5toliPevlaVkcehC 5200201180 8200201180 0064 – 62 6.6
AecneSkcehCB.O.P 6200201180 9200201180 0064 – 62 6.6
elbuoDeludoMkcehC.O.P 7200201180 0300201180 0064 – 62 6.6
wolFlortnoC)elttorhT(
20NMGS1FF 5200031180 6200031180 0064 – 62 4.4
GMH20NMGS1FF 5200231180 9200231180 0064 – 62 4.4
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof3713325359#golataceeS
TA A P B TB
G
TA A P B TB
G
TA A P B TB
TA A P B TB
TA A P B TB
TA A P B TB
G
TA A P B TB
G
TA A P B TB
G
TA A P B TB
G
TA A P B TB
TA A P B TB
TA A P B TB
TA A P B TB
TA A P B TB
180°
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Logic Elements 28 Section 8
Cartridge Valve Inserts
Cartridge valves are designed to insert into manifolds. Thesevalves are offered with two area ratios, varying cracking pressuresand with or without a damping nose. Sizes range from NG16 toNG50 with a wide variety of covers. Covers have check valve,directional or flow control valve options. These valves can becombined with proportional pilot valves for proportional control.
stresnIevlaVegdirtraC
eziS noitpircseD wolFoitaR
ecroFgnirpS)gnikcarc(
)isp(rab.oNlairetaM
mumixaMwolF
)mpl(mpg
etamixorppAthgieW
)sbl(noitpircseDlairetaM
61GN lortnoClanoitceriD 1:1 )isp85(rab4 6429058181 )002(35 44.0 Z/X1E04BD61RL
61GN lortnoClanoitceriD 1:1 )isp51(rab1 5429058181 )002(35 44.0 Z/X1E01BD61RL
61GN lortnoClanoitceriDdereteM 6.1:1 )isp85(rab4 3429058181 )002(35 44.0 Z/X1D04F61RL
61GN lortnoClanoitceriDdereteM 6.1:1 )isp51(rab1 2429058181 )002(35 44.0 Z/X1D01F61RL
61GN lortnoClanoitceriD 6.1:1 )isp85(rab4 5719058181 )002(35 44.0 Z/X1E04F61RL
61GN lortnoClanoitceriD 6.1:1 )isp51(rab1 4719058181 )002(35 44.0 Z/X1E01F61RL
61GN evlaVkcehC 6.1:1 )isp51(rab1 8329058181 )002(35 44.0 03B/X1E01F61RL
52GN lortnoCerusserP 1:1 )isp44(rab3 3039058181 )934(611 88.0 01A/X1E52BD52RL
52GN lortnoClanoitceriD 1:1 )isp85(rab4 2039058181 )934(611 88.0 Z/X1E04BD52RL
52GN lortnoClanoitceriD 1:1 )isp51(rab1 1039058181 )934(611 88.0 Z/X1E01BD52RL
52GN lortnoClanoitceriDdereteM 6.1:1 )isp51(rab1 8929058181 )934(611 88.0 Z/X1D01F52RL
52GN lortnoClanoitceriD 6.1:1 )isp85(rab4 6929058181 )934(611 88.0 Z/X1E04F52RL
52GN lortnoClanoitceriD 6.1:1 )isp51(rab1 5929058181 )934(611 88.0 Z/X1E01F52RL
52GN lortnoClanoitceriD 6.1:1 )isp4(rab3.0 4929058181 )934(611 88.0 Z/X1E30F52RL
23GN feileRerusserP )1 1:1 )isp44(rab3 4329058181 )316(261 0.2 01A/X1E03BD23RL
23GN lortnoClanoitceriD 6.1:1 )isp85(rab4 6229058181 )316(261 0.2 ZT/X1E04F23RL
23GN lortnoClanoitceriD 6.1:1 )isp51(rab1 5229058181 )316(261 0.2 ZT/X1E01F23RL
23GN lortnoClanoitceriD 6.1:1 )isp4(rab3.0 4229058181 )316(261 0.2 ZT/X1E30F23RL
04GN lortnoClanoitceriDdereteM 6.1:1 )isp51(rab1 0129058181 )0021(713 0.4 Z/X1D01F04RL
04GN lortnoClanoitceriD 6.1:1 )isp51(rab1 7029058181 )0021(713 0.4 ZT/X1E01F04RL
04GN evlaVkcehC 6.1:1 )isp4(rab3.0 3029058181 )0021(713 0.4 04B/X1E30F04RL
04GN evlaVfeileR 1:1 )isp44(rab3 6129058181 )0021(713 0.4 21A/X1E03BD04RL
04GN lortnoClanoitceriD 6.1:1 )isp4(rab3.0 6029058181 )0021(713 0.4 ZT/X1E30F04RL
05GN lortnoClanoitceriD 6.1:1 )isp4(rab3.0 8439058181 )0051(693 0.7 ZT/X1E30F05RL)1 .sehctongnireteM
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof5011677891#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Logic Elements 29 Section 8
Right Angle Cartridge Check Valves
Right angle cartridge check valves are used for installation andmanifold blocks.
Leak free closure in checked direction.
– Various cracking pressure options– Up to 4600 psi (315 bar)– Up to 106 GPM (400 l/min)
stresnIevlaVegdirtraC
eziS noitpircseDecroFgnirpS
)gnikcarc()isp(raB
rebmuNdlO .oNlairetaM02@wolF
pordisp)mpl(mpg
etamixorppAthgieW
)sbl(noitpircseDtcudorP
mm01 evlaVkcehC )isp7(raB5.0 2150321189 073417879R )03(98.7 11.0 00/7F01RCVC
mm51 evlaVkcehC )isp7(raB5.0 0250321189 173417879R )08(1.12 81.0 00/7F51RCVC
mm02 evlaVkcehC )isp7(raB5.0 8250321189 273417879R )041(8.63 13.0 00/7F02RCVC
mm52 evlaVkcehC )isp7(raB5.0 6350321189 373417879R )081(6.74 07.0 00/7F52RCVC
mm03 evlaVkcehC )isp7(raB5.0 4450321189 573417879R )032(5.06 30.1 00/7F03RCVC
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof5773325359#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Logic Elements 30 Section 8
Cartridge Valve Covers
Cartridge valve covers combined with the cartridge valve andmanifold can offer several functions such as directional control,pressure control, counterbalance, flow control, check andproportional pressure control. These covers are offered with builtin orifice capabilities to control the main cartridge switching time.The valve cover mounting is per NFPA D03 standard for mountingto any standard pilot valve.
srevoCevlaVegdirtraC
eziS lobmyS noitpircseD .oNlairetaMmumixaMerusserP
F,B,A)isp(
etamixorppAthgieW
)sbl(
61GN lortnoC/tceriD 8720055181 0064 0.2
52GN lortnoC/tceriD 5920055181 0064 80.3
23GN lortnoC/tceriD 4720055181 0064 5.5
04GN lortnoC/tceriD 0720055181 0064 87.01
61GN lortnoCerusserP 7720055181 0064 0.2
52GN lortnoCerusserP 4920055181 0064 80.3
61GN toliPetomeR 6720055181 0064 0.2
52GN toliPetomeR 3920055181 0064 80.3
23GN toliPetomeR 2720055181 0064 5.5
04GN toliPetomeR 8620055181 0064 87.01
23GN gnitnuoM6GN/welttuhS 8740055181 0064 80.01)1 .srevochtiwdedulcnistiktloB
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof5011677891#golataceeS
M M
X YF
P A T
M M
X YF
P T
M
X F
X
M1F
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Flow Control Valves 31 Section 9
Subplate Mounted 3/4" Feed Valves
This valve is rated at 3000 psi and available in four sizes oftraverse flow. Valve flow rates selected should be greater thanthe maximum flow required.
The integral return check valve consists of a two port feedpanel valve. Feed control panel mounting is not restricted.Direct operated, lockable keyknob.
sevlaVdeeF"4/3detnuoMetalpbuS
rebmuNdlO .oNlairetaM noitpircseDmumixaMerusserP
)isp(wolFesrevarT)mpg(etaR
etamixorppAthgieW
)sbl(
058279 521417879R NGKH602SHAR3CF 0003 01 02
158279 621417879R NGLH602SHAR3CF 0003 51 02
258279 721417879R NGMH602SHAR3CF 0003 02 02
358279 821417879R NGPH602SHAR3CF 0003 03 02
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof8513325359#golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Accumulators 32 Section 10
Bladder Accumulators
Hydraulic bladder accumulators can be used in a variety ofapplications such as energy storage, emergency power source,compensation for losses due to leakage, damping of periodicshocks and volume variations.
– 3000 psi (207 bar) and 4800 psi (330 bar) rated– 1/4 gallon to 14 gallon sizes– 3000 psi (207 bar) has ASME approval– 4800 psi (330 bar) has CE approval
srotalumuccA
emuloVdiuqiL)retil(lag
xaMerusserPrab/isp
noitcennoCdiulF reddalBlairetaM rebmuNdlO .oNlairetaM noitpircseD
)1(52. 702/0003 B2NU2161/3-1EAS NanuB 0462111350 375007879R EMSA-111N2-G21U5/X2-702-1BAH
)4(1 702/0003 B2NU218/5-1EAS NanuB 0463111350 485007879R EMSA-111N2-G80U5/X2-702-4BAH
)01(5.2 702/0003 B2NU218/7-1EAS NanuB 0464111350 595007879R EMSA-111N2-G90U5/X2-702-01BAH
)02(5 702/0003 B2NU218/7-1EAS NanuB 0465111350 216007879R EMSA-111N2-G90U5/X2-702-02BAH
)53(01 702/0003 B2NU218/7-1EAS NanuB 0565111350 716007879R EMSA-111N2-G90U5/X2-702-53BAH
)05(41 702/0003 B2NU218/7-1EAS NanuB 0466111350 726007879R EMSA-111N2-G90U5/X2-702-05BAH
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4813325359golataceeS
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Accumulators 33 Section 10
srotalumuccA
emuloVdiuqiLxaM
erusserPrab/isp
noitcennoCdiulF reddalBlairetaM .oNlairetaM noitpircseD
ni6.4 3 )L570.0( 052/3263 B2-FNU81-61/9EAS NanuB 2360161350 H ASU-111N2S21U0/X1-052-570.0DA
ni01 3 )L61.0( 052/3263 B2-FNU81-61/9EAS NanuB 1160061350 H ASU-111N2S21U0/X1-052-61.0DA
ni01 3 )L61.0( 052/3263 FTPN81-8/3 NanuB 0060061350 H ASU-111N2A20F0/X1-052-61.0DA
ni12 3 )L53.0( 061/0232 B2-FNU61-4/3EAS NanuB 9451061350 H ASU-111N2A40U0/X1-061-53.0DA
ni12 3 )L53.0( 702/0003 B2-FNU61-4/3EAS NanuB 2751061350 H ASU-111N2A40U0/X1-702-53.0DA
ni12 3 )L53.0( 061/0232 FTPN41-2/1 NanuB 3351061350 H ASU-111N2A80F0/X1-061-53.0DA
ni13 3 )L05.0( 061/0232 B2-FNU61-4/3EAS NanuB 7251161350 H ASU-111N2A40U0/X1-081-5.0DA
ni13 3 )L05.0( 112/8503 B2-FNU61-4/3EAS NanuB 3061161350 H ASU-111N2A40U0/X1-702-5.0DA
ni34 3 )L07.0( 081/0162 B2-FNU61-4/3EAS NanuB 0652061350 H ASU-111N2A40U0/X1-081-7.0DA
ni34 3 )L07.0( 081/0162 FTPN41-2/1 NanuB 1852061350 H ASU-111N2A80F0/X1-702-7.0DA
ni34 3 )L07.0( 702/0003 B2-FNU61-4/3EAS NanuB 8852061350 H ASU-111N2C40U0/X1-702-7.0DA
ni34 3 )L07.0( 081/0162 FTPN41-2/1 NanuB 3552061350 H ASU-111N2C80F0/X1-081-7.0DA
ni58 3 )L4.1( 702/0003 B2-FNU61-4/3EAS NanuB 1053061350 H ASU-111N2C80U0/X1-702-4.1DA
ni58 3 )L4.1( 702/0003 B2-FNU61-4/3EAS OCE 2053061350
ni58 3 )L4.1( 702/0003 FTPN41-2/1 NanuB 0053061350 H ASU-111N2C80F0/X1-702-4.1DA
ni221 3 )L0.2( 702/0003 B2-FNU61-4/3EAS NanuB 0053261350 H ASU-111N2C40U0/X1-702-0.2DA
ni071 3 )L8.2( 702/0003 FTPN41-2/1 NanuB 0053161350 HA .2D ASU-111N2C80F0/X1-702-8
ni071 3 )L8.2( 702/0003 B2-FNU61-4/3EAS NanuB 3053161350 H ASU-111N2C40U0/X1-702-8.2DA
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4813325359golataceeS
Diaphragm Accumulators
Hydraulic diaphragm accumulators can be used in a variety ofapplications such as energy storage, emergency power source,compensation for losses due to leakage, damping of periodicshocks and volume variations.
– 4.6 in.3 to 170 in.3 sizes– Presures up to 3600 psi (250 bar)– Available in CE and ASME cerification
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Accumulator Accessories 34 Section 11
Safety and Shut-Off Blocks
The Bosch Rexroth safety and shut-off block is a hydraulicelement for the purpose of shutting off and discharging, prefer-ably for use with hydro-pneumatic bladder-type accumulators.
The manifold and accumulator are connected via an adapterfitting or flange.
Approval: DIN 24 552 (TRB 403 and 404)
The pressure-relief valve block is tested and sealed by CErepresentatives.
– Optional electrically operated 2-way directional control valve
skcolBffO-tuhSdnaytefaS
noitpircseD.xaM
erusserP)isp(rab
wolF.xaM)mpl(mpg zH/V
.xorppAthgieW
)sbl(.oNlairetaM
02GN
1A/00/42/G/30/Z/D/MPF/1/02/WAV2350 – – 00/42 43.21 1215102350
1A/LAUNAM/G/30/Z/D/MPF/1/02/WAV2350 – – launam 65.21 9315102350
1A/00/42/G/30/Z/D/05/07/MPF/1/02/WAV2350 )5101(07 )05(12.31 00/42 22.31 2215102350
1A/00/42/G/30/Z/D/001/001/MPF/1/02/WAV2350 )0541(001 )001(24.62 00/42 22.31 4215102350
1A/00/42/G/30/Z/D/001/061/MPF/1/02/WAV2350 )1232(061 )001(24.62 00/42 22.31 6215102350
1A/00/42/G/30/Z/D/031/112/MPF/1/02/WAV2350 )0603(112 )031(43.43 00/42 22.31 8215102350
1A/00/42/G/30/Z/D/031/052/MPF/1/02/WAV2350 )6263(052 )031(43.43 00/42 22.31 0315102350
1A/00/42/G/30/Z/D/031/082/MPF/1/02/WAV2350 )1604(082 )031(43.43 00/42 22.31 4315102350
1A/00/42/G/30/Z/D/051/033/MPF/1/02/WAV2350 )6874(033 )051(36.93 00/42 22.31 2315102350
23GN
1A/LAUNAM/G/30/Z/D/MPF/1/23/WAV2350 – – launam 47.13 1606102350
1A/00/42/G/30/Z/D/001/061/MPF/1/23/WAV2350 )0232(061 )001(24.62 00/42 04.23 4506102350
1A/00/42/G/30/Z/D/001/112/MPF/1/23/WAV2350 )0603(112 )001(24.62 00/42 04.23 6506102350
1A/00/42/G/30/Z/D/051/033/MPF/1/23/WAV2350 )6874(033 )051(36.93 00/42 04.23 8506102350
1A/00/42/G/30/Z/D/051/033/MPF/1/23/WAV2350 )6874(033 )051(36.93 00/42 46.03 0606102350
1A/G/30/Z/KD/062/082/MPF/2/23/WAV2350 )1604(082 )062(86.86 – 04.23 7506102350
.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4813325359#golataceeS
M1A
PT
M2
www.Laheg
hi.com
ServiceAutomation
MobileHydraulics
IndustrialHydraulics
Electric Drivesand Controls
Linear Motion andAssembly Technologies Pneumatics
Accumulator Accessories 35 Section 11
Accumulator discharge valves
Accumulator discharge valves allow for the safe and efficientdischarge of Bosch accumulators.
3000 psi rating 12 to 80 gpm
stekcarBrotalumuccA
.oNlairetaM noitpircseD rotalumuccAeziS
esUroFispotpU
7106131351 6M79-29.AIDROFPMALCMUCCA ni12 3 A/N
6106131351 8M551-541.AIDROFPMALCMUCCA ni221–58 3 0002
0206131351 8M081-071.AIDROFPMALCMUCCA ni071 3 0063
5006131351 L0521M032-422.AIDROFPMALCMUCCA 21/ –2 .lag41 A/N
.stinutset&egrahcdnasnoitacificepsecnamrofrep,noitpircsedetelpmocrof4813325359#golataceeS
sevlaVegrahcsiDrotalumuccA
rebmuNdlO .oNlairetaM noitpircseD erusserP)isp(gnitaR
wolFmumixaM)mpg(
troPeziS
etamixorppA)sbl(thgieW
873289 752517879R 01F151PDA 0003 21 EAS6# 4
582289 552517879R 01F453CDA 0003 04 EAS21# 6
973289 852517879R 01F854CDA 0003 08 EAS02# 21.snoitacificepsecnamrofrepdnanoitpircsedetelpmocrof4813325359#golataceeS
Accumulator Brackets
Brackets allow secure, easy installation of accumulator in eithervertical position for bladder type or unrestricted orientation fordiaphragm type.
Brackets can be bolted or welded to the supporting structure.
Rubber cushioning on straps helps prevent noise from beingtransmitted through metal to metal contact.
Base bracket available for support of vertical mounting oflarge sizes.
P A
DIS
www.Laheg
hi.com
Bosch Rexroth CorporationIndustrial Hydraulics7900 Durand Avenue, Bldg. 1Sturtevant, WI 53177Telephone (262) 554-7100Facsimile (262) 554-8103www.boschrexroth-us.com
Bosch Rexroth CorporationCorporate Headquarters5150 Prairie Stone ParkwayHoffman Estates, IL 60192-3707Telephone (847) 645-3600Facsimile (847) 645-6201
Bosch Rexroth CorporationElectric Drives and Controls5150 Prairie Stone ParkwayHoffman Estates, IL 60192-3707Telephone (847) 645-3600Facsimile (847) 645-6201
Bosch Rexroth CorporationLinear Motion andAssembly Technologies816 E. Third StreetBuchanan, MI 49107Telephone (269) 695-0151Facsimile (269) 695-5363
14001 South Lakes DriveCharlotte, NC 28273Telephone (800) 438-5983Facsimile (704) 583-0523
Bosch Rexroth CorporationPneumatics1953 Mercer RoadLexington, KY 40511-1021Telephone (859) 254-8031Facsimile (859) 281-3491
Printed in the United States9 535 233 792 06/04
Bosch Rexroth CorporationService Automation5150 Prairie Stone ParkwayHoffman Estates, IL 60192-3707Telephone (847) 645-3600Facsimile (847) 645-0804
2315 City Line RoadBethlehem, PA 18017-2131Telephone (610) 694-8300Facsimile (610) 694-8467
Bosch Rexroth CorporationMobile Hydraulics1700 Old Mansfield RoadWooster, OH 44691-0394Telephone (330) 263-3300Facsimile (330) 263-3333
www.Laheg
hi.com
Recommended