Transcript
Page 1: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

3651 N. Hwy 89 • Chino Valley, AZ 86323(928) 636-7080 • www.p-a-g.net

DODGE RAM 2WD2” FRONT COIL SPRINGLEVELING KITINSTALLATION INSTRUCTIONS1994-2002 2500/35002005-2013 1500

KIT# DL222PA WARNING

Read and understand all instructions, warnings, cau-tions, and notes in this sheet and in your owners man-ual before you begin the installation of this coil lift kit.

WARNINGProper installation of a Performance AurtomotiveGroup coil spring lift kit requires knowledge of the fac-tory recommended procedures for disassembly andassembly of original equipment components. We rec-ommend that the factory shop manual and any specialtools necessary to your vehicle be on hand during theinstallation. Installation of this coil lift kit without properknowledge of the factory recommended proceduresmay affect the performance of these components andthe safety of your vehicle. We strongly recommendthat a certified mechanic familiar with the installation ofsimilar components install this coil lift kit.

WARNINGEnsure that your vehicle tires are properly blocked andsecured before you begin installation of this coil springlift kit.

CAUTIONIt is the customer's responsibility to ensure that allmounting hardware is correctly tightened before, dur-ing and after use of coil spring lift kit. DO NOTEXCEED manufacturer's load specifications for yourvehicle. Always operate your vehicle in a safe manner.If your vehicle is equipped with any type of extra dutysuspension or special towing package, this coil lift kitmay not fit properly. If your vehicle is equipped withany type of aftermarket springs, lift kits, or bushings,this coil lift kit may not fit properly.

WARNINGMany states now have laws restricting bumper heightsand vehicle lifts. Local laws should be consulted todetermine if the changes you intend to make to yourvehicle comply with state laws. Before combining abody lift with a suspension lift, consult an installationprofessional to see how this will affect your specificapplication.

WARNINGThis coil spring lift kit should only be installed on vehi-cles in good working condition. Before installation, thevehicle should be thoroughly inspected for evidence ofcorrosion or deformation. This coil lift kit should not beinstalled on any vehicle that is suspected to have beenin a collision or misused. Failure to observe this warn-ing may result in serious personal injury and/or severedamage to your vehicle.

WARNINGTo ensure the Supplemental Restraint System (SRS,or air bag) is not accidentally deployed during coil liftkit installation, always ground yourself and the vehicle.Do not use power or pneumatic tools. Exerciseextreme caution while working near SRS sensors andwiring. Do not allow anyone near air bags during kitinstallation. Accidental deployment can result in seri-ous personal injury or death.

WARNINGAlways wear eye protection when operating powertools.

NOTEPerformance Aurtomotive Group recommends usingthe Loctite® supplied in the kit on all hardware unlessnoted in the instructions.

NOTESpecial tools, such as coil spring compressors, may berequired for installation of this coil lift kit.

1 Dodge Ram 2WD 2” Leveling - Kit DL222

DODGE RAM 2500/3500 2WD (NON RADUIUS ARM 3500) 1994-2013DODGE RAM 1500 2WD(NON AIR-RIDE) 1994-20141.5” FRONT COIL SPRING LEVELING KITINSTALLATION INSTRUCTIONSDL222PA

Page 2: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

2 Dodge Ram 2WD 2” Leveling - Kit DL222

A. Before you start.

1. Read all warnings and instructions completely andcarefully before you begin.

2. Special tools, such as coil spring compressors, arerequired for installation of this coil lift kit.

3. Check to make sure the kit is complete (refer to theParts List, Section E).

4. Only install this kit on the vehicle for which it isintended. If anytime during the installation youencounter something different from what is outlinedin the instructions, call technical support at (928)636-3175.

5. Park the vehicle on a clean, dry, flat, level surfaceand block the tires so the vehicle cannot roll in eitherdirection.

6. Disconnect both battery cables.

a. Disconnect negative cable (1) first, then the pos-itive cable (2) from the battery (3).

B. Get ready to install coil spring leveling kit.

1. Lift front wheel assemblies.

a. If so equipped, remove two caps (4) from frontwheels (5).

NOTEKeep track of hardware quantity and position. Kit partsare prefaced by the word kit in italics.

NOTEDiesel engines are usually equipped with two batter-ies, be sure to disconnect both sets of battery cables.

Page 3: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

3 Dodge Ram 2WD 2” Leveling - Kit DL222

b. Loosen eight lug nuts (6) each from two frontwheels (5).

c. Using a hydraulic jack, slowly lift front of vehicleso that two front tires (7) are three to five inchesoff of ground. Position jack stands under frame(8). Lower frame onto jack stands.

d. Remove eight lug nuts (6) each and two frontwheels (5) from spindle (9).

2. Remove front axle driver side hardware.

a. Lift lower a-arm (10) with hydraulic jack. Do notlift frame (8) off of jack stands.

b. Remove bolt (11), nut (12), and shock (13) fromlower a-arm (10).

c. Remove nut (14), washer (15), bushing (16) andshock (13) from spring perch (17).

d. Remove push clip (18) and sensor wiring har-ness (19) from spring perch (17).

e. Remove cotter key (20), castle nut (21), andspindle assembly (22) from ball joint (23) andupper-a arm (24).

f. Remove nut (25), washer (26), bushing (27) andsway bar link (28) from sway bar (29).

g. Lower lower a-arm (10). Do not remove hydrau-lic jack pressure from lower a-arm.

NOTEWhen lowering the lower a-arm pay special attentionto the brake lines so that they are not being stretchedby the spindle assembly.

Page 4: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

4 Dodge Ram 2WD 2” Leveling - Kit DL222

h. Remove coil spring (30) coil spring bushing (31)from spring perch (17) and lower a-arm (10).

C. Installing coil spring leveling kit.

1. Install coil spring spacer driver side.

a. Position kit coil spring spacer (32) on coil spring(30).

b. Install coil spring (30) and kit coil spring spacer(32) on spring perch (17) and lower a-arm (10).

c. Raise lower a-arm (10) using hydraulic jack,position ball joint (23) and upper a-arm (24) inspindle assembly (22). Position sway bar link(28) in sway bar (29).

d. Install castle nut (21) and cotter key (20) on balljoint (23) and upper a-arm (24). Torque castlenut to 60 ft-lbs.

e. Install sway bar (29) on sway bar link (28) withbushing (27), washer (26), and nut (25). Torquenut to 27 ft-lbs.

Page 5: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

5 Dodge Ram 2WD 2” Leveling - Kit DL222

f. Remove lower shock bushing (16) and washer(15) from shock (13)

g. Install kit shock bushing spacer (tall) (33),washer (15), and lower shock bushing (16) onshock (13).

h. Install shock (13) on upper a-arm (24) with bush-ing (16), washer (15), and nut (14). Torque nut to40 ft-lbs.

i. Install shock (13) on lower a-arm (10) with bolt(11) and nut (12). Torque bolt to 105 ft-lbs.

j. Install sensor wiring harness (19) on springperch (17) with push clip (18).

k. Repeat steps B.2.a. through C.1.j. for driver sidefront wheel assembly.

2. Finish front wheel assemblies.

a. Install two front wheels (5) on front spindle (9)with eight lug nuts (6) each.

b. Using a hydraulic jack, slowly lift front of vehicleso that front tires (7) are three to five inches offof ground. Remove jack stands from frame (8).Lower vehicle to ground and tighten sixteen lugnuts (6) to 85 lb-ft.

c. If removed, install two caps (4) on front wheels(5).

NOTE2005-2006 1500 Models: Install kit shock bushingspacer (short) onto shock for the following substep.

Page 6: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

3. Connect both battery cables.

a. Connect positive cable (2) first, then the nega-tive cable (1) on the battery (3).

D. Finish coil spring leveling kit installation.

1. Double check the vehicle.

a. Check all mounting hardware to ensure it isproperly tightened.

b. Start vehicle and check the steering in bothdirections to ensure that there is no bind. Checkall steering connections. Ensure that the steer-ing gear box has no interference and is in properworking condition.

c. Check the operation of the brakes and the park-ing brake. Check brake lines for adequate travel.Ensure brake lines do not touch any surfaces,moving or otherwise. If necessary, adjust brakelines and or brake line bracketery to eliminate allcontact.

d. Check clutch operation. Check both shift levers’operation. Ensure that there is proper engage-ment in all gears and 4 wheel drive ranges.

e. Ensure that all OEM or aftermarket bumpstopsare installed.

NOTEDiesel engines are usually equipped with two batter-ies, be sure to connect both sets of battery cables.

CAUTIONRetorque all fasteners after 500 miles and after offroad use. All coil spring lift components should be visu-ally inspected and fasteners retorqued during routinevehicle servicing.

WARNINGSuspension overtravel can result in serious damage orfailure of OEM components and aftermarket equip-ment.

Page 7: DODGE RAM 2WD DODGE RAM 2500/3500 2WD 2” FRONT COIL … · DODGE RAM 2WD 2” FRONT COIL SPRING LEVELING KIT INSTALLATION INSTRUCTIONS 1994-2002 2500/3500 ... damage to your vehicle

E. 2” Coil Spacer Lift Kit Parts List.

Callout Quantity Description(32) 2 Coil spacers(33) 2 Shock bushing spacers (tall)

2 Shock bushing spacers (short)1 Warning sticker1 Logo sticker

7 Dodge Ram 2WD 2” Leveling - Kit DL222

f. Test drive vehicle in all gears and 4 wheel driveranges. Pay close attention to all vehicle sys-tems. Check all hardware again in 500 miles andas part of your regular maintenance schedule.

E. Vehicle Alignment

1. Align vehicle to OE specifications. Retain alignmentresults.

Rev. 02 Copyright 06/06Performance Aurtomotive Groupwww.p-a-g.net

CAUTIONPerformance Aurtomotive Group does not recommendany particular wheel and tire combinations for use withits body lifts and cannot assume responsibility for thecustomer’s choice of wheels and tires. Reference yourowner's manual for recommended tire sizes and warn-ings related to the use of oversized tires. Larger wheeland tire combinations increase stress and wear onsteering and suspension components, which leads toincreased maintenance and higher risk for componentfailure. Larger wheel and tire combinations also alterspeedometer calibration, braking effectiveness, centerof gravity, and handling characteristics. Consult withan experienced local off road shop to find what wheeland tire combinations work best with your vehicle.

NOTEAll warranty information, instruction sheets, and otherdocuments regarding the installation of this productmust be retained by the vehicle owner. Informationcontained in the instructions and on the warranty cardwill be required for any warranty claims. The vehicleowner needs to understand the modifications made tohis vehicle and how they affect vehicle handling andperformance. Failure to provide the customer with thisinformation can result in damage to the vehicle andsevere personal injury.

NOTEAll warranty information and instruction sheets regard-ing the installation of this product must be retained bythe vehicle owner. Information contained in the instruc-tions and on the warranty card is required for any war-ranty claims. Failure to provide the customer with thisinformation can result in damage to the vehicle andsevere personal injury.

Kit Shock BushingSpacer (Short)

*For ‘05-’06 Models

Kit Shock BushingSpacer (Tall)

*For ‘94-’02 Models