Service Manual Acer Travelmate 2410

  • View
    46

  • Download
    1

Embed Size (px)

Text of Service Manual Acer Travelmate 2410

  • Acer TravelMate 2410 SeriesService Guide

    PRINTED IN TAIWAN

    Service guide files and updates are availableon the ACER/CSD web; for more information,

    please refer to http://csd.acer.com.tw

  • II

    Revision HistoryPlease refer to the table below for the updates made on TravelMate 2410 service guide.

    2

    2Date Chapter Updates

    005/07/21 Chapter 1 Revise information on Hardware Specification and Configurations.

    005/10/24 Chapter 1 Revise battery vendor and specification on page 24.

  • CopyrightCopyright 2005 by Acer Incorporated. All rights reserved. No part of this publication may be reproduced, tat

    DisT

    Acppdd

    AIPOIII

    ransmitted, transcribed, stored in a retrieval system, or translated into any language or computer language, in ny form or by any means, electronic, mechanical, magnetic, optical, chemical, manual or otherwise, without

    he prior written permission of Acer Incorporated.

    claimerhe information in this guide is subject to change without notice.

    cer Incorporated makes no representations or warranties, either expressed or implied, with respect to the ontents hereof and specifically disclaims any warranties of merchantability or fitness for any particular urpose. Any Acer Incorporated software described in this manual is sold or licensed "as is". Should the rograms prove defective following their purchase, the buyer (and not Acer Incorporated, its distributor, or its ealer) assumes the entire cost of all necessary servicing, repair, and any incidental or consequential amages resulting from any defect in the software.

    cer is a registered trademark of Acer Corporation.ntel is a registered trademark of Intel Corporation.entium and Pentium II/III are trademarks of Intel Corporation.ther brand and product names are trademarks and/or registered trademarks of their respective holders.

  • IV

    ConventionsThe following conventions are used in this manual:SCREEN MESSAGES Denotes actual messages that appear on screen.

    NOTE Gives bits and pieces of additional information related to the current topic.

    WARNING Alerts you to any damage that might result from doing or not doing specific actions.

    CAUTION Gives precautionary measures to avoid possible hardware or software problems.

    IMPORTANT Reminds you to do specific actions relevant to the accomplishment of procedures.

  • PrefaceBefore using this information and the product it supports, please read the following general information.

    1

    2V

    . This Service Guide provides you with all technical information relating to the BASIC CONFIGURATION decided for Acer's "global" product offering. To better fit local market requirements and enhance product competitiveness, your regional office MAY have decided to extend the functionality of a machine (e.g. add-on card, modem, or extra memory capability). These LOCALIZED FEATURES will NOT be covered in this generic service guide. In such cases, please contact your regional offices or the responsible personnel/channel to provide you with further technical details.

    . Please note WHEN ORDERING FRU PARTS, that you should check the most up-to-date information available on your regional web or channel. If, for whatever reason, a part number change is made, it will not be noted in the printed Service Guide. For ACER-AUTHORIZED SERVICE PROVIDERS, your Acer office may have a DIFFERENT part number code to those given in the FRU list of this printed Service Guide. You MUST use the list provided by your regional Acer office to order FRU parts for repair and service of customer machines.

  • VI

  • Table of ContentsChapter 1 System Specifications 1

    Features . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .1

    Cha

    Cha

    ChaVII

    System Block Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .3Board Layout . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4

    Top View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .4Bottom View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .5

    A TravelMate tour . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Front View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .7Closed Front View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8Left View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Right View . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .9Rear Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .10Bottom Panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Indicators . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11Easy-launch Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .12Touchpad . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13Touchpad Basics . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .13

    Using the Keyboard . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Lock Keys and embedded numeric keypad . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Windows Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .15Hot Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .16Special Key . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .17

    Hardware Specifications and Configurations . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19BIOS Setup Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .29

    pter 2 System Utilities 29Navigating the BIOS Utility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .30Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .31Main . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .32Security . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .34Boot . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .38Exit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .39

    pter 3 Machine Disassembly and Replacement 41General Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42

    Before You Begin . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .42Disassembly Procedure Flowchart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .43Removing the Battery Pack . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .45Removing the Memory/the HDD Module/the Wireless LAN Card/the ODD Module and the LCD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46

    Removing the Memory and the HDD Module . . . . . . . . . . . . . . . . . . . . . . . . . . .46Removing the Memory . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .46Removing the ODD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47Removing the LCD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .47

    Disassembling the Main Unit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Separate the Main Unit Into the Upper and the Lower Case Assembly . . . . . . .49Disassembling the Upper Case Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .49Disassembling the Lower Case Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . .50

    Disassembling the LCD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .53Disassembling the External Modules . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54

    Disassembling the HDD Module . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .54

    pter 4 Troubleshooting 55System Check Procedures . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56

  • VIII

    Table of ContentsExternal Diskette Drive Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56External CD-ROM Drive Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56Keyboard or Auxiliary Input Device Check . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56

    ChaMemory check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .56Power System Check

Search related