12
RESOLUTE ENVIRONMENTAL LLC December 28, 2011 Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental Control 2600 Bull Street Columbia, South Carolina 29201 Re: AVX Corporation Title V Renewal Application Revisions Myrtle Beach, Horry County, SC TV-1340-0002 Dear Ms. Clark: As you are aware, Mr. Greg Quina of your office contacted me on November 23, 2011 regarding his review of the air dispersion modeling analysis associated with the Title V renewal application for the AVX Corporation located in Myrtle Beach, South Carolina. In short, some of the September 8, 2011 revisions to the original air permit application were not captured in the air dispersion modeling. There were also some minor corrections to emission source parameters Input into the air dispersion modeling. These revisions and corrections have been made and the necessary re-execution of the modeling completed. There were no changes from the previous modeling results with respect to AVX's modeled concentrations of Standard No.8 compounds compared to the Maximum Allowable Ambient Concentrations. The following items are attached to this letter to update the modeling analysis: 1. Modeling analysis Table 1. Included xylene emissions from Slip. Corrected emission rates from CMAP (process, fugitive, and gas combustion) and Metallization. 2. Modeling analysis Table 2. Corrected exit velocities from Metallization (plating) and soldering. Corrected exhaust temperatures from the CMAP adsorber/desorber and thermal oxidizer. 3. Modeling analysisTable 3. Corrected vertical dimension for the MFGNEWvolume source. 4. Modeling analysis Table 6. Updated modeled concentrations. 5. A compact disk containing the revised electronic modeling files. Mr. Quina also requested additional background Information on AVX's Insignificant sources. During the process of preparing the documentation, Resolute Environmental became aware some corrections needed to the insignificant equipment list provided in the original Title V renewal application. Specifically, the 16 calcining kilns (RMM) and three (3) cooling towers lA, 2A, and 2C have been decommissioned. Added were two (2) non-contact cooling towers used at the MB2 location. Also, the Metals department solvent wash station does not exist at this location and has 114 Oak Fern lane. Willow Spring, NC 27592 (919) 70HlOO9

RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

  • Upload
    others

  • View
    8

  • Download
    0

Embed Size (px)

Citation preview

Page 1: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

RESOLUTE ENVIRONMENTAL LLC

December 28, 2011

Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental Control 2600 Bull Street Columbia, South Carolina 29201

Re: AVX Corporation Title V Renewal Application Revisions Myrtle Beach, Horry County, SC TV-1340-0002

Dear Ms. Clark:

As you are aware, Mr. Greg Quina of your office contacted me on November 23, 2011 regarding his review of the air dispersion modeling analysis associated with the Title V renewal application for the AVX Corporation located in Myrtle Beach, South Carolina. In short, some of the September 8, 2011 revisions to the original air permit application were not captured in the air dispersion modeling. There were also some minor corrections to emission source parameters Input into the air dispersion modeling. These revisions and corrections have been made and the necessary re-execution of the modeling completed. There were no changes from the previous modeling results with respect to AVX's modeled concentrations of Standard No.8 compounds compared to the Maximum Allowable Ambient Concentrations. The following items are attached to this letter to update the modeling analysis:

1. Modeling analysis Table 1. Included xylene emissions from Slip. Corrected emission rates from CMAP (process, fugitive, and gas combustion) and Metallization.

2. Modeling analysis Table 2. Corrected exit velocities from Metallization (plating) and soldering. Corrected exhaust temperatures from the CMAP adsorber/desorber and thermal oxidizer.

3. Modeling analysisTable 3. Corrected vertical dimension for the MFGNEWvolume source. 4. Modeling analysis Table 6. Updated modeled concentrations. 5. A compact disk containing the revised electronic modeling files.

Mr. Quina also requested additional background Information on AVX's Insignificant sources. During the process of preparing the documentation, Resolute Environmental became aware some corrections needed to the insignificant equipment list provided in the original Title V renewal application. Specifically, the 16 calcining kilns (RMM) and three (3) cooling towers lA, 2A, and 2C have been decommissioned. Added were two (2) non-contact cooling towers used at the MB2 location. Also, the Metals department solvent wash station does not exist at this location and has

114 Oak Fern lane. Willow Spring, NC 27592 (919)70HlOO9

Page 2: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Ms. Fatina Ann Washburn-Clark RESOLUTE December29, 2011 -- - -ENVIRONMENTAL llC

Page 2

been removed from the equipment list. The following are additional attachments to this letter per Mr. Quina's request and subsequent revisions to AVX's Title V renewal application:

6. A table listing insignificant sources and exemption basis. 7. Revised Tables 2,4, and 5 from the Title V renewal application supporting documentation. 8. Revised Form G pages 1 and 3 of 3.

If you have any questions regarding the information provided, please contact me at (919) 701·0009 or via electronic mail at [email protected].

Best Regards,

RESOLUTE ENVIRONMENTAL, LLC

Gary T. Yoder Principal Resolute Environmental, LLC

CC Larry Blue - AVX Corporation (via email) Ralph Bryant - AVX Corporation (via email) Max Justice - Parker Poe (via email)

Enc

114 Oak Fern Lane, w.now Spring, NC 27592 (919)70HlOO9

Page 3: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

- ----

-- --- --- -

--

Tllble 1

AVX ColpOllJlion Myrtle Beach. SouIhCarolina

S1MdIINs NIl. 8 ... No. 2 IIDdeIecIEmitIIIIon" ­

-. -. _I _unlll _Ill

CAS --." -..-.~ "-"nd? qu ~ (!!>'J!l (!l/!Hj I-I lpI!l - _m-.....__.- ,. ..... flMA.l.1~.4 HlA 0.08 I_ '.0 No lOA

SIp .... 15 SlF -_.~ 1.76E-<l3 U2E-04 - ...."., ,.... ,",,12__..." SlF 108-10-1 -_.~ 1-'2 9""'''' 1.17E-04

SlF 117-81~7 ....0 0.D:l 3.74E-OO"rs 6lP 1-.0-7 ~--SIp- .... 0.01 9.I5E-<l4 ,. - _.... -lMg. r.lJ(1,213)Cl PIA lOA

~

2340.00 0.27 '.0 No lOA 19 r.lJ(l.213)O-1 ....,Q1F1OU lOA _....- ,....... 0.18 '.0 No lOA ,. MD(1,213)C-l _...- lt1O.00 il.01 ,­' .......7

7..... 1.151. MD(1.2 & 3)0-' ,",,12__ ,......... --,.,.... 1.32E~ 1.8BE005 1. MD(1,213)O-1 - 11741·7 9.79 1.11E-03 '.40£...

MD(1.2 I 3)C-l lQG.4'-<6 ~-- 0.58 $.5IE-05,. --,.,....,. -_-_.......... .­WD(1.213)C-l 67...., 2.84 • .24E-G4 .......... 2.15E-05,. "'(1,213)0-1 --- lOB-1M

--'.50 1.71E-04

..­--17 tlIWS-Fl " frAES.f2 67-58-1 '23.11 0.02 :uJ7E.<l3 -(CIoW'.CMAP......... I '7 NW$-Fl frAES.f2 - lD8-1().1 -- ".2 0.01 1.41&03,",,12__

-"""'*Vl 17 "flFS..Fl&~ - 117-81·7 17.2 2~ 3._ 17 NW$-Fl& NW'S-R lD0-4'''' ~-- '7.2 2~ 3.7OE~--,.,..--,.,.... 17 NWFS-Fl " NIlF&f'2 7..... ,........ 17.2 2_'" 3.7OE...

NWFS-FI &

"

NWS-F2 --- .. .........17 ......__SI*taTp"·F_·F_SoMIrC 17.2 3._' .......7 17 CIoW'flJG 67-511-1 ..... 0.06 5""'" 17 CMAPFlJO --... 108-10.1

__ 177.0 0.D2 3.D2E...

17 CMAPFlJO 117-81·7 ~-_.- 17.4 .-... 3._ 17 CMAPFlJO 101>41-4 ....... __8pirb Trp.......88 - FugIhI 17.4 2....... 3._ - _

cw.PfUG '""-- ,......... 17.4 ........17 T..... 3.79E... 17 CMAPFIJG , .......7 17.4 2JIIE.<I3 3.79E... .7 -""" _,Q1F1OU lOA Termal 0dcIzII' GIl ComtuIrJn ...0 0-01 1.0 No lOA 17 ~1 so, lOA Termal 0dcIz8' GIl CorntuIon 5.3 1-lllE... '.0 No lOA 17 -....., HOx lOA Termal 0JIcIz8rGIl CcmtullDn ....0 0.10 '.0 No lOA

NIoFS-F'

--- --,.,...._.­17 CO lOA T.". 0JIcIz8rGIl Canlu*ln 73lU 0... 10.0 No lOA 19 rEGMBl & MFGNEW 87-56-1 '47.8 0.D2 2.1..... 19 _IMFGHEW 108-10.1 79.0 0.0' 1.1ZE..oo

CMAP_ 18 PINPMolQ1PM.2.5 lOA 300 0.04 1.0 No lOA~.' ""'-.._·_1__·_1_ _1C-2A& 7C-2S -,~ lOA 11.138 1.0 ..... No lOA''''''''' 19 7C-2A&7C-2B .- lOA 0.19 2.21.-00 lOA

19 7C-2A& 7C-2B lOA 27.n :l.fTE-03 3_ -

... _·_1­-

20 N.....lFS .........,.......... No"A ".00 0.0' '.0 "A 20 _8olI'S .- lOA 0.58 •.67E-Oll See ..... lOA ---"

­20 _lFS 7984«>-ll &.32 7..21E~ 9.09E-05.. .......- ­

~T!'S 7911T~-'2 34... 3.IIllE-<I3 ........ -20 _TFS 2_ 141-43-5 ....00 0... ........ 20 _TFS 7&4.7.(11.(1 .... 9.18E-04 1.18E-04 -20 _1FS --..... ,4.0 ,....... 2.o1E-G4

2' SOUJER1 flM/PU.1MV,2.5 lOA 20 2_ '.0 No lOA _lQ1F1OU lOA 0.12 No lOA2' IM'S-ll' '012.4 '.0

2' ~., lOA '.0 "A -- --- ..so, 0.01 No

2' -""1 HOx lOA '4380 '.14 1.0 No lOA 21 1M'S-ll1 CC 1.36 10.0 ..... No "A 21 ........., .- lOA 7£-02 8.2OE-<J6 lOA

"A - '2060 _-21 SOUlERl .- lOA 0-1- 2.13E-05 See ..... lOA -21 lOWER 1,1,1-'bicHoroeItWIe 7' .... 21l31.S 0-30 3._

2' TOWER 1.1-didt::lroe1tw> 711...... - ..... 0.11 ,....... 21 1US-81 ....... 71-4H Q..3 3.45E-oo 2' SOU>ER' Qriam..." (-..ned 4) lOA 1.71E-08 2.15E-07 --- '...... .­21 _S.fll - - '0.8 ,.......''''''''-2' 1US-81 """'" ....0 0.D:l 3.71E-03"...... ­21 SOU>ER' ---- lOA 0.87 1.11E-Q4 ,­21 -..., .,...... -

0.' 1.mE-05 '.2l!E-OO 21 NMFS-B1 -T....... '......... - 0.5 5.57E-Oll 7' ­21 lOWER ~, .. 7111.3 0.00 1.14E-02....- --­_loCT"", 1.18E-04 0.114 No lOA

-. A. ReIerm" MBy2011 TIIllI V rerwwaI appiad:Jn for emIDIonratBcaIcUa1Iar8.

.... '2iOW"'CornloOod__...SIp(......I.e:e.e-CMAP_(I8().CMAP_I_... "' __.....-.._......I.CMAP.._l502.... COl.__.... _.

12J2W2011

Page 4: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Table 2

AVXCorporaIion MyrtleBeach. SouthCBroNna

Summary of Stack ~ - Point Sources

Slack UlU UlU Source DelcrlpUan II) EalInglm)" Nar1IlInp 1m)" ...EIn8IIan (It) Slack Helphliltl T"fI!f!h!r! (F) Yeloalty (I!I!l a-(It)

_ MIl a Ml>Ing_Is MIg. MOle-l 893700 3728108 23 37 70 57.0 1.87

_Mil MD2C·l 893718 3728101 23 22 70 NA" 0.87

_Is MIl MD3C-l 893720 3728101 23 2S 70 28.5 1.00

CMAP CIlil MIg • T.O. MB2-Fl 893341 3727899 23 30 1030 64 2.5

ChilMlg-_ MB2-F2 893344 37Z7899 23 28 90 8.8 2

MeIBlIzatlon AulDIine_aSHE 7e-2A 893773 3728208 23 32 70 3.40 3.43

AulDIlnePtalllraSBE 7C-2B 893773 372ll208 23 32 70 3.40 3.43

Thin F1lmPI1lCOlllI ThInF1\m_ MB2-TFS 893300 3727880 23 35 70 54.0 2.50

- _r1_ ....... SoJp. 0SoIdeIIng 893305 3727844 23 15 70 0.003 025

M82-81 Il93322 3727939 23 35-5 BOO 15.3 0.83

SIri>P">lITOMI" TOWER 893890 3728085 23 20 70 NA" 225

_: Il. VTlol. ZOne 17, NAD27. 8. MD2C-l ond tho Stri>IJIng Towerhav"raln_ so tho~WOI 00101 0.001 mi•• po< tho SC llHECIlirQualily-.g_. C. Tho.-.~ ._IDs and_no hove"" to be -.n1nocL Forc:onoa_••.-__at tho n_ point 10P-'Y boUlldaryon bulling_ a 15 _ ~ _ no

od voIocIy assumad.

RaY 1219/11: Conodod 7C-2/l. 7G-28, and soldering", v._.eo_ TO a NO lomporolul8O

12!2912011

Page 5: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Teble3

AVX Corporation MyrtleBeach, SouthCarolina

Summary of Stack Parameters· Volume Sources

Source Descrlptton Stack

10 UTM UTM

Eeetlng (mt Northing (mt Base EJmdIon (tt) ReInse Height (ft) Hortzontal

om.nsIon (tt) Vertical

DlmenBlon (ft)

SlIpManufacturing Celamic Slip SLIP 693869 372llO57 23 15.0 38.1 14.7

Manufaeturlng Department cleaning" MFGNEW MFGMB1

CMAPFUG

693344

693796

693341

3727899

3728250 3727893.2

23 23

23

12.0

8.0 12.0

53.5

46.6

53.5

11.3

7.5 11.3

Notes: A. UTM, Zone 17, NAD27. B. Cleaningemissionsoccur III only one localion. For fuIJe pennitting flexibilityIn the lIVent of equipmentrelocaIion,the emIssionS8nl modeledIII the exlsllng (MFGMB1) and

poIental MUI1I (MFGNEW) locations.

AIIV12109111: Corrected vertlcaI dimension of MFGNEW

12/2912011

Page 6: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Table 6

AVX Corporation MyrtleBeach, SouthCarolina

Summary of AERMOD Modeling Results· Standard No.8

Contaminant CAS Predicted Maximum Ambient MAACA Percent of Number Concentration- (ug/m 3 ) (ug/m 3) MAAC(%)

1,1,1-Trichloroethane 71-55-6 88.8 9550 <1

2-Ethanolamine 141-43-5 0.46 200 <1

Benzene 71-43·2 0.0005 150 <1

Sis (2-ethylehexyl) phthalate 117·81·7 6.41 25 26

Chriomium (assumed +6) Chrome 0.00006 2.5 <1

Ethyl Benzene 100-41·4 0.249 4,350 <1

Formaldehyde 50-00-0 0.019 15 <1

Hexane 110-54-3 0.46 900 <1

Hydrochloric acid 7647-01-0 o.ooe 175 <1 Manganese Mang 0.004 25 <1 Methanol 67-56-1 4.844 1,310 <1

Methyllsobutyt Ketone 108·10·1 2.49 2,050 <1 Naphthalene 91-20-3 0.0002 1,250 <1

Nickel 7440-02-0 0.258 0.500 52 Nitric Acid 7697-37-2 0.034 125 <1

Phosphoric Acid 7664-38-2 0.014 25 <1 SulfuricAcid 7664-93-9 0.006 10 <1

Toluene 108-88-3 0.250 2,000 <1 Vinylidene Chloride 75-01-4 26.72 99.0 27

Xylene 1330-20-7 1.62 4,350 <1

Notes: A. Basedon a 24-houraveragingperiod.

12129/2011

Page 7: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Insisnlflcant Activity (Form G) Documentation AVXCorporation

Myrtle Beach, SC

COUNJ DIIlICIUPl1C III AD 1. N()'rI$ iI'lOIll Detergent/dispersant added to ceramic for part. size dist. in

RMM water. Ovens USN to remove detergent/ dispersant. Ovens are

11 11 Ovens 10remove detergent/ dispersant from material Drying ovens not vented to atcsphere during heating. They are opened to (UNn·14) eenosphere during cool down. No quantifiable emissions «5

tpy criteria pollutant)

, 3 Rapid temperature furnaces in T&:D Rapid Temperature Furnaces ~mall (-2'x2') bench ovens in Testing &:Deve opment. Used infrequentlv. (61-62.70.9 Section A.12) Binder/ceramic tape shredders to shred tape before rotary

2 2 Tape shredders repe shredders kilns. Not exhausted and no quantifiable emissions known « 5 tpy criteria pollutant).

• q Ovens for moisture remove in T&D Blue M Small (-2'x2'},omcn ovens in Testing & Deve opment. Used. infrequently (61·62.70.9 Section A.12).

I Testing and development pnller Small prillers mail scale pnller or testing &: ceve opment. Neg igtble PM

emissions.(61-62.70.9 Section A.12)

The small rotary kilns bum off binder from the binder/ ceramic tape shredded pieces to roclaim/recycle the ceramic The binder is the same cellulose-carbon material UM'd in the

4 4 Small rotary kilns Rotary kiln'I ceramic to manufacture chips [removed during bum out). The kilns each have a 1 MMBtu/hr natural ga..'l burner. No induced au flow. A maximum oj 2 Ion of tape is processed per kiln per month. Maximum bindereonrent Is 12%. All ceeemtc i5 reclaimed. Therefore a maximum loss of ar~an.ic materiel is 480 lb/mo or 2.9 ton/yr « 5 tpy criteria pollutant)

, 3 Mh.ers in lf8ting and development Spex mixers mall mbcers in testing & neve opment. werprocess. Not

vented. 61-62.70.9 Section A.1Z

16 te Calcmma kilns DECOMMISSIONED

1 rans uard Trans uard Small barium titanium ceramic recess. SeeTable 2.

Non-HAP/TAP enclosed, seal pot cleaning system. The largest SUP

1 Bioact cleaning system Bioact ultrasonic cleaner & distiller monthly usage since January 2001 is 1,189 .lb. AVX reports 1%

(UNn15) loss in this process, which equates to 11.91b VOC/mo Of

maximum 0.07 ton VOC/yr « 5 tpy criteria pollutant).

1 Fume hood Fume hood lnsi2nificant ner 61-62.70,9 Section A12 1 Lab oven and fume hood Lab oven fume hood. lnshmilicant oer 61-62.70.9 Section A.12

Used to filter ethyl ceUulose/terpineol mixture to remove impurtities and reduce viscosity. A detailed chemical

METAl..S 2 2 Filter presses Filter presses

engtneeing ca.lculation for VOC emissions from a filter prt'!lisis (UNIT 16) in the February! 2001 Title V application prepared by Trini.ty

Consultants The calcu.lations .!Jhowa potential emisison rate of 0.2 ton VOC/vr «5 tev criteria oollutantl.

1 1 Pot storage room exhaust Pot room exhaust Storage room for seal pees. Containers are tightly sealed. N~ble VOC emissions « 5 tpy criteria pollutant).

2 2 Lab fume hoods Lab fume hoods Insilmificant ner 61-62.70.9Section A.12 1 1 Lab oven Lab oven Insimificant per 61·62.70.9 Sectioo A.12 2 2 Solvent wash sinks SOURCE DOES NOT EXIST IN THIS DEPARTMENT

CMAP BUILDUP 1 Screen Room Acetone only

(UNIT 17) 1 sink uses acetone only. For the other two sinks, a maximum of 15 gal.lons each of IPA and DC/PM (both voc only) enter wash sink area on a two-week basis. Be/PM: 15 gal/2 wk x 2 2wk/mox 7.57Ib/gal- 227.1 Ib/mo IPA: 15 gal/2 wk x 2

3 3..sink Screen Wash station w/ acetone 1 sink w/ acetone 2wk/mo x 6.23lb/gal'"'186.9Ib/mo. Total Solvent = 414 lb/mo or 2.5 ton/yr « 5 tpy criteria pollutant). This conservatively assumes all material emitted. Actua.l.lygreater than 80% of the used material is collected as waste and reclaim.

CMAP SUPPORT 36 36 Ovens far chip binder burnout (30) Gruenberg, (2) Sierra Therm, (1) Nitrogen

Source test June 25, 2009. Small amount of organic emissions « (UNn·,8) 5 tpv criteria pollutant)

24 Firing Kilns (9) Cladan, (6) Harper, (9)Tokai Follows burn-out step. AVX contends no regulated compounds

resent

16 Ib tow tern perature moisture removal OVtoRS Gruenberg (Blue M) and pre-dice Low temp (-200 F) moisture removal, No quantifiable emesrons

1 Blade cleanina station Cleanmz station Acetone onlv

2 2 Machines for adding paper to plates (1) Nitto, (1) Bilco Applies paper to plates prior to chip buildup. No quantifiable VOCemissions

2 2 Chip dryers (1) grt>encomer rounding, (1) post fire low temp (-200 F) moisture removal for burnout prep. No

uantifiable emtsstoas

1 1 Thermal release ovens Microtoch Low temperature heating to remove paper following chip buildup. No auantifiable emissions

METALLIZATiON 4 4 SBE Plating lines 3 SBE Plating (Ni/Sn and Au) See application calculations. < s tpy PM, < 1,000 lb/yr Ni.

(UNIT ")

2 2 BCBplating lines BCB Plating 9/25/05 DHEC granted exemption. < 5 tpy criteria pollutant

I 1 Copper Plating System Hulik Plating Sytem Exempt per lune2011 AVX request (and DHEC approval) 0.0012 Ib fcemaldehvde/hr «1,000 lb/vr formaldehvde)

I 1 Manual 201d platint?:.line Gold platin2 See application calculations. <5 tDVPM.

11 11 Plating dyers far moisture removal Drying ovens Small (low temp) ovens for moisture removal. No quanifiable emissions.

1 1 plate drying oven for moisture removal Oven for drying cleaned build up plates Small (low temp) ovens for moisture removal. No quanifiable emissions. Quality control for tt>nniniltion. Periodic test of termination

I 1 Copper coupon oven Oven for drying quality control coupon paste paste. Minimal VOC (non HAP/TAP) eeusstons (61-62.70.9 Section A.12).

5 5 t.abelin lasers Labeling lasers Laser used to label parts. No uantifiable emissions

Maximum of 6 gal denatured a1chol enter wash sink area/wk. 6 gal/wkx 6.76Ib/gal x 4 wk/mo '" 162lb VOC/mo or 0.9 ton

2 1 Solvent wa.'lh station (two sinks) 1 Solvent wash station VOC/yr. « Slpy criteria pollutant). This conservatively assumes all material emitted. Actually greater than 80% of the l15N material is collected as wasee and reclaim.

MISC. SUPPORT 1 100 kW (134.1 HP) EG (Kiln Room) Insignificant per 61M62.70.9 Sectton B.2.b (UNIT 21) 1 260 kW (348.7 HP) EG (MIS) lnsignificantper 61-62.70.9 Section B.2.b I 600 kW (804.6 HP) EG (RMM) lnsignificant per 61-62.70.9 Section B.2.b 1 565 kW (757.7 HP) EG (Sol Gel) Insignificant per 61-62.70.9 Section B.2.b 1 Diesel Fire Pum Insilrnifieant ner 61-62.70.9 Section B2.b 1 0,392 MMBtu hr Platin boiler InsimificantDef 61M62.70.9 Section B.I.b I 0.392 MMBtu hr Platin boiler Ins; ificant 61M62.70.9 Section B.1.b I 0.776 MMBtu hr P.latin boiler Insi

.. <ant 61·62.70.9 Section B.l.b

1 Cooling Tower 1 DECOMMISSIONED I Cooling Tower 2A DECOMMISSIONED I Cooling Tower 2C DECOMMISSIONED 1 Coohna Tower MB2A Non-contact coolin tower 91·62.70.9 Section A.20 1 Coolin2 Tower MB2B Non-contact coolin tower 91·62.70.9 Section A.20 1 Lot Quality OPA hood Insi nificant per 61-62.70.9 Section A12 5 Lot uualitv dr tne ovens 5 Blue M ovens Inshmificant cer 61~b2.70.9Section A.12

12/29/2011

Page 8: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

;;;;;;LJi::iL",~;@%~~-::'::~_':"t¥g~""':~'q;,.~~~,?:,~\,%~ [;ff?!.i;~j,t;.;;,

unit No. --6­

RMMLAB

M45-6 - M45-9

Iffii '-IlK«

ISMMl-SMt.13 IVKl.VK16 AGI

........__r&D

Vertica1kllns IStorage tankT&D

I Addition.d Info.

r T 2' n.. I

16

N_

'5.5. No emissions

Removed In operation- No exhaust

Unit NO'1 Desc. 14 RMM

Updated 12/09/11: 16 vertical kilns have been deeomrnls..'iionf'd

Page 9: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

4

TABLE 3 Equipment Cross Reference - Slip

AVX Corporation,. Myrtll? (Witch, SC

lD EquJp. [)esc. Additional Info. INo. Unitli Not" Unit No.Unit No. I Unit Delle.

KMsl-KMS3 Kady Zolvers.f1 - #3 15~Mtg. ~Yl'a 3 ~emovedI MCDI-MC05 Me Djscersera #1- #5 PSD 800 ksr/day ea 5 2 Removed

.pport DlimltenaJl("e: cleaning IJrissions captured in dept

Page 10: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

TABLES Equipment Cross Reference - C1\.fAP

AVX Corporation, Myrtle Beach, SC

Unit No. I Unit Desc.

17 I CMAP Buildu Unit No. I Unit Desc. I lD Equip. Desc. Addition.a.J.Jnfo. No. Units I Notes

7 l SUp Mig, MB1 1 CO-C4 CM:APmachine 1.8 million pesjday 5 jLinear 5.SBU &:JH C5 CMAP machine 1.8 million pes/day 1 C6 CMAP machine 1.8 million pes/day 1 C7 CMAP machine 1.8 million pes/day 1 C8 CMAP machine 11.8million pes/day 1

C9 CMAP machine 1.8 million pes/day 1 00 CMAP machine 1.8 million palday 1 01 CMAP machine 1.8 million pes/day 1

C12·0B CMAP machine 1.8 million pes/day 7 C19·C27 CMAP machine ],8 million pes/day 9 C28 -C32 CMAP machine 1.8 million pes/day 5 C33 -C36 CMAPmadtine 1.8 million pes/day 4

07 CMAP machine 1.8 million JCS/dav 1 C38-C40 CMAP machine 1.8 million pes/day 3 C41· C53 CMAP machine 1.8 million a/day 13

r C54 CMAP machine 1.8 million pes/day 1 ,,'c­

',J'-' Cd':

SRW Screen Wash station w/ acetone

REVISED 12/06/11: Clarification in Note that one sink is acetone, two are solvent.

10 I Slip""M1"g,

THO SO

JHCMAP for chio fab SCMAP for chip feb.

Iiemove Remove

Page 11: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Title V Permit Application Insignificant ActivityEquipment- Form G

Bureau ofAir QualitySourh C.:.aTnllna b~paTrrT1Cnrof'llcalrh ,,"""of ..;."vir·nnh"u~nbLl ("1nnl.r-... 1

Page 1 of3

Please Refer toInstruction I Definitions Pages Before Completing This Form

1. Insignificant Activity(IA)

UnitlD:

2. Insignificant ActIvity UnitIDDescription

3. Construction Pennlt IDor

Approval Date (if applicable):

4­OnSC

InsignifICant Activity Ust (Yes or No)

5. Pollutant(s)

6. Emission Rate (Uncontrolled)

7. Demlnlmil Rate

RMMDO 11 drying ovens toremove moisture and deteraentldispersant (Unit 14) No PMlPM10/PM2.5 Less than 5tpy < 5tpy criteria

ooUutants

RMMTS 2tape shredders (Unit 14) No PMlPM10IPM2.5 Less than 5tpy <5tpy criteria pOllutants

RMMOV 9Ovens formoisture removal intest &dev. (Unit 14) Yes N/A N/A Sec. A, 13

RMMRTF 3rapid temperature furnaces inT&D No N/A N/A Sec. A, 13

RMMTDP Testing &dev. Priller (Unit 14) Yes N/A N/A Sec. A, 13

RMMKILN 4Small rotary knns (Unit 14) No PMJPM101PM2.5 Less than 5tpy < 5tpy criteria pOllutants

RMMSPEX 3 Mixers intest &dev. (Unit 14) No N/A N/A Sec. A, 13

RMMVK 16 Vertical calcining kilns Rev 1219/11: KUns decommissioned

RMMTG Transguard process (Unit 14) 2007 No PMIPM10/PM2.5 Less than 5tpy <5tpy criteria D01Iutants

BOACT Bioact cleaning system (Unit 15) No VOC Less than 5tpy < 5tpy criteria poiiirtants

SFH Fume Hood (laboratory hoods) (Unit15) Yes N/A N/A Sec. A, 13

SO QC lab oven (Unit 15) Yes N/A N/A Sec. A, 13

MFP 2Filter Presses (Unit 16) No VOC Less than 5Ipy < 5tpy criteria pOllutants

MPS Pot storage room exhaust (Unit 16) No VOC Less than 5Ipy < 5tpy criteria pollutants

MFH 2Fume Hoods Oaboratory hoods) (Unit 16) Yes N/A N/A Sec. A, 13

MSW 2Solvent wash sinks (Unit 16) Rev 12109/11: Removed since solvent wash sinks are not inthis department

Me Lab oven (Unit 16) Yes N/A N/A Sec. A, 13

CSR Screen Room (Unit 17) No VOC Less than 5tpy < 5tpy criteria pollutants

CSWS 3Solvent wash stations (Unit17) No VOC Less than 5tpy <5tpy criteria oOIlutants

BO 33 Ovens for chip binder burnout No VOC Less than 5tpy < 5tpy criteria oollutants

DHEC 2944 (0212005)

Page 12: RESOLUTE ENVIRONMENTAL LLC...RESOLUTE ENVIRONMENTAL LLC . December 28, 2011 . Ms. Fatina Ann Washburn-Clark Bureau of Air Quality South Carolina Department of Health and Environmental

Title VPermit Application Insignificant Activity Equipment- Form G

Bureau ofAir Quality Page30f3

1. Insignificant Activity(lA)

UnltlD:

2­insignificant Activity Unit 10 Description

3. Construction Pennlt 10 or

Approval Date (ifapplicable):

4. OnSC

Insignificant ActivIty Uat (Yes orNo)

5. PoilutBnt(s)

6. Eml8slon Rate (Uncontrolled)

7. Deminlmis Rate

B1 0.392 MMBtulhr Plating Bath Boiler (Un~ 21) Yes N/A NA Sec. B, l.b

B2 0.392 MMBtulhr Plating Bath Boiler (Un~ 21) Yes N/A NA Sec. B, l.b

B3 0.779 MMBtuhr Plating Bath Boiler (Unit 21) Yes N/A NA Sec. B, l.b

CT1 Cooling tower 1 Rev 1219/11: Cooling tower decommissioned

CTA Cooling tower 2A Rev 12/9/11: Cooling tower decommissioned

CTC Cooling tower 2C Rev 12/9/11: Cooling tower decommissioned

MB2A Cooling tower MB2A (Rev 12/9/11 addition) Yes N/A NA Sec.A,20

MB2B Cooling tower MB2B (Rev 12/9/11 addition) Yes N/A NA Sec.A,20

DPA Lot quality DPA hood Yes N/A N/A Sec. A, 13

LaO Lot quality drying ovens Yes N/A N/A Sec. A, 13

DHEC 2944 (02J2005)