9
Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007 National Highway Traffic Safety Administration Office of Defect Investigation Attention: George Person, Chief Recall Analysis Division 400 Seventh Street, S.W. Washington, D.C. 20590 Re: 49 CFR Part 573; Recall of Mercedes-Benz M and R-Class (1 64,25 1) Accelerator Pedal Dear Mr. Person: Pursuant to 49 CFR Part 573.5(~)(9), this letter contains 2 documents that were communicated to our dealers on the above subject and will be submitted in Mercedes-Benz USA, LLC (MBUSA) regular monthly mailing for the month of January, 2007. Manufacturer's Campainn Identification Number 2006120008 NHTSA Recall Number 06V-495 Should you have any questions, please do not hesitate to contact Gary Bowne at 201-573-271 9. Sincere 4 di\!-- Enclosure O~;I~ ?,l~?r.:rtit:~. ill, P. PC) Box 350, Monidale. NJ 07645-0350. Phone (201 1 573 5338, Fax (201) 263 1367 www.MBUSA cam - - i .- Fllt-,rc.~li.:7 RC~) ri'gs~ered traderrijrks of Da~rnlerCRiyslc-r PX. Stuttgart, Fedrrdl RP~IIJSII~ of G~~~~,III~

Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

  • Upload
    others

  • View
    3

  • Download
    0

Embed Size (px)

Citation preview

Page 1: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

Mercedes-Benz USA, LLC Rolf Schcrer G ~ n e r a l Manager, i : ~ k ) , ~ r ~ r ; i ' r ~ r ~ p S ~ I U I I - ~ . ;

VIA CERTIFIED MAIL

January 12, 2007

National Highway Traffic Safety Administration Office of Defect Investigation Attention: George Person, Chief Recall Analysis Division 400 Seventh Street, S.W. Washington, D.C. 20590

Re: 49 CFR Part 573; Recall of Mercedes-Benz M and R-Class (1 64,25 1) Accelerator Pedal

Dear Mr. Person:

Pursuant t o 49 CFR Part 573.5(~)(9), this letter contains 2 documents that were communicated to our dealers on the above subject and will be submitted in Mercedes-Benz USA, LLC (MBUSA) regular monthly mailing for the month of January, 2007.

Manufacturer's Campainn Identification Number 2006120008

NHTSA Recall Number 06V-495

Should you have any questions, please do not hesitate to contact Gary Bowne at 201-573-271 9.

Sincere 4 di\!-- Enclosure

O ~ ; I ~ ?,l~?r.:rtit:~. ill, P . PC) Box 350, Monidale. NJ 07645-0350. Phone (201 1 573 5338, Fax (201) 263 1367 www.MBUSA cam

- -

i .- Fllt-,rc.~li.:7 R C ~ ) r i 'gs~ered traderrijrks of Da~rnlerCRiyslc-r P X . Stuttgart, Fedrrdl R P ~ I I J S I I ~ of G ~ ~ ~ ~ , I I I ~

Page 2: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

UPDATE MERCEDESBENZ USA, LLC One Mercedes Dr~ve, P.O. Box 350, Montvale, NJ 07645-0350 Phone (201) 573-0600 Fax (201) 573-01 17 MBUSA.com

To: Mercedes-Benz Dealer Principals, General Managers, Sales Managers, Service Managers, Parts Managers .-

From: Rolf Scherer, General Manager, Engineering Services

~ m m u m z - a n 7 -- - - Re: Recsl I Cag2pai~t1 2086 1 20008 - U o d ~ t e Check Accelerator Pedal N U J anmdlnstall- As Necessary, Models 164 and 25 1 Model Year 2007

An update has been made to the Campaign Bulletin with the inclusion of the owner letter. Revision A.

A copy of the updated campaign bulletin is attached, and may also be found on StarTeklnfo. Please provide the revised campaign bulletin to your technicians and destroy all previous Recall Campaign bulletin versions.

Owner's letters will be mailed early next week.

When scheduling customers for an appointment please ensure that you are aware of any open campaigns in VMI so that the customer is advised about the time necessary to complete all campaigns.

Note: Every vehicle in the VIN range may not be included in the campaign. VMI must always be checked before performing campaigns to verify that the campaign is required on a specific vehicle.

While we regret any inconvenience this causes, Mercedes-Benz USA, LLC is determined to maintain a high level of vehicle quality and customer satisfaction.

Please refer all customer inquiries to the Customer Assistance Center at 1-800-FOR- MERCedes (1-800-367-6372).

Page 3: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

FILE: SERVICE: GROUP 00 OF SERVICE INFORMATION BINDER i i I

PARTS: GROUP I OF INFORMATION - PARTS & ACCESSORIES BINDER !

1 Revision History Revision Date Purpose A 01/12/07 Addition of owner's letter

12/21/06 Initial issue

TO: ALL MERCEDES-BENZ CENTERS

SLIBJECT: MODEL 164,251 MODEL YEAR 2007 CHECK ACCELERATOR PEDAL NUTS AND INSTALL IF NECESSARY

This Recall Campaign has been initiated because DCAG has determined that the accelerator pedal in

some M- and R-Class vehicles (see VIN range on the following page) might not have been fully fastened

to its mounting studs. Due to the geometry and tension in the assembly, the mounting studs will maintain

the position of the accelerator pedal on affected vehicles, but may, over time, not maintain a consistent

pedal position, which could make it more difficult to operate the accelerator. All other functions of the

vehicle (engine acceleration, deceleration, and braking) will, however, remain fully functional.

Please review the Effective Serial Number chart located on the following page.

Attached is a sample copy of a letter which owners of the affected vehicles will receive.

Prior to performing this Recall Campaign: Please check VMI to insure the vehicle is involved and to determine if the vehicle has been previously

repaired. Please review the entire Recall Campaign bulletin.

Approximately 1570 vehicles are affected.

Control, and MBUSA-SLP S424HH001, Control of Quality Records. &

Page 4: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

Effective Serial Number Range

Models Chassis End Number From To

164.122 A208758 A21 4143

164.175 A208631 A21 3999

Note: Every vehicle in the VIN range may not be included in the campaign. VMI must always be checked before performing campaigns to verify that the campaign is required on a specific vehicle. VMI always overrides the bulletin in reference to a specific vehicle's inclusion in a particular campaign. Please also note that Recall and Service Campaigns do not expire and may also be performed on a vehicle with a vehicle status indicator.

Page 5: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

MODEL 164: CHECK ACCELERATOR PEDAL NUTS AND INSTALL IF NECESSARY

1. Switch off ignition and remove transmitter key from EIS control module.

Note - Vehicles with Kevless Go: Press Keyless Go starVstop button repeatedly until ignition is switched off.

Remove transmitter key from vehicle and store in a location beyond its transmission range

(at least 2 meters).

Figure 1

2. Visually check if accelerator pedal nuts (A, Figure 1) have been installed If both nuts are installed: This campaign has been completed.

If either nut is not installed: Proceed to step 3.

3. Lower cover below instrument panel (B).

Remove screws (arrows).

Note: Do not disconnect the electrical connectors.

Page 6: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

4. Install nut(s) (A, Figure 1; part # A 203 301 00 72) according to WIS document AR30.12-P-1321GZ.

Note: Disregard the part number in the EPC; ensure to use the part specified in this bulletin.

5. Reinstall cover below instrument panel.

MODEL 251 : CHECK ACCELERATOR PEDAL NUTS AND INSTALL IF NECESSARY

1. Switch off ignition and remove transmitter key from EIS control module.

Note -Vehicles with Kevless Go: Press Keyless Go staNstop button repeatedly until ignition is switched off.

Remove transmitter key from vehicle and store in a location beyond its transmission range

(at least 2 meters).

Figure 2

2. Visually check if accelerator pedal nuts (A, Figure 2) have been installed. If both nuts are installed: This campaign has been completed.

If either nut is not installed: Install nut(s) (part # A 203 301 00 72) according to WIS document

AR30.12-P-1321 RT.

Note: Disregard the part number in the EPC; ensure to use the part specified in this bulletin.

Page 7: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

Parts /!lf:)r r~'taf'rri1

U1 Y Part Name Part Number Estimated Replacement

Note: Please be aware that only the part number(s) referenced in the Campaign Bulletin islare approved for

use to repair the vehicle. Repairs performed using any other part(s) will not have been performed in

accordance with the campaign. Accordingly, warranty claims submitted with reference to an improper

part number(s) will be denied. The following allowable labor operation should be used when submitting a warranty claim for this

repair:

Warranty Information

Repair 1 (Check only)

Operation: Accelerator Pedal Nuts, Check if Installed (02-5586)

Repair 2 (Check and Install)

Operation: Accelerator Pedal Nuts, Check if Installed (02-5586)

Accelerator Pedal Nuts, Install (after Check) (02-5587)

Damage Code 30 900 01 8

Operation Number 02-5586

Labor Time (hrs.) 0.1

02-5587

Model Indicator(s) BA, BB, BC, BD, Z1,

z2 ,z4

0.2

, . Z2,24

BA, BB, BC, BD, Z1, 22,24

Page 8: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

Mercedes-Benz USA, LLC

Safety Recall #2006 120008

January, 2007

Dear Mercedes-Benz Owner

This notice is sent to you in accordance with the requirements of the National Traffic and Motor Vehicle Safety Act. WE SENT YOU 'THIS NOTICE BECAUSE WE ARE CONCERNED ABOUT YOUR SAFETY.

Daimlerchrysler AG (DCAG), the manufacturer of Mercedes-Benz vehicles, has decided that a defect which relates to motor vehicle safety exists in certain Model Year 2007 M-Class and R-Class vehicles. The accelerator pedal in some M and R- Class vehicles might not have been fully fastened to its mounting studs. Mercedes-Benz USA, LLC (MBUSA) therefore has initiated a recall of these vehicles. Our records indicate that your vehicle is included in the affected population of vehicles.

Due to the geometry and tension in the accelerator pedal assembly, the mounting studs will maintain the position of the accelerator pedal on affected vehicles, but may, over time, not maintain a consistent pedal position, which could make i t more difficult to operate the accelerator. Over time, the pedal will become increasingly difficult to operate. If this condition is not corrected, it could lead to a vehicle crash or accident. All other functions of the vehicle (engine acceleration, deceleration, and braking) will, however, remain fully functional.

Your authorized Mercedes-Benz dealer will inspect and if necessary install the appropriate mounting nuts on the accelerator pedal. This service will be provided free of charge. The working time required is approximately one half hour. As a matter of normal service process, your authorized Mercedes-Benz dealer will also check for other repair measures which might be applicable to your vehicle and this may increase the required working time. Please contact your authorized Mercedes-Benz dealer for additional information and to schedule an appointment at your earliest convenience. Please mention Recall Campaign #2006 120008.

If you are no longer the vehicle owner, or have a change of address, please complete the reverse side of this letter and return the complete letter in the enclosed envelope. If this is a leased vehicle and the lessor and registered owner receive this notice, please forward this information by first class mail to the lessee. If you have paid to have this recall condition corrected prior to this notice you may be eligible to receive reimbursement. Please see the reverse side of this notice for details.

Please contact your authorized Mercedes-Benz dealer should you have any questions or encounter any difficulty regarding this recall. If your dealer is unable to remedy your situation please contact us at 1-(800) FOR-MERCedes (1-800-367-6372).

If an authorized Mercedes-Benz dealer or Mercedes-Benz USA, LLC, fails or is unable to perform this service without charge within 60 days, pursuant to law 49 U.S.C. Chapter 301, you may submit a complaint to the Administrator, National Highway Traffic Safety Administration, 400 Seventh Street, S.W., Washington, D.C. 20590 or call the toll-free Auto Safety Hotline at 1-888-327-4236 (TTY 1-800-424-91 53); or go to http://www.safercar.gov.

We apologize for any inconvenience this situation may cause you.

Sincerely,

Page 9: Mercedes-Benz USA, LLC VIA CERTIFIED MAIL · 2016. 9. 14. · Mercedes-Benz USA, LLC Rolf Schcrer G~neral Manager, i:~k),~r~r;i'r~r~p S~IUII-~.; VIA CERTIFIED MAIL January 12, 2007

IMPORTANT

IF FOR ANY REASON YOU DO NOT NOW OWN THIS VEHICLE OR HAVE A CHANGE OF ADDRESS, PLEASE COMPLETE THE SECTION BELOW, PLACE IN THE ENCLOSED ENVELOPE, AND DROP IN ANY MAIL BOX. IF POSSIBLE, PROVIDE THE NAME AND ADDRESS OF THE PRESENT OWNER SO THAT WE MAY CONTACT THEM.

SCRAPPED STOLEN OTHER

U SOLD I HAVE SOLD THE VEHICLE TO: MY NEW ADDRESS IS:

NAME

STREET APT.

CITY STATE ZIP

PHONE

THANK YOU FOR YOUR COOPERATION

* * * * PLEASE DO NOT DETACH. RETURN COMPLETE LEllER * * * *

DO NOT USE THE ENCLOSED ENVELOPE FOR OTHER CORRESPONDENCE

Reimbursement to Customers for Repairs Performed Prior to Recall

~f you have already paid to have this recall condition corrected you may be eligible to receive reimbursement.

Requests for reimbursement may include parts, labor, fees and taxes. Reimbursement may be limited to the amount the repair would have cost if completed by an authorized Mercedes-Benz dealer. The following documentation must be presented to your dealer for reimbursement.

Original or clear copy of all receipts, invoices and/or repair orders that show:

The name and address of the person who paid for the repair.

The Vehicle Identification Number (VIN) of the vehicle that was repaired.

What problem occurred, what repair was done, when it was done and who repaired it.

The total cost of the repair expense that is being claimed.

Proof of payment of repair (copy of front and back of cancelled check, or copy of credit card receipt).

Reimbursement will be made by check from your dealer. If your claim is denied you will receive a letter from MBUSA within 60 days of receipt with the reason(s) for the denial.

Please speak with your dealer concerning this matter.