CYLINDER HEAD

01 11 12 2343023 Cylinder Head 1

02 11 12 2343273 VALVE GUIDE INLET 2

02 11 12 2343274 VALVE GUIDE EXHAUST 2

03 11 12 2343027 SNAP RING 11X1 4

04 11 12 2343031 CYL.HEAD GASKET 1

05 11 12 2343262 Collar screw M8X45 4

06 07 11 9915558 Hex nut M10 4

07 07 12 9905386 Fillister-head screw M6X30 3

08 11 12 2343030 Stud bolt M8X58 4

09 11 12 2343459 Supporting bracket 1

10 07 11 9919629 Fillister-head screw M6X45 8

11 07 11 9931044 Washer 6,4 8

12 11 11 2343233 Roll pin M8X12 2

CYLINDER WITH PISTON

01 11 11 2343446 CYLINDER WITH PISTON O. BOLZEN/RING 1

02 11 11 2343223 Pin 5X10 2

03 07 12 9905386 Fillister-head screw M6X30 5

04 11 11 7706497 Cylinder base gasket 1

CYLINDER HEAD COVER

01 11 12 2343275 Cylinder head cover 1

02 11 12 2343326 Screw M6X47,9 6

03 11 14 1461475 RUBBER bush 6

04 11 12 2343265 Gasket 1

ENGINE

01 11 00 2343231 Engine 650CCM 1

02 07 58 9062376 Sealing compound Drei Bond 1209 30ML

02 11 00 7660832 Schmiermittel Molykote 111 100G

03 07 58 9056030 Liquid sealant Loctite 638 10ML

03 83 19 2210339 Thread lock, medium-strength 10ML

04 81 22 9407547 Motor oil Super Power SAE 5W-40 1000ML

04 81 22 9407685 Motor oil HD 20W50 1000ML

05 11 00 2343232 Seal and gasket set, engine 1

06 11 00 2317015 REPAIR SET INSPECTION 1

ENGINE HOUSING COVER, LEFT

01 11 14 2343035 Engine housing cover, left 1

02 11 14 2343039 Gasket 1

03 11 14 2343036 NEEDLE SLEEVE 8X12X8 1

04 11 14 2343037 NEEDLE SLEEVE 12X16X10 1

05 11 14 2343038 Shaft seal 12X28X7 1

06 07 12 9905386 Fillister-head screw M6X30 X

07 11 14 2343240 Gasket ring A6X10 2

08 11 11 2343236 Fillister-head screw M6X65 3

ENGINE HOUSING COVER, RIGHT

01 11 14 2343278 Engine housing cover, right 1

02 11 14 2343042 Gasket 1

03 11 14 2343043 BRACKET EXTERIOR 1

04 07 12 9905386 Fillister-head screw M6X30 X

05 11 14 2343044 Screw plug M18X1,5 2

06 11 14 2343241 O-ring 17X1,5 2

07 16 12 2345065 Hose 7,5X13 1

08 11 41 2345092 Hose clamp 12,5X2 1

09 46 51 2345093 Bracket 1

TIMING GEAR – INTAKE VALVE – EXHAUST VALVE

01 11 34 2343225 INTAKE VALVE 36 2

02 11 34 2343226 EXHAUST VALVE 31 2

03 11 34 2343228 VALVE SEAL RING 4

04 11 34 2343227 Stop disk 11,2X28X1 4

05 11 34 1460656 VALVE SPRING 4

06 11 34 2343230 VALVE COLLET 8

07 11 34 2343229 SPRING POCKET 4

08 11 32 1460144 Cam follower 4

09 11 32 1460147 Spacer 2,00MM 4

09 11 32 1460148 Spacer 2,05MM 4

09 11 32 1460149 Spacer 2,10MM 4

09 11 32 1460150 Spacer 2,15MM 4

09 11 32 1460151 Spacer 2,20MM 4

09 11 32 1460152 Spacer 2,25MM 4

09 11 32 1460153 Spacer 2,30MM 4

09 11 32 1460154 Spacer 2,35MM 4

09 11 32 1460155 Spacer 2,40MM 4

09 11 32 1460156 Spacer 2,45MM 4

09 11 32 1460157 Spacer 2,50MM 4

09 11 32 1460158 Spacer 2,55MM 4

09 11 32 1460159 Spacer 2,60MM 4

09 11 32 1460160 Spacer 2,65MM 4

09 11 32 1460161 Spacer 2,70MM 4

09 11 32 1460162 Spacer 2,75MM 4

09 11 32 1460163 Spacer 2,80MM 4

09 11 32 1460164 Spacer 2,85MM 4

09 11 32 1460165 Spacer 2,90MM 4

09 11 32 1460166 Spacer 2,95MM 4

09 11 32 1460167 Spacer 3,00MM 4

TIMING GEAR – CAM SHAFT/CHAIN DRIVE

01 11 31 2343081 INLET CAMSHAFT 1

02 11 31 2343082 CAMSHAFT EXHAUST 1

03 11 31 2343083 SPROCKET 34 2

04 11 31 2343285 Hex bolt M10X20 2

05 07 11 9936436 Washer 10,5 2

06 11 31 2343084 TIMING CHAIN 1

07 11 31 2343087 GUIDE RAIL 1

08 11 31 2343085 CHAIN TENSIONER 1

09 11 31 7728883 Chain tensioner/bolt/seal ring M18X1,5X10 1

10 11 31 2343091 Gasket ring 18,2X24X1 1

11 11 31 7676592 Bearing screw M6 1

12 11 31 2343088 Bow 1

13 11 31 2343089 SPACER BOLT M6X16 1

14 11 31 2343095 Decompression lever 2

15 11 31 2343096 Roll pin 5X23,8 1

16 11 31 2343097 Compression spring 1

WATER PUMP

01 11 51 2343128 WATERPUMP HOUSING 1

02 07 11 9919926 Fillister-head screw M6X25 3

03 11 14 2343240 Gasket ring A6X10 1

04 83 19 2210339 Thread lock, medium-strength 10ML X

05 11 51 2343129 O-ring 1

06 11 00 7660832 Schmiermittel Molykote 111 100G X

07 11 51 2343123 CLAMPING BUSH 4X16 1

08 11 51 2343451 Set, water pump shaft 1

09 11 41 2343107 Stop disk 10,1X17X1 1

10 11 51 2343127 Roll pin 4X19,8 1

11 11 51 2343126 PINION 1

SINGLE PARTS OIL PUMP

01 11 41 2343105 Roll pin 4X15,8 2

02 11 41 2343474 Shaft 2

-- 11 41 2343458 Lock Ring 2

03 11 41 2343098 SET ROTOR 1

04 11 41 2343101 SET ROTOR 1

05 11 41 2343106 OIL PUMP COVER 2

06 11 41 2343109 GEAR WHEEL 25 2

07 11 41 2343108 Roll pin 4X29,8 2

08 11 41 2343107 Stop disk 10,1X17X1 2

09 11 41 7654012 Torx bolt M5X16 6

10 11 41 2343114 OIL STRAINER 1

11 11 41 2343115 GUIDE SHIELD 1

12 11 41 2343116 Screw M5X16 2

13 11 41 2343498 Screw plug M18X1,5 1

14 11 31 2343091 Gasket ring 18,2X24X1 1

15 11 11 2343436 Repair kit, oil drain plug 1

LUBRICATION SYSTEM / PIPES

01 11 41 2345021 Oil pipe 1

02 11 41 2345165 Hose 10X18X1600 X

03 11 41 2345067 Hose clamp 17,5X8,6 6

04 11 42 2345020 OIL STRAINER 1

05 11 41 2345129 O-ring 21,82 X 3,53 1

06 11 41 2345156 Hose 6X12X1000 X

07 11 41 2345068 Hose clamp X12,5 2

07 17 11 1460922 Hose clamp D=12,3MM 2

08 61 13 1367599 Cable strap L=200MM/B=3,6MM 1

09 46 51 2345529 Dipstick 1

10 11 41 2345022 O-ring 26,75X3,53 1

11 46 51 2345499 Screw M8X20 1

12 46 51 2345500 Gasket ring 8X16X1,5 1

13 11 41 2345137 Spring 1

OIL FILTER

01 11 41 2343119 OIL FILTER COVER 1

02 11 41 2343118 OIL FILTER INSERT 1

03 11 41 7654013 O-ring 59,52X2,62 1

04 07 11 9900190 Fillister-head screw M6X20 2

05 11 41 2343120 NIpple 2

06 11 41 2345165 Hose 10X18X1600 X

07 11 41 2345067 Hose clamp 17,5X8,6 1

08 12 63 7670015 OIL PRESSURE SWITCH 1

WRISTPIN / PISTON RINGS

01 11 25 7675304 GUDGEON PIN 22X18X68.7 1

02 11 25 2343445 Ring 22 2

03 11 25 2343266 REPAIR KIT PISTON RINGS 1

REVOLUTION COUNTERDRIVE

01 11 41 2343110 GEAR WHEEL 31 Z 1

02 11 41 2343112 GEAR WHEEL 15/31 Z 1

03 62 13 2343220 HOLLOW BOLT 1

04 23 00 2343261 Washer 6,2X12X1 1

05 62 13 2343221 Shaft seal 6X11X4,5 1

06 62 13 2343222 Circlip 1

07 62 13 2343218 Drive Shaft 1

08 62 13 2343217 HELICAL GEAR WHEEL 1

09 62 13 2343219 Roll pin 2X11,8 1

COMPENSATING SHAFT

01 11 27 2343483 COMPENSATING SHAFT 1

02 11 27 2343289 Stop disk 24,3X41X1,5 1

03 11 27 2343243 WOODRUFF KEY 4X5 1

04 11 27 2343449 GEAR SET 1

05 11 27 2343244 CLAMPING BUSH 8X24 1

06 11 27 2343077 Compression spring 2

07 11 27 2343078 Shim 20,2X41X0,8 1

07 11 27 2343079 Shim 20,2X41X1 1

07 11 27 2343080 Shim 20,2X41X1,2 1

07 11 27 2343332 Shim 20,2X41X1,4 1

08 11 11 7704640 GROOVED BALL BEARING 52X20X15 2

ENGINE HOUSING MOUNTING PARTS

01 11 11 2343516 Engine housing 1

02 11 11 2343013 Bush 2

03 11 11 2343223 Pin 5X10 2

04 11 11 2343004 Bush bearing 48X52X22,8 1

05 11 11 2343233 Roll pin M8X12 5

06 11 11 2343234 Dowel pin 10X50 2

07 11 11 7670399 Bush bearing 48X52X22,8 1

08 11 11 2343238 Fillister-head screw M6X45 9 E

ENGINE MOUNTING HOUSING PARTS (2)

01 11 11 2343012 Gasket 1

02 11 11 2343239 Fillister-head screw M6X75 2

03 11 11 2343476 IDLE SWITCH 1

06 11 11 7652940 Stud M10X223 4

07 11 11 2343006 Valve Guide 2

08 11 11 7672245 Torx bolt M6X35 2

09 11 11 2343224 Ball 8 1

10 11 11 2343007 Spring, pressure maintenance valve 1

11 11 11 2343011 Compression spring 1

12 11 11 2343008 Pin 1

13 11 11 2343009 CONSTANT PRESSURE VALVE 1

14 11 11 2343017 GROOVED BALL BEARING 17X47X14 1

15 11 11 2343019 Shaft seal, compensating shaft 15X24X7 1

16 11 11 7658345 GROOVED BALL BEARING 25X62X17 1

17 11 11 2343018 Shaft seal, output shaft 25X40X7 1

18 11 11 2343016 GROOVED BALL BEARING 25X52X15 1

19 11 11 2343014 GROOVED BALL BEARING 17X47X14 1

20 11 11 2343010 Gasket ring A8X13 1

21 07 11 9904375 Fillister-head screw M8X20-8.8-ZNS3 1

UNDERRIDE PROTECTION / CHAIN COVER

01 46 63 2346275 Underride protection SCHWARZ 1

03 46 51 2345260 Bracket 1

04 11 11 2345125 Collar screw M5X16 4

05 16 11 2345079 Body nut M5 4

06 11 11 2345025 Cover for pinion 1

07 07 11 9919625 Fillister-head screw M6X25-ZNS 3

CRANCKSHAFT / CONNECTING ROD

01 11 21 2343045 CRANKSHAFT 1

02 11 21 2343055 Shim 48X67X1 1

02 11 21 2343056 Shim 48X67X1,25 1

02 11 21 2343057 Shim 48X67X1,5 1

02 11 21 2343058 Shim 48X67X1,75 1

03 11 27 2343243 WOODRUFF KEY 4X5 1

04 21 21 2343255 WOODRUFF KEY 6X9 1

05 12 11 2343250 Lock Ring 22 1

06 12 31 7700301 Hex nut M22X1,5 1

07 11 21 2343055 Shim 48X67X1 1

ENGINE ELECTRICS

STARTER

01 12 41 2343511 Starter, silver 1

02 12 41 2343149 Fillister-head screw M5X127 2

03 07 12 9905386 Fillister-head screw M6X30 2

04 12 41 2343253 O-ring 62X1,5 2

05 12 41 2343512 Repair kit for starter 1

06 07 12 9905542 Hex nut AM6-8-ZNNIV SI 1

07 07 11 9932099 WAVE WASHER B6 1

08 07 11 9934082 Lock Ring 15X1 1

09 12 41 2343252 O-ring 24,4X3,1 1

IGNITION SYSTEM

01 12 14 2343336 Ignition control unit 80DB 1

01 12 14 2343336 Ignition control unit 80DB 1

02 12 13 2343281 Ignition coil 2

03 12 12 2343145 Spark plug socket 2

04 12 12 2343144 SPARK PLUG 12 NGK D8EA 2

05 12 13 2345541 Hex bolt M6X16 2

05 13 71 2343300 Hex bolt M6X20 2

06 07 11 9903791 Washer A6,4 2

07 63 14 2346469 Hex nut M6 2

GENERATOR

01 12 11 2343132 Magneto generator 1

02 12 11 2343325 Pulse generator 1

03 07 11 9919932 Fillister-head screw M6X35 3

04 12 11 2343135 BRACKET INNER 1

05 12 11 2343133 Screw M4X8 2

06 11 41 2343116 Screw M5X16 2

07 12 31 7700301 Hex nut M22X1,5 1

08 12 11 2343250 Lock Ring 22 1

09 11 27 2343243 WOODRUFF KEY 4X5 1

10 12 11 2343520 Hex nut with ribs M6X16 8

11 12 11 2343295 Hub 1

12 12 11 2343296 Free wheel 1

13 12 11 2343290 Cover 1

14 07 11 9921054 Hex nut M6 8

15 12 11 7675940 Free wheel 1

16 12 11 2343139 GEAR WHEEL 11/52 Z 1

17 11 41 2343107 Stop disk 10,1X17X1 1

18 12 11 2343140 Spacer sleeve 10X13X13,7 1

19 11 41 2343267 Stop disk 10X58X1,5 1

20 12 11 2343138 GEAR WHEEL Z=24 1

FUEL SYSTEM

CARBURETOR CAP/PISTON/FLOAT

01 13 11 2343478 CARBURETOR SLS 1

02 11 61 2345007 Rubber grommet 1

03 13 71 2343299 Pipe clamp 47/67 2

04 11 61 2343131 Intake manifold 1

05 11 61 2343249 Hose clamp 51 2

06 07 11 9919625 Fillister-head screw M6X25-ZNS 3

07 11 61 2343248 Washer 6,4 3