4
CHEMICAL PROBLEMS ENCOUNTERED IN FREEZING FOODS' DONALD K. TRESSLER Food and Container Institute for the Armed Forces, Research and Development Branch, Office of the Quartermaster General, Chicago, Illinois TEE changes which may occur during the preparation of food for freezing and during the subsequent freezing, storage, and thawing of the prepared food are physical, chemical, and physicochemical. Physical changes in- clude crystallization, expansion, and desiccation. Chemical changes may be classified as (a) ordinary chemical actions, (b) those caused by enzymes, and (c) those brought about by microorganisms (bacteria, yeasts, and molds). Chemical changes are of many types and usually occur simultaneously with each of the other two types of changes. Oxidation of pigments and catecholtan- nins, hydrolysis of fats and other esters, and dehydra- tion or denaturation of proteins are examples of chemical changes which often occur in frozen foods. Both fruits and vegetables are composed of living matter and consequently respire. That is to say, after harvest they continue to take up oxygen and give off carbon dioxide. This action causes a decrease in sugar content which is especially noticeable in peas and corn. Bruising and freezing both cause mixing of the cell contents and an abnormal respiration which may bring about the development of off-flavors. During vining (threshing) both peas and lima beans are severely bruised. This bruising mixes the cell contents and causes rapid "abnormal" enzyme actions which cause the quick development of off-flavors in the vined vegetables unless they are promptly heated to inactivate enzymes (blanched) or chilled. Commercially, vegetables are blanched preparatory to freezing. This treatment kills the tissues and in- activates catalase and a considerable portion of the other enzymes so that enzyme actions, and conse- auentlv res~iration.are veni areatlv reduced during " - 1 Abstract of an address presented a t the Twelfth Summer Conference of the New England Association of Chemistry Teachers. Universitv of Connectimt, Storrs, Connecticut, August 25, 1950. freezing, cold storage, and thawing. As yet no one has shown what enzymes are responsible for the loss of color and changes in flavor of unheated frozen vegetables during cold storage. Practical experimentation has demonstrated that it is necessary to heat the vegetables long enough to inactivate catalase completely and to destroy practically all of the peroxidase or else "hay flavors" will develop during storage at 0°F. or above. Although heating in boiling water or steam is neces- sary to destroy enzymes and thus prevent the loss of color and change of flavor during freezing and subse- quent storage, this treatment dissolves out an ap- preciable proportion of the water-soluble nutrients and flavors. The losses of ascorbic acid (vitamin C) and sugar are particularly notable. The longer the blanch- ing the greater the losses; therefore it is of considerable importance to blanch vegetables just long enough to inactivate the enzymes. Steam-blanching leaches out less asco~bicacid and other water-soluble nutrients than does water-blanching, but unfortunately steam- blanching does not give as uniformly desirable results with leafy and some other vegetables. Fruit usually is not heated; consequently, enzyme actions often give trouble during freezing and also during cold storage and thawing. Freezing and cold storage even at low temperatures do not inactivate any of the common enzymes; when returned to ordi- nary temperatures their activity is found be to unim- paired. Enzyme actions are markedly slowed down at cold storage temperatures; in general, the lower the temperature, the slower the rate of action. Oxidative enzyme actions are particularly objec- tionable in cold-stored fruit, since these actions cause darkening and changes in flavor. Frozen peaches, apricots, apples, pears, and sweet cherries are particu- larly subject to oxidation by enzyme action. In some instances these fruits are heated with steam in order to inactivate oxidative enzymes prior to freezing. In

Chemical problems encountered in freezing foods

Embed Size (px)

Citation preview

Page 1: Chemical problems encountered in freezing foods

CHEMICAL PROBLEMS ENCOUNTERED IN FREEZING FOODS'

DONALD K. TRESSLER Food and Container Institute for the Armed Forces, Research and Development Branch, Office of the Quartermaster General, Chicago, Illinois

TEE changes which may occur during the preparation of food for freezing and during the subsequent freezing, storage, and thawing of the prepared food are physical, chemical, and physicochemical. Physical changes in- clude crystallization, expansion, and desiccation. Chemical changes may be classified as (a) ordinary chemical actions, (b) those caused by enzymes, and (c) those brought about by microorganisms (bacteria, yeasts, and molds).

Chemical changes are of many types and usually occur simultaneously with each of the other two types of changes. Oxidation of pigments and catecholtan- nins, hydrolysis of fats and other esters, and dehydra- tion or denaturation of proteins are examples of chemical changes which often occur in frozen foods.

Both fruits and vegetables are composed of living matter and consequently respire. That is to say, after harvest they continue to take up oxygen and give off carbon dioxide. This action causes a decrease in sugar content which is especially noticeable in peas and corn. Bruising and freezing both cause mixing of the cell contents and an abnormal respiration which may bring about the development of off-flavors. During vining (threshing) both peas and lima beans are severely bruised. This bruising mixes the cell contents and causes rapid "abnormal" enzyme actions which cause the quick development of off-flavors in the vined vegetables unless they are promptly heated to inactivate enzymes (blanched) or chilled.

Commercially, vegetables are blanched preparatory to freezing. This treatment kills the tissues and in- activates catalase and a considerable portion of the other enzymes so that enzyme actions, and conse- auentlv res~iration. are veni areatlv reduced during " -

1 Abstract of an address presented a t the Twelfth Summer Conference of the New England Association of Chemistry Teachers. Universitv of Connectimt, Storrs, Connecticut, August 25, 1950.

freezing, cold storage, and thawing. As yet no one has shown what enzymes are responsible for the loss of color and changes in flavor of unheated frozen vegetables during cold storage. Practical experimentation has demonstrated that it is necessary to heat the vegetables long enough to inactivate catalase completely and to destroy practically all of the peroxidase or else "hay flavors" will develop during storage at 0°F. or above.

Although heating in boiling water or steam is neces- sary to destroy enzymes and thus prevent the loss of color and change of flavor during freezing and subse- quent storage, this treatment dissolves out an ap- preciable proportion of the water-soluble nutrients and flavors. The losses of ascorbic acid (vitamin C ) and sugar are particularly notable. The longer the blanch- ing the greater the losses; therefore it is of considerable importance to blanch vegetables just long enough to inactivate the enzymes. Steam-blanching leaches out less asco~bic acid and other water-soluble nutrients than does water-blanching, but unfortunately steam- blanching does not give as uniformly desirable results with leafy and some other vegetables.

Fruit usually is not heated; consequently, enzyme actions often give trouble during freezing and also during cold storage and thawing. Freezing and cold storage even at low temperatures do not inactivate any of the common enzymes; when returned to ordi- nary temperatures their activity is found be to unim- paired. Enzyme actions are markedly slowed down at cold storage temperatures; in general, the lower the temperature, the slower the rate of action.

Oxidative enzyme actions are particularly objec- tionable in cold-stored fruit, since these actions cause darkening and changes in flavor. Frozen peaches, apricots, apples, pears, and sweet cherries are particu- larly subject to oxidation by enzyme action. In some instances these fruits are heated with steam in order to inactivate oxidative enzymes prior to freezing. In

Page 2: Chemical problems encountered in freezing foods

MARCH, 1951 189

other processes sulfur dioxide, sulfites, or ascorbic acid are added to the fruit. Sulfur dioxide and sulfites im- part an objectionable flavor to the fruit but ascorbic acid actually improves both its flavor and nutritive value; furthermore, the fruit will not become dis- colored or changed in flavor until almost all of the as- corbic acid is oxidized.

In the case of many fruits which are not so easily changed in color and flavor by oxidation, sugar or sugar sirup is commonly added to retard enzymatic action. The action of the sugar is not perfectly understood, but it surrounds the fruit with sirup or sweetened juice, thus preventing intimate contact of the fruit with air.

Both oxidative and lipolytic enzymes give trouble during the cold storage of fish. Oxidative enzymes are particularly troublesome in the case of fatty fish such as mackerel and salmon. Fish oils are highly unsaturated and readily combine with oxygen, becoming discolored and rancid. Frozen vhole fish may be protected against oxidation by glazing. This is carried out by dipping the frozen fish in cold water, thus forming a protective film of ice (glaze) over the surface. During storage this ice film slowly sublimes; consequently i t is necessary to repeat the glazing operation every two or three months.

Fish fillets are sometimes dipped in an ascorbic acid solution prior to freezing in order to coat the fish with an antioxidant and thus prevent oxidation. Glazing with an ascorbic acid solution is even more effective.

Proper packaging is also of great importance in re- tarding both chemical and enzymatic changes, es- pecially oxidative changes. The relative humidity of cold storages is often lorn, because of the condensation of the moisture on the refrigeration coils (ammonia pipes). Consequently, unless the food is packaged in airtight or moistnreproof packages, there is a slow movement of moisture from the product to the re- frigeration coils. This loss of moisture from the sur- face of poultry, meat, and fish causes freezer burn. The loss of this protective film of moisture exposes the surface to oxidation which is often severe. If paper packages are used for frozen foods, it is necessary to make them impervious to moisture vapor, and, pref- erably, also to air. In some instances this is done by lining or covering them with moistureproof cellophane, pliofilm, or a plastic sheeting. In other packages this is accomplished by coating or lining them with a suit- able wax or other plastic. For some products, e. g . , fruit juices, glass or metal packages are used.

Bacteria, yeasts, and molds are active a t ordinary room temperatures, 70' to 80°F., multiplying rapidly and causing profound changes in both fruits and vegetables. As the temperature is lowered, the rate of growth of these organisms is rapidly reduced until, a t about 15"F., their growth becomes negligible. Since frozen foods are ordinarily stored a t temperatures below 15'F., the action of microorganisms is a hazard only before freezing and during and after thawing.

The physicochemical and colloidal changes occurring are probably equal in importance to the chemical

changes. The changes in the colloidal condition of frozen foods are profound, but not well understood. Meat, poultry, fish, and shellfish are all made up of jelly-like protoplasm-a gel, to the colloid chemist. To fix the original spatial distribution of the colloid the rate of freezing must be rapid enough to form minute crystals uniformly distributed throughout the tissue. If such a quick-frozen product is thawed im- mediately, the moisture is reabsorbed as the crystals melt. If, on the other hand, the freezing is very slow, or the quick-frozen product is held under conditions which permit either the growth of the crystals or the irreversible dehydration or denaturation of some of the proteins, the product does not entirely return to its original gel condition. Some of the liquid resulting from the thawing of the crystals leaks out as "drip" or "leakage."

OFFICIAL BUSINESS The ,957th Meeting of the New England Association

of Chemistry Teachers was held on Saturday, October 14, 1950, a t the Nashua Senior High School, Nashua, New Hampshire. Approximately 50 persons attended the meeting.

Marco Scheer, Chairman of the Northern Division, presided. He introduced Edmund M. Keefe, Head- master of the Nashua Senior High School, who brought greetings to those present and spoke briefly on the ways in which the senior high school is attempting to fit its program to the individual student.

The first paper of the morning was delivered by Geoffrey Broughton of the Lowell Textile Institute, who spoke on "Paper, an old product with an ex- panding future." Professor Broughton outlined briefly the history of the paper industry and then drew atten- tion to the many new uses to which paper is being put. He brought with him a large number of samples to illus- trate these various new uses.

The second speaker was William C. Tallman, Techni- cal Assistant for the Public Service Company of New Hampshire, who spoke on the "Mercury vapor tur- bine," discussing the theory behind its operation and showing under what circumstances such a steam tur- bine would be used.

After the luncheon, opportunity was given for in- specting the school. Particularly interesting were the machine, wood-working, and automobile shops, as vell as the laboratories for home economics, chemistry, biolo~y, and physics.

A business meeting was called to order by the Presi- dent, Helen W. Cradey. For the Membership Com- mittee, the Secretary reported the election of the following new member:

Miss Rita P. Landry, Chemistry Teacher, Lowell High School, Lowell, Massachusetts.

Miss Crawley announced that she has been made a member of the Committee in charge of the Massa-

Page 3: Chemical problems encountered in freezing foods

110 JOURNAL OF CHEMICAL EDUCATION

chusetts State Science Fair. This Committee has met with a representative from the Boston Globe in an effort to clear up the misunderstanding which arose last year because the fair was known as the Boston Globe Science Fair. The Boston Globe has pointed out that it is under an expense of several thousand dollars in sponsor- ing this fair, and that since it has assumed this financial responsibility it feels that it is only rigl~t that the name of the paper should he associated with the project. The Globe and the Committee have agreed, therefore, that the fair shall be called "The Massachusetts Science Fair, Sponsored by the Boston Globe." It is hoped that in this way science teachers will realize that the fair is definitely for the entire state and that the Boston Globe is acting simply to underwrite the ex- penses for it. There were other comments from the floor indicating appreciation of the willingness of the Globe to assume such a financial burden for the sake of holding the fair.

The last speaker of the day was Albert F. Daggett, Professor of Chemistry and Dean of the Graduate School a t the University of New Hampshire. Dr. Daggett spoke on "Element 61." After a brief sur- vey indicating the position occupied by element 61 in the periodic system, Dr. Daggett discussed the recent work which has been done a t the University of New Hampshire in an effort to establish whether this element exists in nature or not. He discussed methods followed in the research work utilizing ion-exchange resins. He closed by stating that there is so far no conclusive proof of the existence of the element in na- ture, hut at the same time it should be recognized that there is no proof of its non-existence. Work continues on the problem.

The 968th Meeting of the New England Association of Chemistry Teachers was held a t Simmons College, Boston, Massachusetts, on December 2, 1950, as a joint meeting with the Eastern Association of Physics Teachers and the New England Biological Association. Ina Granara, Chairman of the Central Division, pre- sided. This was an unusually large meeting, over 200 people attending. The room originally assigned could not hold the group and it was twice necessary to move to larger rooms.

The meeting was opened with greetings by John A. T i who is Director of the School of Science a t Sim- mons College.

Clarence C. Little of the Roscoe B. Jackson Memorial Laboratory, Bar Harbor, Maine, spoke on "Cancer research and the secondary schools." Dr. Little's chief thesis was that in the present unsettled condi- tions it is particularly necessary to awaken the interest in research in the brilliant student while he is still young enough to have uninterrupted opportunity for doing something of this sort, and he pointed out that such an opportunity for research is being offered a t the present time a t the Jackson Memorial Laboratory.

I. Bernard Cohen of Harvard University spoke on

"General education in the sciences." In a brilliant and inspirational address which deplored the present- day emphasis on the gadgets and literature of learning, he begged teachers to stress critical thinking. Through analogies drawn from various personalities, situations, and theories in the history of science, Professor Cohen developed his thesis that we must cease asking students to "learn and learn and learn," and that we must, in- stead, endeavor to train them to see what they really see, not what they think they should observe, and to think critically about the observations which they have made.

The last speaker of the morning was Royal M. Frye, Head of the Physics Department, Simmons College. Professor Frye gave a very clear review of "Physics in 1950," and in the time a t his disposal elaborated on some of the more important points.

The afternoon session opened with an address by Hollis S. Baird of Northeastern University who spoke on "A review of television, past, present, and future." In addition to giving a very comprehensive survey of the problems and techniques of television with special emphasis on color television, Dr. Baird demonstrated projection television and made it possible for the audience to see the last few minutes of the Army- Navy game. This innovation was received with con- siderable enthusiasm.

Following Dr. Baird's lecture, President Helen W. Crawley called a short business meeting. The Treas- urer reported that to date (December 2) there are 404 members who have paid their dues, and that of these, 328 have sent a 50-cent contribution for the News Letter. This makes the News Letter solvent for the year. In the absence of the secretary there was no re- port of the Membership Committee.

It was announced that the dates for the Massa- chusetts Science Fair have been set for May 4,5, and 6, 1951.

SUMMER CONFERENCE COMMITTFZ

The Thirteenth annual summer NEACT conference is planned for the week of August 19, 1951, and will be held on the campus of Rhode Island State College, Kingston, Rhode Island. President Helen W. Craw- ley has announced the appointment of the following committee:

Co-Chairmen Donald C. Gregg, University of Vermont. William S. Huber, Rhode Island School of Design.

Secretary Elimbeth W. Sawyer, Connecticut College.

Registrar and Treasurer Virginia. W. Duval, Catonaville High Schwl, Catonsville,

Maryland.

Assistad Registrar Dorothv Ahel. Brookline Hieh School. Brookline. Mass*

Page 4: Chemical problems encountered in freezing foods

MARCH. 1951 171

Committee Chaimzen Repwsenlatiue of Host Imtilntion: W. George Parka, Rhode

Island State College, Kingston, Rhode Island. Pzlblieitu: Rev. Leo J. Daily. St. Thomas Seminary, Bloom- . . ~.

field, ~onnecticut . Exhibits: George Deckey, Rhode Island, School of Design. Printino and Maililzo: Leslie A. Hsllock. W. M. Welch Sci-

rnrific Compsny, \\'orceirer, >lnasnthusettr. Motion Picture*: Ralph I)i Vnttia, Durclorster, \ I a ~ ~ i l r h u ~ c f t ~ . Soctal Etmts: Ruth R. .JelTereon, Hrunfonl, Connecrirur.

Committee Members Guy F. Burrill, Keene, New Hampshire. Angelica Courniotes, Chicopee Falls, Massachusetts. Helen W. Crawley, NEACT President, ex fib, Walnut

Hill School. Natick, Massachusetts.

Bernard S. Jurale, Meriden, Connecticut. Alfred R. Lincoln, Western Massachusetts College of Phar-

macy, Willimansett, Messachusetts. Russell Meinhold, Rhode Island College of Education, Provi-

dence. Rhode Island. ~a the r ihe M. Murphy, Doreheater, Massachusetts. Andrew J. O'Connell, Worcester Academy, Worcester, Massa-

chusetts. Marian Stine Sowers, Somerville, New Jersey. Walter G. Stewart, Springfield, Massachusetts. Louise 0. C. Swenson, Lynn, Massachusetts. Carl P. Swinnerton, Pomfret School, Pomfret, Connecticut. Elbert C. Weaver, Phillips Academy, Andover, Massachusetts. Roland M. Whittaker. Queens Collexe. Flushin.. New Ymk. Eugene C. Winslow, %ode Island %ate ~olle&, Kingston,

Rhode Island.

Standish Deake, Woodstock Country School, Woodstock, The summer conference program will be printed in Vermont. the June, 1951, issue of THIS JOURNAL. The confer-

Robert D. Eddy, Tufts College, Medford, Maasachusetta. Ruth H. Ellis, Vsasar College, Poughkeepsie, New York. ence is open to all, members and non-members alike. Rose Finkelstein, Woodbury, Connecticut, Inquiries should be addressed to the Conference Secre- Clinton S. Johnson, Rhode Island College of Pharmacy, t&rY, Miss W. Road, Nor-

Providence, Rhode Island. mchtown, Connecticut.