Appendix 1(RDSO)

www.rdso.indianrailways.gov.in

Annual Report 2010-2011

1 BS 106 Broad guidelines for instrumentation of bridge for running higher axleloads.

2 BS 107 Assessment of Residual Fatigue life of Bridge No.586 near KoraputEast Coast Railway.

3 BS-108 Monitoring Report bridge on operation of BOXN wagon loaded up toCC+8+2t/CC+6+2t as Pilot project on identified Routes (VersionMay, 2010).

4 BST-04 Non-Destructive testing of 1474 in Madurari Division of S. Railway.

5 BST-08 Non-Destructive testing of Bridge No. 281 DN on river Kuamow (nearBasti) of NER

6 BST-07 Test report of Non-Destructive testing of concrete sleepers ofAnonsol Division, ER

7 BST - 06 Test report of Non-Destructive testing of IRITEM Building of LKO/NR

8 BST - 09 Non-destructive testing of Br. No.86 on Tungabhadra &Br.No.90 onRunga River in Mysore division of SWR.

9 BST - 10 NDT trial on Bridge No. 24/4 (Thane Creek), Mumbai Division of C.Railway.

10 BST - 11 NDT trial on Tunnel No. 1 in Trivendrum Div. of S. Railway

11 - Guidelines for providing standard spans of ROBs using compositesteel girders were issued inApril 2010.

12 - Document for empanelment of approved design consultants issuedin July 2010.

13 RDSO/2010/EL/IR/0144(Rev.0) Report on problems of breakage of brake hanger mounting bracketTraction Motor mounting plate, Traction Motor mounting lug of WAP-7 / WAG-9 Locomotives.

14 RDSO/2011/EL/IR//0145 (Rev.0) Report on performance of Drivers Vigilance Telemetric Control andMaintaining System (DVTCS ) for Electric Locomotives.

15 TR/ED/2010/211 Performance evaluation of compact brazed plate type lube oil coolerfor 3100 hpALCO 16-cylinder 251B dieel engine

16 TR/ED/2011/211 Development of single entry modified exhaust manifold withcombination of single entry gas inlet casing for ABB TPR-61 highefficiency turbocharger on 3300 / 3600 hp DLW diesel engine

17 TR/ED/2011/212 Valve timing diagram with stiffer unit camshaft for DLW built 16-cyinderALCO engine

18 G-33 (Rev-1) of May.2010 Requirements of Tippler Installation forApproval by RDSO.

19 WD-02-WDA-2009 Procedure of new Wagon DesignApproval

20 WDR-BOXNR-001-2010 AReport on BOXNR Wagon.

21 G -100 Instruction for inspection & Maintenance of AUTOMATIC Twist locks(ALT) Devices fitted on Container flat Wagon

22 WD-QAPCS-BOXNHL-MBS-2010 QualityAssurance plan check for BOXNHL-MBS(91.6t)

Bridge & Structures

Electrical

Engine Development

Freight Stock

APPENDIX-I

Publications brought out during 2010-2011

S.No. Report No. Title

89




23 WD-WPS-BOXNHL-MBS-2010 Welding Procedure for bogie open Wagon (91.6t) type BOXNHL-MBS-2010

24 WD-01-KIN-2010 Estimation of Kinematic Gauge of Double stack Container andothers Wagon.

25 WD-28-IRF-108-HS-BOGIE-98 Schedule of Technical Requirements for IRF-108-HS 22.1

(Rev. - 01) tonne/23.5 tonne Cast Steel Bogies For Broad Gauge Wagons

26 WD-03-Misc. 86 (Rev.- 4 ofAug.2010) Metal Bonded Side Bearer Rubber Pads. for Secondary SuspensionBogie.

27 WD-02-BRSTN-2010 Bogie Rail Wagon Type ‘BRSTN‘.

28 WD-16-BOXNR-2010 Guidelines and technical Requirement for UpgradedRehabilitation ofBOXNR Wagon.

29 WDR-QAWB-2010 Report of QualityAudit of Wagon Builder.

30 G -103 Strengthening of Under frame Repair of Critical weld joint Repair ofcenter sill , Centre Girder & Sole BarCracks.

31 WDI-BMBS-001-2010 WDI-BMBS-001-2010

32 WD-QAPCS-BOBYN22.9-2010 Quality Assurance plan check sheets for Bogie Hopper Wagon(91.6t) type BOBYN22.9 (fitted with conventional Brake Raggingsystem) B.G.

33 WD-QAPCS-BOSTHSM2-2010 Quality Assurance plan check sheets for Bogie Open Wagon(89.28t) type BOSTHSM2 (fitted with conventional Brake Raggingsystem) B.G.

34 WD-WPS-BOSTHSM2-2010 Welding Procedure specification for Bogie Open Wagon (89.28t)type `BOSTHSM2`

35 WD-QAPCS-BOXNHL-MBS-2010 QualityAssurance plan check for BOXNHL-MBS (91.6t)

(Rev.-1 of Nov.-2010)

36 WD-WPS-BOXNHL-MBS-2010 Welding Procedure for bogie open Wagon (91.6t) type BOXNHL-

(Rev.-1 of Nov.-2010) MBS-2010

37 WD-QAPCS-BOSTHSM2-2010 QualityAssurance plan check sheets for Bogie Open Wagon

(Rev.-1 of Dec.-2010) (89.28t) type BOSTHSM2 (fitted with conventional Brake Raggingsystem) B.G.

38 G-103 (Rev.-1 of Dec.-2010) Strengthening of Under frame Repair of Critical weld joint Repair ofcenter sill , Centre Girder & Sole Bar Cracks.

39 WD-QAPCS-BOBYN22.9-2010 Welding Procedure for Bogie Hooper Wagon (91.6 t) Type'BOBYN22.9` Wagon (Fitted With Conventional Brake Riggingsystem) for B.G.

40 RDSO/2009/GE: CR-0137 Consultancy Report On Rehabilitation of Washed out locationsBetween PaliakalanDudhwa&Tikunia-Manjhrapurab Stations,Gonda-Mailani Section, Lucknow Division, North EasternRailway

41 RDSO/2010/GE: CR-0139 Consultancy Report For Geotechanical Problems On Existing MGLine Between Phiding and Mahur Stations, NF Railway

42 RDSO/2010/ GE: CR-0141 Consultancy Report For Geotechnical Problems On Existing BG LineIn Rangiya&Tinsukia Division, N F Railway

43 RDSO/2010/GE: CR-0142 Consultancy Report On Construction of high Bank in BetweenVinaiki-Sikara Stations, Jabalpur-Gondia Gauge Conversion Line inNagpur Division, South East Central Railway

44 RDSO/2010/GE: CR-0143 Consultancy Regarding geo-technical problems in gauge conversionproject on Gadag-Bagalkot Section, Hubli Division, South WesternRailway

Geo-Technical Engineering

Appendix-I

90




45 RDSO/2010/GE: CR-0146 Consultancy Report On Gauge conversion Between Villupuram-Vellore Cantt section, Tiruchchirappalli division, SouthernRailway

46 RDSO/2010/GE: CR-0147 Consultancy Report on Review of Blanket Thickness as perGuidelines and Specifications of Higher Axle Load for New LineBetween Tarkeshwar-Bishnupur Section and Doubling Projects ofAmbikakalna- NabadwipDham and Katwa-Patuli Sections, HowrahDivision, Eastern Railway

47 RDSO/2010/GE: CR-0144 Consultancy Report On Rehabilitation of Weak Formation betweenBallia&Bansdih Stations in Chhapra-Aunrihar Section, VaranasiDivision, North Eastern Railway

48 - Application of nanotechnology enabled anti-graffiti coating oncoaches of Indian Railways- a case study in RDSO- published inIndian Railway Technical Bulletin ofAugust 2010.

49 - Paper on Weld Design published in Indian Railway TechnicalBulletin ofAugust 2010.

50 MP-Misc-254-April-10 List of must change & safety items during POH of diesel locomotives

51 MP-Misc-255-April-10 Commissioning schedule of 4000 HP or 4500 HP microprocessorcontrolled EMD type diesel electric locomotives

52 MP-Misc-256-May-10 Trial of M/s Medha make hotel load system fitted on 4500hp WDP4Blocomotive

53 MP-Misc-258-June-10 Report of Trial on Viscosity Monitoring using MAK RR 513 M of M/sBPCL with BPCL Group II base oil in High Horse Power ALCoLocomotives at Pune diesel loco shed.

54 MP-Misc-259-June-10 Finite element stress analysis of fabricated modified HTSC bogieframe fitted with disc brake

55 MP-Misc-270-March-11 Diesel locomotives defect codification for management informationsystem for EMD locomotives.

56 MP-Misc-272-June-11 Interim Report on Development and Application of H-type tight LockCentre Buffer Coupler and Soft Draft Gear on BG Locomotives ofIndian Railways

57 MP-1408-87-Revised-Jan-06 Operating Instructions For Execution Of Software For Estimation OfEmergency Braking Distance

58 MP-1406_87-Rev-02-Oct-10.pdf Diesel locomotive Defect codification for Management informationsystem

59 MP-INV-50-July-10 A report on failures of Siemens traction motors of EMD locomotives(Steps to control the failures)

60 MP-INV-51-April-11 Failure of broad gauge locomotive wheels due to widening of wheelgauge (An investigation report)

61 MPTP-41-June-10 Test programme for testing compressor capacity of diesel electriclocomotives.

62 MPTP-42-June-10 Test plan for conducting bench marking of Traction motor rubberbellows (EMD part no. 40058521) indigenous Vis-à-vis OEM makeused on EMD locomotives.

63 MPTP-43-June-10 Report of Trial for gear case lubricant "BalmerolPrototrac Lube" ofM/s BalmerLawrie Co. & Pvt. Ltd. for ALCo Diesel Locomotives atAndal diesel shed

64 MPTP-44-June-10 Trial Report of Compressor/Expressor Crank Case Oil "Servo Press100 RR" of M/s IOC onALCo Diesel Locomotives

Metallurgical & Chemical

Motive Power

Appendix-I

91




65 MPTP-45-July-10 Field trial report of servo RR 606 MG plus generation 5 multigradeengine crank case oil forALCo diesel locomotives

66 MP-0-0100-19-Rev-1-June-10 Specification for compact (Tri-plate) type IRAB-1 pure air brake and28 LAV-1 dual brake panel for diesel locomotives

67 MP-0-0100-20-Rev-2-April1-10 Specification for microprocessor controlled air brake system forWDG4/WDP4 andALCo locomotives

68 MP-0-0100-21-Rev-1-June-10 Technical requirements for electro-pneumatic assisted brakesystem for diesel & electric locomotives and air broke coaches.

69 MP-0-0100-27-Apil-10 Specification of control discharge sand ejector for diesellocomotives

70 MP-0-0100-29-May-10 Technical specification of windscreen defogger for diesellocomotives.

71 MP-0-0100-30-May-10 Specification for development of oil free air compressor for ALCotype diesel locomotives

72 MP-0-0400-03-Rev-2-July-11 Specification and test schedule for dc general purpose relay fordiesel-electric locomotive (ALCO)

73 MP-0-0400-08-Rev-1-May-10 Specification and test schedule for electro pneumatic/electromagnetic contactors and power brake switch/reverser for diesel-electric locomotive (ALCO)

74 MP-0-0400-10-Rev-1-June-10 Specification for the development of TFT LCD display for driversCAB [Called DIALS-digital Into analogue LCD-based system] formicroprocessor control based diesel electric locomotives (ALCo andEMD)

75 MP-0-0400-12-May-10 Specification for LED based flasher light for EMD locos.

76 MP-0-0402-04-Rev-4-Aug-10 Specification for the development of remote monitoring andmanagement of locomotives and trains (REMMLOT) for dieselelectric locomotives (ALCo& EMD) with microprocessor basedcontrol system

77 MP-0-0500-03-May-10 Technical specification for after cooler used on 16 Cylinder4000/4500 Horse Power EMD Locomotives

78 MP-0-0800-77-Rev-2-July-2010 Technical specification of 2300 hp 1676 mm gauge microprocessorcontrolled 3200 bogie wheel base locomotives for Srilanka(application for manufacture at DLW/ Varanasi)

79 MP-0-0800-94-june-10 Particular specification for 600 HP NDM5A N.G. diesel- hydrauliclocomotive (610 mm Gauge)

80 MP-0-0800-95-July-10 Particular Specification of wider cab along with crashworthy feature,APU and CCB-II (IR) on WDG4 Locomotive (Applicable formanufacture at DLW, Varanasi)

81 MP-0-0800-96-July-10 Specification of 3300/3500hp,WDM3D BG Diesel ElectricLocomotive (Applicable for manufacture at DLW, Varanasi)

82 MP-0-1400-01-Rev-1-June-10 Tender Specification for Procurement of fully machined Ductile Iron,Cast Engine Blocks along with Main Bearing Caps forALCO 251 (16Cyl.) diesel engines.

83 MP-0-2400-08 Rev-2-May-10 Technical specification for rtm blowers with sealed bearings for wdg2& wdp2 locomotives.

84 MP-0-2400-43-Rev-3-Feb-11 Technical specification for supply of AC-AC traction system for4500HP WDG-4/WDP-4B diesel-electric locomotives.

85 MP-0-2400-60-Rev-2-Sept-10 Specification for procurement of carbon block and tamping powderas a kit, applicable for traction machines of diesel electriclocomotives.

86 MP-0-2400-61-Rev-1-June-10 Specification for Auto Engine Start Stop system (AESS) for NonMicroprocessor Diesel Electric locomotives.

Appendix-I

92




87 MP-0-2400-67-April-10 Technical specification for supply of AC-AC traction system for dualcab 4500HP WDP-4D diesel-electric locomotives

88 MP-0-2400-68-April-10 Specification for auto engine start stop system with intelligent lowidling system (AESS with ILI) for non microprocessor diesel electriclocomotives

89 MP-0-2400-70-Feb-2011 Specification for supply, installation, commissioning & maintenanceof the microprocessor based destination board cum passengerinformation display system with GPS for IR BG DEMUS (wired type)

90 MP-0-2400-71-Dec-10 Specification for constant pressure brush holders for auxiliarymachines ofAG3110 ofALCo locomotives.

91 MP-0-2400-72-Sept-2010 Technical specification of 3-phase squirrel cage induction motor for5500 hpAC-AC WDG5 Locomotives

92 MP-0-2400-74-Sept-10 Technical specification of radiator cooling fan assembly for WDG5(5500HP) locomotive

93 MP-0-2402-03-Rev-3-April-11 Schedule of technical requirements for traction motor, tractiongenerator and traction alternator roller bearings used on BG & MGDE locomotives and DEMUs.

94 MP-0-2402-23-Rev-00-Dec-10 Specification For Energy Efficient Multi-GenSet 2400 BHP BGDiesel-Electric Locomotive

95 MP-0-2402-24-Dec-10 Specification of Guidance for Optimized Loco Driving (GOLD)

96 MP-0-2600-27-April-10 Specification for fuel mag diesel decontamination system for dieselelectric locomotives.

97 MP-0-3900-05-May-10 Specification for non contact type wheel and wheel tread profileparameter measuring instrument set.

98 MP-0-3900-06-Feb-2011 Specification for development of semi-solid type wheel-flangelubrication system.

99 MP-0-4099-03-Rev-2-June-10 Technical requirements for Hydraulic Dampers of WDG4 & WDP4Locomotives

100 MP-0-4100-04-Rev-2-Jan-11 Technical specification of high capacity rubber buffer springs forside buffers of BG locomotives.

101 MP-0-4900-15-Rev-3-Aug-10 Technical specification for self-steering Co-Co bogies of 4000/4500HP broad Gauge (1676 mm) diesel electric locomotives

102 MP-0-4900-16-Rev-1-June-10 Specification for hydraulic dampers of WDG3A, WDM3D (withEqualiser& Compensating Mechanism) and WDM3A (with A.T.H.SBogies) locomotives

103 VL-Spec-6-Rev-02-April-11 Technical specification for fabricated bogie frame& bolsterassembly for locomotives.

104 MP-IB-LD-01-17-10 Instruction for coupling and uncoupling of Transition type tight lockcoupler fitted on Diesel and Electric locomotives.

105 MP-IB-ES-01-18-10 Use of integral type fast coupling as per DLW Part No. 11420054 todrawing No. TPL-0091 Alt w, instead of welded type couplings onALCo Diesel Electric Locomotives.

106 MP-IB-EC-03-19-10 Mounting/Relocating of water pressure sensor on Medha makemicroprocessor based control Diesel Electric locomotive (ALCo).

107 MP-IB-EN-06-20-10 Provision of Canopy on the hydraulic motor of Moatti filter andspecification of Grease & O rings.

108 MP-IB-EC-04-21-10 Consolidated list of the improvement in MEP660 of M/s Medhamake MBCS and to be read along with RDSO docsMP.MOD.EC.09.43.09/01.06..09/07.31.09/05.26.09/08.33.09/03.19.10/07.31.09/09.59.10 and 10.61.10, MP.IB.EC.05.21.09/08.51.09/11.64.09/04.27.08/04.16.09/12.65.09 and MP.0.24.00.26Rev-5 and Rev-6.

Appendix-I

93




109 MP-IB-EC-05-22-10 Instruction bulletin for implementation of Intelligent Low Idle (ILI)equipment on WDS6 locomotives fitted with Wood Ward Governor.

110 MP-IB-EM-04-23-10 Replacing of rubber kit of magnet valve of E.P contactor andChecking of bolt length of the air outlet net for C1012TA of 1400 hpDEMU.

111 MP-IB-EM-05-24-10 Prevention of DB Grid failure inALCo Locos.

112 MP-IB-EM-06-25-10 Prevention of failures of Brush holder assembly of Traction motorC1005TM on 1400 hp DEMU.

113 MP-IB-VL-03-26-10 Instructions for preventing loosening out of TBU bolts in WDP1locomotives.

114 MP-IB-EM-07-27-10 Prevention of failure of RTMBs due to improper and long storage.

115 MP-IB-EC-06-28-10 To identify and replace the defective digital interface module C075and C083 in Siemens supplied TCC applicable for EMDlocomotives.

116 MP-IB-EN-07-29-10 Optimum engine operating line (e.o.l.) of ALCo family 3300 GHPlocomotives fitted with Medha make MCBG and Medha makemicroprocessor based control system.

117 MP-IB-EM-08-30-10 Modification of commutators for use with old serviceable core as wellas with the new core of TM 4907 or equivalent motors.

118 MP-IB-ES-02-31-10 Cleaning of cylinder head. as per specif ication NoMP.0.8000.02(Rev-00), August-08 with the use of "Orion 331R" ofM/s Orient Chemicals & "VC-601" of M/s Vinni chemicals.

119 MP-IB-EN-08-32-10 Introduction of 3RV Kit in ALCo locomotives used on IndianRailways.

120 MP-IB-VL-04-33-10-Rev-01 Instructions for replacement cage to a modified design on CRUbearing of M/s National Engineering Industries Ltd. fitted in Axle BoxAssembly for WDG3Aand WDM3D locomotives.

121 MP-IB-EM-10-35-10 Instructions for storage of MSU arrangement, Axle Box and GearWheel to prevent from direct dust and water ingress.

122 MP-IB-EM-11-36-10 Instructions for Gear case sealant forAlco Locomotives.

123 MP-IB-EN-09-38-10- Introduction of Piston Ring Pack (FE type with Moly Coated TopRing) inALCo locomotives used on Indian Railways.

124 MP-IB-VL-05-39-10-Oct-10-with- Instructions for testing of damping characteristics & overhauling ofCorrigendum hydraulic dampers used in locomotive.

125 MP-IB-EC-08-40-10-Dec-2010 Guidelines for controlling the locomotive during wheel slip inmicroprocessor controlled diesel welectric locomotive (ALCo - fittedwith MBCS of Medha (MEP660), Siemens (KM DIRECT/SIMCONTROL) and GETS (Bright StarTMSirus) and EMD loco -fitted with EM2000, Medha MLC691, Siemens S1/S3)

126 MP-IB-BK-01-01-11 Provision of bypass arrrangement for air dryers in diesel electriclocomotives.

127 MP-IB-EM-01-02-11-April-11 lnstruction bulletin for conversion of 4000 HP GTO based tractionsystem to 4500 HP IGBT based traction system in the existing GTObased EMD Locomotives.

128 MP-MOD-EM-07-32-10 Use of EPDM based cable & pipe sealing system with multi diametertechnology in ALCO locomotives (type WDM3D, WDG3A andWDM3A) fitted with roof mounted dynamic grid to avoid wateringress in DBR chamber / short hood.

129 MP-MOD-EM-08-33-10 Removal of RC circuits (snubber circuits) in existing TractionAlternators fitted in 4000/4500 HP EMD locomotives.

130 MP-MOD-EM-09-34-10 Provision of Fibre glass sheet on RC circuit of M/s Hind makeAlternator Mounted Rectifiers to prevent the chances of flashover onrectifiers.

Appendix-I

94




131 MP-MOD-LD-02-35-10 Retrofitment of Driver's Cab in ALCO diesel locomotives with FRPInteriors.

132 MP-MOD-BK-09-37-10 Modifications for increasing orifice block choke size and provision forrising engine r.p.m. without giving traction for motoring in case ofPCS knock out.

133 MP-MOD-ES-06-38-10-April-10 Use of synthetic rubber neoprene type oil resistant gasket (DLW partno. 17272257, drg.no. D17272257) in place of fuel tank inspectioncover gasket fitted on EMD &ALCo locomotives.

134 MP-MOD-BK-10-39-10 Disconnection of power supply to CRU fans of Computer ControlledBrake (CCB) system.

135 MP-MOD-VL-04-40-10-Rev-1 Provision of Non-metallic, self lubricated Brake rigging Bushes onWDG3A/WDM3D locomotive bogies.

136 MP-MOD-BK-11-41-10 Conversion from EP brake system to dual brake system (EP brake &air brake) for the DPC (dual brake system) to enable coupling ofcomplete consist of EP brake and complete consist of air brake.

137 MP-MOD-EN-04-42-10-April-10 Miscellaneous modification for EMD WDG4 and WDP4 loco toimprove its reliability.

138 MP-MOD-VL-05-43-10 Unification of Plate ASM and Bushing Traction Rod fitted in WDP4locomotives.

139 MP-MOD-EM-10-45-10 Modifications in EMD Locomotives (WDG4 and WDP4) to improvetheir reliability and maintainability.

140 MP-MOD-EN-05-46-10 To avoid premature failure of power assembly no.7 in EMD dieselelectric locomotives on Indian Railways.

141 MP-MOD-BK-12-47-10 Modifications in air brake equipment and its pipeline of EMDlocomotives for easy maintenance & to improve reliability

142 MP-MOD-BK-14-49-10 Modification from conventional hand brake to modified hand brake(Gear type) arrangement for EMD locomotive application.

143 MP-MOD-BK-15-50-10 Provision of high tensile spring for better performance of Fireman'sbrake valve in EMD locomotives.

144 MP-MOD-EC-07-52-10 Mod sheet of Stick type master controller uded on ALCOLocomotives to improve relaibility.

145 MP-MOD-BK-16-53-10 Replacement of Allen head bolts with Hexagon head bolts oncylinder head of Water-cooled compressor, (ELGI Make) on EMDlocomotives.

146 MP-MOD-BK-18-56-10 Standardization of mounting bracket for "Un-loader panel assembly"and "CAB side sanding control and Horn magnet valve assembly" inEMD locomotives.

147 MP-MOD-BK-19-57-10-May-10 Use of 'L' Type Composition Brake Blocks in MG YDM4 diesellocomotives in place of cast iron brake blocks

148 MP-MOD-EC-08-58-10 Rev-01 Modified Mounting location of WP pressure sensor. Revisedalgorithm for the protection of engine by taking inputs of outletpressure of WP, rate of rise of EWT/EOT and LWS applicable forDiesel Electric locomotives (ALCo).

149 MP-MOD-LD-04-60-10 Provision of Stiffening Ring on TCC blowers used on EMDlocomotives to avoid failures on account of breakage of blowercasing

150 MP-MOD-EC-10-61-10 Provision of Inspection hole on the cam gear cover for checking theimproper gap between cam gear teeth and engine speed sensor tipapplicable for MBCS diesel electric locomotives (ALCo)

151 MP-MOD-EN-06-62-10 DMW rebuilt 3 RV locomotives failed due to piston and liner gotseized at diesel shed Ratlam in one location and two pistons seizedat DMW during testing at test bed.

Appendix-I

95




152 MP-MOD-EN-07-63-10 Spray nozzle dimension modification for cam gear lubrication.

153 MP-MOD-EM-11-64-10-May-10 Use of hybrid bearings 6304-2RSL3/ HC5C3S0WT and radial shaftseal CR 20X45X7 HMS5V in AC Crank Case Exhauster motor toimprove reliability and performance.

154 MP-MOD-EC-11-65-10 Modifications in EMD Locomotives (WDG4 and WDP4) for controlequipments to improve their reliability and maintainability.

155 MP-MOD-VL-07-68-10 Provision of Non-metallic Pedestal liner on WDG3A/WDM3D &WDM3A(withATHS bogie) locomotive bogies.

155 MP-MOD-VL-08-69-10 Modification on Pin & cotter arrangement of equaliser&compensating beam mechanism of WDG3A, WDM3B & WDM3Dlocomotives fitted with equaliser& compensating beam mechanism.

156 MP-MOD-EM-14-70-10 Prevention of cable failure in EMD Locomotives (WDG4 and WDP4).

157 MP-MOD-EM-15-71-10 Modification in terminal box cover ofAC small motors.

158 MP-MOD-HYD-02-72-10 Modification for prevention of fire incident in 700 hp DEMU-DPCswith Caterpillar engines.

159 MP-MOD-EN-08-73-10-June-10 Modification to 16 cyl engine block, main bearing cap, main bearingshell and cap studs.

158 MP-MOD-ES-07-74-10 Use of Asbestos free Gasket (with printed silicone bead both sides)in place of existing gasket (HP sheet) in cooling water and lube oilsystem of D.EALCo locomotives.

159 MP-MOD-BK-20-75-10 Increase in the capacity of sand box and standardization of SandingMagnet Valve, Sand Conveyor, Filler assembly & Nozzle on WDG3ALocomotives.

160 MP-MOD-BK-21-76-10 Standardization of FT-2 relay valve (alternate to add. C2W relayvalve) in brake system of diesel and electric locomotive to increasethe periodicity of overhauling from M-4 to M-12.

161 MP-MOD-LD-05-77-10 Modification sheet for drainage from alternator room of WDP4Locomotive.

162 MP-MOD-LD-07-79-10-July-10 Modification in Expansion tank of WDM3ALocomotive.

163 MP-MOD-BK-22-80-10 To provide elbow on breather valve of non upgraded air compressorand provide support to unloader pipe to H.P cylinder on compressorsfitted onALCo type diesel electric locomotives.

164 MP-MOD-EC-12-81-10-June-10 Provision of Speedometer on WDP4B Locomotive with scale rangeof 0-140 Kmph.

165 MP-MOD-EC-13-82-10 To increase the threshold value for current based wheel slipprotection logic on M/s Medha make MEP660 MBCS for dieselelectric locomotives.

166 MP-MOD-BK-23-83-10 Design modification in unloader and suction valve assembly ofwater-cooled air compressor of ELGI make.

167 MP-MOD-LD-08-84-10 Railway Board vide letter no. 2000 M (L) 466/9 dated 06.06.03advised RDSO to issue necessary drawings/specification,instructions and likely sources for modifications for Crew FriendlyDriver's Cab, to be carried out by Railways.

168 MP-MOD-VL-09-85-10-Aug-10 Provision of eye type damper in lieu of stem type dampers on highadhesion bogies of WDG3A & WDM3D (with equaliser&compensating mechanism) locomotives.

169 MP-MOD-EN-09-86-10-July-10 Introduction of oil passage in push rod lifter (Air & Exhaust) fitted withConventional / FE camshaft for lubrication of cam rollers.

170 MP-MOD-EM-16-87-10-July-10 Provision of M16 studs in place M10 studs for mounting of InverterProtection Resistors in 4000 HP/4500HP EMD locomotive toprevent their breakage.

Appendix-I

96




171 MP-MOD-BK-24-88-10-July-10 Modification to improve the reliability of horns (short hood) in EMDlocomotives.

172 MP-MOD-LD-09-89-10-Nov-10 Retro fitment of wider cab on narrow cab WDG4 & WDP4Locomotive.

173 MP-MOD-LD-10-90-10-Dec-10 Modification Sheet for provision of 25 mm plate in place of 6 mmplate in coupler pocket on WDP4 locomotives to avoid infringementof 'H' type transition tight lock couplers with FP & BP hose pipes.

174 MP-MOD-LD-11-92-10-Dec-10 Modification Sheet for provision of 16 mm plate in place of 6 mmplate in pocket structure assembly of newly built WDP4 locomotivesat DLW to avoid infringement of 'H' type transition tight lock couplerswith FP & BP hose pipes.

175 MP-MOD-EM-01-01-11-Feb-11 Stand by inverter forAC Fuel Pump motor.

176 MP-MOD-LD-01-02-11-May-11 Modification of WDM3D locomotives under frame in compressormounting area.

177 MP-MOD-VL-01-03-11-April-11 Design modification in the top mounting & piston rod sub-assemblyof IAI (M/s India Auto Industries (P) Ltd.) make hydraulic damper forALCo locos

178 MP-MOD-EM-02-04-11-April-11 Improvement measures for 3 phaseAC small motors.

179 MP-MOD-EM-03-04-11-April-11 Provision of higher rating contactor for Radiator cooling fanassembly of EMD locomotives

180 MP-MOD-EM-04-05-11-April-11 To implement the use of Constant Pressure Brush Holder onTraction motor type TM4907 on Broad Gauge Diesel ElectricLocomotives.

181 MP-MOD-LD-02-06-11-May-11 Modification for detachable type striker block on WDG4 & WDP4locos.

182 MP-MOD-LD-03-07-11-May-2011 Modification of coupler pocket of WAP7 locos.

183 MP-MOD-EN-01-09-11-July-11 Modification of Exhaust Manifold from existing Three Entry toModified Single Entry design for ALCO locos fitted with ABBTPR?61Turbocharger to improve its reliability.

184 MP-MOD-LD-05-10-11-July-11 Conversion of the CBC Coupler uncoupling arrangment from bottomoperated to top operated.

185 MP-STR-EM-01-01-10-Rev-00 Schedule Of Technical Requirement for Manufacturing of 3-ØSquirrel Cage Induction Motor for 5500HPAC-AC WDG5 Loco

187 MP-STR-EM-02-02-10-Sept-10 Schedule of technical requirements for manufacture and supply ofradiator cooling fan assembly for WDG5 (5500HP) locomotives

188 MP-STR-VL-01-01-11-Feb-11 Schedule of Technical Requirement for Manufacturers and supply ofSemi Solid Type on Board wheel flange Lubricator for locomotives.

189 MP-STR-LD-01-03-11-Feb-2011 Schedule of Technical Requirement Manufacturers of RubberSpring Elements.

190 MP-STR-EM-01-04-11-Feb-2011 Schedule of technical requirements for manufacture and supply ofGPS based destination board display- cum- passenger informationsystem (audio & visual) for IR BG DEMUs - wired type

191 MP-STR-VL-02-02-11-April-11 Special technical requirement for fabricated bogie frame & bolsterassembly (for locomotives)

192 MP-STR-EM-03-08-11-May-11 Schedule of technical requirements for rehabilitation / conversion ofmagnet frames of traction motor type: 4906,165/M and 752 tomagnet frames for TM 4907 of broad gauge diesel - electriclocomotives.

193 - Study on Rationalization of items of Personal Stores of passengerCarrying and Freight Trains Guards and their carriage in Lightweight container

Traffic

Appendix-I

97




194 - Action plan for Traffic Directorate

195 June 2010 Guidelines for using Welding Material For Track CircuitApplication

196 MT1024/F/April-10 Confirmatory Oscillograph car run of consisting all variants LHB(EOG) coaches (3 Tier AC sleeper, 2nd AC Sleeper, AC chair car,buffet car and Generator ( van) hauled by wap1 locomotive overNDLS-LDH -NDLS section of N.Rly up to a max speed of 130 kmph.

197 MT1025/F/April-10 Confirmatory oscillograph car run of consisting all variants LHB(EOG) coaches (3 Tier AC sleeper, 2nd AC sleeper, ac chair car,buffet car and Generator van) hauled by wap7 locomotive overNDLS-LDH-NDLS section of N Rly up to a max speed of 130 kmph.

198 MT1026/F/April-10 Confirmatory Oscillograph car run of consisting all variants LHB(EOG) coaches (generator van, Ist AC & 3 T AC sleeper, car &executive chair car) ) hauled by wap3 a locomotive over NDLS-LDH-NDLS section of N Rly up to a max speed of 130 kmph

199 MT1027/F/April-10 Confirmatory Oscillograph car run of consisting all variants LHB(EOG) coaches (generator van, first ac & 3TAC, sleeper, chair car &executive chair car ) hauled by WDP4 locomotive over NDLS - LDHsection of N Rly. Up to a maximum speed of 130 kmph

200 MT1028/F/April-10 TM Run over, NEW DELHI - HOWRAH-NEW DELHI, RAJDHANIROUTE conducted in March 2010

201 MT1029/L/April-10 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

202 MT1030/F/April-10 Coupler force trial on 25 Air Brake Coaches on KSRA-IGP section ofMumbai Division, Central Railway

203 MT1031/F/April-10 Oscillation trials of Bcacm Car - ACAR-B upto the Maximum Speedof 110kmph in Empty and Different Loaded Conditions -Respectively over Ambala-Chandigarh Section of Ambala Divisionin Northern Railway.

204 MT1032/F/April-10 Controllability Trial Including EBD Trial on 25 Air Brake LoadedCoach (including 1 Inspepection Car) Headed by WAP1, WAP4,WAG5, WAG7, WDP4 AND WAP7 Locomotive in DecendingDirection of IGP-KSRAGHAT Section of Central Railway.

205 MT1033/L/May-10 Endurance and Performance Testing of Automatic Brake CylinderPressure Modification Device (ADM) supplied by M/s FAIVELEYTRANSPORT INDIALTD.

206 MT1034/L/May-10 Oscillation Trials of WDM3F Class of Locomotive upto Max. TestSpeed of 115 kmph on NAD-UJN-BIH Section of Western Railway.

207 MT1035/L/May-10 TM Run on NDLS-BCT-NDLS Rajdhani Route of N.R., N.C.R.,Western CentralAnd Western Railway

208 MT1036/F/May-10 Stress Investigation trials of BOXN HL (WCCCS) WAGONManufactured by Modern Inducstries Ltd., Sahibabad

209 MT1037/L/May-10 Type Acceptance Test of 'K' Type Composition Brake BlocksSupplied by M/s Hindustan Composites Ltd., Mumbai forLocomotive Stock.

210 MT1038/L/May-10 Quality Tests of 'K' Type Composition Brake Blocks of M/s Bic AutoPvt. Ltd. New Delhi for EMU Stock for Warded by Chief VigilanceOfficer, S. Rly Chennai

211 MT1039/F/May-10 Rating Performance and Adhesion Trial of WDM3 D Loco Fitted withEquialiser Less Hahs-1 Bogie

Signal

Mechanical Testing

Appendix-I

98




212 MT1040/L/Jun-10 Fatigue Testing and Deflection characteristics test of Elastomericpad.

213 MT1041/F/Jun-10 Longitudinal Jerk Trial on Duranto Express Between ALD-NDLS-ALD

214 MT1042/F/Jun-10 Longitudianal Jerk Trial on AP Express with Modified CouplerBetween SC-NDLS-SC

215 MT1043/L/Jun-10 TypeAcceptance Test on 'K' Type Conmposition Brake Blocks of M/sBicAuto Pvt., Ltd., New Delhi for Locomotive Stock

216 MT1044/L/Jun-10 Fatigue Testing and Deflection characteristics test of Elastomericpad.

217 MT1045/L/Jun-10 Quality Test of L Type Composition Brake Blocks Supplied by M/sHindustan Composites Ltd., Munmbai for Locomotive Stock

218 MT1046/L/Jul-10 Load Deflection and Fatgigue Tests of Primary Brake BeamSupplied by M/s Escorts, Faridabad

219 MT1047/L/Jul-10 Load Deflection and Fatigue Tests of Secondary Brake BeamSupplied by M/s Escorts, Faridabad

220 MT1048/F/Jul-10 Longidunal Jerk Trial on AP Express with Unmodified CBC CouplerBetween SC-NDLS-SC

221 MT1049/L/Jul-10 Quality Tests of K Type Composition Brake Block of M/s Rane BrakeLining Ltd., Chennai for Freight Stock

222 MT1050/L/Jul-10 Bench Marking Test for TM Bellows of EMD Make as well as Testingof Indian Manufactures

223 MT1051/L/Jul-10 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

224 MT1052/F/Jul-10 TM Run Over NDLS-Chennai Central - NDLS Rajdhani RouteConducted in June-10

225 MT1053/F/Jul-10 Osc. Trial of Prototype BGAC EOG Double Decker Chair Car CoachFitted with Pneumatic Suspension at Secondary Stage on Fiat Bogieupto Max Speed of 115kmph on BE-MB Section

226 MT1054/F/Jul-10 Track Monitoring Run Over NEW DELHI-AGRA CANTT -NEWDELHI Shatabdi Route Conducted in July-10

227 MT1055/F/Aug-10 Coupler Force and Controllability Trials Including EBD Trials onVacuum Braked Coaches for Ascending / Descending the GhatSection 1 In 12.5 Gradient with 2 YDM4 (MU) Locomotive OverMettupalayam - Coonoor Section of Southern Railway

228 MT1056/F/Aug-10 Oscillation Trials of WDP4B Class of Locomotive up to MaximumTest Speed of 145 kmph on Palwal - Agra Cantt Section of NorthCentral Railway

229 MT1057/F/Aug-10 Confirmatory Oscillograph Car Run of Consisting All Varriants LHB(EOG) Coaches (two Generator Van, AC First Class, AC Chair Car,3tier - AC, AC Two-tier, & AC Pantry Car ) Hauled By WAP5Locomotive Over NAD - MTJ - NAD Section of W. C. Railways uptoAMaximum Speed of 140kmph

230 MT1058/F/Aug-10 Oscillation Trial of DelhiAirport Metro Coaches Manufactured by M/sCAF, Spain up to a maximum test speed of 135 kmph overDhaulakuan - Dwarka Sector -21 sections of SG Network in bothEmpty and Loaded condition with Air Spring in fully inflated anddeflated mode

231 MT1059/F/Aug-10 Emergency braking distance trial of Delhi Airport Metro coachesManufactured by M/s CAF,Spain up to a maximum test speed of 120kmph over Dhaulakuan to Dwarka Sector-21 sections of DAMEPL

Appendix-I

99




SG Network in both Empty and Loaded condition withAir suspensionarrangement

232 MT1060/F/Aug-10 Oscillation Trials of WDM3F Locomotive upto the Maximum TestSpeed of 135kmph in New Wheel And Worn Wheel Condition OverPWL-AGC Section ofAgra Division in North Central Railway

233 MT1061/F/Sep-10 Oscillation trial on BG AC EOG Double decker chair car coach fittedwith pneumatic suspension at secondary stage on FIAT bogie.

234 MT1062/F/Sep-10 Oscillation Trials of BOXN UG Wagon, Loaded with CarryingCapacity+8t+2t ( Axle-Load of 22.82 T) upto the Maximum Speed of110kmph in empty and Loaded Conditions Respectively, over Hatia-Bondamunda-Hatia Section of Ranchi Division in South EasternRailway Series-F

235 MT1063/F/Sep-10 Trackmonitoring Run Over New Delhi - Kalka- New Delhi ShatabdiRoute

236 MT1064/F/Oct-10 Oscillation Trial of NGEF KOLKATA Metro Coaches up to amaximum test speed of 90 kmph over Shovabazar- Central stationsections (B.G)

237 MT1065/F/Oct-10 Track Monitoring Run Over New Delhi-Howrah - New Delhi RajdhaniRoute Conducted In September-2010

238 MT1066/L/Oct-10 Performance and endurance testing of automatic brake cylinderpressure modification device (APM) supplied by M/s Escort Ltd.Faridabad

239 MT1067/L/Oct-10 Performance and endurance testing of automatic brake cylinderpressure modification device (APM) supplied by M/s Stone India Ltd.

240 MT1068/L/Oct-10 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

241 MT1069/L/Oct-10 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

242 MT1070/F/Nov-10 Track Monitoring Run over New Delhi-Mumbai Central - New DelhiRajdhani Route Conducted in October' 2010

243 MT1071/L/Nov-10 Quality Tests of L Type Composition Brake Block of M/s IndustrialLaminates (India) Pvt. Ltd .Mumbai for locomotive stock

244 MT1072/L/Nov-10 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

245 MT1073/L/Nov-10 Type acceptance test of 'K' type Non asbestos CBB supplied by SWRly Mysore workshop for coaching stock.

246 MT1074/F/Nov-10 TM run over NDLS-AGC shatabdi route

247 MT1075/F/Nov-10 Stress Investigation of bogie covered Cement Fly Ash type BCFCwagon manufactured by Modern Industries Ltd. Sahibabad

248 MT1076/L/Dec-10 Quality test of 'L' type CBB for freight stock mfg by M/s CemconEnggCo. Pvt Ltd Sonepat Haryana

249 MT1077/F/Dec-10 Route Proving Run (RPR) trial for increase in speed of2273UP12274DN Howrah -New Delhi Duranto Express Train (withself generating variant coaches havingLHB shell and ICF bogiesfitted with pneumatic suspension at the secondary stage from 110kmph to 120kmph over Howrah-Pradhankanta section of ERconducted by Eastern Railway.

250 MT1078/F/Dec-10 Stationary and running braking trial on 08 Double Decker coachesand 2 LHB power car rake on Howrah- Dhanbad section of EasternRailway

251 MT1079/L/Dec-10 Type acceptance test of high friction composition brake blocksmanufactured by Mysore workshop, S.W.Railway for WDG4/WDP4(EMD locomotive).

Appendix-I

100




252 MT1080/L/Dec-10 Type Acceptance Test of 'K' Type non-asbestos Composition brakeblock supplied by central railway, Parel workshop for coaching stock.

253 MT1081/L/Jan-11 Test on Micro process based End-of-Train Telemetry devicesupplied by M/s Medhaservodrives Pvt. Ltd with 58 BOXN Wagonsimulated Train on air brake test rack

254 MT1082/F/Jan-11 Kinematic Behaviour of BGAC EOG Double Decker coach fitted withpneumatic suspension at secondary stage onFIAT bogie in UP aswell as Down direction between Howrah and Dhanbad.

255 MT1083/Jan-11 Acompendium of Calculations used in Testng Directorate

256 MT1084/L/Jan-11 Fatigue test of AluminoThermit welded Rail joints supplied by M/sHarshadThermit Industries Pvt Ltd. Railpur

257 MT1085/F/Jan-11 Longitudinal jerk trials on DibrugarhRajdhani Express train betweenNDLS-LKO

258 MT1086/F/Jan-11 Tm Run Over NDLS-Chennai Central - NDLS Rajdhani Route

259 MT1087/F/Jan-11 Adhesion & Running trials of IGBT based WDG4(4500HP)locomotive fitted with SIEMENS with simulated load equivalent to 59loaded BOXN wagon in 1:100 gradient section of Hubli Division ofSouth Western Railway

260 MT1088/Jan-11 Status report on Pilot Project for Track Side Bogie MonitoringSystem installed in LKO-SLN section of LKO division of NorthernRailway

261 MT1089/L/Feb-11 Tests on Micro Processor based End- of-Train Telemetry Device

Supplied By M/S Medha Servo Drives Pvt. Ltd.With 116 BOXNWagon Simulated Train onAir Brake Test Rack

262 MT1090/L/Feb-11 Quality Tests of ' L' Type Composition Brake Blocks of M/s AlliedNippon Limited, Gaziabad for BLC wagon (840mm dia. Wheel)

263 MT1091/L/Feb-11 Fatigue Testing and Deflection characteristics test of Elastomericpad for ProcessAudit Check

264 MT1092/F/Mar-11 Jerk Trial of LHB rake fitted with Dellner type couplers

265 MT1093/F/Mar-11 Adhesion Trial of WDM3F (3600 HP) Locomotive (M/S GETS) Make

266 MT1094/F/Mar-11 Oscillation Trials of WDP4D Class of Locomotive up to MaximumTest Speed of 115 kmph on Nagda -Ujjain- Bairagarh Section ofWestern Railway

267 MT1095/F/Mar-11 Oscillation trials on BG AC EOG Double Decker Chair Car Coachfitted with pneumatic secondary suspension at fiat bogie upto themaximum test speed of 130 kmph on 2º Curve of BZL-DKAE sectionof Eastern Railway

268 CT-26/Dec.-2010 Field trial of track based lubricator

269 TM-137 Maintenance schedule manual for worksite tamping machine(Metex)

270 TM-138 Field validation report of track recording system TRC 7967

271 TM-139 Trouble shooting manual of shoulder ballast cleaner (FRM-80)

272 TM-140 Draft Inspection check list of worksite tamping machine (Metex)

273 TM-141 Maintenance schedule manual for worksite tamping machine(Metex)

274 TM-142 Fatigue testing of mono block PSC sleepers to Drawing No.RDSO/T-7008 (capacity 25.0 t)

275 TM-143 Fatigue testing of mono block PSC sleepers to Drawing No.RDSO/T-7013 (capacity 22.5 t)

Track Design

Track Machines & Monitoring

Appendix-I

101




276 TM-144 Provisional Inspection check list of worksite tamping machine(Metex)

277 TM-145 Identification of section of Group-A and Group-B routes whereconsistent maintenance inputs are required.

278 TM-146 Provisional maintenance schedule manual of BRM (PBR-400)

279 TM-147 Provisional inspection check list of BRM (PBR-400)

280 TM-148 Trouble shooting manual of dynamic track stabilizer (DGS-62N)

281 TM-149 Fatigue testing (Pulsator Testing of ERC MK-III assembly for 20.32t,22.32t & 22.82t axle loads

282 TM-150 The effect of increased axle load on track maintenance and wear oniron ore route

283 TM-151 Fatigue testing of composite bridge sleeper

284 TM-152 Identification of section of Group 'A' and Group 'B' routes whereconsistent maintenance inputs are required (Based on trackrecording fromApril 2010 to June 2010)

285 TM-153 Maintenance schedule manual for BRM (PBR-400R)

286 TM-154 Deputation report, visit to LORAM maintenance of wayMinneapolis/Minnesota, WSA for RGM by T.K. Pandey, DirectorTrack Machine/RDSO and Dilip Kumar, SSE/TM/RDSO

287 TM-155 Study of track performance of Howrah-New Delhi section

288 TM-156 Inspection check list for BRM (PBR-400R)

Appendix-I

102

Documents

Appendix 1(RDSO)