Embed Size (px)
Citation preview
DEPARTMENT OF THE ARMY TECHNICAL MANUAL
ORGANIZATIONAL MAINTENANCE REPAIR PARTS AND SPECIAL TOOLS LIST
FOR
CARRIER, CARGO, AMPHIBIOUS: M76
(2320-796-5986)
BESCIHOEO
HEADQUARTERS, DEPARTMENT OF THE ARMY
AUGUST 1960
TM 9-2320-205-20P
TECHNICAL MANUAL))
No. 2320-205-20P )
HEADQUARTERS, DEPARTMENT OF THE ARMY
Washington 25, D. C., 31 August I960
CARRIER, CARGO, AMPHIBIOUS: M76
VISUAL TABLE OF CONTENTS
SECTION I INTRODUCTION
CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN) CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) - CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN) CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) - CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN)
- LEFT FRONT VIEW LEFT FRONT VIEW •- RIGHT REAR VIEW - RIGHT REAR VIEW -—-TOP VIEW—————
CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) - TOP VIEW——————•
SECTION II ORGANIZATIONAL REPAIR PARTS ENGINE
POWER PLANT —————————-——————————————————————————————————POWER PLANT TORQUE REACTION LINK - EXPLODED VIEW———————————————————CYLINDER BARREL AND ROCKER VALVE COVER - EXPLODED VIEW ————————————————————OIL FILTER - EXPLODED VIEW————————————————————————————————————————
FUEL SYSTEMFUEL INJECTION PUMP - EXPLODED VIEW ————————————————————————————————FUEL INJECTION NOZZLE - EXPLODED VIEW —————————————————————————————ENGINE FUEL PUMP - EXPLODED VIEW ———————————————————————————————FUEL CELL FUEL PUMP - EXPLODED VIEW—————————————————————————————FUEL CELL - EXPLODED VIEW—————————————————————————————————————AIR CLEANER - EXPLODED VIEW ————————————————————————————————————FUEL CELL COVER - EXPLODED VIEW ———————————————————————————————ENGINE FUEL LINES ——————————————————————————————————————————————————— VfcnlQ*Lt rUtL LINtb ••••——~—————•——••————~™——»™™™———™™^— _______________*_•__«—•———^ENGINE FUEL FILTER - EXPLODED VIEW ——————————————————————————————FUEL PRIMER FILTER - EXPLODED VIEW —————————————————————————————————FUEL PRIMER - EXPLODED VIEW ———————————————————————————————————————FUEL INDUCTION SYSTEM - EXPLODED VIEW—————————————————————————————THROTTLE CONTROL LINKAGE - EXPLODED VIEW ——————————————————————
EXHAUST SYSTEM MUFFLER AND EXHAUST PIPES ———————————————————————————————
COOLING SYSTEMFAN ROTOR AND HOUSING - EXPLODED VIEW ———————————————————————• FAN DRIVE CLUTCH - EXPLODED VIEW————————————————————————————•
ELECTRICAL SYSTEMGENERATOR - EXPLODED VIEW ——————————————————————————GENERATOR REGULATOR - EXPLODED VIEW————————————————————————- STARTER - EXPLODED VIEW —————————————————————————————MAGNETO AND VENT HOSES ——————————————————————————————IGNITION CABLE, BOOSTER COIL, AND SPARK PLUG ——————————————————• BATTERIES AND CABLES ——————————————————————————————————————• HORN, HORN SWITCH, AND HEADLIGHT DIMMER SWITCH —————————————INSTRUMENT PANEL, WIRING HARNESS, AND SAFETY SWITCH ———————————INSTRUMENT PANEL - FRONT VIEW - EXPLODED VIEW ——————————————————- STARTER RELAY AND RECEPTACLE MOUNTING PANEL———————————————INSTRUMENT PANEL - REAR VIEW - EXPLODED VIEW—————————————————SERVICE HEADLIGHT - EXPLODED VIEW———————————————————————BLACKOUT HEADLIGHT - EXPLODED VIEW —————————————————————————- BLACKOUT MARKER LIGHT - EXPLODED VIEW —————————————————————STOP LIGHT - TAILLIGHT - LEFT - EXPLODED VIEW—————————————————STOP LIGHT - TAILLIGHT - RIGHT - EXPLODED VIEW——————————————————- SERVICE HEADLIGHT - INFRARED - EXPLODED VIEW————————————————MISCELLANEOUS LIGHTS AND SENDING UNITS —————————————————SPOTLIGHT - EXPLODED VIEW —————————————————————————— ———DOME LIGHT - EXPLODED VIEW ————————————————————————————MISCELLANEOUS HULL WIRING (NON-ILLUSTRATED) ———————————————
TRANSMISSIONTRANSMISSION SUPPORT —————————————————————————————————————• TRANSMISSION OIL FILTER - EXPLODED VIEW ———————————————————TRANSMISSION OIL FILLER ———————————————————————————————TRANSMISSION OIL COOLER ——————————————————————————————————•
789
1011
1213141516171819202122232425
„__.__.„___ 97.—————— 28
——————— 29.__..__,___„___ 3Q
.—————— 3)
_______ 34——————— 35——————— 36
——————— 38——————— 39——————— 40.——————— 41——————— 42.——————— 43——————— 44——————— 45——————— 46——————— 47——————— 48
49505152
Page
iii-iv
6789
10
1112131415161718192223242526
27
2829
303132333435363738394142434445464748495052
53545556
"This manual supersedes Section II of ORD 7 SNL G245, 31 March 1958 and Changes No. 1, 21 April 1960
SECTION II ORGANIZATIONAL REPAIR PARTS - ContinuedPROPELLER DRIVE
MARINE DRIVE - EXPLODED VIEW————————————————————————————————————————— 53 57 STEERING BRACKET, SKEG BRACKET, AND PROPELLER - EXPLODED VIEW ————————————————— 54 58
SUSPENSION SYSTEM TPA^f PVPI f^nrn WIFW « ____ __________ _—_.___„_______ _-._—___.__—.__-____--. ___ <**\ **QI (\rt\_N CArLWLSCL' V ICVY ——«•——"———————»———™™— ———«——J.-.JIL___—___-.____—_ _ — ____..____-._____>. jj j-y
SPROCKET DRIVE - EXPLODED VIEW ——————————————————————————————————————— 56 61 FRONT SUSPENSION - EXPLODED VIEW ————————————————————————————————————- 57 63 INTERMEDIATE SUSPENSION - EXPLODED VIEW ——————————————————————————'-——"-—— 58 ' 65 REAR SUSPENSION - EXPLODED VIEW —————————————————————————————————————— 59 67
CONTROLS STEERING AND SHIFTING CONTROLS —————————————————————————————————————— 60 69
TOWING PINTLE - EXPLODED VIEW
SPARE WHEEL CARRIER (NON-ILLUSTRATED) ————————————————————————————————————————— 70 HULL
CARGO COMPARTMENT DOOR BUMPERS AND SEALS ————————————————————————————— 62 71
STOWAGESTOWAGE BUMPER AND CLIPS (NON-ILLUSTRATED) ———————————————————————————————————— 72
WINDSHIELD WIPERWINDSHIELD WIPER - EXPLODED VIEW —————————————————————————————————————— 64 . 73
WINCH
MISCELLANEOUS ACCESSORIESPERSONNEL HEATER (NON-ILLUSTRATED) —————————————————————————————————————————— 76 REAR VIEW MIRROR (NON-ILLUSTRATED) ——————————————————————————————————————————— 76 BILGE PUMP - EXPLODED VIEW ————————————————————————————————————————————— 66 77 SPEEDOMETER AND TACHOMETER ADAPTERS AND CABLES - EXPLODED VIEW —————————————— 67 78 VEHICLE DATA PLATES -I-^-^T-,^—m-_ _._______—.. _-—-----_. — - - ----- - r-__-__-r-r_.-.--__. 68 79
AUXILIARY POWER UNIT GENERATORAUXILIARY POWER UNIT GENERATOR AND ACCESSORIES —————————————————————————— 69 80 VOLTAGE REGULATOR HARNESS —————————————————————————————————————————— 70 81 FUEL SELECTOR VALVE, FUEL LINES, AND FITTINGS ————————————————————————————— 71 82 MUFFLER — •_•———-—-——--—-—————„_„_,-T-.__-.-.-ni-— —____—-_—__——-____—_——_______ 72 34EXHAUST HOSE AND MUFFLER BRACKET ————————————————————————————————————— 73 85 GOVERNOR AND THROTTLE CONTROL (NON-ILLUSTRATED) ——————————————————————————————— 86 MISCELLANEOUS ELECTRICAL ITEMS (NON-ILLUSTRATED) ———————————————————————————————— 86
REUSABLE CONTAINERREUSABLE CONTAINER (NON-ILLUSTRATED) ————————————————————————————————————————— 86
WINTERIZATION KITARCTIC VEHICLE WINTERIZATION KIT (NON-ILLUSTRATED) ——————————————————————————————— 86
SECTION III ORGANIZATIONAL SPECIAL TOOLS AND EQUIPMENT VEHICLE —————————————————————————— 74 88 SPECIAL TOOLS FOR VEHICLE ——————————————————————————————————————————— 75 90
SECTION IV INDEXESALPHABETICAL INDEX •—_~_-—-_-_—_»-————----—————-———-—-—_——™-_______—____ 90FEDERAL STOCK NUMBER INDEX ———————————————————————————————————————————————————— 96
VISUAL TABLE OF CONTENTS
TRANSMISSIONOIL COOLER
PAGE. 56TRANSMISSION
PAGE 53
SPROCKETDRIVE
PAGE 61
COOLING FANAND ROTOR HOUSINGPAGE 28
AIR CLEANER PAGE 16
MARINEDRIVE
PAGE 57
BATTERIES PAGE 35
CARGOCOMPARTMENT
DOORPAGE 71
FUEL CELL PAGE 15
MARINEDRIVE
PAGE 57
LEFT TAILLIG PAGE 45
POWER PLANT PAGE 6
'HEADLIGHTSPAGE 42
ENGINE OIL FILTER PAGE 9
TRANSMISSIONOIL FILTERPAGE 54
BLACKOUT MARKER LIGHT PAGE 44
WINCH PAGE 74
MARINE DRIVE PAGE 57
FUEL CELL PAGE 15
BILGE PUMP PAGE 77
RIGHT TAILLIGHT PAGE 46
PROPELLER PAGE 58
ORD E2501VISUAL TABLE OF CONTENTS
iii
VISUAL TABLE OF CONTENTS
REAR VIEW IMIRROR
PAGE 76
BLACKOUTHEADLIGHT
PAGE 43
HORN PAGE 36
SPROCKETDRIVE
PAGE 61
TRACK PAGE 59
FRONTSUSPENSION
PAGE 63
[SPOT LIGHT
I PAGE 49
MUFFLER ANDEXHAUST PIPEPAGE 27 | FUEL CELL
COVER PAGE 17
INTERMEDIATESUSPENSION
PAGE 65
SPARE
PINTLE HOOK PAGE 70
COMPENSATING WHEEL AND TIRE PAGE 67
TIRES ANDWHEELSPAGE 63, 65, 67
VISUAL TABLE OF CONTENTSiv
ORD E2500
SECTION I - PREFACE
INTRODUCTION
1. GENERAL, a. This manual Is an illustrated list of all Items required or authorized for organizational maintenance.
b. For prices of the Ordnance items listed herein, see the appro priate supply manual of the SM 9-2 series. Stock List of All Items - Price List. Prices of items that are the responsibility of technical services other than Ordnance may be obtained from the appropriate type 2 supply manuals for those services.
c. Additional applications of items in this manual are listed in the supply manuals of the SM 9-3 series, Stock List of Repair Parts.
2. REQUISITION NOTES, a. If the exact item requisitioned is not furnished, or if other action is necessary, the exact nature of the action taken by the supplying agency will be indicated by standard symbols on prescribed forms.
b. When requisitioning an item, the requesting agency will order the Fisted item. However, the supplying agencies will take necessary action to issue the exhaust stock item until stock is exhausted, whether it be an Individual items, kit, set, or assembly:
3. EXPLANATION OF COLUMNS, a. Source, Maintenance and Recoverability Code. This column lists a code that indicates the selection status and source of supply of the repair part, the lowest echelon capable of installing or manufacturing the repair part, and the recoverability andexpendability aspects of the repair part. An exam ple of this code isP-O-R. The "P" indicates that the item is a mission stockage list repair part that is procured and stocked on a national program basis, the "O" indicates that the repair part is authorized to first and second echelons, and the "R" indicates the part is a recover able, expendable item. When repair parts supply responsibility has been assigned to a technical service other than Ordnance, the basic number of the supplying technical service is listed in the first position of the source code, for example, "11" for a Signal Corps item. Refer to paragraph 8, for an explanation of all codes appearing in this man ual .
b_. Federal Stock Number. This column lists the Federal stock number which has been assigned by the Cataloging Division, Armed Forces Suppl y Support Center.
c. Description. The Federal item name (shown in capital letters) and any additional description required for supply operations are listed in this column. All dimensions listed are in Inches unless otherwise specified. For further identification, the technical service or manu facturers part number is parenthetically listed at the end of each no menclature.
d. Unit of Issue. The Unit of Issue column lists the actual unit of issue for each item (ea, ft, etc.).
e. Quantity Incorporated in Unit. The quantity shown in this column indicates the number of the listed item required for the par ticular use indicated. This quantity does not reflect the total quantity of the part required for the vehicle since that part may have other functional uses.
f. 15-Day Maintenance Allowance Per 100Equipments. No quan tities are listed in these columns. Refer to TM 9-2300-223-20P for allowance factors for items to be stocked. If an item appears herein and is not listed in TM 9-2300-223-20P, It can be requisitioned as required for immediate use only.
g_. Illustrations. The figure number subcolumn Identifies the il- lustration and the Item number is cross-referenced directly to the il lustration and keyed to a picture of the item.
4. HOW TO FIND PARTS. This manual is arranged by vehicular components (i. e., engine, fuel system, springs and shock absorbers, etc.). Non-illustrated items are listed with closely related items. Parrs may be located as follows:
a. Items of one component closely related to another component may be illustrated with the latter. For example, a spark plug, an electrical system part, could be shown on an engine illustration.
b. If the use, function or location of the part is known, refer to the contents page which will list the pertinent figure number and page. The part will be found on the illustration keyed to a listing on the facing page indicating the complete listing of the item.
c. The page location of major components and assembl ies Is I isted in tne Visual Table of Contents(iii-iv)tofacllltateuse of this manual.
5. ATTACHING PARTS. In some cases, non-Illustrated, attach ing and/or closely related items arelisted indented directly below the item to which they pertain.
6. PERTINENT PUBLICATIONS. The following publications per tain to this vehicle and its components:
PUBLICATION NO.
LO 9-7604
TM 9-7604
TITLE
Carrier, Cargo, Amphibious, M76
Operation and Organizational Maintenance: Amphibious Cargo Carrier, M76
7. ABBREVIATIONS AND SYMBOLS,
a. Abbreviations.
adj ——————————————————————————————— adjust(able) (ing) a| — ———————— ——————————————————————— aluminum al-alloy ———————————————————————————aluminum alloy alloy-S —————————————————————————————— alloy steel amp-hr ———————————————————— — —————— ampere hour(s) anld ——————————————————————————————— annealed asb —————————————————————————————————————— asbestos AWG ————————————————————————— American Wire Gage blk-fin —————————————————————————————————black finish blunt-pt ———————————————————————————————— blunt point br—————————————————————————————————————brass bz ——————————————————————————————————————— bronze cand-bay-base ———————————————————candelabra bayonet base cap. ———————————————————————————————————— capacity ca ————————————————————————————————————— cadmiumck ———————————————————————————————— countersunkcop. —————————————————————————————————— copper corr-res-S ——————————————————————— corrosion resistant steel cp ——————————————————————————————— candle power dble —————————————————————————————————— double dld-f/c-pin —————————————————————drilled for cotter pin exter ———————————————————————————————————— external fil —————————————————————————————————filament(s) fl —————————————————————————————————————————— f| atga ——————————————————————————————— ————— gage gal. —————————————————————————————————gallon(s) glvd ——————————————————————————————— galvanized gr ———————————————————————-•——————grade, grass, grain header-pt —————— ————————————————————— header pointij ___ _ ___ _ ...._, _ K-^J na ————————————————————————————————————— neaahols —————————————————————————————————— handle(s)hex-hd ———————————————————————————— hexagon head hv ————————-——————————————————————————————— heavy ins ————————————————————insulated, insulating, insulator int-ext-^eth ———————————internal-external teeth (lock washer) int-teeth ——————————————————————————— internal teeth |h —————————————————————————————————— | eft nandIg ———————————————————————————————— length (long)lr ————————__________ __ ____..___«.™™—™™—_ i jgntmed —————————————————————————————•———— mediummfd ——-«———-—————————————————— microfarad(s)
rn\ —————•-—••—————— ———————————— malleable iron
min-bay-base —-———————-————-«- miniature bayonet base
NC —————————————————American National Coarse ThreadNEF ———————————————— American National Extra Fine Thread NF --——-————-—-™———— American National Fine Thread
NPT ——————-——.-——.—__ American Standard Taper Pipe ThreadNPTF————————— American Standard Taper Pipe Thread (Dryseal) op ——————————————————————————— degree(s) Fahrenheit opng —«—————————————•——_——_______.__ openingpan-hd ——————————————————————————————————— pan head
psi ————————————————————————— pounds per square inchpt ————————————————————————-—_—.__ point, pint(s)
c ____._____________________«_„„_„____rr _______.__ steelsgle———————————————————————————————————————single sgle-cond ———•—————-————————————— single conductorsh-met-thd -———————-————————— sheet metal thread(s)
Sp g r —————————————————————————„——— specific gravity spst ———————•—--—•-———————•-- single pole, single throwsq-end —————————————————————————————————— square end sq-hd —————————————————————————————————— square head
term. —————————————————————————————————terminal
thk —————————————————————__————__————•— thickfness^tnd ——•——•—•———————————————————————— tinnedtnd-cop. ———-—-—-———-———-——•——————————-tinned copper UNC ——————————————————————————— Unified Coarse Thread UNF —————————————————————————————Unified Fine Thread w ,—-——_„_____.—__——__________———--wide, width, watt(s)
w/o ——•—————————————————————————— withoutwrppd ————•———————-———————.————-——— wrappedwt —-———————•——-———--—.-————————————— weight
UNC ———————————————————————— Unified Coarse Thread.. ,___ ___ ___ ______ .___——— ___ ______ ___ ——— WAltlMv ———————————————————————————————————————— voirysjzn-pltd —-—•—••——-———————————————--_ zinc plated
Indicates items authorized for replacement, but not au thorized for stock.
As required.
tV Indicates items available separately.
#* Indicates items available as part of listed PARTS KIT.
8. EXPLANATION OF COOES,
a. Technical Service Baste Number Code.
5 Corps of Engineers
10 Quartermaster Corps
11 Signal Corps
55 Transportation Corps
b. Source Code.
P Applied to repair parts which are high mortality parts procured by technical services, stocked in and supplied from the technical service depot system, and authorized for use at indicated maintenance echelons.
C Applied to repair parts author! zed for local procurement. If not obtainable from local procurement, such repair parts will be requisitioned through normal supply chan nels with a supporting statement of nonavailability from local procurement.
X2 Applied to repair parts which are not stocked. The in dicated maintenance echelon requiring such repair parts will attempt to obtain from salvage; if not obtainable from salvage, such repair parts will be requisitioned with support justification through normal supply channels.
c. Maintenance Code.
O Assigned to all repair parts authorized to first (1st) and second (2nd) echelon.
d. Recoverability Codes.
R Indicates a repair part or assembly that is expendable and recoverable and is economically repairabTe^ ana^ when available, is furnished by supply on an exchange basis.
NR Indicates a repair part or assembly that is non-expend able and recoverable and is economical I y repairable.
9. MANUFACTURER'S SYMBOLS.
Symbol Former Symbol _______ MS Military Standard FSSN
Manufacturer
80244 General Service Administration
10. SUGGESTIONS AND RECOMMENDATIONS. Notice of dis crepancies and recommendations for additions and deletions of repair parts and special tools should be forwarded on DA Form 2028 to Com manding Officer, Raritan Arsenal, Metuchen, New Jersey, ATTN: ORDJR-OPRA.
FIGURE 1-CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN) LEFT FRONT VIEW
ORD E2154
FIGURE 2-CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) LEFT "FRONT VIEW""
3
FIGURE 3-CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN) RIGHT REAR VIEW
ORD E2155
FIGURE 4-CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) RIGHT REAR VIEW
4
FIGURE 5-CARRIER, CARGO, AMPHIBIOUS: M76 (EARLY DESIGN) TOP VIEW
\
ORD E2156
FIGURE 6-CARRIER, CARGO, AMPHIBIOUS: M76 (LATE DESIGN) TOP VIEW
5
(1)
ILLUST
(a)
FIG NO
7
(bl
ITEM NO
1
(2)SOURCE, AAAINT
AND RECOVERABILITY
CODE
(a)
_• 0
li•- s
(bl
|
P
P
IdMAINTENANCE
IEVEL
0
0
Id)
IECOVEIAIIIITT
(3)
FEDERALSTOCK
NO
2805-7ltl-63U9
(4)
DESCRIPTION
SECTION II
ORGANIZATIONAL REPAIR PARTS
ENGINE
POWER PLANT (Fig. 7}
NON-ILLUSTRATED ITEM
HOOK: lifting (7Ul63U9) - — --————-—--—-———————--
(5)
UNITOF
SSIIF
ea
(6)
OTYINCIN
UNIT
1
(7)1 5-DAY MAINT
ALW PER 100 EQUIP
la)
OS U
(bl
Sljjj"S"
ORD E2157
FIGURE 7-POWER PLANT
6
(1)
IlLUST
la]
FIGNO
8
8
8
8
Ib)
ITEMNO
1
2
34
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
lal
_. 0
li"~(b)
M
i
pppp
(c)
B2 =J|5*
0
0
0
0
Id)
e.11K
(3)
FEDERALSTOCK
NO
2990-753-8641
5310-796-5497
5340-205-5762
5310-O45-1026
<4)
DESCRIPTION
POWER PLANT TORQUE REACTION LINK (Fig. 8)
CUSHION: povrer plant torque (7538641) ———————————————————
WASHES, FLAT: plain, 21/32 Id, 2-1/4 od, 3/32 thk (7965497) ————
BOLT: 5/8-28NF-2 x 6-1/4 (7965496) ————————————————————
NUT, SELF-JJOCKEKG, HEXAGON: S, 5/8-18UNF-2B, 15/16 v, 35/64 thk(451027)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
2
1
1
(7)15-DAYAAAINT
ALW PER 100 EQUIP
(a)
oeg£
(b)j_
u at uSiSin:
[ORD E2158
FIGURE 8-POWER PLANT TORQUE REACTION LINK-EXPLODED VIEW
7
(1)
ILLUST
la)
FIGNO
9
9
9
9
Ib)
ITEMNO
1
2
U
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
S?
-5
•5
Ib)
HJ
S
P
P
P
Ic)
Ssi
0
0
0
Id)
s3
(3)
FEDERALSTOCK
NO
2805-7'H-5303
"•730 -277-6856
U730-278-2066
(4)
DESCRIPTION
CYLIUDER BARREL AND ROCKER VALVE COVER (Fig. 9)
NOZZLE: priming system Jet, assy (5165173) ———————————————— •
NIPPLE: hose, br, 1 in. hose, 3/1* male pipe end (valve rocker oildrain)
CLAMP, HOSE: adj, band type, 8, 1-3/8 to 1-5/8 id (valve cover oildrain (k) and valve rocker cover oil drain pipe (8))
(5)
UNIT OF
SSUF
ea
ea
(6)
QTY INCIN
UNIT
U
2
12
(7)15-DAYMAINT
ALW PER 100 EQUIP
la)
n >-o£u
Ib)
3z5u ™ss»8
'ORD E2159!
FIGURE 9-CYLINDER BARREL AND ROCKER VALVE COVER-EXPLODED VIEW
(1)ILLUST
to)
FIGNO
10
10
10
10
10
10
10
10
10
10
10
Ib)
ITEMNO
1
2
3
4
5
6
7
8
9
9
10
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
<ol
< Xii(b)
aI
P
P
P
P
P
P
P
P
P
P
P
Iclu<E
|l
0
0
0
0
0
0
0
0
0
0
0
Id)ei1
R
(3)
FEDERALSTOCK
NO
2Q40-734-7480
2940-202-6064
5310-050-2245
5310-022-5.853
5310-010-7822
5310-205-9621
4730-741-6239
5310-010-5453
5307-776-7804
5307-776-7805
2940-741-6238
(41
DESCRIPTION
OIL FILTHS (Fig. 10 )
ELEMENT: PACK (8382931) ————————————————————————— ——
WASHER, FIAT: S, 21/64 id, 9/l6 od, 0.063 thk (special) (502245)
NUT, PLAIN, HEXAGON: alloy-S, 5/16-24UNF-2B, 1/2 v, IT/64 thk(225853)
NUT, STAMPED: hex, 9-notch, S, 5/16-24UNF-3B, 1/2 w, 0.120 thk(107822)
WASHER, FIAT: oil filter pack (8382932) —————————————
PLUG: drain, housing, hex-hd, S, 5/8-18NF-3 (7416239) — — — — —
GASKET: annular, cop. and asb, 5/8 dia (105453) ——— — — —— —
STUD, PLAIN: 5/16-18NC x 5/16-24NF-3 x 1-5/16 (0.003 oversize)(7767804)
STUD, PLAIN: 5/16-18NC x 5/16-24NF-3 x 1-5/16 (0.007 oversize)(7767805)
GASKET: mounting (7416238) ——————————————————
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
15
4
4
4
16
1
1
4
4
1
(7)1 5-DAYMAINT
ALW PER 100 EQUIP
lol
O >OS u
(b)^_
D z cijb"
ORD E2160FIGURE 10-OIL FILTER-EXPLODED VIEW
9
(1)
IILUST
lol
FIGNO
11
11
11
11
11
11
11
Ibl
ITEMNO
1
2
2
3U
5
6
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
lol
3g
Si
5
Ibl
u.
a
pp
p
pppp
pp
Icl
S£
I"
0
0
0
0
0
0
0
0
0
Id)S11Si
R
(31
FEDERALSTOCK
NO
2930-798-0268
U730-278-U825
U730-278-U825
2930-798-0267
2805-798-0132
2520-798-0538
2930-798-0266
2805-7U1-5302
U730-277-9732
U)
DESCRIPTION
OIL COOLER (Fig. 11)
LINE: oil, flexible, transmission to engine oil pan (7980268) ——
ELBOW, PIPE TO TUBE: compression, safety sleeve, U5 deg, S, 3/Utube, 3/U male pipe end (engine oil cooler inlet and outlet hose)(U23180)
ELBOW, PIPE TO TUBE: compression, safety sleeve, U5 deg, S, 3/Utube, 3/U male pipe end (transmission to engine oil pan, oilline) (1*23180)
HOSE: oil, flexible, engine oil cooler, outlet, assy (79&0267) —
ELBOW: oil filter, v/integral FIANCE (7980132) —————————————
COOLER: oil, assy (7980538) ——————————————————————————
HOSE: oil, flexible, engine oil cooler, inlet, assy (7980266) ——
NON-ILLUSTRATED ITEMS
GASKET: crankcase, oil, outlet tube (7U15302) —————————————
SLEEVE: safety, compression tube fitting, S, 3/U in. (engine oilcooler inlet and outlet oil hose)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
1
1
1
1
1
1
U
(7)15-DAYMAINT
ALW PER 100 EQUIP
lol
Of
OS«J
Ibl
ozoUCDUJ
};8i«
ORD E2161
FIGURE 11-OIL COOLER 10
(1)ILLUST
lo)
FIG NO
12
12
{bl
ITEM NO
1
2
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la]
1~11-S!
[bl
§g
P
P
P
P
P
P
Ml~
Is5E SS
0
0
0
0
0
0
(d>e1£
R
(3)
FEDERALSTOCK
NO
2910-71*1-6266
5310-022-5851
5310-010-7821
5307-71*1-5375
5310-050-2266
2910-71*1-61*02
(4)
DESCRIPTION
FUEL SYSTEM
FUEL INJECTOR PUMP (Fig. 12)
PUMP: fuel injector, assy (71*16266) ———————————————————
NUT, PLAIN, HEXAGON: S, 1/1*-28UNF-SB, 7/l6 v, 7/32 thk (22585JJ
NUT, STAMPED: hex, 6-notch, S, 1/U-28NF, 7/16 v, 0.110 thk(1078S1)
STUD, PLAIN: S, 1/1*-20NC 9/16 x l/l*-28NF-3 (1/2) X 2-3/16(0.003 oversize) (71*15375)
WASHER, FIAT: aircraft std, S, 17/61| id, 1/2 od, 0.06lt thk,I/I* screv size (502266)
GASKET: mounting, pump (0.012 thk) (71"l61t02) ———————————
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1*
It
It
1
(7)1 5-DAYMAINT
AlW PER 100 EQUIP
la)
onOo
Ibl
Sijf5; iu a:Vt</> °
ORD E2162
FIGURE 12-FUEL INJECTOR PUMP-EXPLODED VIEW
11
(1)
ILLUST
(o>
FIGNO
13
5-3
(bl
ITEM
i
r-
(2)SOURCE, MAINT
AND RECOVERABILITY
CODE
lal
S?
i|
Ibl
«S
r
p
tcl
%
n
0
(d)
es1
(3)
FEDERALSTOCK
NO
3210-1*5-2213
**>"****
(4)
DESCRIPTION
FUEL IXTKJTOR NOZZLE (Tic- 13)
KOZZLE: fuel injector (7Ul62'('t) —————————————————————————
(5)
UNIT OF
ISSIIF
ea
ea
(6)
QTY INCIN
UNIT
It
k
(7)15-DAY MAINT
ALW PER 100 EQUIP
(a)
«tt
On U
(bl
ozo""S
ssg
i—n
ORD E2163
FIGURE 13-FUEL INJECTOR NOZZLE-EXPLODED VIEW
12
(1)
IlLUST
la)
FIGNO
14
14
14
14
14
Ib)
ITEMNO
1
2
3b
5
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODEla)
g£
11
(b)
3
i
pp
p
p
pppp
p
Id
* a* £r
0
0
0
0
0
0
0
0
0
Id)
ESilECOVEUI
R
(3)
FEDERALSTOCK
NO
2910-741-6325
5310-022-5853
5307-776-7804
5307-776-7805
5310-012-0214
2910-737-6909
5305-737-6915
4730-74l-66o6
2910-741-5354
(4)
DESCRIPTION
ENGINE FUEL PUMP (FIG. 14)
PUMP: fuel, assy (Titan Model 200-type H2 x 3-15) (7416325) ———
NUT, FLAM, HEXAGON: S, 5/l6-24uNF-2B, 1/2 w, 17/64 thk(225853)
STUD, PLAIN: S, 5/16-18NC (5/8) x 5/16-24NF-3 (1/2) x 1-5/16(0.003 oversize) (7767804)
STUD, PLAIN: S, 5/16-18WC (5/8) x 5/16-24NF-3 (1/2) x 1-5/16(0.007 oversize) (7767805)
HASHER, LOCK: split, S, 5/16 screw size (120214) ————————
GASKET: pressure adjusting screw (7376909) —————————————
SCREW: adjusting, pressure (7376915) ————————————————
BUSHING, REDUCER: fuel pump, outlet and inlet (al-alloy, hexshoulder, 3/4 x 1/4) (7416606)
GASKET: mounting (7415354) ————————————————————————
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
4
4
4
4
1
1
2
1
(7)15-DAY AAAINT
AI\A/ PFDALW rCK100 EQUIP
la)
o >-oilu
Ib)
OZC
ssi
ORD E2164i=iGURE 14-ENGINE FUEL PUMP-EXPLODED VltW
13
(1)
ILLUST
(o)
FIG NO
15
15
Ib)
ITEM NO
(2)
SOURCE, MAINT AND
RECOVERABILITY CODE
la)
gs§—&
-S -S
(b)
1
P
P
MAINTENANCE - lEVEL -
0
0
HKOVEHAiaiTY S
R
R
(3)
FEDERAL STOCK
NO
2910-776-1709
2910-699-7904
(4)
DESCRIPTION
FUEL CELL FUEL PUMP (Fig. 15)
PUMP: fuel, assy (IUD, then use PUMP 2910-699-790!*) (7761709) __
(5)
UNIT OF
ISSUE
ea
ea
(6)
QTY INC IN
UNIT
2
2
(7) 15-DAY MAINT
ALW PER 100 EQUIP
tol
PIb)
8S2S«s
ORD E2165
FIGURE 15-FUEL CELL FUEL PUMP-EXPLODED VIEW
IS
p 3
P v
og
S
TECH
NICAL
7
SEWI
CE N
O. -
SOUR
CE
Z
MAINT
ENAN
CE -
lEVt
t .
-HE
COVE
RABIU
TT g
S g
n§
>S
Om
§m
3 5
^!i8l
CO
OR
-
BTRY
2-
SEP
CO
SE
P BN
5
OR
RE
GT
(1)
IlLUST
lo)
FIGNO
17
17
17
Ib)
ITEMNO
1
2
3
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
lo)
_, 0
1^Ibl
of
i
ppp
pp
pp
p
p
p
Ic)
i-£ §2X 5
0
0
0
0
0
0
0
0
0
0
Id)
1I
i
13)
FEDERALSTOCK
NO
2940-753-9079
?94o-797-6821
2940-753-9080
291(0-798-0168
5310-045-1011
5305-018-1643
5310-012-0394
4730-350-9848
29140-798-0058
5307-734-8669
(4)
DESCRIPTION
AIR CLEANER (Fig. 17)
CLAMP: retaining, oil cup (7539079) —————————————————————
SCREEN* air cleaner f T9T682L )
GASKET: sealing, oil cup (7539080) ——————————————————————
NON-ILLUSTRATED ITEMS
BAND: supporting (7980168) ————————————————————————————
NUT. SELF-LOCKirc, HEXAGON: S, 3/8-24UHF-2B, 9/l6 v, 21/64 thk (451011)
SCREW, CAP, HEXAGON HEAD: 3/8-24UNF-2A X 1-1/2 (l8l643) .........
WASHER, FLAT: It, S, 13/32 id, 13/16 od, 0.065 thk, 3/8 screwsize (120394)
CLAMP, HOSE: adj, band type, S, 3-7/8 to U-l/8 id (air intake)(502929)
SPACER: al-alloy, 0.1»O6 dia shaft, 1.250 od, 0.820 thk (air clean er supporting band bolt) (7980058)
STUD, PLAIN: control valve, air inlet elbow (7348669) .............
(5)
UNITOP\jr
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
1
2
It
U
U
h
U
2
(7)1 5-DAYAAAINT
ALW PER 00 EQUIP
la)
O>OS
Ib)
oz5umu
ssg
ORD E2167FIGURE 17-AIR CLEANER-EXPLODED VIEW
(!)
ILLUST
lal
FIGNO
18
18
18
18
18
18
18
18
Ib)
ITEMNO
1
2
3
k5
6
7
8
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
lal
j!||
5
Ib)
2g
ppp
ppppp
Ic)
U
z =J
1^
0
o0
0
0
0
0
0
Id)S3
!
R
(3)
FEDERALSTOCK
NO
1*730-278-3391
2910-797-5707
1*730-237-8316
6680-797-6721
6680-797-5712
5310-012-0380
5305-012-31*56
(4)
DESCRIPTION
FUEL CELL COVER (Fig. 18)
PLUG, PIPE: sq.-nd, S, 1/2 in. ......................................
GASKET: fuel tank fuel pump filter (7975707) ——————————
ADAPTER, STRAIGHT, PIPE TO TUBE:- compression, safety sleeve, S,1/1*-NPTF male pipe end, 3/8 od tube end (engine return line(2) and engine supply line (6)) (189921)
UNIT: sending, fuel tank level gage, assy (7976721) ——————— - ——
GASKET: fuel tank level gage (7975712) ————————————
WASHER, LOCK: split, S, 1/U screw size (120380) —————————
ELBOW: tube, compression, safety sleeve. 90 deg, S, 3/8 tube, 1/Umale pipe end (fuel injector cover (1) and fuel pump (2))(189929)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
1*
8
2
2
12
12
3
(7)15-DAYMAINT
ALW PER 100 EQUIP
(a)
(XL
o£ u
(b)
O Z CU a* u
8! Kg
1333
ORD E2168
FIGURE 18-FUEL CELL COVER-EXPLODED VIEW 17
(1)
ILLUST
(a)
FIG NO
19
19
19 19
19 19 19 19
19
19 19
Ibl
ITEM NO
1
2
1*
5 6 7 8
9
1011
(2) SOURCE, MAINT
AND RECOVERABILITY
CODEla)
gg
Ibl
S3
P
P
P P
P P P P
P
P P
P P P P P
MAIHTEMHCE - UVEL -
0
0
0 0
0 0 0 0
O
0 0
0 0 0 0 0
RECOVEUBIimr §
(3)
FEDERAL STOCK
NO
2910-797-51*27
2910-71*1-6263
2910-71*1-61*11 1*730-278-1*61*1*
2910-71*1-6571 2910-71*1-6326 2910-797-5'*26
2910-71*1-61*10
2910-71*1-61*08 2910-797-51*25
2910-71*1-61*06 2910-71*1-61*05 2910-71*1-6572 1*730-71*1-5352 l*730-7l*l-531*6
(4)
DESCRIPTION
ENGINE FUEL LINES (Fig. 19)
LINE: flexible, engine return line coupling to engine fuel in jector pump (79751*27)
LINE: return, fuel injector pump, assy (IUD, then use (2) FITTING 1*730-277-9729, (2) NUT 1*730-351-01*50 and (17 in.) TUBE 1*710-200- 0308) (7H6263)
LINE: supply, fuel injector nozzle, cylinder no. 1*, assy (71*161*11) ELBOW, PIPE TO TUBE: 1*5 deg compression, safety sleeve, S, 1/8NPTF
male pipe end, 3/16 od (fuel injector nozzle supply line, cylinders no. 1, 2 and 3) (1*23157)
LINE: supply, fuel injector nozzle, cylinder no. 2, assy (71*161*09)
LINE: flexible, engine supply line coupling to engine fuel pump, assy (79751*26)
LINE: supply, fuel injector nozzle, cylinder no. 3, assy (IUB, then use (2) PITTINO 1*730-277-9726, (2) NUT 1*730-595-1*830 and (35 in.) TUBE 1*720-350-9896) (7M61*10)
LINE: supply, fuel injector nozzle, cylinder no. 1, assy (71*161*08)
NON-ILLUSTRATED ITEMS
TEE: primer system jet (1/8 tube) (71*15352) —————————— ——TEE: union, primer fuel line (br, 5/16-32NF-3 exter-thd, 1/8 tube)
(cylinder no. 1 and 2) (71*1531*6)
(5)
UNIT OF
SSUE
ea
ea
eaea
ea ea ea ea
ea
ea ea
ea ea ea ea ea
(6)
QTY INCIN
UNIT
1
1
1 3
1 1 11
1
1 1
211 21
(7) 1 5-DAY MAINT
ALW PER 00 EQUIP
(a)
o£U
Ib)
8IS•> "* C
ORD E2169FIGURE 19-ENGINE FUEL LINES
18
(1)
ILLUST
la)
FIG NO
20
2020
20
2020
20
20
2020202020
Ib)
ITEM NO
1
23
It
56
7
8
910111213
(2)SOURCE, MAINT
ANDRECOVERABIUTY
CODEla]
3 sz H
g|
(b)
B
i
p
p p
pppppppppppp
<c)
1g s
0
0 0
00000
0
0
00000
Id)
E
3 s
(3)
FEDERALSTOCK
NO
4730-278-1*310
U820-7U1-106UU730-797-6755
2910-797-675U5305-012-3U355305-012-03802910-797-5761U73Q-351-OU50
5310-208-5255
U730-797-6052
U730-797-5930U730-797-59295305-013-29085310-012-02175310-012-o6lU
(4)
DESCRIPTION
VEHICLE FUEL LIKES (Fig. 20)
ADAPTER, STRAIGHT, PIPE TO TUBE: compression, safety sleeve, S,1/8-HPTF male pipe end, 1/U od tube end (l over-all Ig) (primeroutlet fuel line (l) and heater fuel line (6)) (189920)
VALVE: selector, heater fuel, assy (7U1106U) ———————————————TEE, TUBE: engine return line valve and engine supply line check
valve (compression, safety sleeve, S, 3/8 tube, 3/8 female pipeend) (7976755)
VALVE: engine return line, assy (797675U) —————————————————SCREW, CAP, HEXAGON HEM): S, 1/U-28UNF-2A x 5/8 (123U35) ——————WA3HER, LOCK: split, med, S, 1/U screw size (120380) ————————
VALVE, CHECK: engine supply line, assy (7975761) ————————————NUT, TUBE COUPLING: compression, safety sleeve, S, 3/8 od tube,
5/8 over-all Ig (189898)HUT, PLAIN, HEXAGON: S, 5/8-18UNF-2B, 13/16 v, 1/U thk (engine
return line (3) and engine supply line (3)) (190785)TEE, TUBE: engine supply line coupling (compression, safety sleeve,
S, 1/U tube, 1/U male pipe end) (7976052)COUPLING: engine supply and return line (7975930) ———————————COUPLING: fuel line (7975929) —————————————————————————SCREW, MACHINE: rd-hd, S, no. 10 (0.190)-32NF 2A x 1/2 (132908) ——WASHER, LOCK: split, S, no. 10 (0.190) screw size (96906-35338-2U)NUT, PLAIN, HEXAGON: S, no. 10 (0.190)-32HF-2B, 3/8 w, 1/8 thk
(1206lU)
(5)
UNITOF
ISSUE
ea
eaea
eaeaeaeaea
ea
ea
eaeaeaea
(6)
QTYINCIN
UNIT
7
12
2322
3U
6
1
2133
(711 5-DAYMAINT
ALW PER100 EQUIP
(a)
°5O = (_»
Ib)
812Si Si"w»«»c
FIGURE 20-VEHICLE FUEL LINES 19
II)ILLUST
la)
FIGNO
Ib)
ITEMNO
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODE
lal
^0
—— U4
il
5
11
5
5
5
5
5
5
Ib)
3
i
pp
p
pp
p
p
p
p
p
pp
p
p
p
p
p
pp
(c)
g!=:I 5
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
(d)I1
(3)
FEDERALSTOCK
NO
U730-090-911U
U730-050-1105
1*730-277-8758
U730-090-9112
U730-193-0867
5975-057-3025
531*0-282-751*2
1730-1*96-0004
5340-543-3915
5340-797-6775
5340-797-6058
U730-797-6048
4730-278-5576
4730-797-6060
4730-278- 38UU
4730-278-3844
4730-278-3854
4730-202-69794730-277-9729"
(4)
DESCRIPTION
VEHICLE FUEL LUES (Fig. 20) - Continued
MOK-ILLUSTRATED ITEMS
ADAPTER: fuel line hose (7350991) ———————————————————————
ADAPTER, STRAIGHT, PIPE TO TUBE: soldered sleeve, br, 1/8NPTmale pipe end, 1/8 od tube end (fuel filter outlet) (501105)
ADAPTER, STRAIGHT, PIPE TO TUBE: compression, safety sleeve, S,1/8NPTF male pipe end, 3/l6 od tube end (480873)
ADAPTER: fuel line hose (7064755) ———————————————————————
BUSHING, PIPE: MI, black, outside hez, l/4-l8HFT male, 1/8-27NFTmale, 1/8-27NPT female (Fed Spec WH-P-Vfl, type I, fig 11)(heater fuel lines)
CLAMP, ELECTRICAL: loop type, cushioned, S, 1/8 od tube, hole for 5/16 bolt size (primer tube) (cylinder no. 1 (l) and crankcasecover (2)) (573025)
CLAMP, ELECTRICAL: loop type, S, 1/U od tube, hole for 1/4 bolt(heater fuel lines)
CLAMP, ELECTRICAL: closed, cushioned, S, 3/8 od tube, hole for1-1/U bolt size (fuel pump supply Una and fuel injector pumpreturn line)
CLIP: open, cable, conduit or pipe, S, MI, 1/4 od tube, hole for no 10 screw size (fuel tank fuel line) (191754)
CLIP: open heater fuel line to engine cooling air inlet duct(1/8 od tube, hole for 1/4 bolt size) (7976775)
CLIP: retaining, engine supply and return lines (7976058) ——————
ELBOW: engine return line (2) and engine supply line (2) (tube,compression, safety sleeve, 90 deg, S, 3/8 tube, 1/U male pipe end) (7976048)
ELBOW, PIPE TO TUBE: 45 deg, compression, safety sleeve, S, 1/4-HPT male pipe end, 3/8 od tube end (fuel filter to fuel injec tor pump supply line) (U23l60)
ELBOW: heater fuel linn (tube, compression, safety sleeve, 90 deg S, 1/4 tube, 1/8 male pipe end) (7976060)
ELBOW: tube, compression, safety sleeve, 90 deg, S, 1/U tube,1/8 male pipe end (primer lines)
ELBOW: tube, compression, safety sleeve, 90 deg, S, 1/4 tube,1/8 male pipe end (heater fuel line) (on tank cover)
ELBOW: tube, compression, safety sleeve, 90 deg, S, 3/8 tube,1/4 male pipe end (fuel lines)
FITTIHG: safety, compression tube, S, 1/4 in. (fuel lines) —————
FITTING: safety, compression tube, S, 3/8 in. (fuel lines) — — —
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
5
i3
3
15
2
2
1
12
4
1
4
3
2
8
4
28
(7)15-DAYAAAINT
AlW PER 00 EQUIP
la)
«txos
u
Ib)
OZOu-Ssag
20
(1)
ILLUST
(al
FIGNO
Ib)
ITEMNO
,
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODEla)
|S
5
5
5
5
5
5
(bl
i
p
pp
p
p
p
p
p
p
p
ppp
p
p
p
pp
Ic)
S
jl
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Id)
11 KUnml
(3)
FEDERALSTOCK
NO
1*730-277-9726
1*730-202-6979
1*730-277-9729
1*730-289-1122
1*730-018-9891*
1*730-278-51*53
5310-208-5258
1*730-595-1*830
1*730-018-9891*
1*730-278-3388
1*730-278-0833
1*710-277-5525
1*720-350-9896
1*710-277-5527
1*710-200-0308
2910-71*1-61*01*1*820-797-61*03
(4)
DESCRIPTION
VEHICLE FUEL LINES (Fig. 20) - Continued
NON-ILLUSTRATED ITEMS - Continued
FITTING: safety compression tube, S, 3/l6 in. (fuel injectornozzle supply line)
FITTING: safety, compression tube, S, 1/1* in. (heating fuel lines)
FITTING: safety, compression tube S, 3/8 in. (engine supply line(6) and fuel injector pump return lines (2) )
HOSE, RUBBER: hyd, sgle wire braid reinforcement (oil and greaseresistant) low temp (-650 F) 3/8 id (15-1/2 Ig) (fuel lines)(802l*l*-33-H-133-15)
LINE: primer inlet (fabricate from (21 Ig) TUBE 1*710-277-5525) ——
LINE: primer outlet (fabricate from (22 Ig) TUBE 1*710-277-5525) ——
NIPPLE, TUBE: bulkhead, compression, safety sleeve, S, 3/8 in.(engine return line and engine supply line)
NUT, TUBE COUPLING: compression, safety sleeve, S, 1/1* od tube,9/l6 over-all Ig (fuel lines) (18989!*)
NUT, TUBE COUPLING: solder sleeve, br, 1/8 od tube, 0.1*38 over-allIg (fuel lines) (5165169)
NUT, PLAIN, HEXAGON: S, 1/2-20NF-2B, 11/16 w, 1/1* thk (heater fuellines) (190784)
NUT, TUBE COUPLING: compression, safety sleeve, S, 3/l6 od tube,7/16 over-all Ig (190756)
NUT, TUBE COUPLING: compression sleeve, S, 1/1* od tube, 9/l6 over all Ig (heater fuel lines) (18989!*)
PLUG, PIPE: scj-hd, S, 1/8 in. (heater fuel shut-off cock) — —— —
SLEEVE: solder tube fitting, corr-res-S, 1/8 in. (fuel lines) ———
TUBE, COPPER: seamless, cold drawn, soft anld, 1/1* od, 0.035 wall thk (heater fuel lines) (802l*l*-l*l*-T-5o80-15)
TUBE, STEEL: cold drawn, dble wrppd, cop. br, 3/16 od, 0.028 wall thk (35 in.) (8o2l*l*-l4*-T-5319-55)
TUBE, COPPER: seamless cold drawn, soft anld, size 3/8 0.375 od,0.035 wall thk (802l*l*-l*l*-T-5080-25)
TUBE, STEEL: cold drawn, dble wrppd, cop. br, 3/8 od, 0.035 wallfcbi (air reservoir port no. 15 hydraulic lock) (17 in.) (802U1*-l*!*-T-5319-72)
TUBE: filter to primer tee (7l*l61*0l*) ——————————————VALVE, GATE: stght way, br, 1/8NPTF female pipe ends (shut-off
heater fuel) (79761*03)
(5)
UNITOF
SSUE
ea
ea
ea
ft
ea
ea
ea
ea
ea
ea
ea
ea
ea
ft
ft
ft
ea
ea
(6)
QTYINCIN
UNIT
8
18
8
y
2
1*
10
1*
8
18
1
10
/'f
j
11
(7)15-DAYAAAINT
ALW PER00 EQUIP
lo]«
P
Ib)
Jzi:ii;
21
(1)
ILLUST
1°)
FIGNO
21
21
21
Ib)
ITEMNO
1
2
3
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla]
gS
if
(b)
M
3
P
P
P
P
P
Mu
II S
0
0
0
o
0
Id)
£
2s
R
(3)
FEDERALSTOCK
NO
5306-7U-511U
2940-71(1-61(1(3
5305-21(5-0326
(4)
DESCRIPTION
ENGINE FUEL FILTER (Fig. 21)
FILTER: fuel, assy (741641(0) ------------------------------------
BOLT: fuel filter (hex-hd, S, 1/4-28NF-3 x 2-25/32) (7415111)) — —ELEMENT: fuel filter (7kl6kk3)~ — —— —— —— —— — —————
NON-ILLUSTRATED ITEMS
ELBOW: tube, compression, safety sleeve, 90 deg, S, 3/8 tube,1/1( male pipe end (fuel filter inlet and outlet) (189929)
STUD, PLAIN: bracket in crankcase, S (1/4-20NC (1/2) x l/li-28NF-3 (15/32) x 1-7/6U) (0.003 oversize) (7U.5369)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
1
2
3
(7)15-DAYMAINT
ALW PER 100 EQUIP
(a)
oco 2OS
(bl
OZOU.uj
SS«
ORD E2171FIGURE 21-ENGINE FUEL FILTER-EXPLODED VIEW
22
(1)
ILLUST
la)
FIG NO
22
22
22
(b)
ITEM NO
1
2
3
(2)SOURCE, MAINT
ANDRECOVERABIL1TY
CODEla)
1-S|
5
Ibl
15
P
P
P
P
P
P
P
Ic)
g
1"
0
o
0
0
0
0
0
Id)
g=21
R
(3)
FEDERALSTOCK
NO
2910-776-1059
2910-71*1-6510
5330-265-1089
1(730-050-1105
2910-797-5707
U73O-O11-3175
5310-7l*l-62l;6
(4)
DESCRIPTION
FUEL PRIMER FILTER (Fig^ 22j
FILTER, FLUID PRESSURE: primer (7761059) ———————————————————
ELEMENT: w/SPRING, assy (832861*7) ——————————————————————————
PACKING, PREFORMED: "0" ring, hydro-carbon, fuel resistant, 0.103thk, 1.299 id (802W*-29513-125)
NON- ILLUSTRATED ITEMS
ADAPTER, STRAIGHT, PIPE TO TUBE: solder sleeve, br, 1/8 od tube, end, 1/8-NPT male pipe end (primer fuel filter outlet) (501105)
GASKET: fuel tank, fuel punp filter (7975707) ————————————————
PLUG, PIPE: br or bz, sq-ttd, 1/8-27NPT (Fed Spec WW-P-1*71, type111) (primer)
RING, LOCK, SERRATED: filter screw insert, S, for insert w/5/16outer thd (71*1621*6)
(5)
UNIT OF
ISSUE
ea
ea
ea
ea
ea
ea
ea
(6)
QTY INCIN
UNIT
1
1
1
1
1*
1
2
(7)1 5-DAYMAINT
ALW PER100 EQUIP
(a)
Of.°lOS
(b)
8S2S; fc"tn ">Q
FIGURE 22-FUEL PRIMER FILTER-EXPLODED VIEW
23
(1)ILLUST
(a)
FIG
23
23
23
23
23
23
23
23
23
23
23
Ib)
ITEM
1
2
3It
56
78
910
11
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE(a)
*sil
(b)
aa
ppp ppppppcp
p
M
gi b0
0
0
0
0
0
0
0
0
0
0
Id)^5
i
B
(3)
FEDERALSTOCK
NO
2910-039-7820
2910-360-3675
5330-360-367*
5355-770-0819
2910-360-3670
53ltO-321-6078
531(0-360-3677
5305-52l(-5639
531*0-1196-1910
1*730-709-7362
2910-703-3653
5330-171-6983
(4)
DESCRIPTION
FUEL PRIMER (Fig. 23)
GLAHB: plunger packing (521*561*0) ——————————————————— ———
SPRING, HELICAL, COMPRESSION: diaphragm cap (8376566) ————————
SPRING, HELICAL, COMPRESSION: check valve outlet chamber (521*5638
PLTJB, MACHINE IHREAD: outlet chamber check valve (521*5639) -------CUP: plunger (leather) (7037062) —————— ————————————————
CONNECTOR: outlet (52U5655) -—-——-— ———----—-——
CONNECTOR: fuel inlet v/BALL and SPRING, asay (7033653) — — — —— —
HON- ILLUSTRATED ITEMPACKEKO: leather (83761*65) ——————————— ————————————— ——
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
<6>
OTYINCININIT
1
1
1
1
1
1
1
1
1
1
1
1
(7)15-DAYUAIkIT
00 EQUIP
la)
°f=8 U
Ib)
OZO:;:«ssg
ORD E2173
FIGURE 23-FUEL PRIMER-EXPLODED VIEW
21*
(1)
ILLUST
(0)
FIG NO
2k
2k
•A
2k
2k
(b)
ITEM NO
1
2
2
3
It
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
3*||
(b)
ii
pp
p
pp
(c)
1-££t ̂i
0
0
0
0
0
Id)£=si st
(3)
FEDERALSTOCK
NO
5305-7U1-6368
29110-796-5310
1*720-235- iai8
PQtlfl.TQfl ftllP.7£yH*Jm (;/o— U*4O (
U730-7U1-6U25
(4)
DESCRIPTION
FUEL INDUCTION SYSTEM (Fig. 2U)
SCREW: adjusting idle (hex-hd, S, 7/16-20NF-3 x 1-13/16) (7^16368)
HOSE: engine air intake pipe (IUD, then use HOSE l(720-235-Ull8)(7965310)
HOSE. RUBBER: coolant lines, stght, hv-duty, hv wall, low temp (4o°F), 3 id (802Wt-33-H-787)
LIKE: engine air intake elbow (79801(87) ——————————————————
ELBOW: magneto vent to intake manifold flexible line (flaredtube, 90 deg, br, 1/k in.)
(5)
UNITf-\CLJr
ISSUE
ea
ea
ft
ea
ea
(6)
QTY INCIN
UNIT
1
2
t
1
1
(7)15-DAYMAINT
ALW PER 100 EQUIP
la)
°£OS
(b)
oz5u"S£i&« «>">0
[ORD E2174FIGURE 24-FUEL INDUCTION SYSTEM-EXPLODED VIEW
25
(1)
ILLUST
(a)
FIGNO
25
25
25
25
25
25
25
25
25
(b)
ITEMNO
1
2
3
4
5
6
7
8
9
(2)SOURCE, MAINT
AND RECOVERABILITY
CODEla)
gS
•-&
11
Ibl
Ul
1
P
PPP
PPP
PP
Ic)
B
si3
0
0
0
0
0
0
0
0
0
(dlt
§
B
(3)
FEDERALSTOCK
NO
53140-796- 51*98
25UO TO6-5UQQ
2590-798-0232
53UO-282-75U2
5305-0ll*-33l7
5310-012-03805310-012-0392
5310-012-0367531*0-796-5737
(4)
DESCRIPTION
THROTTLE CONTROL LINKAGE (Fig. 25)
SPRING, HELICAL, COMPRESSION: S, 0.063 wire dia, 17 coils, 0.590od, 3.090 free Ig (7965498)SEAL: accelerator cross tube (7965499)— ——— • —— • — - —— -- — ~ —
CONTROL: manual, assy (79&0232) ———————————————————————
CLAMP, ELECTRICAL: loop type, S, 1/1* od tube, hole for 1/4 screw(manual control)
SCREW, MACHINE: rd-hd, S, 1/4-28UNF-2A x 5/8 (143317) ————————WASHER, LOCK: split, S, 1/4 screw size (120380) ————————————
WASHER, FLAT: S, 9/32 id, 5/8 od, 0.065 thk, 1/4 screw size(120380)
NUT, PLAIN, HEXAGON: S, 1/4-28UNF-2B, 7/16 v, 7/32 thk (120367)--SPRING, HELICAL EXTENSION: S, 0.440 od, 10.250 free Ig (7965737)-
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYIN-rIN
UNIT
1
1
1
1
1
1
1
1
1
I 9 * Is. • *x.o @ O Q< C31 J3) csGao IP
P^4pp. __ ̂-/—E- - —^=Z^ ~X» {L J C
s>j o cf^ [INCHES 1
1
i
(7)1 5-DAYMAINT
ALW PER 00 EQUIP
|a]
O >-
oSu
(bt!_
5 Z G^a.*
ORD E2175FIGURE 25-THROTTLE CONTROL LINKAGE-PARTIALLY EXPLODED VIEW
26
(1)ILLUST
la)
FIGNO
26
o/r
2626
Pfi
(bl
ITEMNO
2
3It
56
7
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
SS5=83 g|
Ib)
S
P
PPPPPP P P
P
(c)uz
i"
0o0000 0 0
0
Id)
£±i
i
(3)
FEDERALSTOCK
NO
53to5315-011-27262990-797-59615306-022-1937 2990-31U-0280OQQO VQ"7 u,'/ 1 IL
2990-31U-02782990-797-5959 5306-022-19372990-31U-0279
1*730-323-8521
(4)
DESCRIPTION
EXHAUST SlfSTEM
MUFFLER AND EXHAUST PIPES (Fig. 26)
BOLT, SELF-LOCKING: hex-M, S, 5/l6-2>njNF-2A x 3/lt (221937) —
BOLT, SELF-LOCKING: hex-hd, S, 5/l6-2ltUNF-2A x 3/U (221937) ~
NON ILLUSTRATED ITEM
CLAMP, HOSE: engine rear exhaust pipe to lower muffler (8720261)
(5)
UNITOF
ISSUE
ea
eaea ea
ea
(6)
OTYINCIN
UNIT
121111 21
3
17115-DAYMAINT
100 EQUIP
la)
n >-ofe
(b)
ozo&& u ">">0
ORD E2176
FIGURE 26-MUFFLER AND EXHAUST PIPES
27
(1)IILUST
la)
FIGNO
27
27
27
27
27
27
2727
Ib)
ITEMNO
12
31*5
6
7
8
12)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
335E "•5 5=<*£
Ib)
G
i
pppppppp
pp
p
p
p
(c)
32 ES -i
0
0
0
0
0
0
0
0
0
0
0
0
0
Id)
§§nii
R
(3)
FEDERALSTOCK
NO
5310-7lH-6276
5315-013-7211*
2930-71*1-6236
2930-71*1-61*35
291*0-798-0207
5306-752-129!*
5310-012-5339
5315-012-1223
5310-752-1252
5307-73l|-8668
5307-73"*-8669
5310-013-101!*
5310-050-221*5
(4)
DESCRIPTION
COOLING SYSTEMFAN ROTOR AND HOUSING (Fig. 27)
HOT, SLOTTED, HEXAGON: S, 15/l6-l6NC-3 (71*16276) ——— ——— — ———
PIN, COTTER: S, 1/8 x 1-3/1* (137211*) -————-——————--——————
FAN, ENGINE COOLING: (71*16296) ——————————— —————————
HOUSING: fan rotor (71*161*35) ———————————————————
SCOOP: inlet, air cleaner, w/integral BRACKET (7980207) -————«
BOLT: hex-hd, dld-f/c-pin, S, 5/16-2UHP-3 x 1-7/32 (752129U) ——
NOT, SLOTTED, HEXAGON: S, 5/Lo-ellUNP-eB, 1/2 v, 21/61* thk (125339)
POT, COTTER: S, 1/16 x 3/1* (121223) —————————————————
NON-ILLUSTRATED ITEO
NOT: rotor housing bracket (7521252) ———————————————————
STUD, PLAIN: rotor housing, 5/16-18NC x 5/16-2UNF-3 x 1-1/2 (0.003 oversize) (73W668)
STOD, PLAIN: rotor housing, 5/16-18NC x 5/16-24NF-3 x 1-1/2(0.007 oversize) (731*8669)
HASHER, FLAT: S, 5/32 id, 3/8 od, 0.01*9 thk, for no. 6 (0.138)screv size (fan rotor housing trace) (131011*)
WASHER, FIAT: S, 21/61* id, 9/L6 od, 0.063 thk (special) (50221*5)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
ca
ea
ea
ea
ea
(6)
QTY
INUNIT
1
1
1
1
1
16
16
16
2
2
6
21
16
(7)15-DAYMAINT
ALW PER100 EQUIP
la)
«O uoSu
Ib)
oz5j m ua. gj""°°
ORD E2177
FIGURE 27-FAN ROTOR AND HOUSING-EXPLODED VIEW
28
(1)
ILLUST
(a)
FIG NO
PR
PR
28
28
(b)
ITEM NO
1
2
2
3
(21SOURCE, MAINT
ANDRECOVERABILITY
CODE(a)
TECHNICAL SEIVICE KO.
(b)
3
f
P
P
(c)MAINTENANCE
LEVEL
0
0
0
(d)
I
(3)
FEDERAL STOCK
NO
2930-7^1-6375
2930-737-60W
5306-752-129U
(4)
DESCRIPTION
FAN DRIVE CLUTCH (Fig. 28)
CLUTCH: drive, assy (71*16375) ————————————————————————
HUB: overload clutch (IUD, then use HUB 2930-699-7776) (7376ol)8)
BOLT: adapter to clutch (hex-hd, dld-f/c-pln, S, 5/16-2UNF-3 x 1-7/32) (752129M
(5)
UNIT OF
ISSUE
ea
ea
(61
QTY INC IN
UNIT
1
10
(7115-DAYMAINT
ALW PER100 EQUIP
la)
P
(b)
8iSi°
! 1 15I '
ORD E2178
FIGURE 28-FAN DRIVE CLUTCH-EXPLODED VIEW
29
(1)
ILLUST
to)
FIGNO
29
Ib)
ITEMNO
1
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
SS
11Ib)
1§
P
P
P
P
P
Ic)
^
11S
0
0
0
0
0
Id)e5
1
R
(3)
FEDERALSTOCK
NO
2920-735-1*165
5310-022-5851*
5310-010-7823
5307-71*l-538l
2920-737-2993
(4)
DESCRIPTION
ELECTRICAL SYSTEM
GENERATOR (Fig. 29)
GENERATOR, ENGINE ACCESSORY: (735U165) ———————— ... ___ . ......
NUT, PLAIN, HEXAGON: alloy-S, 3/8-2l*UNF-2B, 9/l6 w, 21/61* thk (225851*)
NUT, STAMPED: hex, 9-notch, S, 3/8-2UUNF-3B, 9/l6 w, 0.130 thk(107823)
STUD, PLAIN: S, 3/l*-2l*NF-3 (5/8) x 3/l*-l6NC-3l* x 1-19/32 (0.003 oversize) (71*15381)
HON- ILLUSTRATED ITEM
GASKET: mounting (7372993) —————————————— ——.....-......
(5)
UNIT OF
ISSUE
ea
ea
ea
ea
(6)
QTY INCIN
UNIT
1
6
6
6
1
(7)15-DAYMAINT
ALW PER 100 EQUIP
1°)
°gOS
(b)
3 Z cJ CD u
ssg
ORD E2179
FIGURE 29-GENERATOR-EXPLODED VIEW
30
(1)ILLUST
lol
FIGNO
30
30
Ib)
ITEMNO
1
2
(2}SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
gg§i-ss
Ib)
BSa
ppp
pp
(cl
§_.II5
0
0
0
0
0
Id)t=f
5J
i
R
(3)
FEDERALSTOCK
NO
2920-335-^77
53O6-O12-0213
5310-0^5-1007
5310-639-8061
5330-753-9638
(4)
DESCRIPTION
GENERATOR REGULATOR (Pig. 30)
REGULATOR, ENGINE, GENERATOR: control, assy (836O02O) ——— —— ———
BOLT, MACHINE: hex-hd, S, 5/l6-2l«rNF-2A x 7/8 (120213) ———— ——
NUT, SELF-LOCKING, HEXAGON: S, 5/l6-2lHTHF-2B, 1/2 v, 1-7/6^thk (I*510O7)
HASHER, LOCK: int-teeth, S, 5/l6 screv size (138538) —— ——— —
GASKET: cover (7539638) ______ —— — —— — —— — —— ——— — — ———
(5)
UNITOF
ISSUE
ea
ea
ea
(6)
QTYINCIN
UNIT
1
k
k
(7)1 5-DAYMAINT
ALW PER 100 EQUIP
la)
O>OS
(b)
8S2SKg
ORD E2180
FIGURE 30-GENERATOR REGULATOR-EXPLODED VIEW
31
(1)ILLUST
(a)
FIGNO
31
Ib)
ITEMNO
1
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
lal
gg
ii
(b)
21
pp
p
p
P
(c)
{3
Z UJ
ssI
0
0
0
0
0
Wleisi
R
(3)
FEDERALSTOCK
NO
2920-738-625!*
5310-022-585U
5310-010-7823
5305-7>H-5381*
2920-737-2993
(4)
DESCRIPTION
STARTER (Fig. 31)
STARTER- ass 862 M
NUT, PLAIN, HEXAGON: alloy-S, 3/8-2l*UNF-2B, 9/16 w, 21/6U thk(22585)*)
HUT, STAMPED: hex, 9-notch, S, 3/8-2UUNF-3B, 9/16 w, 0.130thk (107823)
STUB: S, 3/8-16NC x 3/5-2UNF-3 x 1-13/32 (0.003 oversize) (7I*15381*)
HON- ILLUSTRATED ITEM
GASKET: mounting, starter (7372993) ————————————————
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
(6)
QTY
INUNIT
1
6
6
6
l
(711 5-DAY MAINT
ALW PER 100 EQUIP
(a)
S >•OS
Ibl
8I|ssg
ORD E2181FIGURE 31-STARTER-EXPLODED VIEW
32
(1)
ILLUST
(a)
FIG NO
32
3232
32
32
323232
32
32
3232
32
(b)
ITEM NO
1
23
1*
5
678
8
9
1011
12
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODE(al
i-g|
Ib)
i
ppppppppppppp
Ic)
B
SIS1"
0
00
0
0
000
0
0
00
0
Id)LIABILITY
S
P.
(3)
FEDERALSTOCK
NO
2920-71*1-61*20
2920-737-29951*720-200-0359
2920-741-61+21
1*730-7^1-53^7
2920-71*1-5301*5310-776-73185307-77^572
5305-77!*-!* 573
5310-010-7823
5310-022-585!*1*730-71*1-531*8
1*730-090-911*3
14}
DESCRIPTION
MAGNETO AND VEHT HOSES (Fig. 32)HOSE: magneto vent to intake manifold, assy (cylinder no. 1, 3
and 5 side) (IUD, then use (2) COUPLING 1*730-090-911*3 and(7-1/1* Ig) HOSE I*720-200-0359)(7l»l61*20)
MAGNETO: assy (7U72995) ————————————————————————————HOSE, RUBBER: air and pressure gage line, low pressure (water,
alcohol and oil resistant), low temp (-65°F), no. 1*, I/1* id,1/2 od (802l*l*-33-H-127-60)
HOSE: magneto vent to throttle valve, assy (IUD, then use (2)COUPLING 1*730-090-911*3 and (5-1/5 Ig) HOSE 1*720-800-0359)(7ltl61*21)
ELBOW, PIPE TO TUBE: 90 deg, 37 deg flare, cop., 1/8-NPT malepipe end, 1/1* od tube end (7l*153l*7)
GASKET: mounting (7l*153oU)WASHER, FLAT: plain, S, 3/8 id, 13/16 od, 7/61* thk (7767318)STUD, PLAIT;: S, 3/8-16NO x 3/8-2UNF-3 x 1-3/1* (0.003 oversize)
(7714,572)STUD, PLAIN: 3/8-16NC x 3/8-2l*NF-3 x 1-3/1* (0.007 oversize)
(771*1*573)HUT, STAMPED: hex, 9-notch, s, 3/8-2ltUMF-3B, 9/l6 w, 0.130 thk
(107823)NUT, PLAIN, HEXAGON: 3/8-2l*UNF-2B, 9/l6 w, 21/61* thk (22585!*)ELBOW: magneto vent to throttle valve line and magneto to intake
manifold line (flared tute, 1*5 deg, I/I* in.) (71*1531*8)COUPLING, HOSE: magneto throttle valve hose (2) and magneto to
manifold hose (2) (cylinder no. 1, 3 and 5 side) (7351007)
(5)
UNITOF
ISSUE
ea
eaft
ea
ea
eaeaea
ea
ea
eaea
ea
(6)
QTYINCIN
UNIT
1
1/
1
1
122
2
2
22
1*
(7)15-DAYAAAINT
ALW PER100 EQUIP
to)
°£ OSu
Ib)
8l|S>"> c
FIGURE 32—MAGNETO AND VENT HOSES
33
(1)
IUUST
(of
FIG NO
3333 3333
33 33
Ibl
ITEM NO
1
3It
6
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
g|
Ibl
g«
PP PP
P P
P
Ic)
1*i"
00 00
0
0
Id)t_J
§s
R
(3)
FEDERALSTOCK
NO
2920-7ltl-lt7362920-7ltl-6283 5310-733-86U55306-151-0788
2920-735-8552 2920-735-3260
2920-571-6731
(4)
DESCRIPTION
IGNITION CABLE, BOOSTER COIL AND SPARK PLUG (Fig. 33)
BOLT, MACHINE: hex-hd, aircraft std, alloy-S, no. 10 (0.190)-32HF-3A x 17/32 (7601593)
NON-ILLUSTRATED ITEMS
GASKET: spark plug (296665) ——————————————————————————— -
(5)
UNITOF
SSUE
ea
eaea
ea
ea
(6)
OTYINCIN
UNIT
11 ItIt
1
liIt
(7)15-DAYMAINT
ALW PER 100 EQUIP
(a)
°£u
Ibl
812sisig
BOOSTER COIL AND CABLE-ASSEMBLED VIEW
ORD E2183FIGURE 33-IGNITION CABLE, BOOSTER COIL, AND SPARK PLUGS
31*
(1)
ILLUST
(a)
FIG NO
31*
,
31*
3^31*
Ib)
ITEM NO
1
231*
5
<2>SOURCE, MAINT
ANDRECOVERABILITY
CODE(a)
11
11
(b)
i
p
p ppp
ppppp
p
Ic)
1 MAINTENANCE [ LEVEL
0
00
0
0
0
0
0
00
0
Id)
HEComAiiuir
R
(3)
FEDERALSTOCK
NO
61UO-057-2553
611*0-61*2-2119611*0-798-0657
6150-279-6723
59liO-705-6730
6810-2U9-9351*
59"*o- 502-3729
5330-505-6609
5330-202-1*061611*5-705-6671*
611*5-705-6675
(4)
DESCRIPTION
BATTERIES AND CABLES (Fig. 3U)
BATTERY, STORAGE: lead acid, charged dry, no. 2 HN (automotiveservice, 12 v, 6 cell, 1*5 amp-hr rating. 10-3/16 x 5-1/1* x 8- 15/16 max) (96906-35000-1)
CABLE: positive (7980655) —————————————————————CABLE: ground (IUD, then use (2) TERMINAL 59!tO-705-6730 and
(11-1/2 in.) WIRE 611*5-705-6675) (7980657)CABLE: ground, battery box, assy (IUD, then use (2) TERMINAL
591*0-705-6730 and (11 in.) WIRE 611*5-708-6675) (7976919)TERMINAL: lug, wire, solderless, wtrprf, sq-end tongue, no. 2
AWO sgle-cond wire, hole for 3/8 screw size (battery and groundcable) (7056730)
NOH- ILLUSTRATED ITEMS
ACID: Bulfuric, storage battery, dilute gal (electrolyte)special, sp gr 1.280, 1-gal (us) container (802UU-51-A-1562-255)
ADAPTER, BATTERY, TERMINAL: clamp type, pos. W/3/8-16NC-2 BOLTand NUT for lug cable term, (positive cable)
RUBBER SHEET, CKLLUIAR: sponge-ru, oil resistant, 1/8 thk, 21* w(802l*l*-33-R-172-50)
RUBBER SHEET, SOLID: syn-ru, 1/8 thk, 20 w (802l*l*-33-R-1260-100)WIRE, ELECTRICAL: low tension, hv-duty, syn-ru jacket, braided,
ins (plastic, natural or syn-ru), sgle-cond (tnd-cop.),stranded, AWG no. 1/0 (8O2l*l*-15-C-2l65-l*OO)
WIRE, ELECTRICAL: low tension, hv-duty, syn-ru Jacket, braided,ins fplastic, natural or syn-ru), sgle cond (tnd-cop.). AWO no. 2 (battery ground and connecting) (802l*l*-15-C-2l65-350)
(5)
UNITOF
ISSUE
ea
eaea
ea
ea
ea
ea
ea
eaft
ft
(6)
QTYINCIN
UNIT
2
11
1
1*
2
2
/
tf
f
(7115-DAYMAINT
ALW PER100 EQUIP
[a]
ol u
(b)
OZC
ORD 2184I FIGURE 34-BATTERY AND CABLES
35
(1)
ILLUST
la)
FIGNO
35
35
35
35
35
35
35
35
Ibl
ITEMNO
1
1
2
3
k
5
6
7
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODE
la)
^ Sjg «.K ^" s
Ib)
u^§
P
P
P
P
P
P
P
c
P
10uisS: ^
i
0
0
0
0
0
0
0
0
0
Id)C133S
i
R
R
(3)
FEDERALSTOCK
NO
25l|O-735-llH2
2590-3119-3650
5930-797-5't88
5305-226-9268
5310-013-101*
5305-012-085l>
5310-012-0392
5930-092-9511
5935-773-0893
(4)
DESCRIPTION
HORN, HORN SWTTCH.AND HEADLIGHT DIMMER SWITCH (FIG. 35)
HORN, ELECTRICAL: assy (IUD, then use JOT 2590-3*9-3650)(772831H)
KIT- ho 2U vnlt (TQVkfil?^KIT. norn, d volt (7971012)
Composed of:
2 CABLE: (8710880)
1 HORN (8380883)
SCREW, MACHINE: rd-hd, S, no. 6 screv size (0.138)-32KC-2A x 3/8(132696)
WASHER, LOCK: split, S, no. 16 screw size (131fllA) —————————
SCREW, CAP, HEXAGON HEAD: S, 1/2-20UNC-2A x 5/8 (120854) ——————
WASHER, FLAT: It, S, 9/32 id, 5/8 od, 0.065 thk, for 1/4 screvsize (120392)
SWITCH, FOOT, ELECTRICAL: dimmer, service headlight, assy (7728788)
RON ILLUSTRATED ITEM
PLUG: Instrument panel, assy (IUD then use (1) GROMMET 5325-338-127U, (1) NOT 5310-771-6633, and (4) PIN 5935-771-6526)(7730893)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTY
INUNIT
1
1
1
2
2
2
2
1
1
(7)15-DAYAAAINT
ALW PER00 EQUIP
(a)
o^OSu
(b)
812ss«
FIGURE 35-HORN, HORN SWITCH, AND HEADLIGHT DIMMER SWITCH
36
ORD E2185
(1)
IUUST
la)
FIG NO
36
36 36
36 36
36
36
36
36
(b)
ITEM NO
1
23it 5
6
7
8
9
(2) SOURCE, MAINT
AND RECOVERABIUTY
CODE(a)
3- = B||
5
(b)
P
P P
P P
P
P
P
P
P
P
Icl
ii"
0
0 0
0 0
o0
0
0
0
0
lECOVEHABIUTT a
H
(3)
FEDERAL STOCK
NO
5310-012-0368
5310-012-0211* 5310-012-0393
5305-018-1608 5305-012-31*50
2590-773-1376
5310-01*5-1003
5310-012-0392
2920-797-5623
1*730-278-38!*!*
2920-797-562lt
(4)
DESCRIPTION
INSTRUMENT PANEL, WIRD*} HARNESS, AND SAFEEf SWITCH (pis. 36)HUT. PLAIN, HEXAGON: S, 5/l6-2l*UNF-2B, 1/2 v, 17/6U thk (panel)
(120368)
WASHER, FLAT: It, S, 11/32 id, 11/16 od, 0.065 thk, for 5/16 screv size (120393)
BOLT, MACHINE: hex-hd, 5/l6-21*UNF-aA x 1 (panel) (I8l6o8) ————— SCREW, CAP, HEXAGON HEAD: S, 1/1*-28UNF-2B, 7/l6 v, 7/32 thk
(1*51003) SWITCH: blackout stop and tailligbt and transmission neutral
safety, assy (7731376) NOT, SELF-LOCKING, HEXAGON: S, 1/1*-28UNF-2B, 7/16 V, 7/32 thk
(1*51003) WASHES, FLAT: S, 9/32 id, 5/8 od, 0.065 thk, for 1/1* screv size
(120392) CABLE: ground, engine, assy (7975623) ——————————————————
NON-ILLUSTRATED ITEMS ELBOW: tube, compression safety sleeve, 90 deg, S, 1/4 tube, 1/8
male pipe end (engine harness) HARNESS: wiring, engine, assy (7975621*) ————————————
(5)
UNIT OF
ISSUE
ea
ea ea
ea ea
ea
ea
ea
ea
ea
ea
(6>
QTY INC IN
UNIT
2
11 11
91*
2
1*
1*
1
1
1
(7) 15-DAY MAINT
AlW PER 100 EQUIP
(ol
SS OS
Ib)
oz5;u» sssg
I 2 3 ,4
V- -"^
ORD E2186,
FIGURE 36-INSTRUMENT PANEL, WIRING HARNESS AND SAFETY SWITCH
37
(1)
ILLUST
(a)
FIG NO
37
37
37
37
37
37
37
37
37
37
Ibl
ITEM NO
1
z
3
i*
5
6
7
8
9
10
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE(ol
3%
||*"*"
(b)
g1
P
P
P
P
P
P
P
P
cP
(cl
Id|5*
0
0
0
0
0
0
0
0
0
0
Id)egi§
R
R
R
R
(3)
FEDERALSTOCK
NO
2520-796-5675
251*0-797-6782
251*0-797-51*83
6680-772-71*66
6625-335-9512
6680-776-0396
6680-021* -2276
6685-772-8853
6685-738-9567
25l*0-797-5l*81»
(4)
DESCRIPTION
INSTRUMENT PANEL - FRONT VIEW (Fig. 37)
PLATE, NAME: windshield wiper motor control switch (7965675) ———
PLATE, IDENTIFICATION: engine oil pressure and temperature gage(7976782)
PLATE, IDENTIFICATION: service headlight beam indicator light(7975W3)
TACHOMETER, MECHANICAL, FIXED, MOUNTING: assy (instrument panel)(77271*66)
VOLTMETER: w/CLAMP, assy (8376377) —————————————————————
SPEEDOMETER: wtrprf, assy (7760396) —————————————————
INDICATOR, LIQUID QUANTITY: fuel, assy (7728852) ———— ——— ————
INDICATOR, PRESSURE: oil, assy (7728853) ——————————————
GAGE, TEMPERATURE, ELECTRICAL RESISTANCE: assy (7389567) — — ——
PLATE, IDENTIFICATION: transmission high temperature warning light(79751*84)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTY
INJNIT
1
1
1
1
1
1
2
1
1
1
(7)15-DAYMAINT
AlW PER 100 EQUIP
(ol
0>Ofe
Ibl
oz5U to u,
%%c
fORD'E2187
FIGURE 37-INSTRUMENT PANEL-FRONT VIEW-EXPLODED
(1)
ILLUST
la)
FIGNO
38
38
38
38
Ib)
ITEMNO
1
1
2
3
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE(al
*S
ll-K
Ibl
i
P
P
P
P
P
P
(c)
CJ
I*S
0
0
o0
0
0
(dl
iia
R
R
R
(3)
FEDERALSTOCK
NO
591*5-612-571*0
59"i5-5l8-9383
2590-797-6367
2590-797-59^7
5310-050-3267
5305-018-0022
(4)
DESCRIPTION
STARTER REIAY AND RECEPTACLE MOUNTING PANEL (Fig. 38)
REIAY SOLENOID: starter (8721*750) ———————————————————
REIAY: starter, assy (IUD, then use REIAY 591*5-612- 571*0 )(7355961)
CABLE: battery to master switch, assy (7976367) ———————————
SWITCH: master, assy (797591*?) ———————————————
NOT, SELF-LOCKING, HEXAGON: S, 1/1*-20UNC-3B, 1/2 w, 3/8 thk(503267)
SCREW, CAP, HEXAGON HEAD: 1/1*-20UNC-2A x 1 (18O022)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
16)
QTYINCIN
UNIT
1
1
1
1
2
2
(7)1 5-DAYMAINT
ALW PER100 EQUIP
la)
,*
OS
Ib)
oz5ssg
ORD E2188FIGURE 38-STARTER RELAY AND RECEPTACLE MOUNTING PANEL
39
(1)
ILLUST
la)
FIGNO
39
39
39
39
39
39
39
39
39
39
39
39
39
Ib)
ITEMNO
1
2
2
3
4
1*
5
6
7
7
8
9
9
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
30—— LU
g|
5
10
Ib)
£1
1
PPcpppp
pp
pc
pp
ppp
p
p
p
p
p
p
p
pp
(cl
gX u!r
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Id)
e-3S
R
R
R
R
R
R
R
R
R
R
R
(3)
FEDERALSTOCK
NO
6220-776-01(18
5930-735-5600
5930-307-8856
5305-013-29H
5925-71*1-11(79
5305-013-2772
5310-012-0622
5310-012-181*1
2590-735-5933
5930-302-1125
2510-752-6596
6220-776-01(12
6220-735-3713
6220-772-3773
5930-752-6287
5305-013-2915
5930-738-9128
5930-735-3523
2590-508-1,592
6220-735-3562
621(0-155-8711*
621(0-019-0877
6220-735-3561
5305-013-276l(
5325-738-5251
5310-012-181.1
(4)
DESCRIPTION
INSTRUMENT PANEL - REAR VIEW (Fig. 39)
LIGHT, INDICATOR: service headlight beam, assy (7760418) ——————
SWITCH: light, assy (IUD, then use SWITCH 5930-307-8856)(7355600)
SWITCH ASSEMBLY: light (73687O8) ——————————————————————————
SCREW, MACHINE: rd-hd, S, no. 10 (0.190)-32NF-2A x 5/8 (132911)
BREAKER: circuit (automatic reset, 15 amp) (7760416) ————————
BOLT, MACHINE: rd-hd, S, no. 8 (0.l64)-32NC-2 x 7/8 (132772)—
NUT, PLAIN, HEXAGON: S, no. 8 (0.l64)-32NC-2B, 11/32 w, 1/8thk (120622)
WASHER, LOCK: split, S, no. 8 (O.l61() screw size (12181*1) ———
SWITCH: selector, fuel tank, assy (IUD, then use (1*) BUSHING5975-6W-3156, (4) FERRULE 5975-057-2929, (l) GROMMET 83-G-2208-13, (2) GROMMET 86-Z-1667-45, (1) SHELL 17-8U05-300-551*, (l)SHELL 5935-030-1561, (1) SHELL 5935-030-1562, (l) SPLICE 5935-350-9273 and (1) SWITCH 5930-302-1125) (7355933)
SWITCH: selector,- fuel tank, assy (7355959) ——————————————
SHIELD: instrument panel light, assy (7526596) ————————————— -
LIGHT: assy (7760412) ———————————————————————————————————
LIGHT, INDICATOR: warning, wtrprf, w/o CONNECTOR, assy (7353713)-
LIGHT: warning, main engine low oil pressure, w/CONNECTOR, assy(IUD, then use LIGHT 6220-735-3713) (7723773)
SWITCH: booster, fuel cut-off, magneto and starter (7526287) ——
SCREW, MACHINE: rd-hd, S, no. 10 (0.190)-32NF-2A x 3/U (132915)
SWITCH, TOGGLE: blackout receiver, assy (IUD, then use SWITCH5930-735-3523) (73&9128)
SWITCH, TOGGLE: blackout receiver, wtrprf, spst, 10 amp (7353523]
NON- ILLUSTRATED ITEMS
COVER: light, w/,SOCKET, assy (used w/LIGHT 6220-776-01*12)(7381*392)
GASKET: transmission high temperature warning light door(7353562)
LAMP, INCANDESCENT: min, 21* v, 0.17 amp, sgle-fil, no. 313 (min-bay-base, T-3-1/4 bulb, C-2F fil) (transmission oil high temp erature warning light) (1930&7)
LAMP, INCANDESCENT: min, 24-28 v, 3 cp, dble-fil, no. 1215 (sgle-contact cand-bay-base, G-6 bulb, two C-2V fils in series)(instrument panel light (2) and service headlight beam indicator(D) (190877)
LENS: transmission high oil temperature warning light door(7353561)
SCREW, MACHINE: rd-hd, S, no. 8 (0.l61()-32NC-2A x 5/8 (fuel tankselector switch) (132764 )
SEAL: lamp socket (IUD, then use COVER 2590-508-4592) (7385251)-
WASHER, LOCK: split, S, no. 8 (0.164) screw size (fuel tankselector switch) (121841)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
1
2
3
6
6
6
1
1
2
2
1
1
1
4
1
1
2
1
1
3
1
2
2
2
(7)1 5-DAYMAINT
ALW PER 00 EQUIP
la)
of.tx
OS
Ib)
oz5J CD LL
3! Kg
1(0
(1)
ILLUST
(a)
FIG NO
(b)
ITEM NO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
lal
3%
-1
(b)
2"•
p
Ic)
3^|£
X
0
W)e=
i
(3)
FEDERALSTOCK
NO
611*5-772-0853
(4)
DESCRIPTION
NON-ILLUSTRATED ITEMS - Continued
WIRE, ELECTRICAL: low tension, hv-duty, syn-ru jacket, braided,ins (plastic, natural or syn-ru), sgle cond (tnd-cop.)>stranded, AHG no. lU (0.160 od) (802U4-15-C-2165-170)
(5)
UNITOF
ISM IF
ea
(6)
QTYINCIN
UNIT
t
(7)15-DAYAAAINT
AlW PER 100 EQUIP
la)DC.°S8-
Ib)
SISssg
IORD E2189
FIGURE 39-INSTRUMENT PANEL-REAR VIEW-EXPLODED
in
ID
ILLUST
(a)
FIG NO
40
40
40
40
40
40
40
40
40
40
Ib)
ITEM NO
1
2
2
3
4
5
6
7
8
9
12)SOURCE, AAAINT
ANDRECOVERABILITY
CODE
(a)
?!11
(bl
B
i
p
p
p
p
pp
pp
p
p
Ic)
B
f 5
0
0
0
0
0
0
0
0
0
0
(d)t-i
(3)
FEDERALSTOCK
NO
6220-741-9686
6220-796-2268
5330-054-6889
5330-541-7160
6220-557-8229
6240-368-4972
5330-796-2255
5330-599-0507
6240-299-6958
6220-796-2263
M)
DESCRIPTION
SERVICE HEADLIGHT (Fig. 40}
HEADLIGHT: service, assy (7419686) ———————————————————
GASKET: service headlight door (IUD, then use PACKING 5330-054-6889) (7962268)
PACKIKG, PREFORMED: "0" ring, class B material (high flexibility).1/8 thk, 5-3/8 id (546889) '
GASKET: blackout bead, door, ru, 3.995 Id, 4.455 od, 0.156 thk(7962267)
LEHS, HEADLIGHT: service, clear, 4.460 od (7962266) —— —— ——— —
LAMP, INCANDESCENT: sealed, all glass, 110-55 w, 24-28 v, 3-contacllug base no. 48ll (par-36 bulb CC-6/CC-6 fll, fluted lens)(453128)
WASHER, NON-METALLIC: Insulating (7962255) ———————————
PACKING, PREFORMED: "0" ring, cold resistant syn-ru, 0.165 thk.1.055 id (7983053)
LAMP, INCANDESCENT: sealed, mtl reflector, 24-28 v, sgle-fil, 40w, v/CABLES and vtrprf CONNECTORS (451990)
DOOR: service headlight and blackout headlight, assy (7962263) ——
(5)
UNITOF
SSUE
e&
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
2
2
2
2
2
4
2
1
2
(7)1 5-DAYAAAINT
AlW PER 00 EQUIP
(a)
°S;OS
Ibl
J to luss"
[QRD E2190JI FIGURE 40-SERVICE HEADLIGHT-EXPLODED _VIEWj
42
(1)
IUUST
lol
FIGNO
1*1
1*1
1*1
1*1
1*1
1*1
1*1
1*1
Ib)
ITEMNO
1
2
31*
1*
56
7
(2)SOURCE, MAINT
AND RECOVERABILITY
CODE
la)
*2£ u
il
10
Ib)
S
i
P
P
P
P
P
P
P
P
P
(c)
la
V
0
0
0
0
0
0
0
0
0
Id)tI§
R
(3)
FEDERALSTOCK
NO
6220-776-0505
5310-013-1*566
5305-012-2101*
2590-693-ln75
5305-752-5938
5305-285-3952
531*0-695-1107
6220-283-9906
5310-350-2655
(4)
DESCRIPTION
BLACKPOT HMm.Tnar (Fig. 1*1)
HEADLIGHT: blackout, shielded, wtrprf, 2U-28 v, assy (7760505) —— -
NUT, PLAIN, HBXAOOH: S, 3/8-16NC-2B, 5/8 v, 1/1* thk (131*566) — —
SCREW, CAP, HEXAGON HEAD: S, 3/8-16UNC-2A. X 5/8 (122101*) —— -——
GROMMBT, RUBBER: blackout driving light (7525365) ————————
CLIP, SPRING TENSION: retaining (7525937) ———————————————
SCREW, MACHINE: blackout headlight door (IUD, then use SCREW 5305-285-3952) (7525938)
SCREW, MACHINE: fil-nd, S, no. 8 (0.l6l*)-32KC-2A x 3/8 (l*538ol*) —
DOOR: blackout driving light, assy (752591*0) ———————————
LAMP UNIT, HEADLIGHT: sealed, shielded, mtl reflector, 2l*-28 v,10 cp, v/CABLES and vtrprf CONNECTORS (5731*35)
WASHER: blackout head light mounting (5291*507) ————————————
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
2
2
6
3
3
1
1
l
(7)1 5-DAYMAINT
ALW PER 100 EQUIP
la)
o>-££8"
Ib)
85§0-fl-JjlU tH"> "* C
ORD E219'l
FIGURE 41-BLACKOUT HEADLIGHT-EXPLODED VIEW
(1)ILLUST
la)
FIGNO
1*2
1*8
1*2
Ib)
ITEMNO
1
2
3
12)SOURCE, AAAINT
AND RECOVERABILITY
CODEla)
§B "3
(b)
P
P
P
Ic)...3E
!§
0
0
0
Id)r^
1ECOVEU
(3)
FEDERALSTOCK
NO
621*0-019-0877
5330-732-0689
6220-732-0690
(4)
DESCRIPTION
BLftOPUE MAmagJJQBr (Pig. 1*2).
LAMP, lECAHDKCHW: min, 2U-28 v, 3 cp, dble-fil, no. 1215 (sgle-contect, cand-bay-baoe, G-6 bulb, tvo C-2V fils In series) (130877)
GASKET: rubber, 2-5/6U Id, 2-27/61* od, 5/32 tbk (7320689)
(5)
UNITOF
SSUE
ea
ea
(6)
OTYINCININIT
2
2
2
(7)1 5-DAYAAAINT
ALW PER 100 EQUIP
(a)
8 !OS
Ib)
ozB
ORD E2192
FIGURE 42-BLACKOUT AAARKER LIGHT-EXPLODED VIEW
1*1*
(1)
ILLUST
la]
FIGNO
U3
1*3
1*3
1*3
lj3
1*3
Ib)
ITEMNO
1
2
3
i*
5
6
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
3S5= S
i|
(b)
sa
P
P
P
P
P
P
PP
P
(c)
B
E S1^
0
0
0
0
.0
0
0
0
0
Id)
1s1
R
(3)
FEDERALSTOCK
NO
6220-695-1200
621*0 -oi*i*-691i*
5330-05l*-6879
6220-752-6020
621*0-019-0877
2590-693-3^52
611*5-51*8-2927
5330-700-6237
5325-57!*-3955
(4)
DESCRIPTION
STOP LIGHT - TAILLIGHT - LEFT (Fig. 1*3)
STOP LIGHT-TAILLIGHT, VEHICULAR: service blackout, wtrprf, 21* v(left) (8378785)
LAMP, INCANDESCENT: min, 2l*-28 v, 32 cp, dble-fil, no. 1683 (sgle-contact, cand-bay-base, S-8 bulb, tvo C-2R fil in series)(96906-351*78-10)
PACKING, PREFORMED: "0" ring, class B material (high flexibility) 1/8 thk, l*-l/8 id (5!*6879)
DOOR: blackout tail, and service tail stop light, flange mtg v/SCREWS, assy (7526020)
LAMP, INCANDESCENT: min, 2l*-28 v, 3 cp, dble-fil, no. 1215 (sgle-contact, cand-bay-base, G-6 bulb, tvo C-2V fils in series)(190877)
SOCKET: left taillight, v/WIRING, assy (IUD, then use STOPLIGHT6220-695-1200) (8378661)
DON -ILLUSTRATED ETEMS
BRAID, WIRE; fl, tnd-cop., 25/32 v, (832 x 36) (802U4-22-C-70) —
GASKET: taillight, syn-ru (-70°F), oil resistant, 2-7/8 od, 1/16thk, 3-mtg holes (7006237)
GROMMET, METALLIC: plain, br, blk-fin., 5/32 nom id (no. 00) v/oWASHER (taillight) (19071*1*)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
1
1
2
1
f
1
1*
(7115-DAYMAINT
AlW PER100 EQUIP
la)
OCO oeOS
Ib)
OZOIj m u.
si Jig
ORD E2193
FIGURE 43-STOPLIGHT-TAIL LIGHT-LEFT-EXPLODED VIEW
(1)
ILIUST
(a)
FIGNO
1*1*
1*1*
1*1*
1*1*
1*1*
(b)
ITEMNO
1
2
3
l.
5
(2)SOURCE, MAINT
ANDRECOVERABIUTY
CODE(a)
^ 5sist
(bl
3
I
pp
p
p
p
pp
p
pp
(cl
££
II=
0
0
0
0
0
0
0
0
0
0
Id)
£1s
R
(3)
FEDERALSTOCK
NO
6220-337-6U71
621*0-019-0877
5330-05l*-6879
6220-752-6018
2590-693-3>»53
611*5-51*8-2927
5330-700-6237
5325-57l*-3955
5970-281* -8672611*5-772-0853
(4)
DESCRIPTION
STOP LIGHT-TAILLIGHT - FIGHT (Fig. 1*1*)
STOP LIGHP-TAILLIGHT, VEHICULAR: right (8378786) ———————————
LAMP, INCANDESCENT: min, 2l*-28 v, 3 cp, dble-fil, no. 1215 (sgle-contact, oand-bay-base, G-6 bulb, tno C-2V fils in series) (190877)
PACKING, PREFORMED: "0" ring, class B material (high flexibility)1/8 thk, l*-l/8 id (51*6879)
DOOR: blackout tall and stop light, flange mtg v/SCREWS, assy(7526018)
SOCKET: right taillight, v/WIRKG, assy (IUD, then use STOP LIGHT6220-337-61*71) (8378662)
NON-ILLUSTRATED ITEMS
BRAID, WIRE: fl, tnd-cop., 25/32 v (832 x 36) (802U4-22-C-70) — -
GASKET: taillight, syn-ru (-70°F), oil resistant, 2-7/8 od, 1/16thk, 3-mtg boles (7006237)
GROMMET, METALLIC: plain, br, blk-fin., 5/32 nom id (no. 00) w/oWASHER (taillight) (1907U1*)
WASHER, NONMEIALLIC: taillight socket (7526026) ————————————
WIRE, ELECTRICAL: lov tension, hv-duty, syn-ru jacket, braided,ins (plastic, natural or syn-ru), sgle cond (tnd-cop.), stranded, AWG no. lU (0.160 od) (bead, tail, and marker light) (802l*l*-15-C-2165-170)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
1
1
1
f
1
1*
1*
(7)15-DAYAAAINT
ALW PER00 EQUIP
(a!
o >-o£
(b)
OZO j at u
ORD E2194FIGURE 44-STOPLIGHT-TAIL LIGHT-RIGHT-EXPLODED VIEW
1*6
(1)ILLUST
la)
FIG NO
•*5
1*5
U5
1*5
1.5
>*5
>*5
>*5
Ib)
ITEM NO
1
2
2
3
5
6
7
8
(2)SOURCE, MAINT
ANDRECOVERABIIITY
CODEla)
g!
(b)
1
p
P
P
P
P
P
P
P
(c)
B
0
0
0
0
0
0
0
0
0
(dlt
1
R
(3)
FEDERALSTOCK
NO
6220-7U1-9688
6220-796-2268
5330-0 5l*-6889
5330-796-2255
62l«)-368-l*972
5330-51.1-7160
6220-796-2263
621*0-299-6958
5330-599-0507
(4)
DESCRIPTION
SERVICE HEAD LIGHT- INFRARED (Fig. 1.5)
GASKET: service headlight door (IUD, then use PACKING 5330-051*-6889) (7962268)
PACKING, PREFORMED: "0" ring, class B material (high flexibility)1/8 thk, U-l/8 id (51.6879)
WASHER, NON-METALLIC: insulating (7962255) —————————————————
LAMP, INCANDESCENT: sealed, all glass, 110-55 v, 2U-28 v, 3-contact lug base no. 1*811 (Par-36 bulb CC-6/CC-6 fil, flutedlens) (U53128)
GASKET: blackout head', door, rubber, 3-995 id, U.1.55 od, 0.156thk (7962267)
DOOR: service headlight blackout headlight, assy (7962263) —————
LAMP, INCANDESCENT: sealed, mtl reflector, 2l*-28 v, sgle-fil,1.0 v (7723898)
PACKING, PREFORMED: "0" ring, cold resistant, syn-ru, 0.165 thk,1.055 id (7983053)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTY
INUNIT
2
2
2
1.
k
S
2
1
2
(7)15-DAYMAINT
ALW PER TOO EQUIP
la)
o£
Ib)
SIS
ORD E2195
FIGURE 45-SERVICE HEADLIGHT-INFRARED-EXPLODED VIEW
"*7
(1)
ILLUST
(a)
FIGNO
1*6
1*6
1*6
1*6
1*6
1*6
1*6
1*6
1*6
1*6
.1*6
Ibl
ITEMNO
i
2
3
I*
5
6
7
8
9
10
11
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
(a)
3°
il— st
10
Ib)
C3S
P
P
P
P
P
P
P
P
P
P
P
P
P
c
cP
(c)
311 S
0
0
0
0
0
o0
0
0
o0
0
0
0
0
o
Id)tz;lis
R
R
R
R
(3)
FEDERALSTOCK
NO
6220-752-81*79
5325-797-6392
5307-206-2601*
5310-639-8061
5310-050-33U5
531*0-752- 593>*
5935-773-l'*28CTAC npi liiiiopjup-u*ij.- itj*j.y
5310-O12-O392
5310-012-0380
5310-012-0367
621*0-010-0877
5305-013-1*225
6620-738-9566
6633-71*1-6363
5930-797-6356
(4)
DESCRIPTION
MISCELLANEOUS LIGHTS AMD SENDING UNITS (Fig. U6)
LIGHT, MARKER, CLEARANCE: blackout marker, assy (75281*79) ————
GROKMET: split, blackout marker light cable (rubber, 3/1* id,1 od, 1/16 v mounting groove)
STUD, CONTINUOUS THREAD: S, 5/l6-2l*UNC-2A x 1-1/1* overall Ig(blackout marker lamp body) (75281*90)
WASHER, LOCK: int-teeth, S, cd- or zn-pltd, 5/16 screv size(138538)
NUT, SELF-LOCKING, HEXAGON: cd- or zn-pltd, 5/l6-2l*UNF-3B, 1/2 w, 11/32 thk (5033!*5)
CLIP: cable connector "2l*" volt auxiliary outlet socket (7525931*1
COVER: trailer receptacle w/HINGE (77311*28) —————————
SCREW, MACHINE: rd-hd, S, 1/U-28NF-2 x 3/U (2ll*l*19) — —— ——— —
WASHER, FLAT: S, 9/32 id, 5/8 od, 0.065 thk, 1/1* screv size(120392)
WASHER, LOCK: split, S, 1/U bolt size (120380) ——————————
NUT, PLAIN, HEXAGON: S, 1/I*-28UNF-2B, 7/16 w, 7/32 thk (120367)--
NON-ILLUSTRATED ITEMS
LAMP, INCANDESCENT: min, 2U-28 v, 3 cp, dble-fil, no. 1251 (sgle-contact, cand-bay-base, G-6 bulb, two C-2V fils in series)(telephone signal light) (190877)
SCREW, MACHINE: oval-hd, S, no. 8 (0.l6U)-32NC-2A x 1/2 (blackoutmarker light door) (131*225)
TRANSMITTER, TEMPERATURE, ELECTRICAL RESISTANCE: engine oil gage,assy (7389566)
UNIT: sending, engine oil pressure gage, assy (7728856)—. ————— -
UNIT: sending, transmission high oil temperature warning light,assy (7976356)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
2
2
2
2
1
1
1*
1*
1*
It
1
1*
1
1
1
(7)15-DAYMAINT
ALW PER00 EQUIP
lol
°£Om U
(b)
812oej Si a5S">o
FIGURE 46—MISCELLANEOUS LIGHTS AND SENDING UNITS
1*3
ORD E2196
(1)
IlLUST
la)
FIG NO
U7
Ib)
ITEM NO
1
(2)SOURCE, MAINT
ANDRECOVERABIUTY
CODEla)
gssail
|b)
ii
p
p
M; MAIHTEIUIICI
1 LEVEL
0
0
Id)t1 lECOVEUHUl
(3)
FEDERALSTOCK
NO
621(0-299-6931
6220-797-6161
(4)
DESCRIPTION
SPOTLIGHT (Fig. U7)
LAMP, INCANDESCENT: spotlight, sealed-unit, mtl reflector, 2U-28v, 50 w (PAR U6 bulb, CC-6 fil, fluted glass lens), w/CABLE, wtrprf CONNECTOR and terminal LUG (1*51991)
NON- ILLUSTRATED ITEM
PAD: spot light mounting bracket (7976161) ————————————————
15)
UNITOF
ISSUE
ea
ea
(6)
QTYIKIC"I|N<-IN
UNIT
1
1
(7)15-DAYMAINT
ALW PER 100 EQUIP
la)
SgOm U
Ib)
SISiSi« ">">0
FIGURE 47-SPOT LIGHTORD E2197
ORD E2198FIGURE 48-DOME LIGHT-EXPLODED VIEW
50
(1)
IlLUST
(0)
noNO
1*8
148w1*8
w1.8
1(8
U8
1*8
W
1(8
1(8
W
1(8
1(8
1(8
1(8
1(8
U8
bl
HEMNO
1
2
3It
5
6
7
9
10
11
12
13
lit
15
16
17
18
19
(2)SOURCE. MAINT
ANDRECOVERABIUTY
f f\TVCmuc(a)
||-1
}!
»
>
j
>
>
>
3
p
3
3
P
3
3
>
P
3
P
P
P
P
P
P
cl
1
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
o0
0
o
0
0
(3)
FEDERALSTOCK
NO
6220-735-1*521*
5930-705-7187
53>(0-705-7l89
5305-732-0657
5355-732-0656
5310-732-0652
6220-796-221*3
5930-732-0651
6220-796-221*5
6220-796»22U2
6220-796-22ltll
621(0-019-3093
6250-796-221(8
62110-295-2668
5330-796-2255
5330-05U-6879
5330-732-061(5
6220-732-O6U7
6220-732-06U6
521(0-368-1(969
5330-705-7598
5970-2&V8672
(4)
OESCRPnON
DOME LIGHT (Fig. 1(8)
LIGHT: dome, assy (IUD, then use GASKET 533O-796-225>t, GASKET6220-796-221*2, GASKET 6220-796-221*3, KKOB 5355-732-O656, LAMP621(0-019-3093, LAMP 621*0-295-2668, LKHS 622O-796-221A, LENS6220-796-221(5. (2) SOCKET 5935-796-221(8 and SWITCH 5930-732- 0651) (735*521*)
PLUNOER: dome light (7057187) ————————————————————————
SPRING, HELICAL, COMPRESSION: dome light (7057189) ——————————
SETSCREW: stop, done light svltcb knob (7330657) ———————————
KNOB: dome light switch (7320656) —————————————————————
NUT: mounting dome light switch (7320652) ————————————————
GASKET: red lens (square type dome light) (796221*3) —————————
SWITCH: dome light, crew and cargo compartment (7320651) —
LENS, DOME LIGHT: red (square type dome light) (7962245) ——— ——
GASKET: white lens (square type dome light) (79622^2) ———————
LENS, DOME LIGHT: white (square type dome light) (79622WO ————
LAMP, INCANDESCENT: min, 2U-28 v, 6 cp dole no. 623, 6 cp (cand-bay-base, G-6 bulb, two C-2V fils in series) (red lens, squaretype dome light (2) and round type dome light (U)) (193093)
SOCKET: w/PLATE and Wllffi, assy (796221(8) —————————————————
LAMP, INCANDESCENT: min, 2U-28 v, 15 cp, 0.66 amp, dble-fil no.1691 (sgle-contact cand-bay-base, S-8 bulb, C-2R fil) (whiteside) (white lens, square type dome light) (453701)
WASHER, NON-METALLIC: insulating, dome light body (square typedome light) (7962255)
PACKING, PREFORMED: "0" ring, 1/8 thk, lt-1/8 id (round type domelight) (5"t6879)
GASKET: lens (round type dome light) (732O61i5) —————————————
LENS, DOME LIGHT: clear (round type done light) (732O6U7) —————LENS, DOME LIGHT: red (round type dome light) (732061*6) ——————
NON-ILLUSTRATED ITEMS
LAMP, INCANDESCENT: min, 2U-28 v, 15 cp sgle-fil, no. 3O5 (sgle-contact cand-bay-base, S-8 bulb, C-2V fil) (white lens, squaretype dome light) (1(1(6878)
WASHER, NON-METALLIC: dome light hole plug (7O57598) ——————————
WASHER, NON-METALLIC: dome light socket (7526026) ———————————
5)
NITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
6)
QTYNCIN
JNIT
2
2
U
2
2
2
2
2
2
2
2
6
It
2
2
U
It
2
2
1
It
U
(7115-DAYMAINT
AlW PER00 EQUIP
(al
°£8 s
(b)
is&«"0
51
(1)ILLUST
lot
FIGNO
Ib)
ITEMNO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
lol
a-|B~ 2
10
10
11
11
(bl
Si
1
P
P
P
P
P
P
P
P
P
P
P
Iclu==
ga 3
0
0
0
0
0
0
0
0
o
0
0
Idl
si
(3)
FEDERALSTOCK
NO
2920-797-5622
5325-797-6369
5325-797-6370
5970-250-3021
5970-6Wt-2632
61U5- 519-2675
6lU5-299-UnU
6lU5- 299-1*13
61^5- 299->*ll
(4)
DESCRIPTION
MISCELLANEOUS HULL WIRING (NOD- ILLUSTRATED)
CABLE: engine to starter, assy (7975622) ————————————————
GROHMET, RUBBER: auxiliary generator cable (plain, 2-1/2 id,3 od, 1/16 w mounting groove)
GROMMET, RUBBER: radio cable (plain, 2 Id, 2-1/2 od, 1/16 wmounting groove)
INSULATING MATERIAL; elec, extruded, plastic transparent tube(KEL-I-631A, grade B, form U, class 1, AWG no. 2, 0.263 Id, O.020 nom wall thk) (802Wt-17-I-1726-76)
INSULATING MATERIAL: elec, extruded, plastic transparent tube(ML-I-631A, type F, form C, class 1), category 1AWG no. 8, 0.133 id, 0.020 wall thk (802M(-17-I-1725-lH)
INSULATION SLEEVING, ELECTRICAL: extruded, plastic transparenttube, AWG no. 6, 0.166 Id, 0.020 wall thk
INSULATION SLEEVING, ELECTRICAL: extruded, plastic white tube,AWG no. 5/8 in., 0.655 max id, 0.030 wall thk
WIRE, ELECTRICAL: low tension, vtrprf and flame retardantbraided Jacket (syn-ru or plasticXins, w/SEPARATOR, Bgle-cond (cop.), stranded, AWG no. 2 (802l*-15-C-2213-350)
WIRE, ELECTRICAL: low tension, vtrprf and flame retardantbraided jacket (syn-ru or plast levins, w/SEPARATOR, sgle-cond (cop.), stranded, AWG- no. 8 (80SW*-15-C-2213-250)
WIRE, ELECTRICAL: low-tension, vtrprf and flame retardantbraided jacket (plastic or syn-ru), ins, v/SEPARATOR, sgle- cond (cop.), stranded, AWG no. 12 (802l*-15-C-2213-150)
WIRE, ELECTRICAL: lov-tension, vtrprf and flame retardantbraided jacket (plastic or syn-ru), ins, v/SEPARATOR, sgle-cond (cop.), stranded, AWG no. Ik (802Wt-15-C-2213-100)
(5)
UNITOF
SSUE
ea
ea
ea
ft
ft
ft
ft
ft
ft
ft
ft
(6)
QTYINCIN
UNIT
1
1
1
J
i
t
4
i
i
/
i
(7)1 5-DAYMAINT
ALW PER 00 EQUIP
1°)
|OS
(bl
ozoJ to uj
»">C
52
(1)
ILLUST
(0)
FIGNO
1*9
1*9
Ib)
ITEMNO
1
2
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElo)
^ g— UJ
§1
(b)
UlM
0
P
P
Ic)
Sl=!5= 5I
0
0
(d)t5S2
i
(3)
FEDERALSTOCK
NO
531*0-798-0111
2520-796-5383
(4)
DESCRIPTION
TRANSMISSION
TRANSMISSION SUPPORT (Fig. 1*9)
BOLT: supporting bracket cap, S, 1/2-20NF-2 x U-l/2 (7980111) ——
BUSHING: supporting (rubber, S, core, 3/970 id, 6.115 od,2.250 v) (7965383)
(5)
UNIT OF
ISSUE
ea
ea
(6)
QTYINCIN
UNIT
2
2
(7115-DAYMAINT
AlW PER 100 EQUIP
la)
oett
Om°
(b)
O Z c(j m u.
£&„
FIGURE 49-TRANSMISSION SUPPORT
53
(1)
ILLUST
lol
FIGNO
50
50
50
50
Ib)
ITEM
1
=)
I*
(2)SOURCE, MAINT
AND RECOVERABILITY
CODE(a)
3 =
11
(b)
aS
p
f
p
(c)
1 =||
0
0
0
Id)£
fj
1
R
(3)
FEDERALSTOCK
NO
2520-798-01)08
5306-022-1926
5310-012-0392
29140-796-5120
(4)
DESCRIPTION
TRANSMISSION OIL FILTER (Fig. 50)
BOLT, SELF-LOCKING: hex-hd, S, 1/U-28UNF-2A X 3/U (221926) —————
WASHER, FLAT: It, S, 9/32 id, 5/8 od, 0.065 thk, 1/U screv size(120392)
(5)
UNIT OF
SSUE
ea
ea
ea
(61
QTY INCIN
UNIT
1
6
6
1
(7)15-DAY MAINT
ALW PER 100 EQUIP
(a!
OSu
Ibl
«:§
2 3
ORD E2200FIGURE 50-TRANSMISSION OIL FILTER-EXPLODED VIEW
(1)
ILLUST
1°)
FIG NO
51
51
Ib)
ITEM NO
1
2
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
(a)
15-~
5
Ib)
B
P
P
Icl
Mi
0
Id)e3s
(3)
FEDERALSTOCK
NO
2520-798-0185
U730-278-3380
(4)
DESCRIPTION
TRANSMISSION OIL FILLER (Fig. 51)
GACffi: oil level, w/filler pipe CAP, assy (7980185) —————————
PLUG, PIPE: aq-socket, hdls, MI, 3/U in. (engine and trans mission oil drain)
(5)
UNIT OF
ISSIIF
ea
(6)
QTY INCIN
UNIT
2
17)15-DAYMAINT
ALW PER 100 EQUIP
[a]
OSu
Ibl
81S &&«
ORD E2201
FIGURE 51-TRANSMISSION OIL FILLER
55
(1)
ILLUST
la)
FIGNO
52
52
52
52
52
52
52
Ib)
ITEMNO
1
2
3
U
5
6
7
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElal
gg
11
5
|b)
«
i
ppppppp
pp
p
Ic)
X
V0
0
0
0
0
0
0
0
0
0
Id)SsS
R
(3)
FEDERALSTOCK
NO
2520-797-6022
5305-012-3520
2530-797-5926
1*730-350-9788
2530-797-5925
5305-012-353!*
1*710-203-0518
5310-012-0382
1*730-050-0718
(4)
DESCRIPTION
TRANSMISSION OIL COOLER (Fig. 52)
COOLER: oil, assy (7976022) ————————————————————————————
SCREW, CAP, HEXAGON HEAD: S, 3/8-2l*UNF-2A X 3/1* (123520) ——————
ELBOW: tube, compression, safety sleeve, 9O deg, S, 3A tube,3/1* male pipe end, assy (1*5-1*327.060-070)
PIPE: oil cooler, outlet (IUD, then use (31-1/8 in.) TUBE,STEEL (1*710-203-0518) (7975926)
CONNECTOR: tube, compression, safety sleeve, S, 3/1* tube, 3/1*male pipe end, assy (1*22297)
PIPE: oil cooler, inlet (IUD, then use (26-1/2 in.) TUBE 1*710-203-0518) (7975925)
^PTWW PAP TTFXA.GON HEAD • S ^/8— 2UUNK"*3i X l~l/8 ( 12353*t j— — — — — —
NON-ILLUSTRATED ITEMS
TUBE, STEEL: seamless, cold dravn and stress relieved, 3/1* od,0.035 wall thk (802l*l*-l*-T-5326)
WASHER, LOCK: split, med, S, 3/8 screw size (oil cooler)(120382)
POWER TAKE-OFF COVER NON-ILLUSTRATED
PLUG, PIPE: hex-socket, head, S, tnd, solid body, 1/8-27NPT
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ft
ea
ea
(6)
QTYINCIN
UNIT
1
1
2
1
2
1
1
^
2
1
(7)15-DAYMAINT
ALW PER00 EQUIP
la)
O >•
o£
Ib)
OZOj to u.
ass
ORD E2202FIGURE 52-TRANSMISSION OIL COOLER
56
(1)
ILLUST
1°)
FIGNO
53
53
53
Ib)
ITEMNO
1
2
3
(21SOURCE, MAINT
ANDRECOVERABIUTY
CODEla)
|!ll•- sz
Ib]
wK
i
pp
p
pp
IclUJ£Z LU
1-
i
0
0
0
0
0
Id)e=;~|X
R
(3)
FEDERALSTOCK
NO
2520-797-6309
5310-OU5-1011
5310-012-0 39 "t
2520-797-6I4OU
U730-050-U208
(4)
DESCRIPTION
PROPELLER DRIVEMARINE DRIVE (Fig. 53)
SPROCKET: idler, w/BEARING, assy (7976309) —————————————————
NUT, SELF-LOCKING, HEXAGON: S, 3/8-2UUNF-2B, 9/16 v, 21/61).thk (U51011)
WASHER, FLAT: S, 13/32 id, 13/16 od, 0.065 thk, 3/8 screw size(12039^)
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF,short male (96906-15003-1)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
1
1
1
(7)15-DAYMAINT
ALW PER100 EQUIP
la)
o *•OS
(b)
OZOU ea LLo. a-UJ 111 O£*><"O
ORD E2203
FIGURE 53-MARINE DRIVE-EXPLODED VIEW
(1)
ILLUST
la)
FIGNO
54
54
54
54
54
5454
54
54
Ibl
ITEMNO
1
2
3
4
56
78
9
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE(al
< zz u
il
(bl
gi
p
ppppppp
p
(c)
sI_J|5
0
0
0
0
0
0
0
0
0
(d)E=3
1
R
R
(3)
FEDERALSTOCK
NO
4730-050-4208
5315-796-5651
2520-797-5777
5315-187-1811
5310-796-5473
5310-013-1018
5315-012-1222
5310-012-0394
5340-796-5206
(4)
DESCRIPTION
STEERING BRACKET, SKEG BRACKET, AND PROPELLER (Fig. 54)
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF, short male (96906-15003-1)
KEY, MACHINE: flat, sq.-ends, S, 19/64 x 3/8 x 3-3/16 (7965651) —— -
PROPELLER: al, 3 blade, 1.2505 shaft dia (7975777) — —— —— — ———
PIN COTTER* S 5/32 x 2 (137243)—— ---------- - ---
NUT, PLAIN, CAP: blind, br, high crown, hex, 7/8-14NF-2 (7965473)-
WASHER, FLAT: S, 15/16 id, 1-3/4 od, 0.134 thk (131018) —— —— — ——
PIN, COTTER: S, 3/32 x 3/4 (121222) ————————————————————
WASHER, FLAT: It, S, 13/32 id, 13/16 od, 0.065 thk, 3/8 screw size(120394)
SPRING, HELICAL, EXTENSION: retracting propeller (S, 0.1875 wiredia, 1.250 od, 23-1/2 coils, 6.75 free Ig) (7965206)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
1
1
1
1
1
4
8
2
(7)15-DAYMAINT
ALW PER 00 EQUIP
la)
O >-OS
(bl,_3 z cot
ij 1U CK U>tOQ
09-—
\
ORD E2204
FIGURE 54-STEERING BRACKET, SKEG BRACKET, AND PROPELLER-EXPLODED VIEW
58
(1)
ILLUST
(a)
FIGNO
55
55
55
55
(b)
ITEMNO
1
2
3k
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE(a)
< K
z iS
Si
Ib)
u
ss
pp
pp
10S32 5:§-•=
0
0
0
0
(d)
IiSs
R
(3)
FEDERALSTOCK
NO
2530-092-9276
5310-01*5-1003
2530-796-5338
5306-797-6831
(4)
DESCRIPTION
SUSPENSION SYSTEM
TRACK (Fig. 55)TRACK SECTION: assy (U4 in.) (7977319) ————— -———-————-——
NUT, SELF-LOCKING, HEXAGON: S, 1/1*-28UNF-2B, 7/16 w, 7/32 thk(1*51003)
PLATE: connecting bar, S, 2-11/16 v, 3-1/8 Ig (7965338) ——————
BOLT, MACHINE: connector bar (l/l*-28NF-2 x 7/8) (7976831) —————
(5)
UNIT OF
ISSUE
ea
ea
ea
ea
(6)
QTY INCIN
UNIT
16
256
fk
256
(7)15-DAYMAINT
ALW PER 100 EQUIP
lal
Of.
OS
(bl
812V) t/> r
FIGURE 55-TRACK-PARTIALLY EXPLODED VIEW
59
ORD E2205
(1)ILLUST
(a)
FIGNO
56
56
56
56
56
c /r56
56
56
56
56
56
56
56
56
56
56
56
(bl
ITEMNO
1
2
3
1*
5
6
7
8
9
10
11
12
13
ll*
15
16
17
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
^ §1"£|
5
b)
u*
gS
p
p
p
p
p
p
p
p
p
p
p
p
p
p
p
p
p
Ic)
i_.il = 3
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
d)t3
i1
(3)
FEDERALSTOCK
NO
1*730-278-3380
2520-796-57"*6
2520-796-571*3
^>tO-796-^>tO
Z 20 98-01*91
2520-796-5735
5306-022-1937
2520-798-01*98
5330-057-0231*
2520-798-01*88
1*730-278-2086
531*0-796-51*81
2520-039-7716
5305-335-1*208
2520-039-7718
2520-039-7717
2520-318-001*9
(4)
DESCRIPTION
SPROCKET DRIVE (Fig. 56)
PLUG, PIPE: sq-socket, hdls, MI, 3/U in. ————————————————
COVER: outer housing (79657"*6) ————————————————————————
GASKET: outer housing cover (796571*3) ———————————————————
SPRIHG, HELICAL, COMPRESSION: retaining, outer shaft (S, 0.192dia wire, smallest coil 1.82 od, largest coil 3.18 od, 3.00free 1«) (79657-*0)
HOUSING* outer (79801*91)--------- - - --- — - » — ™
RETAIHER: outer (7965735) ——————————————————————— ————
BOLT, SELF-LOCKIEG: hex-hd, S, 5/l6-2l*UHF-2A x 3/1* (221937) ————
SHAFT: outer (79801498) ——————————————————————————————
PACKING, PREFORMED'* "0" ring, class A material (low flexibility),1/1* thk, 5-3A id (570231*)
BOOT: universal joint, outer, w/HETAHJER, assy (79801*88) ——————
CLAMP, HOSE: adj, band type, S, 1-3/1* to 2 id (502gl*l) ————————
RXKG, RBIAiHiKG: snap, external, Inner flange (S, 1.812 in. shaftdia) (79651*81)
FLAKGE: inner (7976858) —————————————————————————————
SCREW: cap, Inner Journal bearing to flange (socket-lid, 7/16-2ONF 3 x 1)( £ -{f KIT 2520-039-7718) (7976857)
PARTS KIT, UNIVERSAL JOIHT: repair, inner (7976860) —————————
Composed of:
1 BEARIHG and JOURNAL, assy (7976856)
16 SCREW: journal bearing to flange ( ) (7976857)
1* WIRE: lock, screw (797685!*)
SHAFT: sprocket drive, inner (companion flange) (7976859) —————
JOIHT: inner, w/JOURNAL and BEARIHG, assy (7976855) ——————————
(5)
NITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYNCNNIT
2
2
2
2
2
1*
8
2
2
2
2
1*
2
16
t
2
2
15-DAYMAINT
ALW PER00 EQUIP
(a)
5 >.55u
(b),_
m il&l
60
(1)
ILLUST
lo!
FIGNO
Ibl
ITEMNO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
(a)
isi|
Ibl
B
1
P
P
P
P
Ic]
5 ^" £1"
0
0
0
0
Id)
£&si£
(3)
FEDERALSTOCK
NO
1*730-278-1*216
5330-05l*-69l*8
2520-797-61*80
5330-797-6531
(4)
DESCRIPTION
NON-ILLUSTRATED ITEMS
ELBOW, PIPE: lubr, fitting, 1*5 deg, S, 1/8NPT male and female(inner journal) (501*201)
PACKING, PREFORMED: "0" ring, class A material (low flexibility), 1/8 thk, 1-3/1* id (inner shaft) (51*691*8)
PARTS KIT, UNIVERSAL JOINT: repair, outer (79761*80) —————————
Composed of:
2 BUTTON: centering (796571*7)
2 KIT: bearing (79761*97)
1 PIN: trunnion (796571*2)
2 WASHER: trunnion (798005!*)
5EAL: oil, inner bearing (ck, 1.0l*3 id, 1.3&8 od, 0.3!*!* thk)(7976531)
(5)
UNITOF
SSUE
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
2
f
8
(7)15-DAYMAINT
ALW PER00 EQUIP
la)
hoSo
Ibl
OZO(J Cfi LLJ
ssg
ORD E2206FIGURE 56-SPROCKET DRIVE-EXPLODED VIEW
61
(1)ILIUST
M
FIG NO
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
57
(b)
ITEM NO
1
2
3
4
4
5
6
7
8
9
10
1112
13
15
16
17
18
18
19
20
20
21
21
(2) SOURCE, AAAINT
AND RECOVERABILITY
CODEla)
_, 0
£5
|b)
a
P
P
P
P
P
P
P
P
P
P
P
P
p
p
p
P
P
P
P
P
P
p
P
P
P
P
P
p
p
MAINTENANCE - LEVEl -
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
WlE
I
R
R
R
R
(3)
FEDERAL STOCK
NO
5330-796-5^93 5306-796-5466 5310-013-1016
2540-798-0677
2540-798-0607
5310-045-1027
5310-012-0377 5310-012-0382 2540-798-0023 5330-796-53223110-505-6672 3110-120-3330 4730-050-4208
5305-022-2563 2530-796-5851 2530-796-5850 4730-050-4208
2510-796-5600 5310-595-7327 2530-797-5614
2530-797-5615
2530-797-5613 2530-796-5092 2530-796-5091 2530-796-5358 2530-796-5359
5306-797-511*9 2530-798-0475 . 3110-100-0754
Ml
DESCRIPTION
FRONT SUSPENSION (Fig. 57)
SEAL: (PACKING), "0" ring, rubber, 1/4 thk, 2-1/2 id (7965^93) —
BOLT: hex-hd, S, 5/8-18NF-2 x 4-11/16 (7965466) ————————
WASHER, FLAT: S, 21/32 id, 1-5/16 od, 0.095 thk, 5/8 screw size (131016)
SHOCK ABSORBER, LEVER ACTION: left front and right rear, assy (7980677)
SHOCK ABSORBER, LEVER ACTION: right front and left rear, assy (7980607)
NUT, SELF-LOCKING, HEXAGON: S, 5/8-l8UNF-2B, 15/16 w, 35/64 thk (451027)
NUT, PLAIN, HEXAGON: S, 3/8-l6UNC-2B, 9/l6 w, 21/64 thk (120377)-
SEAL: oil (rubber, 5.24 id, 5.^*5 od, 3/16 thk, 1.25 v) (7965322)-
BEARING, ROLLER, NEEDLE: MLL-STD-CODE 993-63023-OOOO (712450) ———
FITTING, LUBRICATION: stght. hyd, surface check, S, 1/8NPTF, short male (96906-15003-!)
BOLT, SELF-LOCKING: hex-hd, S, 5/8-11UNC-2A x 1-1/4 (222563) — ——
ARM: front suspension, right road wheel, w/SFINDLE (7965850) ————
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8-NPTF, short male (96906-15003-1)
MASHER: spring (8724063) ————————————————————————————
CLUTCH: front suspension primary torsion bar, outer (no. 1 left) (7975614)
CLUTCH: front suspension primary torsion bar, outer (no. 1 right) (7975615)
NON-ILLUSTRATED ITEMS
BOLT: rd-hd, serrated, S, 1/2-20NF-2 x 1-17/64 (7975149) — —— ——
CAP: hub (7980475) ————— — ———— — — —————
CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-STD-CODE 711-02984- 3000 (705277)
(5)
UNIT OF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTY INC IN
UNIT
2
4
8
1
1
4
4
4
4
2
2
2
4
4
1
1
2
2
2
1
1
2
1
1
1
1
24
4
4
(7) 15-DAY AAAINT
ALW PER 100 EQUIP
(a)
06
Ib)
OzSu giifcoe
62
(1)
ILLUST
(a)
FIG NO
(b)
ITEM NO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
(a)
2-II
5
(b)
i1
Ppppp pp
pppPPP
(c)
3
r
0
000
0
0 00
0 0 0
00
0
0
0
0
Id)
1i
R
R
R
R
(3)
FEDERALSTOCK
NO
3110-198-1958
3110-101-17873110-198-19571*730-278-1*216
1*730-050-1*208
2530-796-5380 2530-797-61*675310-796-5378
5310-523-21*05 5315-013-7303 1*730-278-31*25
53!*o-050-l5975330-796-5913
2610-269-71*53
2610-051-93105310-26l*-l*in
2530-798-0288
(4)
DESCRIPTION
FRONT SUSPENSION (Kg. 57) - Continued
NON-ILLUSTRATED ITEMS - Continued
CONE AND ROLLERS, TAPERED ROLLER BEARING: MJX-STD-CODE 725-0201*9-3600 (7133!*9)
CUP, TAPERED ROLLER BEARING: MJi-STD-CODE 7JLL-O2925-1000 (713352)CUP: tapered roller bearing, MIL-STD-COIE 725-O2010-1600 (713350)ELBOW, PIPE: lubr, fitting, 1*5 deg, S, 1/8-NPT male and female
(50U021)FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF, short
male (96906-15003-1)GASKET: hub cap (7965380) ———————————————————————————— HUB: w/BOIffi and CUP, assy (79761*67) —————————————————————NUT, SLOTTED, HEXAGON: retaining, adjusting (hex, S, 1-1/2-12NF-2,
6 slots) (7965378)NUT, CONE SEAL HEXAGON: S, 1/2-20NF-2 (5232llO5) ————————————— PIN, COTTER: S, 1/1* x 2-1/1* (137303) —— i -——-——-—— ——-——-——--PLUG, PIPE: sltd, hdls, S, 1/8 in. (welding gas release hole)
(front suspension road wheel arm)PLUG, EXPANSION: S, 1 dla (wheel arm spindle) (501597) -——-——-—SEAL: oil, type P, hub inner bearing (2.625 id, 3.5l*!*5 od, 0.1*69
w) (7965913)TIRE, PNEUMATIC: road wheel, 10-ply, smooth tread, 6.60 x 15
(nylon cord) (new) (510910)TUBE, PNEUMATIC: tire, road wheel, hv-duty, 6.60 x 15 (new)
(519310)WASHER, FLAT: retaining, .hub, outer bearing (S, 1.535 id, 2.25 od,
0.192 thk) (7965305)TjUL.'L'i , wmrl f *7GA^9Aft^ «__
(5)
UNITOF
SSUE
ea
eaeaea
ea
ea eaea
ea ea ea
eaea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1*
1*1*1*
1*
1* 1*1*
21*6 l*
1*81*
i*
l*
1*
(7)15-DAY MAINT
ALW PER 100 EQUIP
(a)
OS
(bl
8I|""o
'ORD £2207JFIGURE 57-FRONT SUSPENSION—EXPLODED VIEW.
63
(1)ILLUST
la)
FIGNO
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
58
Ibl
ITEMNO
1
2
3
4
5
6
7
8
9
10
11
12
13
14
15
16
17
18
19
20
21
21
22
22
23
24
24
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODEla)
it
Si
Ibl
3
1
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
IdSz =J
1
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Id)sJ3
3
R
R
R
R
(3)
•FEDERALSTOCK
NO
3110-198-1957
5306-797-5149
3110-101-1787
4730-050-4208
2530-798-0475
2530-796-5380
5315-013-7303
5310-264-4111
3110-198-1958
2530-797-6467
3110-100-0754
5330-796-5913
2530-798-0161
3110-227-3427
2530-796-5359
5310-796-5378
5330-796-5309
2610-269-7453
2530-798-0288
5310-523-2405
2530-796-5358
2530-796-5359
2530-796-5092
2530-796-5091
2530-797-5613
2530-797-5616
2530-797-5617
(4)
DESCRIPTION
INTERMEDIATE SUSPENSION (Fig. 58)
CUP: tapered roller bearing, MIL-STD-CODE 725-02010-1600 (713350)
BOLT: rd-hd, serrated, S, 1/2-20NF-2 x 1-17/64 (7975149) ——————
CUP, TAPERED ROLLER BEARIHG: MIL-STD-CODE 711-02925-1000 (713352)
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF, short male (96906-15003-1)
CAP- hub (7980475) ___________________ —
GASKET: hub cap (7965380) ————————————————————————————
PIN (DTTER* S, 1/4 x 2 1/4 (137303) T- . -.. . -
WASHER, FIAT: retaining, hub, outer bearing (S, 1.535 id, 2.25od, 0.192 thk) (7965305)
CONE AMD ROLLERS, TAPERED HOLLER BEARING: MIL-STD-CODE 725-02049-3600 (7133W
HUB: w/BOLT and CUP, assy (7976467) ——————————————— ——
CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-STD-CODE 711-02984-3000 (705277)
SEAL: oil, type P, hub inner bearing (2.625 id, 3.5445 od, 0.469w) (7965913)
ARM: intermediate suspension road wheel, w/SPINDLE, assy (7980161
BEARIHG, ROLLER, HEEELE: MIL-STD-COnE 993-54077-OOOO (713356) ———
BEAKraG: needle, MIL-STD-CODE 354-05601-4300 (713355) ————————
NUT, SLOTTED, HEXAGON: retaining, adjusting (hex, S, 1-1/2-12NF-2 6 slots) (7965378)
SEAL: oil (rubber, 4.250 id, 4.445 od, 13/16 thk, 1.25 w)(7965309)
TIRE, PNEUMATIC: road wheel, 10-ply, smooth tread, 6.60 x 15(nylon cord) (new) (510910)
WHEEL: road (7980288) ————————— —————————
NUT, CONE SEAL HEXAGON: S, 1/2-20NF-2 (5232405) ——— -
BAR: torsion, secondary (intermediate) (7965358)— - -
BAH: torsion, secondary (intermediate) (7965359) —— ——
BAR: torsion, primary (intermediate) (counter-clockwise) (7965092'
BAR: torsion, primary (intermediate) (clockwise) (7965091) —————
CLUTCH: secondary torsion bar (7975613) ————————————————
CLUTCH: intermediate suspension primary torsion bar, outer (no. 2left) (7975616)
CLUTCH: intermediate suspension primary torsion bar, outer (no. 2 right) (7975617)
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
161
QTYINCIN
UNIT
8
48
8
8
8
8
8
8
4
4
4
8
4
8
48
2
2
2
2
4
1
1
(7115-DAYAAAINT
ALW PER00 EQUIP
(a)
«^ ecO<5 u
(b)
)ZC(J tO U
si siS
(1)ILLUST
la)
FIGNO
58
58
58
58
58
Ib)
ITEMNO
Zk
2k
25
26
27
(2)SOURCE, AAAINT
AND RECOVERABILITY
CODE
(al
S S5E Sil
5
(b)
&§j
P
P
P
P
P
P
P
P
(cl—at1 ^i
0
0
0
0
0
0
0
0
(d)
1Iis
R
(3)
FEDERALSTOCK
NO
2530-797-5618
2530-797-5619
5310-595-7327
2510-796-5600
^730-050-^8
53")0-050-1597
^730-278-31125
2610-051-9310
(4)
DESCRIPTION
INTERMEDIATE SUSPENSION (Fig. 58) - Continued
CLUTCH: intermediate suspension primary torsion bar, outer (no. 3 left) (7975618)
CLUTCH: intermediate suspension primary torsion bar, outer (no. 3 right) (7975619)
WASHER: spring (87211063) ————————————————————————————
GASKET: torsion bar clutch cover (7965600) ————————————————
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF, short male (96906-15003-1)
NOH-ILLUSTRATED ITEMS
PLUG, EXPANSION: S, 1 dia (wheel arm spindle) (501597) ———————
PLUG, PIPE: sltd, hdls, S, 1/8 in. intermediate suspension roadwheel arm
TUBE, PNEUMATIC: tire, roadwheel, hv-duty, 6.60 x 15 (new)(519310)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
k
k
8
8
(7115-DAYAAAINT
ALW PER 100 EQUIP
la)
a:0£
U "
(b)
8Sgs£§
20
ORD E2208
FIGURE 58-INTERMEDIATE SUSPENSION-EXPLODED VIEW
65
(1)ILLUST
(a)
FIG NO
59 59 59 59
59
59 59
59 59 59 59
59 59
59
59 59
59
59
59
59 59 59 59 59 59 59 59 59 59
59 59 59 59
59
59
59
59 59 59 59
59 59
Ib)
ITEM NO
12
4
5
6 7
8 9
10 11
12 13
Ik
15 16
17
18
19
20 21 21 22232425 2627 28
29 30 31 32
33
33
34
35 36 37 38
391*0
(2)SOURCE, MAINT
AND RECOVERABILITY
CODE
TECHKIUL ? SEIVICE NO. -
(W
a S S
p p p ppp pp p p pp ppp pp p pp p p p p p p p p pp p p pp p pp p p pp p
MAINTENANCE - LEVEL -
0 0 0 0
0
0 0
0 0 0 0
0 0
0
0 0
0
0
0
0 0 0 0 0 0 0 0 0 0
0 0 0 0
0
0
0
0 0 0 0
0 0
(dl
R
R
R R
R
R
(3)
FEDERAL STOCK
NO
3110-198-1957 5306-796-5593 3110-101-1787 5310-045-1019
5310-012-0396
2805-798-051*8 4730-050-1|.208
2530-798-01*75 2530-796-5380 5315-013-730353io-264-4:ui1*730-796-5535 5330-0511-6931*3110-198-19582530-797-5<n4 3110-100-0751*
5330-796-5913
25ltO-796-5373
5330-054-6883
2530-039-77252530-039-7721 2530-039-77222530-039-7723 2530-039-7721+ 5305-335-4209 3110-120-3330 3110-505-6672 5330-796-5322 5310-796-5378
251*0-798-0023 5310-012-0382 5310-012-0377 5310-01*5-1027
251*0-798-0677
251*0-798-0607
5310-015-1016
5306-796-51*66 5305-022-2563 5330-796-51*93 1*730-050-1*208
2510-796-5600 5310-595-7327
(4)
DESCRIPTION
REAR SUSPENSION (Fig. 59)
CUP: tapered roller bearing, MIL-STD-CODE 725-02010-1600 (713350) BOLT: rd-hd, serrated (S, 1/2-20NF-2 x 1-15/32 Ig) (7965593) — —CUP, TAPERED HOLIER BEARING: MIL-STD-CODE 711-02924-1000 (713352) NUT, SELF-LOCKING, HEXAGOH: S, 1/2-20UNF-2B, 3/1+ w, 7/16 thk
(451019) WASHER, FLAT: S, 17/32 id, 1-1/16 od, 0.095 thk for 1/2 in. screw
size (120396)tJUViiT • XJ/TTRP f 7Qfin tillfi\
FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF, short male (96906-15003-1)
GASKET: hub cap (7965380) ————————————————————————————PTH fyuiiiiL'p, o T /It w O "\ /I], f 1 V7J(\t\
WASHER, FLAT: retaining, hub, outer bearing (S, 1.535 id, 2.25 od, 0.192 thk) (7965305)
PLUG: spindle (sltd-hd, 0.965 dia) (7965535) —————————————— PACKING, PREFORMED: "0" ring, class A material (low flexibility),
1/8 thk, 3/1* id (51*693!*) CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-STD-CODE 725-02049-
3600 (713349)HUB: w/BOLTS and CUPS, assy (7975l*ll*) —————————————————— CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-STD-CODE 711-02984-
3000 (705277)SEAL: oil, type P, hub inner bearing (2.625 id, 3-5445 od, 0.1*69
w) (7965913) SHIELD: hub inner bearing oil seal (S, 2.311 id, I*.l8 od, 0.50 w)
(7965373) PACKING, PREFORMED: "O" ring, class B material (high flexibility).
1/8 thk, 4-5/8 id (51*6883) ' SPINDLE: arm (7976889) ———————————————————————————
WEDGE: arm spindle (7/8-15 LH thread) (7976887) ——————BOLT: adjusting, spindle (7976888) ———————————————————
BEARING, ROLLER, NEEDLE: MIL-STD-CODE 993-63023-0000 (7121*50) —— - SEAL: oil (rubber, 5.24 id, 5.445 od, 3/16 thk, 1.25 w) (7965322) NUT, SLOTTED. HEXAGON: retaining, adjusting (hex, S, 1-1/2-12NF-
2, 6 slots) (7965378) BUMPER, RUBBER: anchor arm (7980023) ——————————————————WASHER, LOCK: split, S, 3/8 screw size (120382) —— —— — —— ——— NUT, PLAIN, HEXAGON: S, 3/8-16UNC-2B, 9/l6 w, 21/61* thk (120377)- NUT. SELF-LOCKING, HEXAGON: S, 5/8-l8UNF-2B, 15/l6 w, 35/64 thk
(451027) SHOCK ABSORBER, LEVER ACTION: left front and right rear, assy
(7980677) SHOCK ABSORBER, LEVER ACTION: right front and left rear, assy
(7980607) WASHER, FIAT: S, 21/32 id, 1-5/16 od, 0.095 thk, 5/8 screw size
(131016)BOLT: hex-hd, S, 5/8-18NF-2 x 4-11/16 (7965466) ——— — ~— ———BOLT, SELF-LOCKING: hex-hd, S, 5/8-11UNC-2A x 1-1/4 (222563) ———SEAL: (PACKING), "0" ring (rubber, 1/4 thk, 2-1/2 id) (7965493)-- FITTING, LUBRICATION: stght, hyd, surface check, S, 1/8NPTF,
short male (96906-15003-1) GASKET: torsion bar clutch cover (7965600) ————————————————
(5)
UNIT OF
SSUE
ea ea ea ea
ea
ea ea
ea ea ea ea
ea ea
ea
eaea
ea
ea
ea
ea ea ea ea ea ea ea ea ea ea
ea ea ea ea
ea
ea
ea
ea ea ea ea
ea ea
(6)
QTY INC IN
UNIT
4 24 4
24
24
4 4
4 4 6 l*
4 4
4
h 4
8
4
1*
2 1 1 2 2 2 2 2 2 1*
4 4 4 4
1
1
8
4 4 2 4
2 2
(7) 15-DAY MAINT
ALW PER 00 EQUIP
la)
s*OS
Ib)
8l|a. Q- u >u of « *° C
66
(1)
ILLUST
la)
FIGNO
59
59
59
59595959
IbiITEMNO
in
in
kz^^i*kk
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
a*§s«i
(b)
UJ
g
p
p
ppppp
Ic)
g£
ili
0
o
0
0
0
0
0
Id)t
1i
(3)
FEDERALSTOCK
NO
2530-797-5620
2530-797-5621
2530-797-5613
2530-796-5092
2530-796-5091
2530-796-5358
2530-796-5359
(4)
DESCRIPTION
REAR SUSPEMSIOH (Fig. 59) - Continued
CLUTCH: rear suspension primary torsion bar, outer (no. k left)(7975620)
CLUTCH: rear suspension primary torsion bar, outer (no. k right)(7975621)
CLUTCH: secondary torsion bar (7975613) ———————————————
BAR: torsion, primary (rear) (counter-clockwise) (79&5092) ————
BAR: torsion, primary (rear) (clockwise) (7965091) ————————
BAR: torsion, secondary (rear) (7965358) ————————————————
BAR: torsion, secondary (rear) (7965359) ——————————————
(5}
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
2
1
1
1
1
(7)15-DAYAAAINT
ALW PER 100 EQUIP
la]
o >OaU
|b)
OzS
8j2ia""°
FIGURE 59-REAR SUSPENSION-EXPLODED VIEW
ORD E2209,S38
(1)
ILLUST
(a)
FIGNO
(bl
ITEMNO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
la)
_, 0
li^ S
5
Ibl
2 §
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
(c)
i\"
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
o
0
(dleii is
R
R
R
R
(3)
FEDERALSTOCK
NO
5306-797-51^9
2530-798-0475
3110-100-0754
3110-198-1958
3110-101-1787
4730-010-9350
2530-797-6467
5310-523-2405
5310-796-5378
5315-013-7303
4730-278- 3te5
5330-796-5913
2610-269-7453
2610-051-9310
5310-264-4111
2530-798-0288
U)
DESCRIPTION
REAR ROAD WHEEL (NON- ILLUSTRATED)
BOLT: rd-hd, serrated, 3, 1/2-20NF-2 x 1-17/64 (7975149) ——————
CAP: hub (7980475) ———————————————————————————————
CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-3TD-CODE 711-02984-3000 (705277)
CONE AND ROLLERS, TAPERED ROLLER BEARING: MIL-STD-CODE 725-02049-3600 (713349)
CUP: tapered roller bearing, MIL-STD-CODE 711-02925-1000 (713352)
FITTING, LUBRICATION: elbow, 67-1/2 deg, hyd surface check, S,1/8NFTF extra short male (hub cap (4) and spindle (2)) (109350)
mrn. u/'RnT'P anA n IP naav f rjcn£*\\(*n \
NUT, SLOTTED, HEXAGON: adjusting hub bearing (S, 1-1/2NF-2 x 12,6 slots) (7965378)
PIN, COTTER: S, 1/4 x 2-1/4 (137303) ———————————————
PLUG, PIPE: sltd, hdls, S, rear suspension road wheel arm ——— --
PLUG, EXPANSION: 3, 1 dia (wheel arm spindle) (501597) ———————
SEAL: oil type, hub, inner bearing (2.625 id, 3-5445 od, 0.469 v)(7965913)
TIRE, PNEUMATIC: road wheel, 10-ply, smooth tread, 6.60 x 15(nylon cord) (new) (51O910)
TUBE, PNEUMATIC: tire, road wheel, hv-duty, 6.60 x 15 (new)(519310;
WASHER, FLAT: hub, outer bearing (s, 1.535 id, 2.25 od, 0.192 thk)(7965305)
WHEEL: road (7980288) ———————————————————————
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
24
4
4
4
4
6
4
24
4
4
4
4
4
4
4
4
4
(7)15-DAYMAINT
ALW PER 00 EQUIP
(a)
at
osu
Ibl
oz5U at u.
*"°
68
(1)
ILLUST
la)
FIGNO
60
60
60
Ib]
ITEMNO
1
2
3
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
—— LU
ii U
Ib)
J3I
P
P
P
P
(c)^
isi- x
0
0
0
0
Id)fc5
S
§
(3)
FEDERALSTOCK
NO
psto 7Q.6 sq^8
5355-797-5005
53"<0-796-5691
53^-796- 5692
(4)
DESCRIPTION
CONTROLS
STEERING AMD SHIFTING CONTROLS (Fig. 60j
GRIP: tar (7965938) ———————————————————————————————
KNOB: lever (7975005) —————————————————————————————
SPRING, HELICAL, COMPRESSION: shifting control shaft (S, 0.072 vire dia, 0.660 dia, 8 coils, 1.500 free Ig) (7965691)
NON-ILLUSTRATED ITEM
SPRING, HELICAL COMPRESSION: shifting control lever (s, 0.050vire dia, 0.250 dia, 10 coils, 0.690 free Ig) (7965692)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
1
1
1
(711 5-DAYMAINT
ALW PER 100 EQUIP
la)
§ l
8
Ibl
tj at u
SK°=
ORD E2210
FIGURE 60-STEERING AND SHIFTING CONTROLS
69
(1)ILLUST
lal
FIGNO
61
61
Ib)
ITEMNO
1
2
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElal
:« zz "*
5 S"S
5
(W
C
i
pp
p
p
tclL~
Z
£ "*S ~5
0
0
0
0
(dlt
I
3
H
(3)
FEDERALSTOCK
NO
251*0-318-001*7
1*730-278-5660
1*730-277-961*1
5310-523-21*05
(4)
DESCRIPTION
TOWING PINTLE
TOWING PINTLE (Fig. 6l)
PINTLE, ASSEMBLY, TOWING: hull, light duty (7355391) ——— —— -----
FITTING, LUBRICATION: elbow, 1*5 deg, hyd surface check, S, 1/8NFTF, male short (1720028)
NON-ILLUSTRATED ITEM
NIPPLE, PIPE: S, glvd, std wt, 1/8-27NPT (Fed Spec WW-N-351, type1) (rotating pintle lubricating fitting)
SPARE WHEEL CARRIER (NON-ILLUSTRATED)
NOT: hex, s, 1/2-20NF-2 (mounting, spare wheel) (52321*05)
(5)
UNIT OF
ISSUE
ea
ea
ea
ea
(6)
QTY INCIN
UNIT
1
1
1
3
(7)15-DAYMAINT
ALW PER 100 EQUIP
(a)
&
OfO aj
Ibl
OZOU to u.
5; 5j o£»«>o
ORD E2211
FIGURE 61-TOWING PINTLE-EXPLODED VIEW
70
(1)
ILLUST
(a)
FIGNO
62
62
62
!b)
ITEM
1
2
3
(2)SOURCE, AAAINT
ANDRECOVERABILITY
CODE(a)
^0
—— LU
X&"
(bl
a
pp p
pp
(cl
B
"
0
0
0
(d)
14»~
(3)
FEDERALSTOCK
NO
8510-797-5115
2510-797-6041
2510-797-5062
a510-797-5'i07
(4)
DESCRIPTION
HULL
CARGO COMPARTMENT DOOR BUMPERS AND SEALS (Fig. 62)
SEAL: outside, roof door (7975115) ————————————————
SEAL: left and right rear door (7976oUl) ———————————————
NOB-ILLUSTRATED ITEMS
BUMPER: right (79751<07) —————————————————————————
(5)
UNITOF
ISSI1F
ea
ea
ea
(6)
QTY INCIN
UNIT
2
2
2
k
(7)15-DAYMAINT
ALW PER100 EQUIP
la)
a^
OS
(b)
OzS
a. o.
ORD E2212
FIGURE 62-CARGO COMPARTMENT DOOR BUMPERS AND SEALS
71
(1)
ILLUST
(ol
FIGNO
636363
63
63
63
Ib)
ITEMNO
123l*
5
5
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
SS
g|
5
5
Ib]
|
PP P
P
P
P
PPPP P
P
PP
MB
ISi
00 0
0
0
0
0000 0
0
00
Id]
1is
(3)
FEDERALSTOCK
NO
2510-797-55162510-797-5W* 2510-797-5068
1*730-278-3380
2530-796-5277
2510-797-55102510-797-55132510-797-571>52510-797-571*91*730-278-31*1*0
5330-797-5520
2510-797-5!*072510-526-6186
(4)
DESCRIPTION
HULL MISCELLANEOUS ITEMS (Fig. 63)
PAD: crash, assistant driver's escape hatch, rear (7975516) ———— •SEAL: assistant driver's (7975^) ————————————————— COVER: access, utility (engine access cover (1) , engine compart
ment deck lid (1), and antenna (3)) (7975068) ——————————— PLUG; PIPE: sq-socket, hdls, MI, 3/1* in. (drain, hull, bottom
panel)CORK, SHEET:- composition, med hv, 1/16 thk, 12 w, 36 Ig (802M*-
J2-C-3050)GASKET: bottom panel drain hole cover (IUD, then use (12 x 36 in.)
CORK) (7965277)
NON-ILLUSTRATED ITEMS
PAD: crash, assistant driver's escape hatch, left front (797551O)-PAD: crash, assistant driver's escape hatch, right front (7975513)PAD: crash, driver's escape hatch, front (79757'*5) ———————PAD: crash, driver's escape hatch, rear (79757^9) —— —— — — —PLUG, PIPE: hex-socket, hdls, bz, 3/1* in. (cargo compartment floor
panel flange and hydraulic steering cylinder)SEAL: communication terminal access cover (7975520) -----------
STOWAGE
STOWAGE BUMPER AHD CLIPS (HOH- ILLUSTRATED)
BUMPER: cushion, liquid container (7975'iO7) —————————————CLIP: carbine muzzle (5266186) —————————————————
(5)
UNITOF
SSUE
eaeaea
ea
ea
ea
eaeaeaeaea
ea
eaea
(6)
QTYINCIN
UNIT
11 5
1*
/2
11212
1
1*1*
(7115-DAYMAINT
ALW PER100 EQUIP
lo)Cf
olu
Ib]
OZOJOg
ssg
ORD E2213
FIGURE 63-HULL MISCELLANEOUS ITEMS
72
(1)
ILLUST
la)
FIGNO
6k
Ib)
ITEMNO
1
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
la)
_, 0
li" 2
Ib)
g
P
P
P
P
(cl
B
i
0
0
0
0
Id]E
£
R
(3)
FEDERALSTOCK
NO
25to-797-6096
5310-012-0613
5310-012-01423
25l4O-050-08lO
25l40-050-o8lU
(4)
DESCRIPTION
WINDSHIELD WIPER
WINDSHIELD WIPER (Fig. 6k)
NUT, PLAIN, HEXAGON: 3, 1/14-28UHF-2B, 7/l6 v, 5/32 thk (120613)
NON-ILLUSTRATED ITEMS
ARM, WINDSHIELD WIPER: adj, od, 7-1/2 closed, 12 extended (500810)
BLADE, WINDSHIELD WIPER: 10 in. Ig (5O08ll() ———— .... ——— .. ————— -
(5)
UNITOF
ISSUE
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
1
2
2
(7)1 5-DAYMAINT
ALW PER 100 EQUIP
la)
O£
u
(b)
oz<5&&«
ORD E2214
FIGURE 64-WINDSHIELD WIPER-EXPLODED VIEW
73
ORD E2215FIGURE 65-WINCH-EXPLODED VIEW
(1)
ILLUST
(a)
FIG NO
65
65
65 6565
65 65 6565
65
(bl
TEM NO
1
2
3
4
5
5
6
7
8
9
(2) OURCE, MAINT
AND RECOVERABILITY
CODEa)
i-\ g
5
55
55
55
55
b)
P
P
P
P
P
P
X2
P
P
P
P
P
P
P
P
P
P
X2
X2
cl
5
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
o
KCOVEMBILITr a
R
(3)
FEDERAL STOCK
NO
4730-278-2338
4730-196-1503
2520-741-1935
2520-741-1934
5315-695-8814
5315-014-1203
2520-796-5595
2520-796-5315
5306-018-1591
5310-012-0214
2540-797-6086
2540-298-7230
4222-550-0504
4010-186-9403
4030-274-3469
4010-274-6839
1249-516-5050
2510-797-6251
251O-797-5243
(4)
DESCRIPTION
MUCH
WINCH (Fig. 65)
NIPPLE, PIPE: S, std, glvd, 3/8 x 1-1/2 (short) ———————
RETAINER: grease, clutch housing bushing (rubber) (7411934) ————
PIH: dowel, straight, headless (l/4x 1-1/4) (7977014) ————————
PUT: straight, headless, S, 1/4 x 1-1/4 (l4l2O3) —-————--
HOB: sprocket (7965595) ——————————————————————
BOM, MACHIHE: hex-hd, 5/l6-24UNF-2A x 1/2 (181591) ————————
WASHER, LOOK: split, S, 5/l6 screv size (120214) ———— — —— ————
NON-ILLUSTRATED ITEMS
CABLE: (3/8 in. x 85 ft Ig) (7976086) ————————————————
CHAIN: single, cable, 3/8 in. (IUD, then use (4 ft) CHAIN 42- 2255-00-504, (1) LINK 12-4951-65-050, (1) LINK 4010-274-6839 and (1) HOOK 4030-274-3469) (7717029)
CHAIN: welded, stght, link, high carbon high test S, natural, 3/8 In. nom size (cable) (42-2255.00-504)
CHAIN: weldless, sash, S, give, 0.035 in. nom size (retaining, cable outlet unility cover (2 ft))
HOOK: hoist or sling, direct eye, S, 3/8 In. (cable) — —— —— —
LINK CHAIN, END: oval forged or «elded, S, 15/32 thk material f/3/8 chain (cable) (7717005)
LINK: repair, swing, S, 3/8 in. (cable) (12-4951.65-050) — —— ——
ROLLER: cable, horizontal (7976251) ————————————————————
(5)
UNIT OF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ft
ft
ea
ft
ea
ea
ea
(6)
QTY INCIN
UNIT
2
2
2
1
1
1
1
1
3
3
1
1
/
X
1
1
1
1
2
(7) 1 5-DAY MAINT
ALW PER 00 EQUIP
la)
°S05
(b)
8S2 s$§
75
(1)ILLUST
la)
FIGNO
Ib)
ITEMNO
(2)
SOURCE, MAINTAND
RECOVERABILITY CODE
la)
-i 03"ll
ll
11
ll
11
ll
11
ll
Ibl
B
1
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
Icl
| a
P
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
Id)eSs
R
R
R
(3)
FEDERALSTOCK
NO
5910-128-1991*
1*730-278-21*93
251*0-752-0358
25140-770-0170
P590-695-5161*
5970-61*1*-261*9
5970-21*5-3860
59*10-050-7095
591*0-020-0327
591*0-386-1029
611*5-772-0853
611*5-350-9292
251*0-058-3261*
25i»o-737-2703251*0-798-01*17
25l*0-05l*-7202
5310-012-0613
5310-012-01*23
(4)
DESCRIPTION
MtSCELLAHBOUS ACCESSORIES
PERSONNEL HEATER (NON-ILLUSTRATED)
CAPACITOR, FIXED, PAPER DIELECTRIC: 0.01 rafd, type CA-1»32, rhmounting bracket, 1/1* bolt size (rh mounting clip)
CAPACITOR, FIXED, PAPER DIELECTRIC: In mounting clip, 100 v dc,10.000 mmfd, type CA-U35, 9/32 screw size (ventilating airblower) (3l*-D-l*35)
CLAMP, HOSE: adj, band type, S, 7/8 to 1-1/8 id (combustion airduct) (502913)
GASKET: igniter (7520358) ———————————————————————————
IGNITER: assy (IUD, then use IGNITER 2590-695-516!*) (7700170) -----
IGNITER- fTTLSOQ^l
INSULATING MATERIAL: elec, extruded, plastic, transparent tube(Spec JAN-1-631, type F, gr A, form IT), AHG no. 8, 0.133 id, 0.016 wall thk (terminal strap to resistor wire)
INSULATION SLEEVING, ELECTRICAL: extruded, plastic black tube,0.106 id, 0.016 nom wall thk, AWG no. 10 (control wire)
TERMINAL: cable, solder, eyelet, dole-ear, tad-cop., 0.032 in. thk, no. l8-ll*AWG cable, no. 6 screw size (terminal strip toresistor) (507095)
TERMINAL, LUG: wire, solder, eyelet, dble-grip, br, tnd, no. lo ll* AWG wire, no. 8 screw size (type B) (control)
TERMINAL, LUG: 90 deg solderless, snap on spark plug (cage type),crimp on, 7-mm cable (igniter to resistor) (A193987)
WIRE, ELECTRICAL: low tension, hv-duty, syn-ru jacket, braided,ins (plastic, natural or syn-ru), sgle cond (tnd cop.), strandedAWG no. ll* (0.160 od)(resistor) (spec AXS-1819) (802l*l*-15-C-2165-170)
WIRE, ELECTRICAL: low tension, wtrprf and flame retardant braidedjacket, plastic or syn-ru ins. w/SEPARATOR, sgle-cond (cop.), stranded, AWG no. IB (8021A-15-C-2213-75)
REAR VIEW MIRROR (NON-ILLUSTRATED)
ARM, REAR VIEW MIRROR: adj, od, 15 closed, 25 extended, assy(583261*)
BRACKET: mounting, outside rear view mirror (7372703) —— —— — —— -
MIRROR ASSEMBLY REAR VTEW: (IUD, then use ARM 251*0-058-3261*,BRACKET 251*0-737-2703 and MIRROR 2540-05U-7202) (79801*17)
MIRROR ASSEMBLY, REAR VTEH: outside, mtg, 5-1/2 od, l/l*-28NF-2 shaft (51*7202)
NUT, PLAIN, HEXAGON: S, 1/I*-28U1IF-2B, 7/l6 w, 5/32 thk (120613)
WASHER, LOCK: int-teeth, S, 1/U screw size (12O321*) -— — —— ——
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ft
ft
ea
ea
ea
ft
ft
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
1
2
1
1
1
f
2
2
2
j.
j
1
1
1
1
1
1
(7)1 5-DAYMAINT
ALW PER 00 EQUIP
(a)
O >at.ofe
(b)j_) z ca
SSg
76
(1)ILLUST
(a)
FIGNO
66
66
Ibl
ITEMNO
1
1
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla)
^0
— UJ
11
Ib)
K
S
P
P
P
P
P
P
Icl~S u|S
0
0
0
0
0
0
(dlcII
R
R
(3)
FEDERALSTOCK
NO
25to-0 39-7715
5306-022-1939
5310-012-0393
2590-693-3372
5306-022-1939
5310-012-0393
(4)
DESCRIPTION
BILGE PUMP (Fig. 66)
PUMP: bilge, assy (partial) (used on vehicles thru serial no. 110)(797681*9)
BOLT, SELF-LOCKING: hex-hd, S, 5/l6-2ltUNF-2A X 1 (221939) —————
WASHER, FLAT: S, 11/32 id, 11/16 od, 0.065 thk, 5/l6 screw size(120393)
PUMP: bilge, assy (partial) (used on vehicles after serial no.110) (7976978)
BOLT, SELF-LOCKING: hex-hd, S, 5/l6-2l»UNF-2A X 1 (221939) —————
WASHER, FLAT: S, 11/32 id, 11/16 od, 0.065 thk, 5/l6 screw size(102393)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
2
10
10
2
10
10
(711 5-DAYMAINT
ALW PER100 EQUIP
(al
Ofo ^o£
(b)
ozo(J CD £
Si S§
1FIGURE 66—BILGE PUMP—EXPLODED VIEW
77
ORD E2216
(1)
ILLUST
(0)
FIGNO
67
6767676767
Ibl
ITEMNO
1
2
1*
6
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElol
5 —£ >-K
Ibl
u
i
pppppp p
ppp ppppp
Ic)
S|_,£ ^
£
00
0 000 0
000 0000
0
Id)c1>2
(3)
FEDERALSTOCK
NO
2520-798-30585306-01*2-5378
5305-361*- 32295330-753-96882520-772-U3385330-7"n-53952990-798-3062
5330-252-33916680-797-61636680-798-30565330-753-96892520-797-5U702520-797-67385307-733-861*6
5330-753-9688
(4)
DESCRIPTION
SPEEDOMETER AND TACHOMETER ADAPTERS AND CABLES (Fig. 67)
ADAPTER: flexible drive, aoay (90 deg) (7983058) —«—————BOLT, ASSEMBLED WASHER: hex-hd, Int-teeth lock washer, header-
pt, S, 1/1*-20UNC-2A x 7/16 (1*25378)KEY: drive shaft adapter (5263592) ————————————————GASKET: sealing, lower flexible drive shaft core (7539688) ————GEAR: driven, speedometer shaft (7721*338) —————————————SEAL: oil, drive shaft (7/8 x 1-3/8 x 3/8) (71*15395) —— ——— — —ADAPTER: flexible shaft to engine, assy (7983062) ----- — — ———
NON-ILLUSTRATED ITEMS
CEMENT: non-hardening, no. 2 (11 01 tube) ——————————————CORE, FLEXIBLE SHAFT ASSEMBLY: lower (51-3/1* lg) (7976163) ——— ——COUPLING: shaft, assy (7983056) ———————————————GASKET: sealing, upper flexible drive shaft core (7539689) — ———SHAFT ASSEMBLY, FLEXIBLE: lower, v/CASING and FITTINGS (79751*70)-SHAFT ASSEMBLY, FLEXIBLE: upper, w/CASING and FITTIBG (7976738) —STUD, PLAIN: adapter (S, 1A-20KC x 17/32 x l/l*-28NF-3, 39/6* x
1-5/16) (0.003 oversize) (733861*6)WASHER, NON-METALLIC: sealing, lower flexible drive shaft and
flexible driven shaft adapter (7539688)
(5)
UNITOF
SSUE
eaea
eaeaeaea ea
eaeaeaeaeaeaea
ea
(6)
QTYINCIN
UNIT
12
22111
t221*221*
2
(7)15-DAYMAINT
ALW PER 100 EQUIP
to]
° «O m
Ibl
^_U muj
u 2i ttUXOQ
ORD E2217
[FIGUREi 67-SPEEDQMETEJLAND TACHOMETER ADAPTERS AND CABLES- (EXPLODED VIEW
78
(1)
ILLUST
la]
FIGNO
68
68>68
6868
Ib)
ITEMNO
1
23
45
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElo]
I-ll
(b)
i
PPPPp
P*P
(cl
3
eai
0
00
00
00
0
0
Id)
i=s i
(3)
FEDERALSTOCK
NO
2540-796-5276
25)10-797-66442540-796-5195
2540-797-67572540-796-5079
2590-512-91672540-796-5200
5304-011-1688
2590-512-9160
U)
DESCRIPTION
VEHICLE DATA PLATES (FIG. 68)
PLATE, DESTRUCTION: control (on engine cooling air duct leftside panel) (7965276)
PLATE, DESTRUCTION: vehicle speed (7976644) ——————————————PLATE, IDENTIFICATION: name, vehicle (on Tigl"** cooling air
inlet duct, left side panel) (7965195)PLATE j DESTRUCTION: heater fuel selector valve (7976757) —————PLATE, DESTRUCTION: tattery heat control (7965079) —— —— — —— —
DON ILLUSTRATED ITEMS
PLATE DESTRUCTION: connector, auxiliary generator (7977027) ———PLATE, DESTRUCTION: deck lid (on engine cooling air Inlet duct
left side panel and engine compartment deck lid) (7965200)SCREW, TAPPING. THREAD FORMDJ3: pan-hd, blunt-pt, sh-met-tnk, S,
no. 8 (0.163) x 3/8 (instruction plate, connector (4) andselector valve (4)) (111688)
PLATE, DESTRUCTION: fuel cell selector valve, auxiliary generator(7977028)
(5)
UNITOF
ISSUE
ea
eaea
eaea
eaea
ea
ea
(6)
QTYINCIN
UNIT
1
11
12
12
8
1
(7)1 5-DAYMAINT
ALW PER100 EQUIP
la)
Of
ofe
Ib)
oz5w
ORD E2218
FIGURE 68-VEHICLE DATA PLATES
79
(1)
ILIUST
lol
FIG NO
69
69 69
69
69 69 69 69 69 69
Ibl
ITEM NO
1
2 3
U
6
8 9
10
(2) SOURCE, MAINT
AND RECOVERABILITY
CODE1°)3°
11
5
Ib)
Bi
pp pp p p p p p p p p p
p p p
(c)
S
g5
0
0 0
0 0 0 0 0 0 0 0 0 0
0 0 0
Id)es S
i
R
RR
B
R R
13)
FEDERAL STOCK
NO
5930-096-6926 5930-221-8966
2920-625-9302 5310-017-1(855 5305-012-2138 5310-010-3321 2805-625-9296 5306-012-3771* 5310-012-0393 5310-012-0211* 2920-37U-3180 2920-7U1-0072
2910-625-9298 2910-37U-3562 5310-012-0380
14)
DESCRIPTION
AUXILIARY POWER UNIT GENERATOR
AUXILIARY POWER UNIT GENERATOR AND ACCESSORIES (Fig. 69)
GENERATOR: auxiliary power unit, assy (Wisconsin model 68) (8376772)
SWITCH, PUSHs spot, dble break, normally open, metal case, plunger type, 2 terminal studs, 2 mtg holes (starter) (8720161*)
STARTER, ENGINE, ELECTRICAL: (8738191) ——————————————————NUT, PLAIN, HEXAGON: S, 3/8-l6l©-3 (171*855) —————————————SCREW, CAP, HEXAGON HEAD: S, 3/8-l6UNC-2A X 1-1/8 (122138) ——— WASHER, LOCK: split, S, 3/8 bolt size (103221) —— —— — ———— —
GAGE, ROD, LIQUID, LEVEL: oil filler pipe (797^183)- —— —— — ———BOLT, MACHINE: hex-hd, S, 5/l6-2l*UNF-2A x 1-1/1* (12377!*) —— ————WASHER, FLAT: S, 11/32 id, 11/16 od, 0.065 thk (120393) —— —— —— -WASHER, LOCK: split, S, 5/l6 bolt size (120211*) ————— ————— ——
SPARK PLUG: shielded, iSum suppressor, 1 in. hex. 1/2 reach (150 psi preignition rating, 5/8-2UMEF-3 shield thd) (71*10072)
NON- ILLUSTRATED ITEffi
HASHER, LOCK: S, 1/U bolt size, 0.062 thk, 0.1*93 od (120380) ——
(5)
UNIT OF
SSUE
ea
eaea
ea ea ea ea ea ea ea ea ea ea
ea ea ea
(6)
QTY INC IN
UNIT
1
1 1
1 3 331
6 6 ll
1 12
(7) 15-DAY MAINT
ALW PER 00 EQUIP
(a)
os
Ib) i-
10
FIGURE 69-AUXILIARY POWER UNIT I GENERATOR AND ACCESSORIES
80
(1)ILLUST
la)
FIG NO
70
70
70
70
70
Ibl
ITEM NO
1
2
3
l*
5
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
1-^ £
Ibl
1\S\
P
P
P
P
P
P
P
(cl
a
<*
0
0
0
0
0
0
0
Id)Sg
SS
(3)
FEDERALSTOCK
NO
5310-012-0392
5310-01*5-1003
5305-021-1*1*20
531*0-282-7521
5975-333-9M1*
5305-013-2760
5310-012-18U1
(4)
DESCRIPTION
VOLTAGE REGULATOR HARNESS (Fig. 70)
WASHER, FLAT: S, 9/32 id, 5/8 od, 0.065 thk (harness clip)(120392)
NUT, SELF -LOCKING, HEXAGON: S, 1/1*-28UNF-2B, 7/16 V, 7/32 thk(harness clip) (1*51003)
SCREW, MACHINE: rd-hd, S, 1/1*-20UNF-2A x 7/8 (harness clip) (211*1*20)
CLAMP, ELECTRICAL: loop type, S, 5/8 od tube, 1/1* bolt size(harness to side panel) (120527)
NUT, GROMMET, RETAINING: elec, connector, al, 1-1/1* x 18NEF-2 x 1(knurled or w/8 tightening nubs) (adapter cable) (7723308)
NON-ILLUSTRATED ITEMS
SCREW, MACHINE: rd-hd, S, no. 8 (0.l61*)-32NC-2A x 1/2 (voltageregulator cable) (132760)
WASHER, LOCK: split, med, S, no. 8 screv size (voltage regulatorcable) (12181*1)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
1
1
2
1*
1*
(7)1 5-DAYMAINT
ALW PER100 EQUIP
la)
°£O 03(J
Ibl
ozo(J m u.
£">0
FIGURE 70-VOLTAGE REGULATOR HARNESS
81
QQl \
—— «^-~a W£j_j, ^ ;
FIGURE 71-FUEL SELECTOR VALVE, FUEL LINES, AND FITTINGS
82
(1)
ILLUST
(a)
FIGNO
71
71
71
71
71
71
71
71
(b)
ITEMNO
1
2
3
U
5
6
7
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODE
la)
S£
11
5
5
55
5
5
5
5
(b)
u
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
P
p
P
P
P
P
Ic)
1-|Ex
0
0
0
0
o
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
o
Id)eS
Ia
R
V
(3)
FEDERALSTOCK
NO
29K>-7Ul-lo6U
5310-01U-22U7
5305-012-3U35
5310-012-0380
5305-012-3U35
U730-278-U310
U730-1U1-9098
U730 -018-9891*
U710-277-5525
531*0-282-7521
2910-796-71*68
U730-277-87U5
53UO-282-75U2
U730-273-8o6l
U730-202-6979
5310-OlU-22l*7
U730-011-6U52
U730-01U-0682
5305-01U-3317
1*730- 512-9230
5310-oUU-6l6l
5310-012-0380
(4)
DESCRIPTION
FUEL SELECTOR VALVE, S»UEL LINES, AND FITTINGS (Fig. 71)
VALVE: fuel selector, assy'(7Ullo6U) ——————————————
NUT, PLAIN, HEXAGON: S, 1/U-28UNF-2B, 7/16 w, U/32 thk(1U22U7)
SCREW, CAP, HEXAGON HEAD: S, 1/U-28UNF-2A x 5/8 (1231*35) ———
WASHER, LOCK: split, S, 1/U screw size (120380) — ———— ———
SCREW, CAP, HEXAGON HEAD: S, 1/U-28UNF-2A x 5/8 (selector valvebracket) (1231*35)
ADAPTER, STRAIGHT, PIPE TO TUBE: compression, safety sleeve, S,1/3-27NFTF male pipe end, 1/U od tube end, 1 over-all Ig (fuelline) (189920)
BUSHING: pipe, shoulder, MI, glvd, 1/U x 1/8 (fuel selectorvalve to fuel lines)
NUT, TUBE COUPLING: compression safety sleeve, S, 1/U od tube,9/l6 over-all Ig (fuel selector valve to bulkhead tee, Ih andrh (U) and fuel selector valve (l))(l8989U;
TUBE, COPPER: seamless, cold drawn, soft anld, 1/U od, 0.035wall thk (19-1/2 in.) (fuel selector valve to flexible hose(20-1/2 in.), fuel selector valve tee to left fuel tank (120in.) right fuel tank and (12-1/2 in.) fuel line pump tocarburetor) (802UU-UU-T-5080-15)
CLAMP, ELECTRICAL: loop type, S, 5/8 od tube, 1/U screw size(fuel line to seat panel) (120527)
HOSE: fuel, assy (79671*68) ————————————————————
NON ILLUSTRATED ITEMS
ADAPTER, STRAIGHT, PIPE TO HOSE: flared tube, br, 7/l6 tube,1/U male pipe end (fuel pump outlet)
CLAMP, ELECTRICAL: loop type, S, 1/U od tube, 1/U screw size(fuel line to roof rail)
ELBOW: flared tube, 90 deg, br, 1/U tube, 1/8 male pipe end(fuel strainer outlet, fuel pump inlet and carburetor fuelline)
FITTING: safety, compression tube, S. 1/U in. (fuel selectionvalve to bulkhead tee, Ih and rh (U) and selector valve topump flexible hose (1))
NUT, PLAIN, HEXAGON: S, 1/U-28UNF-2B, 7/l6 w, 3/l6 thk (fuelline clamp (6) and selector valve bracket (2))(lU22U7)
NUT, TUBE, COUPLING: U5 deg flare, short, br, 1/U od tube, 3/1*over-all Ig (fuel primer to carburetor)
NUT, TUBE FITTING: short, br, 7/l6 od tube, 1-1/16 Ig (fuelline pump to carburetor)
SCREW, MACHINE: rd-hd, S, 1/U-28UNF-2A x 5/8 (fuel line clamp)(1U3317)
TEE, TUBE: fuel connecting, IB and rh bulkhead (7977030) ———— —
WASHER, FLAT: S, 7/32 id, 7/l6 od, 0.0!*9 thk, no. 1O (0.190)screw size (fuel line clamp) (UU6l6l)
WASHER, LOCK: split, S, 1/U screv size (fuel line clanp (6) and selector valve bracket (211 (12O38O1
(5)
UNITOF
SSUE
ea
ea
ea
ea
ea
ea
ea
ea
ft
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
1
2
2
2
2
3
3
5
t
1
1
1
6
1
5
8
2
2
6
2
1
8
(7)15-DAYMAINT
ALW PER100 EQUIP
(a)
„
OS U
Ib)
oz5U <u u-
83
(1)ILLUST
la]
FIG
72
72
72
72
72
72
Ib)
ITEM
2
3 It
5
6
(2)SOURCE, MAINT
AND RECOVERABILITY
CODE(o)
^ K
11
5
Ib)
i~SS
P
P
P
P
Ic)
K
I 51
0
0
0
o
Id)e
1
(3)
FEDERALSTOCK
NO
2990-512-9195
2990-512-9190
5310-01(5-1003
5305-012-1(070
5306 -012- 3^73
(4)
DESCRIPTION
MUFFLES (Fig. 72)
NUT, SELF-LOCKING, HEXAGON: S, 1/1*-280HF-2B, 7/l6 v (1(51003) ——RFXAnON BEAD- S 1A-2&THF 2A 2 ^iA f!2l(O70}, , »
BOLT, MACHINE: hex-hd, S, 5/l6-2l(OHF-aA x 5/8 (tracket to roof) ( 123^73)
(5)
UNITOF
SSUE
ea
ea
ea
ea
(6)
OTYINCININIT
1
1
1
1
k
(7)15-DAY MAINT
ALW PER 00 EQUIP
la)
o >-8°
Ib)
&&K(/)«/) ^
/ rFIGURE 72-MUFH.ER
8k
ORD E2222
(1)
IUUST
la)
FIG NO
73
73
73
73
73
73
73
(b)
ITEM NO
1
2
3k
5
6
7
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODEla]
3°
i^
(b)
B
&
P
P
P
P
P
P
P
P
(c)
1*|3
0
0
0
0
0
0
0
0
Id)
E=J 3
1
(3)
FEDERALSTOCK
NO
5310-012-039S
5310-OU5-1003
5305-012-3l)-56
2990-512-9183
2990-512-9227
5305-0*5-1007
5310-012-0393
5306-012-07^1
(4)
DESCRIPTION
EXHAUST HOSE AND MUFFLER BRACKET (Fig. 73)
WASHER, FLAT: S, 9/32 id, 5/8 od, 0.065 thk, 1/k screw size(exhaust hose to roof) (120392)
NOT, SELF-LOCKING, HEXAGON: S, l/k-28UNF-2B, 7/16 w (It51003) ——
SCREW, CAP, HEXAGON HEAD: S, 1/1*-28UNF-2A X 7/8 (96906-35292-7)
COUPLING: exhaust to hose (7977018) --———_——————
HOSE: exhaust, engine (7977023) ——————————————————————
NUT, SELF-LOCKENG, HEXAGON: S, 5/l6-2l«JNF-2B, 1/2 w, 17/6^ thk (bracket to roof (U) and exhaust hose to coupling (2J) (U51007)
WASHER, FLAT: S, 11/32 id, 11/16 od, 0.065 thk, 5/16 screw size(120393)
NON-ILLUSTRATED ITEM
BOLT, MACHINE: hex-hd, S, 5/l6-2l«JNF-2A x 3/U (exhaust hose tocoupling) (1207U1)
(5)
UNITOF
ISSUE
ea
ea
ea
ea
ea
ea
ea
ea
(6)
QTYINCIN
UNIT
6
6
6
1
1
6
8
2
(7)15-DAYMAINT
ALW PER100 EQUIP
(a)
0£o£ u
(bl
8l|ssg
ORD E2223
FIGURE 73-EXHAUST HOSE AND MUFFLER BRACKET
85
(1)ILLUST
la)
FIG NO
(bl
ITEM NO
(2)SOURCE, MAINT
ANDRECOVERABILITY
CODElal
S =
is
11
Ib)
si
pp
p
pp
p p
p
p
p
p
pp
pp
p
p
p
p
p
p
Icl
jg
s5 3
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
0
o
0
0
0
0
Id)Ej isst
NR
(3)
FEDERALSTOCK
NO
2990-625-9304
5305-012-1832
9505-596-1623
2540-524-4313
2920-71(0-2852
5325-011-273U
5310-014-2247
5305-021-4419
5310-012-0380
5310-017-8571
810.5-333-1550
5330-599-8454
5340-597-6233
5310-012-0377
5310-050-3275
5305-012-2408
5305-012-2513
5305-012-0323
5310-044-6230
5310-012-0384
254o-039-7'78o
251x3-039-7782
251*0-039-7781
(4)
DESCRIPTION
GOVERNOR AND THROTTLE CONTROL (NON- ILLUSTRATED)
CONNECTOR, CONTROL, WIRE: governor spring (797*11810 ————————
SCREW, MACHINE: rd-hd, S, no. 8 (0.l64)-32NC-2A x 3/8 (governor control rod) (121832)
WIRE, STEEL, CARBON: 0.055 dia (governor control rod) (2 Ig)(80244-22-W-1835-000)
CLAMP: throttle control (86991*36) —————————————————————
SCREW, CAP, HEXAGON HEAD: S, 1/4UNC-2A x 11/16 (H001-541-7621)
MISCELLANEOUS ELECTRICAL ITEMS (NON- ILLUSTRATED)
GASKET: cover (lead) (7402852) ———————————————————————
GROMMET, RUBBER: 3/8 id, 1/2 dia x 1/16 w, mtg groove (ammetershunt plate) (112734)
NUT, PLAIN, HEXAGON: S, 1/4-23UNF-2B, 7/l6 w, 3/16 thk (seatpanel clip (10) and generator cable clip (2)) (142247)
SCREW. MACHINE: rd-hd, S, 1/4-23UNF-2 x 3/4 (seat panel clip) (211*19)
WASHER, LOCK: split, S, 1/4 holt size (generator cable clip (2)and seat panel clip (10)) (120380)
WASHER, LOCK: int-ext-teeth, S, 7/16 "bolt size, 1.070 od(generator ground terminal) (17857!)
REUSABLE CONTAINERREUSABLE CONTAINER (NON- ILLUSTRATED)
CONTAINER: reusable, metal, assy (used w/ENGINE 8805-574-1044) —
GASKET: container closure (for continental engine AOI-268-3B)(8723064)
MOUNT, RESILIENT: shock, engine support (8689978) ——————————
NUT, PLAIN, HEXAOOII: S, 3/8-l6UNC-2B, 9/l6 w, 21/64 thk (upperto lower section (18) and skid to lower container (4)) (120377)
NUT, SELF-LOCKING, HEXAGOK: S, 3/8-16UNC-3B, 11/16 w, 35/64 thk(mounting to mounting bracket (8) and cross member (3)) (503275)
SCREW, CAP, HEXAGON HEAD: 1/2-13UNC-2A x 1 (upper to lowersection) (1224o8)
SCREW, CAP, HEXAGON HEAD: 1/2-13UNC-2A x 4 (skid to lowercontainer (122513)
SCREW, CAP, -HEXAGON HEAD: S, 1/2-20UNF-2A x 8 (shock mount tomounting bracket) (120323)
WASHER, FLAT: S, 9/l6 id, 1-1/4 od, 0.109 thk, 1/2 screw size(skid to lower) (446230)
WASHER, LOCK: sul.it, S, 1/2 screw size (skid to lower container)(1203S4)
WIKTERI7.ATIOI1 KITARCTIC VEHICLE WINTERIZATION KIT (NON- ILLUSTRATED)
WIIWERIZATIOH KIT, VEHICLE: arctic (refer to SB 9-l6) (forservice parts see ORD 8, SUL G249, volume 42) (7976851)
Composed of:KIT: accessories (7076598)KIT: heater, personnel (7977277)
(5)
UNITOF
ISSUE
ea
ea
ft
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
ea
<6)
QTYINCIN
UNIT
1
1
f
1
1
1
1
12
10
12
1
1
1
4
22
16
18
4
8
4
It
(7)15-DAYAAAINT
ALW PER00 EQUIP
(a)
%ZOS
(b)
812Ssg
86
(1)
ILLUST
(0)
FIGNO
(bl
ITEMNO
(2)
OURCE, MAIN! AND
RECOVERABILITY CODE
(a)
C S
i|
(b)
w
g°
Icl
SE
5 £I
Id)t^
§
i
(3)
FEDERAL STOCKNO
5180-836-667^
5180-836-6675
(4)
DESCRIPTION
SECTIOH III
ORGANIZATIONAL TOOLS AND EQUIPMENT TOR VEHICLE
VEHICLE TOOL KITS
Tool Kits A and B will not be issued to units unless mechanics are authorized.
All units should have either an A or B Kit but not both. Ordnance units
authorized 3rd, Irth, and/or 5th echelon special sets will not be authorized
Kit A or B.
TOOL KIT: organizational maintenance (2nd echelon), special, Kit A: one per
lettered battery, company; headquarters of units above battalion bead-
quarters, when battalion has a service company.
TOOL KIT: organizational maintenance (2nd echelon), special, Kit B: one per
battalion and regiment headquarters (except when battalion or regiment has
a service company); service company; numbered battery, company; and similar
headquarters performing maintenance work for other units. (802U4-1U-T-
3569-110)
The items listed hereunder are components of the above Tool Kits and may be
requisitioned under their individual stock numbers. Stockage of components
of these Tool Kits which are duplicated in basic Kits for other type vehicles
assigned by TOE are not required beyond actual need.
The quantities shown in subcolumn 5(a) and (b) indicate the number of com
ponent items allotted to the particular Tool Kit shown.
(5)
QUANTITYPER
TOOL KIT
MKITA
1
(b)
KITB
1
,6
:£aH£_»u_.~_ jijj'"1
(INCHES) I i '"1
ijljsj^^^
MI T3 I?I INCHES I 1 '
FIGURE 74-SPECIAL TOOLS FOR VEHICLE
88
ORD E2224
(1)
ILLUST
(2) OURCE, MAIN!
ANDECOVERABILITY
CODE(a) Ib) [a) Ib)
(3)
FEDERALSTOCK
NO
(4)
DESCRIPTION
(5)
QUANTITYPER
TOOL KIT
Ib)
KIT
71*
71*
74
7 1*
10
10
10
10
5120-322-5961
5120-795-0895
5120-322-6219
5120-795-01*31*
4910-620-3690
5120-0311-81*61
5120-707-6223
SPECIAL TOOLS FOR VEHICLE (Kg. 7!*)
FIXTURE, TRACK CONNECTING: (suspension) (7950797) (802Wi~la-F-2°95-170)-
WRENCH, CROWFOOT: 3/1* opng, 3-5/16 offset hdl, 10 Ig (engine ignition harness nut) (7950895) (802l*l*-l*l-W-871-6a)
HEPLACER, OIL SEAL: 2 and 2.375 id, 2.562 od, 9/l6 thk (engine: fan tower Vertical shaft) (8708852)
REMOVER AND REPLACER, PRIMARY TORSION BAR: 3/8-2l*UW-2A X 1-1/1* dia, 12 Ig w/t handle 6 Ig (79501*84) (802l*l*-ln-R-2378-9l*0)
TESTING EQUIPMENT, FUEL INJECTION: w/TACHOMETER, absolute manifold pressure ga, manifold temp ga, nozzle pressure ga, burette primer pump, 2 tube assy, drain-fill sw and. generator (engine testing) (formerly KIT) (7003330)
PULLER, MECHANICAL: secondary torsion bar (87085!*!*)-
PULLER, WATER PUMP: drive gear (suspension: propeller) (7076223) (802W*.1*1- P-2951-16)
5120-592-3679
5120-795-01*87
NON-ILLUSTRATED ITEMS
LIFTER, ROAD WHEEL AND AM: hinged base and beam type (suspension: road wheel arm) (7010269)
PULLER, SCREW: 3/8-2l*uK?-2A x 6-1/2 Ig (suspension steering pivot pin) (use w/WEIGHT 5120-795-01*88) (79501*87) (802l*l*-l*l-2951-83)
[INCHES
10v
ORD E2225FIGURE 75-SPECIAL TOOLS FOR VEHICLE
9°
(1)
ILLUST
la)
FIGNO
75
75
75
75
75
75
75
75
75
75
75
Ib)
ITEMNO
1
2
3
1*
5
6
7
8
9
10
11
(2)OURCE, MAIN!
ANDECOVERABILITY
CODEa)
33isSB
10
10
10
10
b)
w3cl
g
i g
i
d)
i33
(3)
FEDERALSTOCK
NO
6620-795-0330
5120-289-8661
5120-795-01(88
5120-795-0826
5120-795-0812
5120-317-8081*
5120-795-0696
11910-300-0300
5120-795-01*1*
14910-098-671
4030-300-0297
U>
nCCr"DIDTIOKIUtOCKIr 1 H_JIN
SPECIAL TOOLS FOR VEHICLE (Fig. 75)
GAGE, PRESSURE, DIAL INDICATING: 300 Ib max, v/coupling and hose (transmission oil) (7950330) (802l*l*-l*5-G-U27-500)
WRENCH, SOCKET: 6 pt, 0.390 opng, 2 Ig, w/dble offset hdl, 5 lg (hydraulic steering system) (used w/TUBE 1*810-300-0300) (2 required per operation)(795010)0) (802l*lt-l*l-W-282l*-250)
WEIGHT, SLIDE HAMMER: 25/64 id, 1-3/1* od, 3-3/4 lg (suspension: used w/PULLER 5120-795-01187) (79501)88) (802i*l*-i*l-w-l90-200)
PIN ALIGNING- 0.2^7 dia, 2.24 lg knurled hdl (transmission: lower steering rod (used w/PIN 5120-795-0812) (7950826) (&02l*l*-l*l-P-555-28o)
PIN, ALIGNING: 0.21+7 dia, 5-1/2 lg, knurled hdl (transmission: upper shift rod and upper steering rod (1 required per operation) intermediate steeringrod, intermediate shift rod and power take-off rod (2 required per operat ion), and lower steering rod, used w/PIN 5120-795-O812 (1 required peroperation) (80244-41-P-555-290)
WREBCE, SOCKET: dole end, hex, 0.797 and 1-1/1* plugs, 17-1/2 lg (suspension: track tension adjusting) (802l*l*-l*l-W-1962-200)
REPIACER, BEARING CUP: 3.3 1* and 3.1*0 dia, 1-1/4 thk (suspension: road wheel hub inner and outer) (7950696) (802l*l*-l*l-R-2385-960)
TUBE, HYDRAULIC: steering system bleeder, O.l6 id, 0.28 od, 10-32KF-2A nipple, 16-13/61* lg (suspension: marine hydraulic valves) (used w/WREKCH 5120-289-8661) (2 required per operation) ( 802l*l*-l*l-T-l*170-100 )
REMOVER, TIRE, PMCEER TYPE: 2.38 to 7.38 range, w/hdl, 17 lg (7050443) (802M*-l*l-R-2373-2l*l*)
SPREADER, SLING: 1/2 thk, 11-1/1* lg, w/two 1 dia holes and one 2 dia hole (engine lifting) (used w/HOOK 1*030-300-0297) (7082676)
HOOK, HOIST: thd 1/2-2ONF-3, 9-1/2 lg (engine: used w/SPHEADER 1*910-098-6713) (2 required per operation) (7082677)
(5)
QUANTITYPER
TOOL KIT
la)KITA
2
1
2
1
1
2
1
2
Ib)KITe
i
2
1
1
2
1
1
2
1
1
91
SECTION IV - INDEXES
ALPHABETICAL INDEX
This index does not include Special Tools which are listed on pagos 89 and 91. Standard hardware items are also not included because of their common and multiple application in the supply system.
ITEM
ACID, storage battery ————————————
ADAPTERBattery terminal ————————————————
PAGE
————————— 35______ , , JO
Engine return and supply line ———————————————————— 17 Fuel line—————————————————————————————— 19, 20 Shaft to engine——————————————————————————— 78 Vehicle fuel lines ————————————————————————— 20
ARMFront, intermediate and rear suspension—————————— 62, 64, 66 Mirror ——-_•__--__-«.——————_____-_-•————— /A
BAND, air cleaner ———————————————
BAR, front, intermediate and rear suspension •
BATTERY, storage—————————————————
62, 64, 67
———— 35
BOLTBooster coi I ——————————————————————————— Connector bar —————————————————————————————
Fan rotor and housing———————————————————————— Front suspension ———————————————————————————
345929286222647
Intermediate suspension -—————---—•————-———-—— Power plant torque ———————————————-——_——— Rear suspension ————————————————————————————66, 67Spindle —_____.——____________._._____.___._•«_ AA
BOOT, universal joint——————————————————————————— 60
BRACKET, mounting, mirror -——-——-————-——————.-— 76
BRAID, stop light and taillight———————————————————— 45
BREAKER circuit -_____•_—_-__—————•_-—•—-——-- 40
BUMPERCargo compartment door —————————————————Front suspension anchor arm ——————————————————— Rear suspension————————— ——————
BUSHING, reducer fuel pump •
71626672
13
CABLEBattery to master switch ——— Engine to starter —————————————— Ground, battery —————————————— Ground, engine ——————————————— Igni tion ————————————————————
Positive, battery ———————————— Wi nch —————————————————————•
39— 51—— 35—— 37—— 34—— 34— 35—— 75
CAPFiller neck, fuel cell ———————————————• Hub, front, intermediate and rear suspension •
CARBURETOR, generator ——
CELL, fuel ——————————
___._____ 15 —— 62, 64, 66
ITEM
CHAINMarine drive' ————————— Winch —————————————
CLAMPMuffler ———————————- Oil cup ———————————•Throttle control —<—————— Valve rocker cover —————
PAGE
————— 57
271686
8
CLIPBlackout head light ———————————————————————— 43 Cable connector —————————————————————————— 48IUL I 79 IWZZIB ——————— «•——————————-••————————————— / i_Vehicle fuel line —————————————————————————— 20
CLUTCH
Secondary torsion bar ——— ------- •- — — - ——— — — — —— - 67Torsion bar, front, intermediate and rear suspension— — 62,64, 67
COIL, booster • 34
CONNECTORFuel primer ——— Governor spring • _________..________.....________„____ 86
CONTAINER, metal —————————————————————————— 86
CONTROL, manual —————————————————————————— 26
COOLEROil, engine ——————————————————————————————— 10 Oil, transmission —————————————————————— - — — 56
... m. » -_ __ __ __ 7H—— •— ——>——*— —™—«™™™™————™—™— / o
CORK, sheet —————————————————————————————— 72
COUPLINGExhaust hose to muffler — Exhaust to hose ————— Fuel line ————————— •
COVERAccess ——————
Outer housing ——---————------Trailer receptacle -——-—————
CUP, plunger ——-----——--------
CUSHION, power plant torque ————
84851978
72406048
24
7
DIAPHRAGM, fuel primer -————————————————————— 24
DOORBlackout driving light •Blackout marker light ———————————•——
4344
Blackout tail and service stop light ——————————————— 45 Service and blackout headlight—————————————————42,47
15ELBOW
Engine harness - —— 37
92
ITEM PAGE ITEM PAGE
ELBOW - ContinuedEngine return and supply line —— Fuel induction system —————— Heater fuel line ————————— Magneto and vent hoses ————— Oil filter ______________ Transmission oil cooler ——————
202520331056
ELEMENTFuel filter —————————————— Fuel primer filter ————————•—— Pack, oil filter ————————————
_————_-—_, 22 __________________ ^^
FAN, engine cooling •
FILTERElement ——————• Element, oil ———• Fuel ————————• Pri mer ————————
— 28
9542223
FITTINGFront, intermediate, and rear suspension —————>62, 64, 65, 66 Towing pintle ———————————————————————————• 70
FIXTURE, track connecting ————————————————————— 89
FLANGE, sprocketdrive ——————————————————————— 60
GAGEOil filler pipe ———• Oil level —————— Temperature ————• Transmission oil———
QO 55 38
GASKETBlackout head ——————————————————————————— Blackout marker light——————————————————————— Container ————————————————————————————————— Cover ———————————————————————————————————— Cover, generator regulator —————————————————————— Crankcase, oil, outlet tubes———•————————————————
Door, blackout head———————————————————————— Drain hole cover ————————————————————————————• Fuel pump—————————————————————————————— Fuel pump filter Fuel tank level gage
4744868631105142
- 72- 13 19, 23- 17
Generator —————————————————————————————— 30 Hubcap, front, intermediate, and rear suspension———63, 64,66 Igniter, personnel heater ——————————————————————— 76 Magneto and vent hoses ———————————————————————— 33 Nozzle ~-______-•_•_—•______-___•___—--- 12 Oil CUD ————————————————————————————————————— 16Oil filter—————————————————————————————————— 9
Oil filter cover————————————————————————————— 54 Outer housing cover ———————————————————————————— 60
Pressure, fuel pump ——————————————————————————— 13 Pumo —————————————•-—————«««—————————————————— 11
Sealing, drive shaft core ———————————————————————- 78
Service headlight door ————————————————————— 42, 47 Spark plug —————————————————————————————— 34
Starter ———————————————————————————————— 32
Taillight —————————————————————————————————— 45
Torsion bar clutch cover ————————————————————62, 65,67 Valve rocker cover ——————————————————————————— 8
Warning light door ——————————————————————————— 40
GEAR, speedometer shaft •
GENERATOREngine accessory —— Power unit ——————•
—— 78
•—— 30—— 80
GRIP bar ——--__«——_•—--—————«—-—«-.«..»..«_ 69
GROMMETBlackout driving light ——————————————————————— 43 Distributor cable —————————————•————————————• 34
HARNESS, engine, wiring ———————————————————————— 37
HEADLIGHT
Service ——— •
HOOK
Lifting, power plant ———— • HORN, electrical
HOSE
Engine oil cooler ————————————————pi _ _ .-— —— _ _ _ . _ .__« _ . ___ ._«..«Fuel induction system ———————————— • Fuel line ———————————————————— Magneto and vent ——————————————
4342
916
34
851083242133
HOUSING, sprocketdrive————————————————————— 60
HUBFan drive ———————————————————— Front, intermediate, and rear suspension - Overload clutch ———————————————— Sprocket ———————————————————
_.„______ 29• 62, 64, 66, 68 ______ 29—————— 75
INSULATING MATERIAL, hull wiring ——————————————— 51
JOINT, sprocketdrive——————————————————————————— 60
KIT, horn •
_______ 78 ——————— 78
KNOBDome light switch ———————————— Fuel primer —————————————————
LAMP, stoplight, taillight-
•—— 51—— 24•—— 69
—— 45
LENS
Headlight, service ————————————— Warning light door ——————————————•
514240
LIFTER, road wheel and arm ————————————————————— 89
LIGHTBlackout marker ——————————————•
Indi cator ———————————————————• Service blackout ————————————— Service headlight beam ———•————— Warning ————————————————————
LINEEngine air intake elbow ———————— Engine fuel ——————————————————
Transmission to engine oil pan —————•
GLAND, fuel primer —— — 24 LINK, chain, cable, winch —————
485140474040
25181810
75
93
ITEM PAGE ITEM PAGE
MAGNETO—————————————————————————.
MIRROR, rear view ——————————————-————--
MOTOR, wiper ——————————————————————
MOUNT, engine support ——————————————————
MUFFLER
NIPPLE, valve rocker arm •
33
76
73
86
8427
— 8
NOZZLE
NUTAdapter cable, regular harness ————————————————— 81 Fan rotor and housing ——————————————————————— 28 Front suspension —————————————————————————— 63
Hub bearina ——•_——•_——_—-_———————_.__-—.._ AftIntermediate suspension ————————————————————— 64Mounting, dome light switch •——————•———————————— 51Mounting, spare wheel ——————•———————————————• 70Steering bracket, skeg bracket and propeller ————————— 58
PACKINGFuel primer ————————————————————————————— 24 Fuel primer filter———————————————————————————— 23 Service headlight ———————————————————————— 42, 47
PADDriver's escape hatch —————————————•—————————— 72 Spot light mounting bracket ———————————————————— 49
PARTS KITSprocket drive ———————————————————————————— 60 Universal joint, sprocket drive -———————————————— 61
PINSteering rod ————— Winch —————————
———_ 01———— 75
PINTLE, towing ————————————————————————————— 70
PIPEMuffler —————————Oil cooler —————————
—— 27—— 56
PLATEConnecting bar -————————-Data ——————————————Identification ———————————— Name —————————————————
___„____.____„•,.——— 79 .„.._.,_„__,__..__„_.,.. 38
PLUGDrain, housing —————————————————• Engine and transmission oil drain ——————— Instrument panel -—————————————•——— Outlet chamber check valve ———————— Road wheel arm ———————•—•———————— Spindle, rear suspension ————————————
_____m o————— 55————— 36————— 24————— 65.————— 66
PLUNGER, dome light ————
POWER PLANT ————————
PROPELLER ———————————-
51
__ ._„. __ , ___ CO
PUMPBilge ——————• Engine fuel ———
——— 77——— 13
PUMP - ContinuedFuel —~__———« -_.——_.———._———_———_._ 14Fuel, generator ————————————————————•————— 80Fuel injector ———————————————————————————— 11Fuel primer ——•—————————————————•————————— 24
REGULATOR, engine, generator —————————————————— 31
RELAY SOLENOID, starter —————————————————————— 39
RELAY, starter ————————————————————————————— 39
RETAINER
Sprocket drive ——————————————————————————— 60
RINGFlange —————— Fuel primer filter •
6023
ROLLER, cable, winch ———————
RUBBER SHEET, batteries and cable •
SCOOP, air cleaner —————————
— 75
— 35
—— 28
SCREEN, air cleaner ————————————————————————— 16
SCREWBlackout headlight door —— Fuel induction system ———— Journal bearing to flange — Pressure, fuel pump —————
———————— 25———————— 60
———— 26——— 72———— 71———— 78———— 62
SEALAccelerator cross tube ——————————• Access cover ——————————————• Door ———————————————————————• Drive shaft ———————————————• Front suspension —————————-————— Hub, Inner bearing, intermediate and rear suspension———64, 66LJ II __ „ ___ 70null ——————————————————•*——————————————— •— — i L
Inner bearing, rear suspension —————————————————— 68Inner bearing sprocket drive —————————————————————— 61Lamp socket ————————————————————————————— 40Oil, rear suspension —————————————————————•————— 66"O" ring, rear suspension ————————————————————— 67
SETSCREW, dome light switch knob ——-
SHAFT
Sprocket drive —•————————————————————————————— 60
SHIELDHub inner bearing oil seal ———-————————————•———— 66 Instrument panel light ———————————————————————— 40
SHOCK ABSORBERFront suspension —————————————— Lever action, rear suspension ——•————
SOCKETDome light ——— Right taillight —
5145
SPACER, air cleaner support band bolt——————————————— 16
SPARK PLUGEngine —————————————————————•——————————— 34
SPEEDOMETER —————————————————————————————— 38
SPINDLE, arm, rear suspension———————————————————— 66
ITEM PAGE ITEM PAGE
SPREADER, engine lifting ——
SPRINGCheck valve outer chamber •Diaphragm cap ————————————
Outer shaft sprocket drive -—————— Retracting propeller ———————————— Shifting control lever ————————— Throttle control linkage ——————————
———— 91
24245160586926
TRACK SECTION • —————— 59
SPROCKETDrive ——————————— Marine drive ————————
STARTERAuxiliary engine ————————— Main engine———
STOP LIGHT, taillight, service blackout———————
STUDAdapter ——------™Blackout marker lamp body ————Control valve, air inlet elbow •Engine fuel filter ——————————————Engine fuel pump —————————————Fan rotor and housing ——Fuel injector pump •Generator —————Magneto and vent hoses ————————
SWITCHBlackout receiver •Blackout stop and taillight ———————Dome light ———Foot, service headlight-Horn —•--Light ————Magneto and starter •Magneto to ignition ——————————Master ——————Selector, fuel tank •Starter ———————
7557
8032
45
784816221328103033
9
40 45 51 36 36 40 40 80 39
•40
TACHOMETER, mechanical—
TEEEngine supply line coupling - Fuel connecting • Primer fuel line • Vehicle fuel line •
TERMINAL, battery and ground cable —
TESTING EQUIPMENT, fuel injection
38
19831819
89
TRANSMITTER, engine oil gage ————————— 48
TUBEFuel tank and fuel line pump to carburetor ———• Heater fuel line ——— Hydraulic ———————— Transmission oil cooler — Vehicle fuel line ———
UNITEngine oil pressure gage •Transmission high oil temperature warning light————————
VALVEEngine return line —————————•-————« Engine supply line ————— Fuel selector ————————Heater fuel ——————— Shut-off hearer fuel •
VOLTMETER ———_
WASHERBlackout headlight • Distributor cable • Dome light body •
4848
1919831921
———— 38
— 43— 34— 51— 51— 51— 78— 62
Hub, outer bearing, intermediate and rear suspension—— 64, 68Hub, rear suspension —————————————•————————— 66Magneto and vent hoses ———————•————————————— 33Oil niter pack—————————————————————————— 9
Dome light hole plug • Dome light socket - Drive shaft and adapter • Front suspension ————•
Power plant torque — Service headlight — Spring, rear suspension • Taillight socket ——
——————— 7————— 42, 47
67
WEDGE, arm spindle, rear suspension -—>
WEIGHT, slide hammer ————————
WHEEL, road •
WIREBattery ground and connecting - Electrical, hull wiring ————— Governor control rod ————— Head, tail, and marker light — Instrument panel ———————— Personnel heater ————————
——— 66
————— 91
—— 63, 64, 66, 68
355286464176
WINTERIZATION KIT, vehicle ———
95
FEDERAL STOCK NUMBER INDEX
This Index is prepared in numerical sequence to assist in locating items when only the Federal Stock Number is known. Standard hardvare items having a cordon application in the supply system are not included in this index.
Stock Number Page Stock Number
2510-526-6186 —————————————— 72 2510-752-6596 ———————————— to2510-796-5600 —————————— 62, 65, 67 2510-797-5068 ———————————————— 72 2510-797-5082 ———————————————— 71 2510-797-5115 ——————————————— 71 2510-797-5'i07 ——————————— 71, 72 2510-797-51*1*1* ——————————————— 72 2510-797-5510 ——————————————— 72 2510-797-5513 —————————————— 72 2510-797-5516 ———————————————— 72 2510-797-571*5 —————————————— 72 2510-797-571*9 —————————————— 72 2510-797-601*1 —————————————— 71 2510-797-601*2 —————————————— 71 2510-797-621*8 —————————————— 75 2510-797-6251 —————————————— 75 2520-039-7716 —————————————— 60 2520-039-7717 ——————————————— 60 2520-039-7718 2520-318-001*9 2520-512-9167 2520-71*1-1931*
————————— 60-—————————- 75
2520-71*1-1935 —————————————— 752520-772-1*338 —————————————— 782520-796-5315 —2520-796-5383 —2520-796-5595 —2520-796-5675 —2520-796-5735 —2520-796-571*3 —2520-796-571*6 —2520-797-51*70 —2520-797-5777 —2520-797-6022 ———.2520-797-6309 ——————
2520-797-61*80 ——— 2520-797-6738 —————— 2520-798-0185 — 2520-798-01*08 ... 2520-798-01*88 ————————. 2520-798-01*91 ——— 2520-798-01*98 ———. 2520-798-0538 —— 2520-798-3058 —————. 2530-039-7721 — 2530-039-7722 2530-039-7723 — 2530-039-772U ——————. 2530-039-7725 — 2530-092-9276 ————— 2530-796-5091 —— 2530-796-5092 —————————62, 61t, 67 2530-796-5277 —————————————— 72 2530-796-5338 —————————————— 59 2530-796-5358 —————————62, 6U, 67 2530-796-5359 —————————62, 6U, 67 2530-796-5380 ——————————63, 61*, 66 2530-796-5850 ——————————————— 62 2530-796-5851 ——————————————— 62 2530-797-5'H'* ——————————————— 66 2530-797-5613 ——————————62, 6I», 67 2530-797-5611* ——————————————— 62 2530-797-5615 ——————————————— 62 2530-797-5616 —————————————— 61* 2530-797-5617 —————————————— 61* 2530-797-5618 —————————————— 61* 2530-797-5619 —————————————— 6U 2530-797-5620 —————————————— 67 2530-797-5621 —————————————— 67 2530-797-5925 —————————————— 56 2530-797-5926 —————————————— 56 2530-797-61*67 —————————63, 61*, 68 2530-798-0161 —————————————— 6U 2530-798-0288 ——————————63, 6U, 68 2530-798-01*75 ——————— 62,61*, 66, 68 251*0-039-7715 ——————————————— 77 251*0-039-7780 —————————————— 86
781 —————————————— 86
251*0-039-7782 251*0-058-326!*
251*0-318-001*7 251*0- 52U-1*313 251*0-698-0607 251*0-735-11*12 251*0-737-2703 251*0-752-0358 251*0-770-0170 25to-T96-50T9 251*0-796-5195 251*0-796-5200 251*0-796-5276 251*0-796-5373 251*0-796-51*99 251*0-796-5938 25to-797-5!i83 251*0-797-:
Page
- 86
- 75- 70- 86- 62- 36- 76~ 76- 76- 79- 79-- 79-- 79- 66
2590-693-31*532590-693-1H752590-695-516U2590-735-59332590-773-13762590-797-591*72590-797-63672590-798-02322805-563-W16 ———2805-625-92962805-71*1-53022805-71*1-5303 —2805-71*1-631*9 —2805-798-0132 .2805-798-051*82910-039-7820 —————————2910-360-3675
2910-1*85-2213 — 2910-699-7901* — 2910-625-9298 2910-703-3653
2910-71*1-1061* ————2910-71*1-5351*2910-7U1-62632910-71*1-62662910-71*1-6325 -2910-71*1-63262910-71*1-61*022910-71*1-61*01* -2910-71*1-61*05 -2910-71*1-61*06 ——2910-71*1-61*08 ——2910-71*1-61*09 ~2910-71*1-61*10 —2910-71*1-61*11 —2910-71*1-61*262910-71*1-6510 ~2910-71*1-65712910-71*1-65722910-773-55652910-776-10592910-776-1709 ~2910-796-71*682910-797-51*25
— 18
1818181812231818
1U— 83— 18
Stock Number2910-797-5'*27 • 2910-797-5707 • 2910-797-5761 • 2910-797-6711 • 2910-797-6751* • 2920-3ll|-0276 . 2920-335-1*677 • 2920-37U-3180 . 2920-571-6731 • 2920-625-9302 . 2920-735-3260 • 2920-735-1*165 • 2920-735-8552 • 2920-737-2993 • 2920-737-2995 • 2920-738-6251* . 2920-71*0-2852 2920-71*1-1*736 2920-71*1-530!* 2920-71*1-6283 2920-71*1-61*20 2920-71*1-61*21 2920-797-5622 2920-797-5623
30, 32
2930-699-77762930-737-601*8 .2930-71*1-6296 .2930-71*1-63752930-71*1.61*352930-798-02662930-798-0267
291*0-71*1-61*1*3 29!iO-753-9079 291*0-753-9080 291*0-796-5120 291*0-796-5310 291*0-797-6821
291*0-798-0168 291*0-798-0207
2990-3111-0278 2990-3ll*-0279 2990-3ll*-028o 2990-512-9183 2990-512-9190 2990-512-9195 2990-512-9227 2990-625-9301*
2990-797-5711* 2990-797-5959
———— 18
3110-100-075!* 1*010-27l*-6839 1*030-300-0297 1*710-200-0308 1*710-277-5525 1*710-277-5527 1*720-200-0359 1*720-235-1*118 1*720-350-9896 1*730-050-1*208 1*730-090-901*0 1*730-O9O-9112 1*730-090-9111* 1*730-090-911*3 1*730-278-51*53 1*730-278-5660 U730-323-8521 1*730-512-9230 1*730-709-7382
-57,58,62,63,6U,65,66,67—————————————— 8
20
Stock Number Page Stock Number Stock Number
1*730-71*1-53118 -l*730-7Ul-5352 - U730-7U1-6239 - 1*730-71*1-61*25 - 1*730-71*1-6606 . 1*730-796-5535 - >*730-797-59S9 - >*730-797-5930 - 1*730-797-601*8 - 1*730-797-6052 . 1*730-797-6060 - >*730-797-6755 • 1*820-71*1-1061* • 1*830-797-61*03 • 1*910-098-6713 • 1*910-300-0300 • 1*910-680-3690 . 5120-O3l*-81*6l • 5130-289-8661 • 5120-317-808!* • 5120-322-5981 • 5120-322-6219 • 5120-592-3679 • 5120-707-6223 • 5120-795-01*1*3 • 5120-795-01*81* • 5120-795-OW7 • 5120-795-01*88 . 5133-795-0696 . 5120-795-0812 . 5120-795-0826 • 5120-795-0895 • 5305-012-31*56 • 5305-21*5-0326 . 5305-335-U208 . 5305-335-!*209 . 5305-361*-3229 • 5305-523-21*05 • 5305-52U-5639 • 5305-732-0657 • 5305-737-6915 • 5305-7U1-5381* • 5305-7'*l-6368 . 5305-752-5938 •5305-77U-U573 •5306-151-0788 5306-71*1-511!* 5306-752-129!* • 5306-796-51*66 , 5306-796-5593 5306-797-51'*95306-797-68315307-206-2601* 5307-733-861*6 5307-73>*-8668 5307-73>*-8669 5307-7>H-5375 5307-71*l-538l 5307-77l*-l*572 5307-776-780!* 5307-776-7805 5310-205-9621 5310-261*-l*lll 5310-350-2655 5310-523-21*05 5310-595-7327
———— 33—————— 9, 13—————.9, 13
63, 61*. 66, 68 — 1*3
63, 6U, 68, 70 62, 65, 67
5310-732-06525310-733-861*5 531o-7!*l-62l*6531Q-7'*l-62765310-752-1252 5310-776-73185310-796-5378
5315-695-881!*5315-796-5651 5325-738-52515325-752-5365 5330-05U-68795330-171-69835330-202-1*0615330-265-10895330-360-3671* 5330-505-66095330-5"*l-7l6o
5330-599-81*51*5330-700-6237
5330-732-061*55330-732-06895330-71*1-5395 5330-753-96385330-753-96885330-753-96895330-796-22555330-796-53095330-796-5322
5330-796-99135330-797-55205330-797-6531531*0-050-159753to-2D5-5762531*0-282-752153to-321-6078531*0-360-3677531*0-1*96-1910531*0-597-623353to-695-1107531*0-705-7189
53to-T96-520653to-796-5l*8l
^^lifl TQf^S^TQl531*0-796-5692531*0-796-573753to-797-596253to-797-605853to-797-677553>*0-798-01115355-732-06565355-770-08195355-797-5005 cQpc_viii i II.TQRO^n—fioo om iWWX)lwAQ3£
5930-221-89665930-302-1125•M?D-«7-88s6
—————————————— 23- 28
__ 6^ 6U 6858
—————————————— 7—————————————— 75
« .. - I(O
°)l
Oti
————— , ———————— 35ho 1,7
QX;
- - llR hft
—————————————— 51
____ ..__.__.,.,____.__.. tjl|
70
"7ft
78———————— 1*2, 1*7, 51
__ _ 51,6" 66
—————— 63, 61*, 66, 68
61_, .I.™ ^ 68
81—— - . — 2U
- .. "»'i____ „ _ 2U
Q/-
-. .....-..___-_ _ h?
J,Q... __._-_-.... ..... Sfl
. __ 60.„ ._._—_„,_ , _ ... ^6
*Vi_ fn
- 60
— • MI 'Y)
• " 51*»lTg
So^,/r
Qrt
« . .. ----- )|Q
5930-705-7187 —— •CQ'3f) *7^O_Afi^7 _
5930-752-6287 ———'sQ'^n TQ7 RliAft _••«5930-797-6356 ——————
5935-773-11*28 _—-5937-738-9128 ———59to-705-6730 ———
591*5-612-571*0 ———5970-28U-8672 ———5975-333-91*!1* — —6lto-057-2553 _— -6lto-61*2-2119 ———
6lU5-299-U4l4 ———£\\ llt\_'3Q")_Q9QC>611*5-519-2675 -——611*5-51*8-2927 _— -611*5-705-6675 — — —611*5-772-0853 ———6150-279-6723 — ——6220-337-61*71 —— —6220-557-8229 —— ~6220-695-1200 ———
6220-732-061*7 _— -6220-732-0690 _-—6220-735-3561 —— —6220-735-3562 — -—6220-735-3713 — — -6220-71*1-9686 ———6220-71*1-6988 ———6220-752-6018 ———6220-752-6020 — _—6220-752-81*79 _— -6220-772-3773 — — —6220-776-01*12 ———
6220-796-221*2 _— —6220-796-221*3 _-—6220-796-221*1* ———6220-796-221*5 ———6220-796-2263 — — .6220-796-2268 ———6220-797-6161 __—6250-796-221*8 — —
6620-795-0330 — — -6625-335-9512 ——— -6680-02U-2276 — — —6680-772-7U66 ——— -6680-776-0396 ——— -6680-797-5712 ——— -6680-797-6163 ———
6680-798-3056 ——————— -
6685-738-9567 ——————— -
6685-772-8853 ——————— -
68in-pUQ-Q^sU ———
_ __ e-|
- - .... ... __ .... Itf)
... .- 1|0
..„ ______ ... -if.
———————————— 1*8__ „__„_„_ -jfi
———————————— 1*8-„_,.— l+o
———————————— 39
_ , ______________ „_ L6 CT
QT
•2C
•ac
_____ .__._...... 76
- „„.„„_._ 1*5 k6—————————— 35——— . —— 1*1, 1*6, 76
———— .... —— -. 1*6_____ , __ ... ___ 1^2
... .... L^Cl
— Cl
- hh
.„ —— _ ————— JK>. . -» IK)
_ ___ ___ . 1^2......... Il7
————— . —————— U6
„ . ________ .__ i^
. - ............ Ito
.......... h.^——————————— 51———————————— 51
. ———————————— 51———————————— 51
. ————————— U2, U7... . - kQ
——————————— 51 . ——————————— k&. .................. k8. .................. 91
__ , _ __ riQ
. _ _______ „ if.
ryQ
•7A
. . . "5ft
^O
. ——— _ ———————————— -5S
97
By Order of WILBER M. BRUCKER, Secretary of the Army:
L L. LEMNITZER, General, United States Army,
Chief of Staff.
OFFICIAL:R. V. LEE,
Major General, United States Army, The Adjutant General.
DISTRIBUTION:
Active Army:
To be distributed in accordance with DA Form 12-7 requirements for TM 9 Series (UNCL) plus the following additional formula:
Tech Stf, DA (1) except Ord Co (2) exceptCofOrd(l2) 9-17,9-57,9-229,9-347,
US ARADCOM (2) 9-367, 9-377 (None)US ARADCOM Rgn (2) MAAG, Japan (2)Div (2) Units org under fol TOE (2 copiesOrd Gp (2) except each)
9-12 (None) 29-55Ord Bn (2) except 55-27
9-45, 9-375, 9-376 ( None ) 55-38
NG: State AG (3); Units - Same as active army except allowance is one copy to each unit.
USAR: None
For explanation of abbreviations used, see AR 320-50.
. S. GOVERNMENT PRINTING OFFICE: 1960-570875/57
